Harman Stove Company TL300 Bedienungsanleitung

   EP A Certied by OMNI-T est Laboratories      ?[...]

2 Harman TL300[...]

Harman TL300 3 Please read this entire manual before you install and use your new heating appliance. Failure to follow instructions may result in property damage, bodily injury , or even death.  Hearth & Home T echnologies, Inc. 352 Mountain House Road Halifax, P A 17032 ~ U.S.A. Intr oduction 4 Specications 5 Installation 8 V[...]

4 Harman TL300 sERIAL nUMBER Thank you for purchasing the Harman TL300 W ood Stove. W e are condent that you will enjoy the warmth and convenience of your Harman Stove for decades to come. W ith the TL300 you will notice even heat throughout your home and long burn times. This is possible because of Harman’ s special FireDome Non-Catalytic Com[...]

Harman TL300 5 The Harman TL300 meets the U.S. Environmental Protection Agency’ s emission limits for wood heaters sold after July 1, 1990.  W eight Flue Size Log Length Recommended Heating Capacity A verage Emissions Emissons on Low Outside Air Size 525 Lbs 6 inch 18 in. / 20 in. Max 1,500 - 3000 sq. ft. 1.[...]

6 Harman TL300  Andirons Grate Air Control Front Load Door T op Load Door Handle Ash Door Ash Door Latch Front Load Door Latch T op Load Door T op Load Opening[...]

Harman TL300 7 The Stove Doors Y our stove has a large glass-paneled door for loading and re viewing, a separate smaller door for removing ashes, and a top loading door . Front Door Before opening, always check for wood, embers, or ash that may be ready to fall out of the door . T o open the glass door , open bypass damp er rst, by pulli ng f[...]

8 Harman TL300 Clearances Clearance is the empty space required between the stove or chimney connector and the nearest combustible surface or object, such as walls, ceilings, oors, or furniture. Clearance distances may only be reduced by using methods approved by either the CAN/CSA B365 standard (Canada) or NFP A 21 1 (U.S.) Contact your buildin[...]

Harman TL300 9 *Check with your local building codes for clearance. Single W all Pipe - Parallel Installation Single W all Pipe Double W all Pipe  T op V ent to vent ed out side wall with 90 o elbow T op vent vented out back wall with 90 o elbow .    [...]

10 Harman TL300   Chimney Connectors and Chimneys Draft Draft is widely misunderstood. It is important that you, the stove operator , realize that draft is a variable effect , not a given quantity . Stoves and chimneys do not have draft, yet draft is the key to your stove’ s performance. Draft is a force, produced by an opera[...]

Harman TL300 1 1   The Chimney The TL300 must be installed into a chimney approved for use with solid-fuel appliances. In the U.S., the TL300 must be connected to (1) a prefabricated chimney complying with the requirements for T ype HT chimneys in the Standard for Chimneys, Factory-Built, Residential T ype and Building He ati n[...]

12 Harman TL300 Do not burn any fuel other than wood, such as charcoal, which can cause increased carbon monoxide production or overring. Never use highly volatile substances in your stove, such as gasoline, which could cause an explosion. When solid fuels are burned compl etely , they produc e water and carbo n dioxid e. Howev er , in long slow[...]

Harman TL300 13   Standard Ceiling Installation with Factory Built Chimney Cathedral Ceiling Installation with Factory Built Chimney[...]

14 Harman TL300   Minimum Clearance to Unprotected Ceiling 18" Chimney Connector Sealed at Thimble Flue Liner with Re- quired Air Space Minimum of three Sheet Metal Screws per Joint of Chimney Connector Mantel and T rim Protection * Floor Pr otection in Accordance with Solid Fuel Appliance Listing Airtight insulated Clean-[...]

Harman TL300 15   Chimney Br each Fireplace Conversion with Combustible W all Minimum Clearance from Chimney Connector to Un- protected Ceiling Flue Liner with Requir ed Air Space Listed or Approved Thimble Assembly 1" Clearance for Exterior Chimney or 2" Clearance for Interior Chimney and 2" Clearance for NFP A [...]

Harman TL300 16 Combustion in the Harman TL300 is precisely con- trolled and is divided into two parts. During combustion, primary air enters at the bot- tom front of the stove and travels up channels at either side of the front door . This pre-heated air then enters the manifold, located above the front door , where it is released into the rebo[...]

Harman TL300 17  Begin with the bypass damper open, and the air control lever at the maximum setting, all the way to the right. Be sure the ash pan door is closed and latched. Start with a b e d o f crumpled pa pe r an d k i n d l i n g sized about nger width; p l a c e se ve r a l 1 " - 2" [...]

Harman TL300 18  Always remember to open the bypass damper when you are loading, this allows the exhaust gases to pass directly into the ue outlet and reduces the chance of smoke spillage into the room. Rel oadi ng: Onc e you have prep ared and mai ntai ned a thick charcoal bed, and the secondary comb[...]

Harman TL300 19 Glass - Cleaning Sometimes it will be necessary to clean accumulated ash from the glass surface; allowing this ash to remain on the glass for long periods can result in “etching” due to the aci dit y of the ash. The cre osot e whic h accum ula tes on the glass should burn off during hot res. Never clean the glass while it is [...]

20 Harman TL300 The Chimney System Cr eosote When wood is burned slowly , it produces tar and other organic vapors, as well as soot, which combine with expell ed moist ure to form creosote. The creosote vapors condense in the relatively cool chimney ue (associated with a slow burning re). As a result, creosote accumu- lates on the ue linin[...]

Harman TL300 21 Cooking Grill- #1-00-08121 The TL300 offers a unique sta inl ess ste el coo king grill tha t can easily be taken in and out of the stove for easy cleaning. No te : Ple as e us e hea t r es is t an t gloves when handling the cooking grill. Surfaces will be hot enough to cause physical harm. Cozy Scr een- #3-40-06960 Y our Harman TL30[...]

 02/1 1                   [...]

 02/1 1 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .    ?[...]

 02/1 1 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .    ?[...]

 02/1 1 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer .    ?[...]

26 Harman TL300 This page intentionally left blank.[...]

4021-645C 12-29-10 Page 1 of 2 Hearth & Home T echnologies Inc. LIMITED LIFETIME W ARRANTY Hearth & Home T echnologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer . W ARRANTY COVERAGE: HHT warr[...]

4021-645C 12-29-10 Page 2 of 2 W ARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor . A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. • Co[...]

Harman TL300 29 [...]

30 Harman TL300 [...]

[...]

Proudly P rinted On 100% R ecycled P aper[...]