Heat & Glo LifeStyle 6100PLUS Bedienungsanleitung

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 1 Owner ’ s Manual Installation and Operation Models: 6100PLUS Fresh Air Fireplace Installation and service of this appliance should be performed by qualified personnel. Hearth & Home T echnologies suggests NFI certifi ed or factory-trained professionals, or technician[...]

2 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 Read this manual before installing or operating this appliance. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Heat & Glo gas appliance—an elegant and clean alternative to wood burning appliances. The Heat & Glo gas appl[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 3 T able of Contents 1 Listing and Code Approvals 4 A. Appliance Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . 4 B. BTU Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 C. High Altitude Installations . . . . . . . . . . . . . . . . [...]

4 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 1 Listing and Code Appro v als A. Appliance Certifi cation Do NOT use this appliance if any part has been under water . Immediately call a qualifi ed service technician to inspect the appliance and to replace any part of the control system and any gas control which has be[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 5 A. Design and Installation Considerations Heat & Glo vented gas appliances are designed to operate with all exhaust gases expelled to the outside of the build- ing. Check building codes prior to installation. • Installation MUST comply with local, regional, state and [...]

6 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 Note: • Illustrations refl ect typical installations and are FOR DESIGN PURPOSES ONL Y . • Illustrations/diagrams are not drawn to scale. • Actual installation may vary due to individual design preference. Fire Risk Provide adequate clearance: • Around air openings[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 7 B. Construct the Appliance Chase A chase is a vertical boxlike structure built to enclose the gas appliance and/or its vent system. V ertical vents that run on the outside of a building may be, but are not required to be, installed inside a chase. Construction of the chase [...]

8 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 C. Clearances 1 in. (25 mm) min. to perpendicular wall A 3-1/2 in. (89 mm) min. from fireplace opening to perpendicular wall B 48 in. (1219 mm) max. Mantel Leg or Perpendicular W all T op of Appliance Drywall A B Figure 3.4 Clearances to Mantel Legs or Wall Projections (Acc[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 9 A. V ent T ermination Minimum Clearances Fire Risk Explosion Risk • Do not pack air space with insulation or other materials. Maintain vent clearance to combustibles as specifi ed. W ARNING Failure to keep insulation or other materials away from vent pipe may cause fi r[...]

10 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 5 5 V ent Informat ion and Diagrams Note: Refer to the HRV20 0PLUS installation manual for additional installat ion and ven ting instr uctions. Fire Risk Fumes Risk This unit MUST be vented with the HRV200PLUS. • Do not connect to a chimney fl ue. The 6100PLUS will not [...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 1 1 6 Appliance P reparation Do NOT notch into the framing around the appliance spacers. CAUTION Figure 6.1 Proper Positioning, Leveling and Securing of an Appliance A. Securing and Leveling the Appliance Fire Risk • AL W A YS maintain specifi ed clearances around the appl[...]

12 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 A. Fuel Conversion Before making gas connections ensure appliance being in- stalled is compatible with the available gas type. Any natural or propane gas conversions necessary to meet the appliance and locality needs must be made by a quali- fi ed technician using Hearth [...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 13 • A small amount of air will be in the gas supply lines. When fi rst lighting appliance it will take a short time for air to purge from lines. When purging is complete the appliance will light and operate normally . W ARNING Fire Risk Explosion Risk • Gas build-up dur[...]

14 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 A. Recommendation for Wire • Requires 1 10 V AC to be wired to the junction box for proper operation of the appliance. Batter y po lar i t y mu st be c o r rec t or m o dul e d ama ge wi ll occur . CAUTION Shock Risk Explosion Risk Do NOT wire 1 10V to valve. Do NOT wire[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 15 C. System Wiring Note: The 6100 PL US must be elect ricall y wired and grounded in ac cordanc e with loc al codes or , in the absenc e of local codes, with National E lec tr ic Cod e ANS I /N FP A 70 - lat est ed iti on or the Cana dian Elec tri c Cod e, CSA C22. 1. Figure[...]

16 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 HRV200PLUS Control W iring The 6100PLUS is designed to operate as a system with the HRV200PLUS. Six low-voltage wires are required to electrically connect the two appliances. Common 24 gauge solid conductor thermostat wire, or equivalent may be used. EMBER LIGHTS OFF/ON HI[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 17 Figure 8.3 Appliance Circuit Board Wiring[...]

18 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 D. W all Switch This appliance comes with a triple-gang wall switch which controls the following functions: • Flame - On/Off T urns the appliance burner operation on and off. This switch may be overridden by the use of a wall switch, remote control or hearth thermostat c[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 19 Figure 8.6 Junction Box WHT WHT BLK BLK GRN wire inside box Copper ground attached to GRN screw with GRN wire 14/2WG Cover Plate outside firebox Romex Connector Figure 8.5 Junction Box Detail F . Junction Box Installation If the box is being wired from the OUTSIDE of the a[...]

20 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 A. Mantel Projections Figure 9.1 shows the minimum vertical and corresponding maximum horizontal dimensions of appliance mantels or other combustible projections above the top front edge of the appliance. B. Facing Material 1 in. (25 mm) min. to perpendicular wall A 3-1/2 [...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 21 A. Remove the Shipping Materials Remove shipping materials from inside or underneath the fi rebox. Shock Risk Fire Risk Use ONL Y optional accessories approved for this appliance. • Using non-listed accessories voids warranty . • Using non-listed accessories may resul[...]

22 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 Placing the Rock Wool • Place a small amount of 1/2 in. diameter pieces (dime-size) of rock wool on the burner pan so the rock wool touches but does not cover the holes in the burner pan. This will provide the “glowing embers” look. It is not necessary to use the ent[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 23 D. Grate and Log Assembly Place the Grate • Place the grate around the burner . Push back the grate until the left middle piece of the grate comes in contact with the burner assembly . See Figure 10.8. Place the Back Log • Place the back log along the back of the burne[...]

24 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 Fire Risk Burn Risk HOT! DO NOT TOUCH. SEVERE BURNS MA Y RESUL T . CLOTHING IGNITION MA Y RESUL T Glass and other surfaces are hot during operation and cool down. W ARNING • Keep children away . • CAREFULL Y SUPERVISE children in same room as appliance. • Alert child[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 25 Note: The H RV200 PL US can use indoor air instead of t he gas appliance for defrost if t he op tional defrost kit (par t # HRV 99DEFKI T) is in sta ll ed . HRV200PLUS Defrost Mode • The HRV200PLUS demands gas appliance operation for defrost. This occurs when the followi[...]

26 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 B. Lighting the Appliance[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 27 C. After the Appliance is Lit Initial Break-in Procedure When you light the appliance, you may notice that it pro- duces heat which does have an associated odor or smell. If you feel this odor is excessive it may require the initial three to four hour continuous burn on hi[...]

28 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 With proper installation, operation and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualifi ed service person in the diagnosis of a problem and the corrective action to[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 29 Although the frequency of appliance servicing and maintenance will depend on use and the type of installation, a qualifi ed service technician should perform an appliance check-up at the beginning of each heating season. Fire Risk Explosion Risk Inspect external vent cap [...]

30 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 This page intentionally left blank.[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 31 A. Appliance Dimension Diagram Dimensions are actual appliance dimensions. Use for reference only . For framing dimensions and clearances refer to Sec- tion 3. Figure 14.1 Appliance Dimensions 1 4 14 Ref erenc e M ater ia ls 38 in. (965 mm) 36 in. (914 mm) 41 in. (104 mm) [...]

32 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 B. Service Parts List Exploded Parts Diagram Service Parts 6100PLUS Beginning Manufacturing Date: 02/04 Ending Manufacturing Date: Active[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 33 Service Parts List Service Parts 6100PLUS Beginning Manufacturing Date: 02/04 Ending Manufacturing Date: Active 1 Grate 370-361A 370-361A 1 2 Burner Assembly 4041-006 4041-006 1 3 V alve Assembly - Natural Gas 4041-003 4041-01 1 1 4 Light Film 4041-101 4041-101 2 5 36-in. [...]

34 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 Exploded Parts Diagram Service Parts 6100PLUS Beginning Manufacturing Date: 02/04 Ending Manufacturing Date: Active[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 35 Service Parts List Service Parts 6100PLUS Beginning Manufacturing Date: 02/04 Ending Manufacturing Date: Active # Description of Part 6100PLUS 6100PLUS-LP Qty . 1 IPI Pilot-NG 385-510A 1 1 IPI Pilot-LP 385-51 1A 1 2 Orifi ce, Burner #29 582-829 1 2 Orifi ce, Burner #45 5[...]

36 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 C. Optional Components Exploded Parts Diagram Optional Components Service Parts 6100PLUS Beginning Manufacturing Date: 02/04 Ending Manufacturing Date: Active 1 - Remote Control 2 - W all Switch 3 - Essence Series Cabinet Door 4 - Prism Series Cabinet Door 5 - SPCL* Decora[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 37 Optional Components Service Parts 6100PLUS Beginning Manufacturing Date: 02/04 Ending Manufacturing Date: Active # Optional Components 6100PLUS 6100PLUS-LP Qty . 1 Remote Control RC-SMART -HNG RC-SMART -HNG 1 Remote Control - Multi-Function RCT -ML T -HNG RCT -ML T -HNG 1 [...]

38 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 This page intentionally left blank.[...]

Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 39 D. Limited Lifetime W arranty 6100PLUS Gas Appliance Limited W arranty Hearth & Home T echnologies Inc. (“HHT”) extends the following warranty for Heat-N-Glo® 6100PLUS (“Appliance”) products installed in homes in the United States of America and Canada. Dealer[...]

40 Hearth & Home T echnologies • 6100PLUS • 4041-127 Rev D • 09/05 E. Contact Information Hearth & Home T echnologies Inc. 800 W . Jef ferson Lake City , MN 55041 Please contact your Heat & Glo dealer with any questions or concerns. For the number of your nearest Heat & Glo dealer , place call 1-888-427-3973. - NOTES - DO NOT [...]