Majestic Appliances SC36A manual

SR/SC Series "A" W oodbur ning Fireplace For Models: SR36A SR42A SC36A SC42A For use in U.S./Canada Underwriter's Laboratories Report No. MH6018 DO NOT DISCARD THIS MANUAL: Retain for future use. ™ 7412948 2/04 Rev . 14 Homeowner's Installation and Operating Manual 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 •[...]

2 SR/SC Series "A" Woodburning Fireplace 7412948 Safety Information PLEASE READ THIS MANUAL BEFORE INST ALLING AND USING FIREPLACE. IMPORT ANT : Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty . Description The S[...]

3 SR/SC Series "A" Woodburning Fireplace 7412948 FP590 Fig. 2 SC36A Series specifications and framing. SC36A Series W oodburning Fireplace — Circulating Model ⁵⁄₈ " (16mm) ¹⁄₂ " (13mm) ¹⁄₂ " 36" (914mm) 38 ¹⁄ ₄ " (971mm) 40" (1016mm) ⁵⁄₈ " (16mm) 22³⁄₄ " (578mm) 1³[...]

4 SR/SC Series "A" Woodburning Fireplace 7412948 ⁵⁄₈ " (16mm) ¹⁄₂ " (13mm) ¹⁄₂ " 42" (1067mm) 38 ¹⁄ ₄ " (971mm) 46" (1 168mm) ⁵⁄₈ " (16mm) 22³⁄₄ " (578mm) 1³⁄₄ " (45mm) 38 " (965mm) 24" (610mm) 7³⁄₄ " (197mm) 7¹ ⁄₂ " (191mm) Rec[...]

5 SR/SC Series "A" Woodburning Fireplace 7412948 Chase Installation Insulation methods shown are optional for cold climate, not a requirement for unit operation. FP554 Fig. 5 Fireplace and chase parts identification. T ermination Cap Storm Collar Pan Flashing Draftstop Batt Insulation (cut out around fiestop) Firestop Ceiling Level Nailin[...]

6 SR/SC Series "A" Woodburning Fireplace 7412948 Chimney Requirements - Offset Installations 0000 0 3 " 1 1 " 1000 0 8 ¹⁄₄ " 20" 0100 0 1 1 ¹⁄₄ "2 5 ¹⁄₄ " 2000 0 1 3 ¹⁄₂ "2 9 ¹⁄₄ " 1100 0 1 6 ¹⁄₂ "3 4 ¹⁄₄ " 0010 0 2 0 ¹⁄₄ "4 0 ³⁄₄ " 21[...]

7 SR/SC Series "A" Woodburning Fireplace 7412948 Planning Information Preplanning an installation is very important to ensure safety and to save time and money . An installer must predetermine where a fireplace will be set and how the chimney system will be run. Mounting The Fireplace A fireplace may only be mounted on the following surfa[...]

8 SR/SC Series "A" Woodburning Fireplace 7412948 Insulating Fireplace Enclosure for Cold Climates If you live in a cold climate, it is not required but highly recommended that you insulate fire- place enclosure to eliminate cold air penetration as much as possible. Insulate base of fireplace with a noncombustible insulation rated for a mi[...]

9 SR/SC Series "A" Woodburning Fireplace 7412948 Framing Framing can be constructed before or after the fire- place is set in place, however , most installers build the frame before setting the fireplace. Frame fireplace with 2 x 4 lumber or heavier materials. Refer to framing dimensions in Figures 1, 2, 3 or 4 for basic fireplace specifi[...]

10 SR/SC Series "A" Woodburning Fireplace 7412948 Straight-Up Chimney Installation To mark the centerline of the flue, put the fireplace in final position and measure out from the wall: 9 ¹⁄₄ " (235mm). Mark a spot on the ceiling directly above the fireplace. Draw a line parallel to the back wall through this mark. (Fig. 1 1) Us[...]

11 SR/SC Series "A" Woodburning Fireplace 7412948 NOTE: Safety strips are not required over noncom- bustible floors where all supports at the base of the fireplace are noncombustible. Four (4) nailing flanges are incorporated on each corner of the surround. Bend the nailing flanges out, level the box, then secure it firmly in place by nai[...]

12 SR/SC Series "A" Woodburning Fireplace 7412948 Continue installing the pipe as required until pipe is installed up through the ceiling. At this point, you must install a firestop spacer . Installing the Firestop Spacer in the Ceiling Hole A firestop spacer is used to keep pipe spaced properly and required for safety . Nail the firestop[...]

13 SR/SC Series "A" Woodburning Fireplace 7412948 Install the attic insulation shield with the flanges on its base extending down into the framing hole. Nail each corner of attic insulation shield to the framing members of the ceiling hole using 8d nails. Attic shields are not required at the roof. Continue Installing Pipe to Complete Run[...]

14 SR/SC Series "A" Woodburning Fireplace 7412948 Installing T op Housing or T ermination Follow the installation instructions provided with the chimney termination you have selected. Installing Chimney In a Chase Refer to Page 5, Figure 5 for an illustration of a typical chase installation. CAUTION: T reatment of firestop spacers and con[...]

15 SR/SC Series "A" Woodburning Fireplace 7412948 MA81 Fig. 22 Combustible mantle clearances. 1 ¹⁄₂ " Ref. Combustible materials are permitted within a shaded area shown in Figure 23 titled Minimum W all Clearances. * ** *12" from top of fireplace opening for radiant models 12" from top of grille opening for circulatin[...]

16 SR/SC Series "A" Woodburning Fireplace 7412948 Hearth Installation A hearth extension is required to protect a combustible floor in front of the fireplace. Refer to Figure 23 for minimum dimensions and mounting detail. NOTE: Hearth Extension must not cover the air inlet opening of a fireplace. The hearth extension described in Figure 2[...]

17 SR/SC Series "A" Woodburning Fireplace 7412948 COMMON MA TERIALS AND F ACTORS MA TERIAL K* R MINIMUM THICKNESS EH2416 Common Brick 0.458 5.0 1.09 0.50 in.** 0.10 5.46 in.** (CFM Corporation) R V alue is for ¹⁄₂ inch. * Units of K = BTU/SQ FT/HR/ßF/IN ** Thickness of Listed Material FP533ADD W ARNING: HEARTH EXTENSION MUST BE INST[...]

18 SR/SC Series "A" Woodburning Fireplace 7412948 Installing Line for Gas Logs CFM Specialty Home Products fireplaces are designed to accept a 1/2" (13mm) gas line for installation of an approved gas appliance. (CFM Specialty Home Products manufactures a wide variety of gas logs for use in CFM Specialty Home Products fireplaces.) Be [...]

19 SR/SC Series "A" Woodburning Fireplace 7412948 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. 948 1 2 3 4 5 6 a b c 7 8 9 10 11 12 d 14 13 e SR36A/42A, SC36A/42A SERIES Item/Model Number SR/SC36A SR/SC42A 1. Dam[...]

20 SR/SC Series "A" Woodburning Fireplace 7412948 The following accessories for this appliance are available from your local Majestic Fireplaces distributor . Should you need additional information beyond what your distributor can furnish, contact: CFM Specialty Home Products, 410 Admiral Blvd., Mississauga, Ontario, Canada L5T 2N6, Attn:[...]

21 SR/SC Series "A" Woodburning Fireplace 7412948 Chimney Components Round T op T ermination T op used to terminate chimney at roof. RL TSK8 (Flashing not included.) Round T op T ermination - T op used to terminate chimney at chase. RL TSK8L Extended (Flashing not included.) Flashing Metal finishing required around Contemporary 8-6-12 wit[...]

22 SR/SC Series "A" Woodburning Fireplace 7412948 Chimney Collar Enclosure Installs on the "over the chimney collar" of the CCE-SK fireplace; provides outside air to assist in cooling the chimney system. Attic Insulation Shield Used to prevent insulation from coming in AIS-SK contact with the chimney system. SK8 Chimney Sections[...]

23 SR/SC Series "A" Woodburning Fireplace 7412948 ™ LIMITED W ARRANTY & 30 YEAR PROTECTION PLAN For MAJESTIC FIREPLACES ® PRE-ENGINEERED Fireplace Systems CFM Specialty Home Products warrants its MAJESTIC FIREPLACES® Pre-Engineered Fireplace (“Fireplace”) and the CFM Specialty Home Products supplied firegrate, glass doors, out[...]

410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www .majesticproducts.com • www .vermontcastings.com CFM Specialty Home Products[...]