Weiman Products Deva 100 manual

Deva 100 (8220) W ood-fir ed cookstove OWNER'S MANUAL INSTALLATION AND OPERATING INSTRUCTIONS PLEASE READ THIS ENTIRE OWNER’S MANUAL BEFORE YOU INSTALL AND USE YOUR NEW Deva WOOD STOVE. To reduce the risk of fire, follow the installation instructions. Failure to follow these instructions may result in property damage, bo dily injury, or even[...]

HearthStone Quality Home Heating Products Inc ® 2 Model 8220[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 3 TABLE OF CONTENTS INTRODUCING YOUR DEVA 100 COOKSTOVE ............................................................................ 4 C ODES .............................................................................................................................. .....................[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 4 Intr oducing Y our Deva 100 W ood-fir ed Cookstove Congratulations! You have just invested in a most unique wood burning cook stove – the Deva 100 from HearthStone Quality Home Heating Products Inc®. The Deva 100 Model 8220 is a wood burning cook-stove. At 1.6 cubic feet firebox and 2[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 5 The performance of your stove depends on many variables. Since all installations are unique, the general information and operating procedures presented here can only serve as useful if you have any qu estions; do not hesitate to contact your dealer for additional information. Validate yo[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 6  Never modify this cookstove in any way.  Never burn kiln dried wood, painted or treated wood, solvents, trash, plywood, colored or glossy pape r, artificial logs, cardboard, coal, garbage or driftwood. Especially, do not burn c oal in this stove.  Never Use gasoline type fuel, [...]

HearthStone Quality Home Heating Products Inc ® Model 8220 7 sealed properly.) To tig hten the seal, change the door gasket. Every Season: Have a qualified service technician inspect your chimney and wood burning system. • Dismantle the chimney connecto r and clean it thoroughly. Replace any pieces that show signs of rust or deterioration. • I[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 8 Specifications Oven Capacity: 2.47 cubic feet Firebox Capacity 1.6 cubic feet Maximum Heat Output: 46,000 BTUs per hour of cordwood (based on independent laboratory test results) Maximum Log Length: 17" (43 cm) fuel loading door Height : 33-3/4" (85 cm) Width: 40” (102 cm) De[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 9 Setting Up Y our Deva W ood S tove U NPACKING HearthStone packages your Deva 100 cookstove with the greatest care, so that it ships safely. Under certain circumstances, however, damage can occur during transit and handling. When you receive your cookstove , unpack it carefully, inspectin[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 10 H EARTH R EQUIREMENTS A ND F LOOR P ROTECTION Install your stove on the following:  A non-combustible floor protector that you obtain from your dealer, or any other noncombustible material. A floor protector is any noncombustible surface laid on the floor underneath the stove that ex[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 11 Figure 2. Clearance to Combustibles MINIMUM CLEARANCES TO COMBUSTIBLES (from closest point of stove) Alcove requirements Maximum alcove depth is 48”/122cm Minimum alcove height is 96”/ 2439cm Minimum alcove width is 63”/ 160c m (with single wall connector) Minimum alcove width is [...]

HearthStone Quality Home Heating Products Inc ® Model 8220 12 DOUBLE WALL CONNECTOR SINGLE WALL CONNECTOR CLEARANCE TO COMBUSTIBLES CHIMNEY CONNECTOR V ENTING C OMPONENTS AND C ONFIGURATION C OMPONENTS OF A V ENTING S YSTEM DO NOT CO NNECT THIS UNIT TO A CHIMNEY FLUE SERVING ANOTHER APPLI AN CE The complete venting system consists of several compo[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 13 o Double wall connector (close clearance pipe) which must be used with a listed factory-built “Type HT" chimney and may also be used with a masonry chimney to reduce clearances, is available from several manufacturers, your dealer can help you choose. Some air insulated connector[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 14 Install the stove as c lose as practical to the chimney, while maintain ing all proper clearances. Install stovepi pe that is as short and as straight as possible. Horizo ntal runs of stovepipe should always rise away from the stove a minimum of 1/4" per foot (21mm/m). Long runs of[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 15 Tee Suppor t Bracket Adju stable R oof Wal l S t rap Chase En closure Chim ney S ections Flashing Storm Col lar Chim net C ap Chimney through outer wall with enclosed chas e. Starter section Collar with bu ilt-in Support Box and Trim Two story house instal lation with attic. Fire safe E[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 16 2) Locate and remove the four bolts that hold the block-off pl ate on the back of the stove. Remove the plate. 3) Place the flue collar on the back of the stove over the rear flue exit with the gasket side towards the stove. Rotate the collar so the 3 chimney connector screws are easies[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 17 Chimney height requirements: (See Illustration)  At least 3 feet (0.9 m) higher than the highest part of the roof opening through which it passes.  At least 2 feet (0.6 m) higher than any part of the roof within 10 feet (3 m) measured horizontally from the top of the chimney. This[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 18[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 19 Ash Pan Door Primary Air Control Oven Thermomete r Flue Bypass Fuel Loading Door Oven Door Figure 2 Controls and Features Operating Y our Deva W ood S tove WARNING: DO NOT INSTALL IN A S LEEPING ROOM WARNING: HOT WHILE IN OPERATI ON. KEEP CHILDREN, CLOTHIN G AND FURNITURE AWAY. CONTACT [...]

HearthStone Quality Home Heating Products Inc ® Model 8220 20 PRIMARY AIR CONTROL: This feature is located on the lower portion of the ash door of the stove. The primary air control allows you to regulate the amount of ai r entering the firebox. Generally speaking, the more air allowed into the firebox, the faster and hotter the rate of burn; conv[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 21 B UILDING Y OUR F IRST F IRE Once you understand the cont rols of your wood stove and have chosen th e appropriate firewood, you are ready to start a fire. When you light your first fires, the wood stove will emit some sm oke and fumes. This is normal “off-gassing” of the paints and[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 22 B URN R ATE HIGH BURN: Fully load the firebox with wood on a bed of hot coals or on an actively flaming fire and fully open the pr imary air control. A high burn rate is recommended once or twice a day to fully heat the stovepipe and chimney, which will help minim ize creosote accumulat[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 23 Ashes should NEVER be placed in wooden or plastic containers, or in paper or plastic bags, no matter how long the fire has been out. Coals within a bed of ashes can remain hot for several days once removed from the firebox. MAINTENANCE C REOSOTE F ORMATION A ND N EED F OR R EMOVAL When [...]

HearthStone Quality Home Heating Products Inc ® Model 8220 24 G LASS Do not operate the stove with a broken door glass. Do not abuse th e fuel loading door by striking or slamming it. When necessary, the glass can be cleaned with low alkaline content commercial stove glass cleaners, which are available from your local dealer. Never attempt to clea[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 25 C AST I RON Exterior cast iron parts are porcelainized with an enamel finish. Use a damp sponge to wipe clean. Dry the cast iron thoroughly to prevent rusting. Enamel castings can be cleaned with a standard glass cleaner. With time and use, a very fine, subtle network of cr azed lines m[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 26 T ROUBLESHOOTING G UIDE PROBLEM POSSIBLE CAUSE SOLUTIONS STOVE SMOKES Operating Tec hnique Fully open the primary air contr ol one minute before opening doors . Fully open the flue bypass sytem Cold Chimney Preheat the chimney when first starting a fire. Blocked Chim ney Examine the chi[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 27 R EPLACEME NT P ARTS & O PTIONAL A CCESSORIES PART NUMBER: DESC RIPTION: PART NUMBER: DESCRIPTION: GLASS 3030-050 FUEL LOADING DOOR GLASS MISC. COMPONENTS 3030-051 OVEN DOOR GLASS 91-59710 SIDE ASSEBLY 91-58710 TOP GLASS ASSEMBLY 91-58711 OVEN DOOR ASSEMBLY 91-58712 ASH DOOR ASSEMBL[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 28 S AFETY L ABEL CO NT A CT Y O UR LO CA L BU I L DING O F FICI AL S A BOUT R ES T R I C TI O NS Lis t ed Ro om H ea ter , S olid F uel T y p e Int e r te k Te sti n g Se rvic e s NA , in c . SE R I AL # MO DE L NA ME : DE VA 8 2 2 0 TE S T E D T O: UL 1 482, U L C S 6 27 D o not us e g r[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 29 HEARTHSTONE WOODSTOVE LIMITED WARRANTIES These warranties give you speci fic legal rights. You may also have other rights, which var y from State to State. HearthStone Quality Home Heating Products, Inc. (HearthStone) warrants to the original purchaser only (the “Original Purchaser”[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 30 6. Damage due to installation of the Cookstove in an atmosphere contaminated by dama ging chemicals, including but not limited to chlorine, flu orine or salts. 7. Scratches on glass, enameled surfaces or stones due to mechanical abrasion. 8. Standard wear and tear of the Cookst ove resu[...]

HearthStone Quality Home Heating Products Inc ® Model 8220 31 allow a Dealer to make a service call, HearthStone or a Dealer, as the case may be, will request that the Original Owner return the defective part, or the entire Cookstove (i f needed), with shipping prepaid, to HearthStone or a Dealer. Notwithstanding any other provision of this docume[...]