Charmglow 720-0289 инструкция обслуживания

S t ainless S teel Gas Grill USE AND CARE GUIDE MODEL NO.: 720-0289 FOR OUTDOOR USE ONL Y PLEASE CONT ACT 1-800-913-8999 FOR ASSIST ANCE DO NOT RETURN T O PLACE OF PURCHASE ® ® K15Y06P-1[...]

1 SECTION ONE Safety Instructions…………………………2~6 Placement of the grill………………………6 S E C T I O N T W O Side shelf Assembly………………………7 Side shelf handle Assembly………………..8 Battery assembly……………………………9 Condiment assembly……………………… 9 Propane T ank Ass[...]

2 FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open Lid. 4. If odor continues, immediately call your gas supplier or your fire de p artment. SAFETY INSTRUCTIONS ***** W ARNING ***** FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or[...]

3 W ARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. DO NOT LEA VE THE GRILL UNA TTENDED WHILE COOKING . SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMB OLS, WORDS AND LABELS LP Gas Cylinder must be fitted with Overfill Protection Device (OPD). W ARNING a) DO NOT store a spare LP-gas[...]

4 Keep a spray bottle of soapy water near the gas supply valve and check the conn ections before each use. Do not attempt to light the grill if odor of gas is present. Call for serv i ce 1-800-913 -8999. SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMB OLS, WORDS AND LABELS W ARNING: Always keep your face and body as far awa y from the burner as possible[...]

5 TESTED IN ACCORDANCE WITH ANSI Z21.58a • CSA 1.6a-2006 ST ANDARD FOR OUTDOOR COOKING GAS APPLIANC ES. THIS GRILL IS FOR OUTD OOR U SE ONL Y . Check your local building codes for the proper method of installation. In the absen ce of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFP A 54, or CAN/CGA-B149.1, Natural Gas and prop[...]

6 When using the grill, do not touch the grill rack, burner grate or immediate surroundi n gs as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp pot hold ers on hot surfaces may cause burns from steam. Do not use a t owel or bulky cloth in place of potholders . Do not let potholders touch hot portions [...]

7 SIDE SHELF ASSEMBL Y 1. The screws used to attach the side sh elf are already screwed into the left side burner And right side panel(see the fi gure below).loosen the screws from the left side burner And right side panel, inst all the side shel ves and tighten screws as the figure show below . Attention: The lef t side shelf should be screwed fro[...]

8 SIDE SHELF HANDLE ASSEMBL Y 1. The screws used to attach the side shelf handle are already screwed into the side shelf handle(see the figure below).loosen t he screws from the side shelf handle, align with the holes in the side shelf, and secure into the holes on the right side shelf of the grill. K15Y06P-1[...]

9 BA TTER Y ASSEMBL Y In order to install the battery , remove the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed. CONDIMENT RACK ASSEMBL Y Assemble the condiment rack inside of the lef t door . K15Y06P-1[...]

10 O P E N C L O S E g PROP ANE T ANK ASSEMBL Y 1. Att ach regulator to the propane t ank by turning the regulator handle clockwise (FIGURE 1). 2. T urn off LP supply at cylinder when appliance is not in use. 1. Put the gas tank into the gas tank tray . Then tighten up the gas tank retention kit for fixing the gas tank as shown in the figure 1 belo[...]

11 T O MA TCH LIGHT THE GRILL 1. If the burner will not light after several attempt s then the burner can be match lit. 2. If you’ve just attempted to light the burner with the igniter , allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit extended match or lighter thr[...]

12 Only the pressure regulator and hos e assembly supplied with the grill should be used. An y repl aceme nt pressure, regulator and hose assembly must be specifi ed by the grill manufacturer. This is a liquid propane config ured grill. Do not attempt to use a natural gas supp l y unless the grill has been pre-configured for n atural gas use. T ota[...]

13 PRECAUTIONS A tank of approximately 1 2 inc hes in diameter b y 18-1/2 inches high is the maximum size LP gas tank to use. Y ou must use an OPD gas ta nk which offers an Overfill Prevention Dev ice. This safety feature prevents the tank from being overfilled which can cause malfunction of the LP gas tank, regulator and/or grill. The LP gas tank [...]

14 GENERAL Although all gas conn ections on the grill ar e leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandlin g in shipment, or excessive pressur e unknowingly bein g applied to the unit. Periodicall y check the whole system for leaks following the proce[...]

15  S pecified clearance maint ained 24” from combustibles.  All internal pa ckaging removed.  Knobs turn freely .  Burners are tight and sitting properly on orifices.  Pressure regulator con nected and set for 1 1.2” W .C. LP gas. Gas connections to grill using hose & regulator assembly provided (pre-set for 1 1.0” water c[...]

16 General use of the grill and rotisserie Each main burner is rated at 10,000 BTU/hr . The main grill burners encomp ass the entire cooking area and are side ported to minimize blocka ge from falling grease and debri s. Above the burners are stainle ss steel radiant (flame tamers). The igniter knobs are located on the lower center portion of the v[...]

17 Do not attempt to light t he grill if odor of gas is present. Call for service 1-800-913 -8999. LIGHTING INSTRUCTIONS W ARNING: IMPORT ANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cut s, wear , or abrasion, it must be replaced prior to us e. Do not use the grill if the odor of gas[...]

18 LIGHTING ILLUSTRA TIONS Main& side burner lighting illustration S tep 1: Make sure the lid is open. S tep to light the rotisserie burner: Push and turn the rotisserie knob to ”IGNITE/ON” position and hold for 3~4 seconds, then push electronic ignition button at the same tim e until burner S tep to light the searing burner: Push and turn [...]

19 USING THE SIDE BURNER CARE & MAINTENANCE ST AINLESS STEEL The grill is made from non-rusting and non-magn etic stainless stee l. There are m any differe nt stainle ss steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the di rection of the grain. T o touch up noticeable scratches in the st ainless steel, [...]

20 CARE & MAINTENANCE OF SIDE BURNER SIDE BURNER CLEANING: Clean the exterior of the burner with a wire b ru sh. Clear any cl ogged burner port s with a straightened paper clip. Never enla rg e the burne r ports. Never use a wooden to othpick as it may break of f and clo g the port. ST AINLESS STEEL: There are many dif ferent st ainle ss steel [...]

21 TROUBLE SHOOTING PROBLEM SOLUTION When I light the grill it does not flame immediately . --Make su re you have turn on the gas --Make sure it has spark while yo u are trying to ignite the burner . --Push in for approximately 5 second before to turn and ignite the grill. --Make sure your burn er is clean. Rotisseries burner will not light when th[...]

22 Rotisserie motor will not turn --Check the voltage at the outlet. --If an extension cord is re quired, ensure it is a 16 gauges, grounded cord. --Ensure the on/of f switch is on. --Ensure the load does n ot exceed the 40 pounds operational capacity . --Ensure the spit is fully inserted in the motor . --Ensure there is no encumbrance or d rag. Gr[...]

23 EXPLODED VIEW 38 04 04 82 69 11 13 12 17 53 54 56 66 65 64 63 48 36 37 81 81 81 79 20 31 25 76 05 05 49 41 67 76 70 34 83 26 77 35 81 50 82 39 40 80 79 78 75 74 73 30 29 28 27 68 59 58 57 55 49 47 46 45 44 43 42 37 36 24 23 22 21 19 18 16 15 14 10 09 08 71 51 52 07 06 72 62 61 60 33 32 03 02 01 K15Y06P-1[...]

24 MODEL 720-0289 P ARTS LIST REF# DESCRIPTION Q’TY REF# DESCRI PTION QTY 01 Main Lid 1 44 Light ing rod 1 02 T e mperature G auge 1 45 Door hin ge rod 1 03 Logo 1 46 Door assembly 1 04 Main Lid Handle Heat Insulating cover 2 47 Door handle 1 05 Main Lid Handle Heat Ins ulating Spacer 2 48 C ondiment rack 1 06 Main lid han dle seat 2 49 Drawer ha[...]

25 GRILLING HINTS The doneness of meat, whether rare, m edium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is af fected by the kind of meat, the size and shape of the cut, the temperature of the me at when cooking begins,[...]

26 GRILL COOKING CHART FOOD WEIGHT OR THICKNESS FLAME SIZE APPROXIMA TE TIME SPECIAL INSTRUCTIONS AND TIPS VEGETABLES Slice. Dot with butter o r margarine. W rap in heavy-dut y foil. Grill, turning occasionally . Fresh: Beets C a r r o t s T u r n i p s Medium 12 to 20 minutes Grill, turning once. Brush occasionally with melted butte r or margarine[...]

27 Rare 1 inch High 10 to 15 minutes Remove excess fat from edge. Slash remaining fat at 2-inc h intervals. Grill, turning once. 1-1/2 inch High 14 to 18 minutes Medium 1 inch Medium to 13 to 20 minutes 1-1/2 inch High 18 to 25 minutes Well-done 1 inch Medium 17 to 30 minutes Pork Chop s 1 inch Medium 20 to 30 minutes Remove excess fat from edge. S[...]

28 BBQ SALMON 2 large salmon steaks 2 tbs. oil Salt & pepper 2 oz. thin bacon slices 2 tbs. butter 1 tbs. lemon juice S prig of pa rsley Lemon wedges Note: Substitute catfish, halibut or cod for salmon. Preheat the BBQ Brush the steaks with oil and season with salt and pepper. Place on BBQ grill and cook for 10 minutes, turning steaks over half[...]

29 ½ tsp. salt ½ tsp. celery salt ¼ tsp. garlic powder ½ tsp. pepper ¼ tsp. oregano ¼ tsp. cumin Flour tortillas Lemon Pound flank steak to ¼ inch thickness or flatten chicken breasts. Mix oil, limejuice and seasonin gs in a zip lock bag. Add meat and shake bag to coat the meat. Refrigerate over night or at least 6 to 8 hours. Wrap tortillas[...]

30 LIMITED W ARRANTY MODEL 720-0289 ST AINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrant s to the original consumer purchaser of each Out door Gas Grill that when subject to normal residen tial use, it is free from defect s in workmanship and materials for the periods specified below . This warranty excludes grills used in rent al o[...]