Alto-Shaam Quickchiller Processing Freezer/Chiller/Refrigeration System manual

PROCESSING FREEZER / CHILLER / REFRIGERATION SYSTEM  PHONE: 262.251.3800 • 800.558.8744 u s a / c a[...]

Delivery ..................................... 1 Unpacking ................................... 1 Safety Procedures and Precautions ................ 2 Installation Site Installation ............................. 3 Clearance Requirements ...................... 3 Installation Requirements ..................... 3 Guide Installation for Trolley Option .[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 1. deLiVery This Alto-Shaam appliance has been thoroughly tested and inspected to insure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to th[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 2. note For equipment delivered for use in any location regulated by the following directive: DO NOT DISPOSE OF ELECTRICAL OR ELECTRONIC EQUIPMENT WITH OTHER MUNICIPAL WASTE. caution Used to indicate the presence[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 3. CLEARANCE REQUIREMENTS 18" (457 mm ) m i n i m u m c l e a r a n c e f r o m h e a t p r o d u c i n g e q u i p m e n t . INSTALLATION REQUIREMENTS    ?[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 4. INSTALLATION REQUIREMENTS The model QC2-3 is a counter mounted unit and must use legs that allow for a 4" (102mm) clearance between the cabinet and the counter. For all other models, install the appliance[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 5. SITE INSTALLATION INSTALLATION QC2-100 Bottom View WATER DRAINAGE A 1" NPS drain is located under the QC2-100. Connect the drain pipe using Teflon tape to discharge through an indirect waste pipe into an [...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 6. SUB TITLE TITLE 5" (127mm) Electrical Connection Cord Length: 9 ' (2743mm) 55-3/4" (1416mm) 27" (686mm) ALTO SHAAM 30" (762mm) 35-1/4" (895mm) with caster option 10-1/4" (260[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 7. SUB TITLE TITLE QC2-20 57 " (1448mm) 36 " (914mm) Cord Length 9 ' (2743mm) 36 " (914mm) 42 " (1067mm) 60 " (1524mm) 36 " (914mm) PRODUCTPAN CAPACITY m a x i m u m c h i l l [...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 8. SUB TITLE TITLE QC2-40 ALTO SHAAM 36" (914mm) 7" (178mm) Electrical Connection Cord Length 9 ft (2743mm) 44" (1118mm) 75" (1905mm) 34" (864mm) 26-7/16" (671mm) 60-7/16" (1534[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 9. SUB TITLE TITLE QC2-100 INSTALLATIO N SITE INSTALLATION 41-1/2" (1054mm) 14" (355mm) Electrical Connection Condensate Drain 51" (1294mm) 93-5/8" (2377mm) 35-1/2" (902mm) 40" (1015[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 10. SUB TITLE TITLE QC2-100R INSTALLATIO N SITE INSTALLATION 41-1/2" (1054mm) 51" (1294mm) 83-1/4" (2114mm) 77-5/8" (1970mm) 8-1/8" (205mm) Condensate Drain ALTO SHAAM Electrical Connecti[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 11. SUB TITLE TITLE MODEL > QC2-3 QC2-20 QC2-40 QC2-100 QC2-100 remote Casters, 3" (76mm) [ s e t o f 4] 5014890 — — — — Casters, 5" (127mm) [ s e t o f 4] 5014751 5014751 5014751 — — HAC[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 12. SUB TITLE TITLE ELECTRICAL INSTALLATION This appliance must be branch circuit protected with proper ampacities, in accordance with the wiring diagram. The Quickchiller must be properly grounded in accordance [...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 13. TITLE OPERATION OPERATING INTRODUCTION The Alto-Shaam ® Quickchiller ™ is a processing refrigeration system designed to rapidly and uniformly decrease the temperature of hot foods to either a chilled or fr[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 14. TITLE OPERATION CHILL PROCESSING CYCLES The Alto-Shaam Quickchiller uses high velocity cold air circulation to remove heat from prepared foods for the purpose of rapidly reducing temperatures through the dang[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 15. TITLE OPERATION ADDITIONAL INFORMATION ➤ Clean the Quickchiller and probes prior to use and make certain all processing modes are operating properly before chilling or freezing foods. ➤ To maintain proper[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 16. TITLE OPERATION  … To rapidly decrease the temperature of foods by internal product probe temperature or time within a range of 24°F to 36°F (-4°C to 2°C). Soft Chill is re[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 17. SUB TITLE TITLE BASIC OPERATION OPERATION  Starting from the o f f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will appear on the display. The compre[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 18. SUB TITLE TITLE caution ADEQUATE SPACING MUST BE ALLOWED BETWEEN PANS FOR PROPER AIR CIRCULATION FOR BOTH PROCESSING AND SUBSEQUENT HOLDING. ADVANCED OPERATION OPERATION The date and time will appear in the d[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 19. SUB TITLE TITLE MANUAL OPERATION  Starting from the o f f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will appear on the display. The compressor will[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 20. ADVANCED OPERATION — PRESET PROGRAMMING OPERATION PRESET PROGRAM OPERATION 1. Starting from the o f f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will ap[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 21. SUB TITLE TITLE chanGinG user settinGs Starting from the of f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will appear on the display. The compressor will b[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 22. 8. HACCP DOWNLOAD (O nly on units with optional HACCP Datalogger ) Insert USB data stick into data port on front of the unit. Display will indicate USB. Press the PROGRAM key and then press the down 6 arrow k[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 23. ADVANCED OPERATION – USER SETTINGS OPERATION 9. PROBE VERIFICATION With the probe verification selected, press the Start key to enter the probe verification mode. The offset and the temperature will display[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 24. TITLE OPERATION FOOD PROBE USE Unpacking Food Probes 1. Cut and remove the plastic ties keeping the probe cables coiled during shipment. When removing the ties, exercise caution to avoid accidentally cutting [...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 25. SUB TITLE TITLE OPERATION FOOD HANDLING GUIDELINES PRODUCT COVERING To maintain sanitation control when loading the Quickchiller, foods should be above 140°F (60°C) and should be tightly covered. A tight co[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 26. TITLE OPERATION PRODUCT CAPACITY PER PAN: Foods for chill or freeze processing should be portioned into shallow pans to a depth not to exceed 2-inches (51mm). The individual pan capacity chart below is provid[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 27. TITLE OPERATION THE FOLLOWING CHART OF PORTION SIZES AND SERVING CAPACITY PER PAN IS PROVIDED AS A GENERAL REFERENCE ONLY. PORTION SIZES and PAN CAPACITIES   ›  [...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 28. TITLE CARE AND CLEANING protecting stainLess steeL surfaces It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely dest[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 29. TITLE INTERIOR CLEANING Remove the optional roll-in cart (trolley) from cart equipped models. Open the Quickchiller door to warm the interior of the cabinet. 1. Remove any loose food debris with a cleaning cl[...]

Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 30. TITLE TROUBLESHOOTING CONTROL ERROR DISPLAYS control d i s p l a y a c t i o n r e q u i r e d Real Time Clock Bad E-60: REAL TIME CLOCK DEFAULTS LOADED, VERIFY CORRECT TIME, POWER CYCLE UNIT TO CLEAR THIS ME[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 31. QC2-3 BOTTOM 1 2 3 4 5 5 6 7 8 9 10 11 12 13 14 Item Part Description Qty. 1 RE-29821 Condensing Unit Duct 1 2 PE-29819 Top Louver Channel 1 3 PE-29830 Compressor Louver 1 4 SW-29823 Pressure Swi[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 32. 1 3 2 4 7 5 6 8 9 10 11 12 13 14 21 20 16 17 18 15 19 4 QC2-3 BOX VIEW Item Part Description Qty. 1 BT-29841 Holding Bracket Ref Line 1 2 PR-34299 Probe Receptacle Assembly 1 3 PR-34298 Probe, Qu[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 33. QC2-3 COIL VIEW 1 2 3 4 5 6 7 8 9 10 11 12 14 15 13 16 Upon installation of drip pan, silicone pan perimeter to interior liner bottom Add plastic edge guard to drip pan 6 Item Part Description Qt[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 34. QC2-3 COMPRESSOR VIEW 1 3 2 4 7 4 5 6 Item Part Description Qty. 1 RE-29861 Condensing Assembly, 1/2 MED R404A 120V 1 2 SW-29823 Pressure Switch 1 3 FI-29862 Dryer, 1/4" Filter with 2nd 1/4&[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 35. QC2-3 CONTROL BOX 2 1 3 4 5 6 7 8 9 11 12 14 15 16 17 10 18 13 1 Item Part Description Qty. 1 BT-29929 Dinrail, End Stop 2 2 BA-34010 Digital Relay 2, Circuit Board 1 3 BA-34009 Digital Relay 1, [...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 36. QC-20 BOTTOM 2 3 4 5 6 6 7 8 1 Item Part Description Qty. 1 PN-29968 Compressor Louver 1 2 FI-29954 Filter Dryer 1 3 VA-29900 Valve, Pressure Regulator 1 4 RE-29947 Compressor, 3/4 HP LO R404A 1 [...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 37. QC-20 BOX VIEW 14 9 12 11 9 10 7 8 4 3 5 1 2 6 15 16 17 18 18 19 13 20 21 20 Item Part Description Qty. 1 CU-29964 Capacitor, 14MFD, 440VAC 1 2 BT-29918 Din Rail 1 3 FU-29926 Fuse. 10 Amp Time De[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 38. QC-20 COIL VIEW 3 10 1 2 17 6 7 8 9 4 5 11 12 13 14 16 15 Item Part Description Qty. 1 RE-29944 Coil, QuickChiller 1 2 PR-34704 Probe Receptacle Assembly 1 3 SN-33541 Cavity Sensor 1 4 BK-24427 M[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 39. 1 2 3 4 4 5 6 8 9 7 QC-20 COMPRESSOR VIEW Item Part Description Qty. 1 FI-29954 Filter Dryer 1 2 VA-29900 Solenoid Valve, Sporlan Pressure Regulator 1 3 RE-29947 Compressor 1 4 VA-29863 Solenoid [...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 40. 3 2 Apply Weather Stripping to Front T op Edge of Panel 4 1 5 5 6 9 7 8 Item Part Description Qty. 1 SC-29933 Bolt, M5 12 2 CC-34682 Control Board 11 3 PI-26098 Pipe, .125" Thick Acrylic Tub[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 41. QC2-40 COMPRESSOR 5 6 2 1 3 4 2 7 Item Part Description Qty. 1 VA-29898 Valve, Liquid Line Solenoid 2 2 SE-29897 Solenoid Valve & Coil, Danfoss, 120V 2 3 VA-29900 Valve, Sporlan Crankcase Pre[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 42. QC2-40 COMPRESSOR HOUSING 2 3 4 5 6 1 Item Part Description Qty. 1 FU-29901 Breaker, 2 Pole 20 AMP, 60Hz 1 FU-29996 Breaker, 2 Pole 30 AMP, 50Hz 1 2 PE-29902 Compressor Louver 1 3 LG-29904 6"[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 43. QC2-40 COIL 2 2 1 Suction Line 1 3 Hot Gas Defrost Line Discharge Line Item Part Description Qty. 1 RE-29905 Coil Assembly, 19x20 2 2 VA-29906 Valve, Expansion 2 3 CD-29860 Wire, 11" (279mm)[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 44. QC2-40 DOOR, LEFT HAND (PRIOR TO JUNE 1, 2012) 1 6 7 4 5 4 3 2 Item Part Description Qty. 1 HG-29913 Upper Hinge, Bracket, Left-Hand 1 2 HD-26967 Handle, Door 1 3 BT-29911 Lower Bracket, Horizont[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 45. QC2-40 DOOR (AFTER JUNE 1, 2012) 1 3 2 1 4 1 3 2 1 4 LEFT-HAND RIGHT-HAND Item Part Description Qty. 1 HG-29992 Hinge, Adjustable 1 2 HL-29840 Food Probe Holder 3 3 GS-29914 Gasket, Door 1 4 HD-2[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 46. QC2-40 INTERIOR 5 4 1 2 3 4 6 Item Part Description Qty. 1 PR-34299 Probe, Receptacle 3 2 PR-34298 Probe, Quick Connect 3 3 PE-29916 Panel, Fan Guard, Right 1 4 SR-29915 Rack, Pan Support 2 5 PE-[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 47. QC2-40 CONTROL PANEL - HINGED LEFT (PRIOR TO JUNE 1, 2012) 12 13 1 2 3 4 5 6 7 8 9 10 16 15 14 11 17 19 18 19 20 Item Part Description Qty. 1 TM-29921 Terminal Block, Pluggable, 180 Deg, 7 Positi[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 48. QC2-40 CONTROL PANEL - HINGED LEFT (AFTER JUNE 1, 2012) 6 5 1 2 3 15 14 7 10 11 8 16 9 12 13 4 17 Item Part Description Qty. 1 TM-29921 Terminal Block, Pluggable, 180 Deg, 7 Position 1 2 TM-29922[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 49. QC2-40 CONTROL PANEL - HINGED RIGHT (AFTER JUNE 1, 2012) 6 5 2 3 4 14 13 7 10 11 8 1 9 12 17 15 16 Item Part Description Qty. 1 SC-29928 Bolt, 6-32x1/2, Philip Truss Head 7 2 TM-29921 Terminal Bl[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 50. QC2-40 FAN 1 2 3 Item Part Description Qty. 1 FA-29853 Motor, Fan Evaporator, 60Hz 2 RE-35856 Motor, Fan Evaporator, 50Hz 2 2 FT-29908 Plastic Collar, 14-1/2" Round 2 3 FA-29907 Blade, 14&qu[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 51. QC2-100 COMPRESSOR 1 2 2 3 4 5 6 7 8 Item Part Description Qty. 1 TE-29986 Tee, Copper, 3/8 x 3/8 x 3/8" ID 4 2 RE-35155 Solenoid Valve & Coil, Danfoss, 120V 2 3 TE-35153 Tee, Copper, 1/[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 52. QC2-100 COIL 1 2 3 4 5 Item Part Description Qty. 1 RE-29905 Coil Assembly, 19x20 1 2 VA-29906 Valve, Expansion 1 3 TE-35153 Tee, Copper, 1/2 x 1/2 x 3/8" ID 1 4 FA-29945 Fan, Axial Evaporat[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 53. QC2-100 DOOR 1 2 3 4 5 6 Item Part Description Qty. 1 HD-26967 Handle, Door 1 2 GS-29994 Gasket, Compression 1 3 GS-29993 Gasket, Door 1 4 HG-29992 Hinge, Adjustable 3 5 SC-29991 Screw, Pan Head,[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 54. QC2-100 INTERIOR, LEFT-HAND VIEW 9 10 11 12 13 1 2 3 4 8 5 6 7 Item Part Description Qty. 1 RE-29983 Condensing Unit, 3HP 208/230V 1 Phase 1 RE-35172 Condensing Unit, 3HP 208/230V 3 Phase 1 2 PN-[...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 55. QC2-100 INTERIOR, RIGHT-HAND VIEW 8 9 10 11 12 1 2 4 3 7 5 6 * not shown Item Part Description Qty. 1 RE-29983 Condensing Unit, 3HP 208/230V 1 Phase 1 RE-35172 Condensing Unit, 3HP 208/230V 3 Pha[...]

parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 56. QC2-100 CONTROL PANEL, UNIT HINGED LEFT 8 12 16 18 17 19 10 9 14 20 5 13 11 4 3 7 1 6 2 15 Item Part Description Qty. 1 CC-34682 Control Board 1 2 5014750 HACCP Data Logger, USB Port, option 1 3 [...]

PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 57. QC2-100 CONTROL PANEL, UNIT HINGED RIGHT 9 12 11 10 13 14 4 7 8 6 5 19 17 16 18 1 2 3 15 Item Part Description Qty. 1 CC-34682 Control Board 1 2 TI-35860 Strap, Transformer Tie Down 1 3 5014750 H[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

[...]

TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me[...]