Baja Marine Outlaw 23 Bedienungsanleitung

Baja Marine Owner ’ s Manual 23 O utla w Owner ’ s Manual Part Number: MRP 1810950 R Speed changes you. TM.[...]

R Speed changes you. TM. B aja M arine C OrpOra tiOn , 2600 S ea r a y B l vd ., K nOxville , tn 37914 F Or inFOrMa tiOn Call 1-865-971-6270 Or F ax 1-865-971-6716 i nternet addreSS : http :// www . BajaMarine . COM[...]

i 23 Outlaw ® Congratulations on becoming the new owner of the world’s #1 performance boat. Baja ® Marine Corporation welcomes you into our worldwide and ever-expanding family of boating enthusiasts. The Owner ’s Manual Packet, to be kept on board your Baja, gives you important information on all the features of your Baja. For years of troubl[...]

ii 23 Outlaw ® THIS P AGE INTENTIONALL Y LEFT BLANK[...]

iii 23 Outlaw ® i ntrOduCtiOn 1. T his M anual The material within this manual and your Owner ’s Manual Packet: • Gives you basic safety information • Describes the features of your boat • Describes the equipment on your boat • Describes the fundamentals of boat use • Contains service and maintenance information Y ou must learn to oper[...]

iv 23 Outlaw ® 6. h ull i DenTifica Tion n uMber (hin) The “Hull Identication Number” located on the starbo ard side of the trans om, is the most import ant identifying factor and must be included in all correspondence and orders. Failure to include it creates delays. Also of vital importance are the engine serial numbers and part numbers w[...]

v 23 Outlaw ® a bouT Y our e xpress l iMiTeD W arranTY Baja Marine offers an Express Limited W arranty on each new Baja purchased through an authorized Baja dealer . A copy of the Limited W arranty was included in your owner ’s packet. If for any reason, you did not receive a copy of the Limited W arranty , please contact your local dealer or ca[...]

vi 23 Outlaw ® 23 O utla w O wner ’ S M anual • t aBle OF C OntentS i nTroDucTion 1. This Manual ............................................................iii 2. Y our Responsibilities ..............................................iii 3. Sources of Information ...........................................iii 4. Dealer Responsibilities ........[...]

vii 23 Outlaw ® A. Maintenance & Service ................................. 4.2 B. Vibration & Causes ....................................... 4.2 C. Impact to Stern Drive .................................... 4.3 D. Propeller Removal and Installation ............... 4.3 s ecTion 5 • f uel s YsTeM 1. Fuel System.............................[...]

viii 23 Outlaw ® Information in this publication is based upon the latest product specications available at printing. Baja ® Marine Corporation reserves the right to make changes at any time, without notice, in the colors, equipment, specications, materials and prices of all models, or to discontinue models. Should changes in production mod[...]

23 Outlaw ® 1.1 R Speed changes you. TM. S eCtiOn 1 • S aFety SAFE boating means: • Knowing the limitations of your boat • Following the "Rules of the Road" • Keeping a sharp lookout for people and objects in the water • Not boating in water or weather conditions that are beyond the boat's and the operator's capabilit[...]

23 Outlaw ® 1.2 S eCtiOn 1 • S aFety R Speed changes you. TM. 2. l eGall Y M anDa TeD M iniMuM r equireD e quipMenT Consult your national or state boating law enforcement agency . The following equipment is the minimum required by the U.S. Coast Guard for a boat less than 26' [7.9 meters] in length. Person al Flotatio n Devices (PFDs): One [...]

23 Outlaw ® 1.3 S eCtiOn 1 • S aFety R Speed changes you. TM. Dangerous concentrations of carbon monoxide will be present if: • the engine exhaust systems leak; • a nearby vessel's engine is running • insufcient fresh air is circulating where people are present; and • fumes move from the rear of the boat into the cockpit and cabi[...]

23 Outlaw ® 1.4 S eCtiOn 1 • S aFety R Speed changes you. TM. Even strong swimmers can tire quickly in the water and drow n due to exha ust ion, hy pothe rmia , or both. The buoyancy provided by a personal otation device (PFD) will allow the person who has fallen overboard to remain aoat with far less effort and heat loss, extending surviv[...]

23 Outlaw ® 1.5 S eCtiOn 1 • S aFety R Speed changes you. TM. 6. a DDiTional r ecoMMenDeD e quipMenT for s afe o pera Tion In addition to legally mandated equipment, the following items are necessary for safe boating especially if your boat is out of sight of land. • First aid kit • V isual distress signals for day and night use (required in[...]

23 Outlaw ® 1.6 S eCtiOn 1 • S aFety R Speed changes you. TM. 9. p oWer c ap aciTY The engine options available for your boat have been selected as the best suited for general use for this size boat. Do not install an engine larger than the largest option available. Y our boat will be difcult to handle and will be less stable. Y our B aj a ®[...]

23 Outlaw ® 1.7 S eCtiOn 1 • S aFety R Speed changes you. TM. 1 1. M ainT ain c onTrol On the water there are no marked trafc lanes, no tra f c s ig ns or lig ht s, and boa ts hav e no tur n si gn al s. The boat operator must keep her or his attention focused not only on what's ahead but what's on the left, right and behind the b[...]

23 Outlaw ® 1.8 S eCtiOn 1 • S aFety R Speed changes you. TM. D. Sheltered waters Maximum speed: 15 knots (18 mph) Maximum wave height: 0.5 meters (1.5 feet) Boat use is limited to small lakes, rivers and canals. Y our 23 Outlaw boat is Design Category C. The wind speed and wave height specied as the upper limit for your category of boat does[...]

23 Outlaw ® 1.9 S eCtiOn 1 • S aFety R Speed changes you. TM. 14. W a Ter s por Ts a. s WiMMinG • Do not permit anyone to swim from a moving boat, or a boat with an engine running. • Many localitie s prohibit swimming from boats except in designated areas. • Make sure boat's engine is turned off and the stern drive is fully down befor[...]

23 Outlaw ® 1.10 S eCtiOn 1 • S aFety R Speed changes you. TM. DIVERS FLAGS (FIG. 1.10.1) CODE ALPHA FLAG SPORT DIVER'S FLAG RED WHITE BLUE WHITE Faster - Thumb pointed up or palm up, move hand up and down. Speed OK - Raise arm and form a circle with thumb and index nger . S t o p - Raise arm with palm vertical and facing forward. T urn [...]

23 Outlaw ® 1.1 1 S eCtiOn 1 • S aFety R Speed changes you. TM. D. f looDinG , s W aMpinG anD c apsizinG In the event of ooding, swamping or capsizing: • T ry to shut off engines, generators and blowers before leaving the boat. • Have everyone put on Personal Flotation Devices (PFDs). • Account for all who were on board. • If the boat[...]

23 Outlaw ® 1.12 S eCtiOn 1 • S aFety R Speed changes you. TM. f . G rounDinG In the event of running aground: • Check for leaks. If water is coming in, sto p the intake of water before attempting to get the boat free. • Inspect for damage to the hull, propulsion and steering systems. • Determine if the tide, wind and current will drive th[...]

23 Outlaw ® 1.13 S eCtiOn 1 • S aFety R Speed changes you. TM. 18. e nvironMenT al c onsiDera Tions The following warning is offered for boats sold in the State of California in accordance with California Heath & Safety Code §§ 25249.5-.13: a. f uel anD o il s pillaGe Regulations prohibit discharging fuel or oily waste in navigable waters.[...]

23 Outlaw ® 1.14 S eCtiOn 1 • S aFety R Speed changes you. TM. 19. n auTical T erMs Abeam - object 90 degrees ( 90° ) to center line on either side of boat. Abaft - a point on a boat that is aft of another . Aft - toward the rear or stern of the boat. Beam - the maximum width of a boat. Bilge - the lowest part of the hull on the inside where ?[...]

23 Outlaw ® 1.15 S eCtiOn 1 • S aFety R Speed changes you. TM. 20. k eY To s YMbols on c onTrols & p rinTs These symbols may be found on your controls and gauges and/or used in this owner's manual. This page is to help you understand what the symbols mean. PROPULSION SYSTEM TRIM PROPULSION SYSTEM TRIM BOW UP PROPULSION SYSTEM TRIM BOW D[...]

23 Outlaw ® 1.16 S eCtiOn 1 • S aFety R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK[...]

23 Outlaw ® 1.17 R Speed changes you. TM. 21. W arninG l abel l oca Tions w arning l aBel l OCa tiOnS (F ig 1.17.1) California Residents Only The above warning is attached to the steering wheel prior to delivery of any boats sold in the state of California in accordance with California Health and Safety Code §§ 25249.5-.13 Replaces NMMA capacity[...]

23 Outlaw ® 1.18 R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK[...]

23 Outlaw ® 2.1 R Speed changes you. TM. S eCtiOn 2 • g eneral B Oa t a rrangeMent ! CAUTION Do Not use cleats for lifting. B Ow e ye l OCa tiOnS (F ig 2.1.2) Bow Eye Bow & Stern Eyes 2. p assenGer l oca Tions 1. When the boat is moving, all passengers must be on the seating provided or , if standing, holding on rmly . While the person at[...]

23 Outlaw ® 2.2 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. 3. b asic b oa T D iMensions anD c learances (u niTeD s T a Tes s T anDarD s.a.e.) 23 O utla w s pecifica Tions Overall Length ................................................................. 23'6" Overall Length (w/ drive down).........................[...]

23 Outlaw ® 2.3 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. b asic b oa T D iMensions anD c learances (M eTric ) 23 O utla w S peCiFiCa tiOnS Overall Length .............................................................. 7.16 m Overall Length (w/ drive down).....................................7.69 m w/std. Swim Platform ..[...]

23 Outlaw ® 2.4 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. 6. G eneral D eck l a YouT GENERAL DECK LA YOUT (FIG. 2.4.1) FWD REAR (AFT) LEFT (PORT) RIGHT (STBD) Navigation Light (Bow) Cleat Cleat Deck Hatches Gauges Switch Panel Shift / Throttle Con- trol Steering Wheel Helm Seat Passenger Seat Inspection Plate Aft Bench S[...]

23 Outlaw ® 2.5 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. 7. D escripTion of M ajor c onTrols a. G ear s hifT anD T hroTTle c onTrol The shift/throttle control unit for the engine is activated by individual handles. (See Figure 2.5.1) The shift handle must be in neutral position to start your engine. Moving the shift han[...]

23 Outlaw ® 2.6 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. c. T railer s WiTch The trailer switch (Power T ilt) is not to be confused with the Power T rim function. The trailer switch is to be used only when the engine is off. The trailer switch allows the drive unit to be raised for trailering, beaching and launching. T [...]

23 Outlaw ® 2.7 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. t ypiCal t aChOMeter with h Our M eter (F ig 2.7.2) e. i GniTion s huTDoWn s WiTch Figure 2.7.1 shows the ignition shutdown switch, if your boat has one. The purpose of the switch is to shut down the engine if the operator unintentionally leaves the helm station. [...]

23 Outlaw ® 2.8 S eCtiOn 2 • g eneral B Oa t a rrangeMent R Speed changes you. TM. 9. n a viGa Tion anD a nchor l iGhTs Navigation lights must be on while underway from sunset to sunrise or in conditions of reduced vis ibi lit y . "Un der way " me ans the boat is not doc ked or at anchor . Trolling or drifting with engine of f is consi[...]

3.1 23 Outlaw ® R Speed changes you. TM. S eCtiOn 3 • u Sing y Our B Oa t 1. p re -l aunch , l aunch anD p osT - l aunch c hecklisT Listed below are the critical items you must check and do each time you use your boat. It does not list all of the necessary maintenance and service items required to keep your boat running properly . These other it[...]

3.2 S eCtiOn 3 • u Sing y Our B Oa t 23 Outlaw ® R Speed changes you. TM. 3. f uelinG The b oa T The fue l ll cap is lo cat ed on th e por t si de of the boa t (Figu re 3.2.1 ). Do not mista ke the wate r tank ll and waste pump out caps for the gasoline ll cap. Refer to your engine manual for the proper grade of gasoline. b efore f ueli[...]

3.3 23 Outlaw ® S eCtiOn 3 • u Sing y Our B Oa t R Speed changes you. TM. f illinG T he T anks • Check the ll plate label to ensure that fuel is placed ONL Y in the fuel tank. The fuel ll plates are located on the port s ide of your boat (Figure 3.2.1). • Keep nozzle in contact with fuel ll opening at all times during fueling. • L[...]

3.4 S eCtiOn 3 • u Sing y Our B Oa t 23 Outlaw ® R Speed changes you. TM. 3. Close engine compartment. 4. Check fuel level. Be sure you have enough fuel for your trip. Remember the “1/3 Rule”: Use no more than 1/3 of your fuel for outbound trip; use 1/3 of the fuel for return trip; keep 1/3 for reserve in case of emergency (FIG 3.4.1). 5. Ru[...]

3.5 23 Outlaw ® S eCtiOn 3 • u Sing y Our B Oa t R Speed changes you. TM. 8. s hifTinG To D rive The b oa T Bring throttle lever all the way back. Once done, the drive is ready to shift. Move shift lever either forward or reverse. Then move throttle lever forward, the dr ive unit will engage and boat will start to move slowly in either for war d[...]

3.6 S eCtiOn 3 • u Sing y Our B Oa t 23 Outlaw ® R Speed changes you. TM. 10. s TeerinG s YsTeM The steering system is an enclosed push-pull cable that is hydraulically assisted (power steering) at the stern drive end (Fig. 3.6.4). THE CABLE AND ITS CON NE CTI ON S TO THE ST EE RIN G WH EE L AND TO THE OUT DRIVE MUST BE INSPECTED A T LEAST TWICE[...]

4.1 23 Outlaw ® R Speed changes you. TM. S eCtiOn 4 • B ilge & u nder w a ter g ear 1. b ilGe a. f uel & o il s pillaGe Regulations prohibit discharging fuel or oily waste in navigable waters. Discharge is dened as any ac ti on w hi ch ca u se s a lm , sh ee n or d is co lo r at io n on the water surface, or causes a sludge or emul[...]

4.2 23 Outlaw ® S eCtiOn 4 • B ilge & u nder w a ter g ear R Speed changes you. TM. Except for checking the operation of the bilge pump using the ON position, leave the switch in the OFF (AUT O) positio n. In the OFF (AUT O) positi on, whe n the bilge liquid is deep enough to activate the oat switch, the bilge pump turns on and pumps out [...]

4.3 23 Outlaw ® S eCtiOn 4 • B ilge & u nder w a ter g ear R Speed changes you. TM. c. i Mp acT To s Tern D rive The stern drive can be damaged by impact, either wh ile tr ai le ri ng or boat in g. T o min im iz e the po ss ib il it y of impact damage while trailering, keep the stern drive raised to the trailering position. The hydraulic sys[...]

4.4 23 Outlaw ® S eCtiOn 4 • B ilge & u nder w a ter g ear R Speed changes you. TM. f. Install the thrust washer , propeller , continuity washer , thrust hub, propeller nut retainer and the propeller nut onto the shaf. g. Place a block of wood between the gear case and the propeller (Figure 4.4.1) and torque the propeller nut to recommended [...]

23 Outlaw ® 5.1 R Speed changes you. TM. S eCtiOn 5 • F uel S ySteM 1. f uel s YsTeM Sec tio n 3 • Usi ng Y o ur Bo at con tai ns important fueling information. T ake time to read all the fuel related information in the owner ’s manual. The 23 Outlaw standard gasoline fuel system consists of a 80 gallon fuel tank, fuel tank vent, an anti-sip[...]

23 Outlaw ® 5.2 S eCtiOn 5 • F uel S ySteM R Speed changes you. TM. 2. f uelinG p recauTions Ce r ta in pr e ca u t io n s mus t be car e fu lly an d co m pl ete l y observed every time a boat is fueled, even with diesel fuel. Diesel fuel is nonexplosive but it will burn. a. s T a Tic e lecTriciTY anD The f uel s YsTeM There is a danger that sta[...]

23 Outlaw ® 5.3 S eCtiOn 5 • F uel S ySteM R Speed changes you. TM. • Doors, hatches – closed. • Smoking material – extinguished. • Inboard tanks – grounded. • Filler pipe – marked GAS or DIESEL. • Fue l no zz le – in c ont ac t wi th ller pip e to pre ve nt static sparks. • Fill level – ll less than rated capacity [...]

23 Outlaw ® 5.4 S eCtiOn 5 • F uel S ySteM R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK[...]

23 Outlaw ® 6.1 R Speed changes you. TM. S eCtiOn 6 • e leCtriCal S ySteMS 1. e lecTrical s YsTeMs D irecT c urrenT (Dc) The 12 volt direct current (DC) electrical system (similar to that in your car or truck) derives its power from the battery . An engine-dri ven alternato r keeps the battery in a charged condition. The battery voltage is indic[...]

23 Outlaw ® 6.2 S eCtiOn 6 • e leCtriCal S ySteMS R Speed changes you. TM. Protective terminal covers, such as rubber boots on electrical connections, must be in place when engine is operating or when working in the engine compartment. Jumper cables are not ignition-protected. DO NOT US E ju mp er ca bl es in the en gi ne co mp ar tm en t. The e[...]

23 Outlaw ® 6.3 S eCtiOn 6 • e leCtriCal S ySteMS R Speed changes you. TM. Zinc anodes require replacement about every six months, i f the b oat is o perated in salt water . In fresh water , the zinc anodes can be replaced about once a year . If the anodes deteriorate more rap idly than this, there is probably a stray current problem within the [...]

23 Outlaw ® 6.4 S eCtiOn 6 • e leCtriCal S ySteMS R Speed changes you. TM. d rive p uMp (F ig . 6.4.1) TRAILER TRIM BLUE/WHITE RED GREEN/WHITE 14 A WG RED 14 A WG GREEN 14 A WG BLUE 14 A WG PURPLE TRAILER LIMIT SWITCH TO GROUND BLOCK TO ENGINE ST ARTER 8 AWG BLACK 8 AWG RED 100 AMP Note: This drawing contains information proprietary to Baja Mari[...]

23 Outlaw ® 6.5 S eCtiOn 6 • e leCtriCal S ySteMS R Speed changes you. TM. d rive p uMp w / K-p lane t riM t aBS (Fig. 6.5.1) TRAILER TRIM BLUE/WHITE RED GREEN/WHITE TRAILER LIMIT SWITCH TO GROUND BLOCK TO 75 AMP BREAKER 8 A WG BLACK 8 A WG RED 100 AMP PORT T AB STBD T AB 14 A WG BLUE 14 A WG RED 14 A WG GREEN TO GROUND BLOCK TO 75 AMP BREAKER 8[...]

23 Outlaw ® 6.6 S eCtiOn 6 • e leCtriCal S ySteMS R Speed changes you. TM. i gnitiOn S witCh (Fig. 6.6.1) TO ENGINE RUN CIRCUIT 16 A WG PURPLE/BLACK 16 A WG PURPLE/BLACK LANY ARD STOP SWITCH B EXHAUST 12 A WG RED TOEXHAUST BREAKER FROM IGNITION SWITCH ( I ) 16 A WG PURPLE/BLACK TO ENGINE B RUN OFF I B S ST ART 16 A WG YEL/RED TO ST ARTER SOLENOI[...]

6.7 23 Outlaw ® R Speed changes you. TM. (156) SPLASH PROOF CONNECTOR RECEPT ACLE (250) HEAT SEALED QUICK SLIDE RECEPTACLE HEAT SEALED 14-16 NO RING TERMINAL D C A PLUG 4 12 AWG ORANGE # 2 #1 12 AWG ORANGE WITH A RED STRIPE 2 - Way Deutsch DTP Series Plug Plug DTP06-2S Secondary Lock WS-2S # 1 DOCKING LIGHTS #2 12 VOL T PLUG 3 12 AWG BROWN WITH A [...]

6.8 23 Outlaw ® R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK[...]

23 Outlaw ® 7.1 R Speed changes you. TM. S eCtiOn 7 • O ptiOnS & a CCeSSOrieS 1. o pTions & a ccessories l oca Tions Figure 7.1.1 shows the location of some of the components. T ake time to walk through your boat, locate the features, and become familiar with their operation and maintenance. ST ANDARD & OPTIONAL EQUIPMENT LOCA TIONS [...]

23 Outlaw ® 7.2 S eCtiOn 7 • O ptiOnS & a CCeSSOrieS R Speed changes you. TM. 2. a uToMa Tic f ire e xTinGuisher s YsTeM (o pTion ) The 23 Outlaw may be equipped with an automatic f i r e e x t i n g u i s h e r s y s t e m located aft of the engine on th e tr an so m. In th e e ve nt of a re, the he at sensi tive automatic head will rele[...]

23 Outlaw ® 7.3 S eCtiOn 7 • O ptiOnS & a CCeSSOrieS R Speed changes you. TM. a. c anv as c are anD M ainTenance See Sec tion 9, page 9.3 , for ins truc tion s on the car e and maintenance of your canvas. b. T railerinG W iTh c anv as T o trailer your boat with the cockpit cover installed, you must install a mooring cover over the cockpit co[...]

23 Outlaw ® 7.4 S eCtiOn 7 • O ptiOnS & a CCeSSOrieS R Speed changes you. TM. 8. s Tereo s YsTeMs Y ou r 23 Outl aw com es with a Clario n CMD4 AM/FM CD stereo (Fig. 7.4.1) package from Marine Audio. Clarions CM design eliminates the need for after- market housing kits or splash covers, while the silicon oil-dampened suspension ensures smoot[...]

8.1 23 Outlaw ® R Speed changes you. TM. S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe ITEM REQUIRED MAINTENANCE/SERVICE REFERENCE SOURCE BEFORE EVERY USE AFTER FIRST 20 HOURS EVERY 25* OR 50 HOURS EVERY 50* OR 100 HOURS EVERY 6 MOS. OR ANNUALL Y Battery Check water level Owner ’ s Manual p. 6.1 • • • Bilge Area Cle[...]

8.2 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. s uMMar Y G uiDe f or i nspecTion , s er vice anD M ainTenance *Use in salt water or other severe operating conditions requires shorter maintenance/service intervals **May not be on your boat ITEM REQUIRED MAINTENANCE/SERVICE REFERENCE SO[...]

8.3 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. 2. u seful s er vice i nforMa Tion OWNER HOME PORT BOA T NAME REGISTRA TION NUMBER ST A TE HULL SERIAL NUMBER W ARRANTY REGISTRA TION DA TE ENGINE MAKE & MODEL SERIAL NUMBER GEAR MAKE & REDUCTION RA TIO SERIAL NUMBER PROPELLER SIZ[...]

8.4 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. 3. i nspecTion , s er vice anD M ainTenance p roTocol a. b ilGe a rea Many of your boat’ s systems have critical features located in the bilge area. A thorough and organized inspection of the bilge area will address many of these critic[...]

8.5 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. • Check your rst aid kit, making certain it is complete and that the items in it have not passed an expiration date. • Check the signaling equipment and emergency flares. Make sure all items are within their expiration dates. • I[...]

8.6 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. 5. f iTTinG o uT a fTer s ToraGe a. f uel s YsTeM Check the entire fuel system for loose connections, worn hoses, leaks, etc. and repair . This is a primary safety precaution. Ch ec k fue l l in es fo r da ma ge a nd ma ke s ur e that t h[...]

8.7 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. c. M iscellaneous • Che ck al l th ru -h ul l t ti ng s fo r u nob st ru ct ed wat er passage. Be alert for any deteriorated hoses and/or ttings below the water line which might fail in service and admit water . • T est the navi[...]

8.8 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. 8. q uick r eference c hecklisT As the owner/operator of a Baja ® Boat, you are responsible for the safe operation your boat and the safety of your passengers. Always be sure that required documents, navigational equipment and Coast Guar[...]

8.9 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. q uick r eference c hecklisT ( conT ’ D ) *I f en g in e fa i ls t o st a rt , re f er t o t he E ng i ne O wn e r’ s Ma n ua l fo r f ur th er tr ou bl e sh oo ti n g pr oc ed u re s b. p rep arinG To D ep arT anD a fTer l aunchinG G[...]

8.10 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. c. D ep arTinG G eneral 1. Passengers/Crew ................................................... Safely seated with PFDs on or immediately accessible 2. Lines, Fenders and Anchor ..................................... Stowed b oa T s YsTeMs[...]

8.1 1 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. q uick r eference c hecklisT ( conT ’ D ) 3. Ignition .................................................................... Once the motor is cooled down, turn the ignition keys counter clockwise to stop the engine. 4. Engine Operation[...]

8.12 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. 9. a fTer M arkeT e quipMenT c hecklisT Any safe ty or opera tiona l equipm ent adde d to your boat after deliv ery sho uld be chec ked for sea worthi ness and proper working condition. Use the area below to list any equipment and the pr[...]

8.13 23 Outlaw ® S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe R Speed changes you. TM. 10. M ainTenance l oG Follow the recommended maintenance listed on pages 1 & 2 of this section and keep a record of this and ALL maintenance performed on your boat. Date Maintenance Description Engine Hours[...]

8.14 23 Outlaw ® R Speed changes you. TM. S eCtiOn 8 • r equired i nSpeCtiOn , S er viCe , & M aintenanCe M ainTenance l oG (c onT ’ D ) Date Maintenance Description Engine Hours[...]

9.1 23 Outlaw ® R Speed changes you. TM. S eCtiOn 9 • C are & r eFiniShing Y our new boat has been designed to provide you with years of enjoyment and satisfaction. In order to maintain the factory new appearance of your boat, we recommend the use of Y acht Bright ™ products designed specically for pleasure boats. Fol low ing p rop er ?[...]

9.2 S eCtiOn 9 • C are & r eFiniShing 23 Outlaw ® R Speed changes you. TM. • Minor scratches and deeper stains that do not penetrate the gelcoat may be removed by light sanding and bufng. 4. p erManenTl Y M ooreD or D ockeD b oa Ts If permanently moored in salt water or fresh water , your boat will collect marine growth on its bottom. T[...]

9.3 23 Outlaw ® S eCtiOn 9 • C are & r eFiniShing R Speed changes you. TM. 38°C); rinse thoroughly to remove soap. DO NOT USE DETERGENTS. Allow to completely dry . W ash and clean vinyl windows with a warm soap solution. Use a soft cloth or sponge and do not scratch the surface. If you have stubborn cleaning cases, call your dealer for prop[...]

9.4 S eCtiOn 9 • C are & r eFiniShing 23 Outlaw ® R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK[...]

23 Outlaw ® Index R Speed changes you. TM. A Accessories. See Options & Accessories Locations B Bilge 4.1 Blower 4.2 Maintenance 4.2, 8.4 Pump 4.1 Boarding 3.3 Breakers. See Electrical Systems Builder ’ s Plate 1.6 C Canvas 7.2, 9.2 Carbon Monoxide 1.2 Certications CE (Common European) Mark iv NMMA (National Marine Manufacturers Assoc.) i[...]

23 Outlaw ® Index i ndex R Speed changes you. TM. T his P age i nTenTionall y l efT B lank[...]