Bakers Pride Oven CO1-G manual

INST ALLA TION AND OPERA TING INSTRUCTIONS GA S CONVECTION O VEN Model: CO1-G INTENDED FOR OTHER THAN HOUSEHOLD USE RET AIN THIS MANUAL FOR FUTURE REFERENCE OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES IMPORT ANT INSTRUCTIONS After the gas supply has been connected to your unit, it is extremely important to check piping for possible leaks. [...]

I. INST ALLA TION INSTRUCTIONS SECTION ITEM P AGE A Receiving B Set-Up Mounting C Installation with Casters (Optional) D Location and Minimum Clearances E Gas Connection F Electrical Connection G Flue Connections-V entilation H Burner Operation I System Check - Rotary Control II. OPERA TING INSTRUCTIONS 1 General Instructions 2 System Operation Seq[...]

3 observe the clearances detailed in Section D (Location). Provide adequate ventilation and make up air in accordance with local codes. Servicing your oven is done through the front control panel and right side access cover . Assure that these areas are kept unobstructed for easy access. For a single unit: (1) T ilt Oven over onto left hand side, a[...]

E. GAS CONNECTIONS: The ovens should not be installed on the same gas line with space heaters, boilers or other gas equipment with high intermittent demand. The installation of this oven must conform with the latest local codes or Nationa/Fuel Gas Code. ANSI Z223.1, Natural Gas Installation Code. CAN/CGA-BJ49.1. or the Propane Installation Code. CA[...]

installation and thence to an independent earth connection in compliance with EN 60335-1 and/or local codes. The electric motor , all the related switches, interior lights and the timer/buzzer , are all connected through the 6ft (1829 mm) power supply cord located at the rear of the oven. The supply cord must be plugged into a properly grounded thr[...]

II. OPERA TING INSTRUCTIONS 1. GENERAL INSTRUCTIONS: (a) This equipment has an Electronic T emperature Control and Electronic Hot Surface Direct Ignition System. (b) Due to the increased efficiency of this oven, the temperature of standard recipes may be reduced 50°F (30°C). (c) Always load each shelf evenly . Space pans away from each other and [...]

(5) Load the oven with product to be cooked. (6) T urn the timer knob to the desired bake time and timer will start counting down. (7) When timer reaches zero, a buzzer will sound. (8) T urn the T imer knob to '0' position to reset. (9) T urn the thermostat knob to the desired hold temperature. (10) Remove the product from the oven when d[...]

4. SERVICING: NOTE: This appliance must be serviced by an authorized service agent. a) Power supply to the unit must be disconnected before any service is performed. b) Most of the service on the unit can be performed from the front and/or control panel side. c) For proper servicing, access to the Control Panel side of the unit will be required. d)[...]

WHEEL PULLER BOL T 3/8”-HEX BLOWER WHEEL MOTOR SET SCREW (2) ASSEMBL Y OF LEGS (SHOWN WITH OPEN RACK ST AND) 30” CONVECTION OVEN LEGS TOP LEFT ANGLE TOP RIGHT ANGLE 1/2” FLA TW ASHER (4 CORNERS ONL Y) 1/2”-13 x 1” HEX HEAD BOL T (12 REQUIRED) 5/16” FLA TW ASHER (4 REQUIRED) 5/16”-18 HEX NUT (4 REQUIRED) OPEN RACK SHELF RACK SUPPORT 3/[...]

6. ELECTRICAL SCHEMA TIC (ROT AR Y CONTROL) CO1-G Flame Sensor Ignitor Gas Control therm. ignitor valve ground sensor l1 4 3 2 1 P4 P3 P2 P1 120V AC SSAC X 0 - O 0...60' X 0...60' O 0 - 5 4 2 1 NOTO 3 7 6 COM HI LO GC-20 NO COM L2 L1 NO NC ooox ooxo oxoo oxxo 24V 120V BUZZER TIMER M450 1 2 4 S Fan Rotary Switch (Off, Low , High, Cool Down[...]

timer M450 flame rod combination control VR 8205 4 3 2 1 P4 P3 P2 P1 light switch COM NO L2 L1 NC NO C flame sensor ground valve hot thermostat L1-24vac ignitor 3 4 5 6 2 1 7 steam switch steam timer potentiometer blk yel red blu solenoid valve FF PILOT IN 120v 24v ignitor 120V AC 1 2 3 4 S Rotary Switch Door Switch Pilot Light (Thermostat) Pilot L[...]

12 VALVE WATER SOL EN OI D BLU RED YE L BLK A1 H1 H2 A2 BRN A1 BLU 29 BLU 31 BLU H2 B R N H1 BRN POTENTIOMETER STEAM TIMER STEAM SW I T CH 7 1 2 6 5 4 3 BUTT CON N E CT OR STEAM OPT I O N A B D2 BLU RED Purple T2 BLU BLU NC NO 120 V Light s 120 V 2 Speed Mot or VR8605A Thermost at Igni ter GDN Valve Sensor L1 Ign itor Sensor RAM COM HI LO Door Sw. [...]

CO1-G F ull Size Gas Convection Oven Figure B Burners / V alve / Door Chain / Legs (864) 963-3471 (864) 963-5316 (800) 927-6887 customerser vice@bkideas.com fax US & Canada web address OUT IN IN Safety V alve Legs & Open Rack Stand Door Chain Assy Steam Option (Not Shown) Item Part # Description Item Part # Description Burners 7 8 9 10 11 1[...]

Figure A Exterior / Interior / Controls / Doors 95 94 1 2 3 4 5 6 8 10 11 12 13 14 15 17 18 19 20 23 24 25 26 27 28 29 30 31 32 34 35 36 37 38 39 40 41 42 43 44 45 47 46 48 49 9 50 51 52 53 54 56 55 57 58 58 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 74 75 75 75 73 76 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 16 ER BK S A ER BK S A I PE D R I [...]

Exterior / Interior / Controls / Doors I t e m Part # D e s c r i p t i o n I t e m Part # Description Conversion Kit (Natural to LP) Conversion Kit (LP to Natural) 1 E3450X Door Seal, T op or Bottom, each (2) 49 P6007X Elec Line Cord, 250V (UK) 2 E3451K Door Seal, Sides, each (2) 50 N5048P Rear Pipe Connection 3 E3466U Door Closure Strip 51 P1 144[...]

16 WHA T IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated and maintained in accor dance with National an[...]