Hearth and Home Technologies 42 manual

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 Owner ’ s Manual Installation and Operation Models: Montana-36 Montana-42 Woodburning Fireplace DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible [...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 2 Read this manual before installing or operating this replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Outdoor Lifestyles wood burning replace. The Outdoor Lifestyles replace you have se[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started A. Design and Installation Considerations . . . . . . . . . . . . 5 B. T ypical Fireplace Syste[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 4 1 Listing and C od e Appro vals A. Appliance Certication This replace system has been tested and listed in accor- dance with UL 127 and CAN/ULC-S610-M87 standards by Underwriters Laboratories Inc. for installation and operation in the Unit[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 5 2 Get ting Star t ed A. Design and Installation Considerations Draft is the pressure difference needed to vent replaces successfully . Considerations for successful draft include: • Location of replace and chimney Check building code[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 6 Before beginning the installation be sure the following tools and building supplies are available: Reciprocating saw Framing material Pliers High temp caulking material Hammer Gloves Phillips screwdriver Framing square Flat blade screwdriver Ele[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 7 3 F raming and Clearances A. Selecting Fireplace Location This outdoor replace will shed moderate amounts of water , but is not waterproof. W ater and condensing water vapor may enter the chase under certain conditions. The replace wil[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 8 B A H F Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D G G C D H G F J I E Figure 3.1 Fireplace Locations FREEST ANDING INST ALLA TION (Combustible Structure) (Encl[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 9 0 in. 0 in. to level of standoffs Combustible Object 36 in. (914 mm) 1-1/2 in. (38 mm) Drywall 0 in. 1/2 in. (13 mm) 1-1/2 in. (38 mm) B. Clearances Figure 3.3 Clearances to Combustible Materials Fire Risk • Comply with all minimum clearan[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 10 2 in./51 mm minimum air space clearance to the enclosure. Use only noncombustible material below the top of the top standoffs. 28-3/8 in. 721 cm 74-1/2 in. 1892 cm 53- 7/8 in. 1368 cm C. Sidewalls/Surrounds Adjacent combustible side walls must [...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 1 E. Chimney Requirements When planning your replace location, the chimney construc- tion and necessary clearances must be considered. The re- place system and chimney components have been tested to provide exibility in construction[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 12 72 in./183 cm min. TR1 1/TR444 T ermination Cap A. Install the Dual Cooling Air Kit The cooling air kit is supplied as a standard feature with this replace and is required for safe operation. Installation must be done at the time of initial [...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 13 B. Secure the Fireplace • Position the Fireplace This replace may be placed on either a combustible or noncombustible continuous at surface. Follow the in- structions for framing in Section 3.D. Slide the replace into position. B[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 14 A. Chimney Requirements V ertical distances are measured from the base of the re- place. • Minimum overall straight height is 6 ft 4 in. if the replace is fre est andi ng and a min imu m of 10 ft fro m a comb ust ibl e structure. See Fi[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 15 B. Using Offsets/Returns T o bypass any overhead obstructions, the chimney may be offset using an of fset/return. An offset and return may be attached together or a chimney section(s) may be used between an offset and return. Perform the fo[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 16 C. Assemble the Chimney Sections Attach either a straight chimney section or an offset to the top of the replace (depending on your installation require- ment). Chimney sections are locked together by pushing downward until the top section m[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 17 E. Install the Attic Insulation Shield An insulation shield must be installed when there is a pos- sibility of insulation coming into contact with the factory built chimney system. • Be nd the tab s at the to p of the att ic ins ula tio n[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 18 6 Complete the Enclosure Figure 6.1 Multiple Chimneys A. Chimney T ermination Chimney T ermination Requirements (See Figure 6.1) • Must have a cap approved and listed for this replace system • Must not be located where it will become plu[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 19 T ermination Cap Storm Collar Slope Downward T urn-down Drip Edge Chase (Chimney) 2 in. (51 mm) Collar on Chase T op Caulk .018 (26 ga) min. Galvanized Chase T op Figure 6.3 Chase T op Construction B. Chase T op A metal chase top is require[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 20 Not e : T o protect against the ef fect of cor rosio n on t hose par ts exposed to the weather , t he ter mination cap can be painted with a r ust-resist ant paint. Fire Risk • The minimum overlap of cap to pipe MUST be met or chimney may sep[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 21 • TCT1 175 T erra Cotta Cap Chimney Pipe Chase T op T ermination Cap Chase Collar 2 in. (51 mm) Minimum Height Remove 2 screws from front & back to lift the top off T ermination cap pipe and chimney section must overlap 1-1/2 in. (38 [...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 22 A. Gas Log/Lighter Provisions A certied gas log lighter or decorative gas log set can be installed in this replace. This replace was not tested and listed for use with an un- vented gas log heater . Do not install an unvented gas log h[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 23 8 F inishing A. Hearth Extension A hearth extension must be installed with all replaces to protect the combustible oor in front of the replace from both radiant heat and sparks. See Figures 8.1 -8.3. 2 in. (51 mm) required Continuo[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 24 B. Finishing Material • Combustible Material Material which is made of or surfaced with wood, compressed paper , plant bers, plastics, or any material capable of igniting and burning, whether ame proofed or not, plastered or not plaster[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 25 9 Operat ing Instruct ions A. General Information Fireplaces, as well as other woodburning appliances, have been used safely for many years. It has been our experience that most problems are caused by improper installation and operation of [...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 26 D. Flue Damper The  ue damper must be in full open position, and is oper- ated by moving the handle up toward the top of the  replace. Before lighting the  re, verify this by looking up from the in- side of the  replace. Always oper[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 27 G. Grate The factory installed integral grate must be used to hold the logs from falling out of an open replace and to allow air to pass between the burning logs. It is important to keep the re off the hearth and to allow the ashes to[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 28 I. Starting a Fire Check the ue damper to be certain it is in the full open po- sition. Place crumpled or twisted paper under the replace grate. Loosely arrange kindling or small pieces of wood to form a layer above the paper . The res[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 29 Diagnostics and Problem Solving 1 0 T roubleshooting I can’t get a good re going. What am I doing wrong? Diagnostic Questions Possible Causes of Condition Solutions Is the damper open? • No draft Open damper . Is there enough paper/s[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 30 A. Disposal of Ashes Ashes should be placed in a metal container with a tight-t- ting lid. The closed container of ashes should be placed on a noncombustible oor or on the ground, well away from all combustible materials, pending nal d[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 31 Fire Risk • Do not use chimney cleaners or ame colorants in your replace. Will corrode chimney . W ARNING D. Maintenance T ask List Asphyxiation Risk Fire Risk Annual inspection by qualified technician recommended. Check: • Condit[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 32 1 2 Reference Materials A. Fireplace Dimensions C 23 in. [597 mm] D B 9-1/2 in. [241 mm] E Gas Log Knockout (both sides) F 2-3/8 in. [60 mm] Outside Air (both sides) Gas Knockout for Optional Integrated Burner (both sides) Model A B C D E F MON[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 33 B. Fireplace Components Bi-fold Glass Doors Herringbone Pattern Refractory T raditional Brick Pattern Refractory 20 in. (508 mm) 66 in. (1676 mm) 1/2 in. (13 mm) HX4 Hearth Extension 16 in. (406 mm) 52 in. (1321 mm) 1/2 in. (13 mm) HX3 Hear[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 34 C. Chimney Components The following pictures show only those chimney components which may be safely used with this replace. 13 in. (330 mm) 14 in. (356 mm) 14 in. (356 mm) 5-1/4 in. (133 mm) 4 in. (102 mm) CAK5A Chimney Air Kit ID4 Insulated[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 35 A B 17 in. (432 mm) Ceiling Firestop Assembled Diameter: 17 in./432 mm Height: 24 in./610 mm AS10 Straight Attic Insulation Shield 2 in. (51 mm) 13 in. (330 mm) JB577 Chimney Joint Band 13 in. (330 mm) CB576 Chimney Joint Band 39-7/8 in. (1[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 36 72 in. (1829 mm) 36 in. (914 mm) 2 in. (51 mm) 13-3/8 in. (340 mm) CT56 Chase T op A B C D LDS33/LDS46 Decorative Shroud TR1 1/TR444 Round T ermination Cap 15-3/4 in. (400 mm) TR1 1T/TR442 Round T elescoping T ermination Cap 32-3/8 in. (822 mm)[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 37 Woodburning T ermination Cap Shroud TS345/T445 (T op V ent) TR342/TR344 TR442/TR444 TV342 TR342/TR344* TR442/TR444* (* with TR-TVK installed) TR1 1/TR1 1T TV1 1/TV1 1T TR1 1/TR1 1T* (* with TR-TVK installed) OPEN TOP with solid sides and 3 [...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 38 D. Service Parts Service Parts 06/1 1 36” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 Part number list on following page. MONT ANA-36, MONT ANA-36H Beginning Manufacturing Date: Sept 2003 Ending Manufacturing Date[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 39 D. Service Parts (continued) Service Parts 06/1 1 42” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 MONT ANA-42, MONT ANA-42H Part number list on following page. Beginning Manufacturing Date: Sept 2003 Ending Ma[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 40 This page intentionally left blank.[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 41 This page intentionally left blank.[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 42 E. Limited W arranty Outdoor Lifestyles by Hearth & Home T echnologies, Inc.™ Limited W arranty Hearth & Home T echnologies, Inc. (“HHT”) extends the following warranty for all Outdoor Lifestyles by HHT™ brand products (“Produ[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 43 Limited W arranty (continued) • Damages resulting from: (1) failure to install, operate, or maintain the Product in accordance with the installation instructions, operating instructions, and listing agent identification label furnished wi[...]

Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 44 – NOTES – F . Contact Information DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation. • Read, understand and follow these in[...]