Keating Of Chicago 2000 инструкция обслуживания

1-800-K EA TI NG www .keatingofchicago.com Users Manual M I RA CLEAN ® EL EC T RIC GRIDDL E S E R I E S 2000 R EAD AN D SA VE TH I S MAN U AL F OR FUTUR E R E FE R E NCE. Keep this manual for training new personnel. G EN E RAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 ST AN DARD FEA TUR E S . . [...]

i POST THIS LABEL IN A PR OMINENT L OCA TION ON Y OUR UNIT . W A RNIN G Do not store flammable liquids near this or any other appliance. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE V APORS OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. IMPROPER INST ALLA TION, ADJUSTMENT , AL TERA TION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMA[...]

1 INTRODUCTION GENERAL Keating MIRACLEAN ® Electric Griddles are designed to give maximum production efficiency , delivering high quality food products. The following design features are incorporated into Keating MIRACLEAN ® Electric Griddles. ST ANDARD FEA TURES  MIRACLEAN ® energy efficient plate  Welded st ainless steel perimeter  We[...]

2 II INST ALLA TION This unit must be installed, inspected, calibrated and serviced by qualified and/or certified and licensed service personnel - you may void your Keating warranty if installation is not completed per local, national and Keating specifications. Contact your dealer for assistance. INST ALLA TION Installation must conform with local[...]

3 pages 1 1 - 12 Wiring Diagram) to see if the griddle is connected three phase or single phase. All wires, cords, plugs, receptacles and circuit breakers must be sized adequately for the full load rating of the griddle as specified by local codes or , in the absence of local codes, by the current National Electrical Code ANSI/NFP A 70 or the Canad[...]

4 NOTE: Because of the superior heating characteristics and heat retention properties found in the MIRACLEAN ® Griddle, operating temperatures should be set 10°F to 25°F below conventional griddles. 3. Locate the inverted “V’s” on the front of the griddle cooking plate. Depending on your model you may have from one to six thermostat s. The[...]

5 CLEANING THE GRIDDLE The surface of the MIRACLEAN ® Griddle is very durable and with proper care, following the procedures below , will last many years. A sample of Keating Klenzer , Keating palmetto brush and a 4” scraper are included with each new griddle. 1. Scrape MIRACLEAN ® surface with the Keating Scraper . 2. Clean with potable t ap w[...]

6 A. Griddle Surface With proper care, the MIRACLEAN ® surface and its unique cooking properties will last for many years. However , nicks or dent s in the griddle surface may cause the griddle surface to lift from the depressed area. If nicks are close together , the surface may raise and be torn when a spatula or scraper is used. Care should be [...]

7 V SER VICE DIAGNOSIS A. T rouble shooting The following diagnosis is only to be used as a guide to qualified personnel. Keating recommends that you use a qualified service company . Call 1-800-KEA TING if you need assist ance in locating a qualified service company . PROBLEM PROBABLE CAUSE SOLUTION Griddle won't heat. a No electricity to gri[...]

D 052505 Grease Drawer (Not Shown) 8 VI P ARTS LIST ORDERING P ARTS Parts may be ordered by calling 1-800-KEA TING or your local Keating service company . Y ou may also order on- line at Keating’s p art store, www .keatingofchicago.com Refer to the Keating MIRACLEAN ® Electric Griddle Limited W arranty for complete service and ordering informati[...]

9 T o replace thermostat: • Loosen nut s (#7) • Loosen nut s to Dispersion Plate (if needed) • Slide thermost at bulb through slots pictured in items 2, 3, & 4. • With bulb tight against the plate, tighten all nuts. Figure 6-3 Heating Element Assembly ITEM DESCRIPTION P ART NUMBER QTY 24" DEEP QTY 30" DEEP QTY 33" DEEP 1 [...]

10 Assembly instructions for griddle st and on casters (There is no top on this stand)[...]

11 208 - 240 VOL T WIRING DIAGRAM (3-PHASE CONNECTIONS)[...]

208 - 240 VOL T WIRING DIAGRAM (SINGLE-PHASE CONNECTIONS) 12[...]

13 480 VOL T WIRING DIAGRAM NOTE: Griddles rated at 480 V olts use type D-1 thermostats which include On/Of f switches. Separate On/Of f switches are not provided with these griddles.[...]

14 VIII KEA TING GRIDDLE SPECIFICA TIONS 24" DEEP MODELS 27x24 30x24 36x24 AMPS VOL TS kW SINGLE L1 L2 L3 PHASE 208 4.1 10 17 10 20 220 4.6 1 1 18 1 1 21 240 5.5 1 1 20 1 1 23 AMPS PER LINE-THREE PHASE  2 ELEMENTS (2300 W EACH) AMPS VOL TS kW SINGLE L1 L2 L3 PHASE 208 6.2 17 17 17 30 220 6.9 18 18 18 31 240 8.2 20 20 20 34 AMPS PER LINE-THR[...]

15 30" DEEP MODELS AMPS VOL TS kW SINGLE L1 L2 L3 PHASE 208 5.4 13 22 13 26 220 6.0 14 24 14 27 240 7.1 15 26 15 30 AMPS PER LINE-THREE PHASE  2 ELEMENTS (3000 W EACH) AMPS VOL TS kW SINGLE L1 L2 L3 PHASE 208 8.0 22 22 22 39 220 9.0 24 24 24 41 240 10.7 26 26 26 45 AMPS PER LINE-THREE PHASE  3 ELEMENTS (3000 W EACH) AMPS VOL TS kW SINGLE[...]

16 36" DEEP MODELS AMPS VOL TS kW SINGLE L1 L2 L3 PHASE 208 10.1 28 28 28 48 220 1 1.3 30 30 30 51 240 13.4 32 32 32 56 AMPS PER LINE-THREE PHASE  3 ELEMENTS (3750 W EACH) AMPS VOL TS kW SINGLE L1 L2 L3 PHASE 208 13.4 43 43 28 65 220 15.0 45 45 30 68 240 17.9 49 49 32 75 AMPS PER LINE-THREE PHASE  4 ELEMENTS (3750 W EACH) AMPS VOL TS kW [...]

[...]

SER VICE INFORMA TION If you hav e a service related question call 1-800-KEA TING. Please state the nature of the call; it will ensure speaking with the appropriate person. Hav e your serial and model number av ailable when ordering parts. KEA TING OF CHICA GO, INC. 8901 W . 50th Street, McCook, Illinios 60525-6001 Phone: (708) 246-3000 F AX: (708)[...]