United States Stove 5500M инструкция обслуживания

USSC 1 King/Ashley Pellet Stove Please read this entire manual before installation and use of this appliance. Failure to follow these instructions could result in property damage, bodily injury, or even death. Contact your local building or re ofcials about restrictions and installation inspection requirements in your area. Save these instruc[...]

2 USSC T ABLE OF CONTENTS .............................................................................................. 2 SAFETY PRECAUTIONS ........................................................................................... 3 SPECIFICA TIONS ..................................................................................................[...]

USSC 3 Safety Precautions IMP OR T ANT :  Read  this  ent ire  manu al before  ins tal ling an d op er at ing  th is p ro du ct.   Fa ilu re  to d o s o m ay result in property damage, bodily injury , or even death.  Properinstallationofthis stoveis?[...]

4 USSC Specications HeatOutput 1 48,000BTU/hr . Heating Capacity 2 800-2,000sq.ft. Fuel Burn Rate 3 2.0-6.0lbs./hr . BurnT ime(lowestsetting) 5500/5500M -60hrs. 5500XL -160hrs. HopperCapacity 5500/5500M -150lbs. 5500XL -320lbs. ?[...]

USSC 5 INST ALLA TION OPTIONS       King/Ashley    ?[...]

6 USSC Installation CLEARANCES Y ourKing/Ashley stove has beentested and listed for installationin residential, mobile home,and alcove applications inaccordancewiththeclearancesgiveninFIGURES3-5andT ABLE1. NOTE: Distance “C” on the left -hand side of your King/A[...]

USSC 7 Installation VENTING REQUIREMENTS   ?[...]

8 USSC Installation VENT TERMINA TION CLEARANCES: A) Minimum4-footclearancebeloworbesideanydoororwindowthatopens. B) Minimum1-footclearanceaboveanydoororwindowthatopens. C) Minimum3-footclearancefromanyadjacentbuilding. D) Minimum7-footclearancefrom?[...]

USSC 9 Installation THROUGH THE W ALL INST ALLA TION (RECOMMENDEDINST ALLA TION) T o vent the unit through the wall, connect the pipe adapter tothe exhaustmotoradapter . Iftheexhaust adapteris at least 18-inches above ground level, a straight section of [...]

10 USSC Installation OUTSIDE AIR SUPPL Y (optional) Dependingonyourlocationandhomeconstruction,outsideairmaybenecessaryforoptimalperformance. Metal pipe (solid or exible) must be used for the outside air installation.  PVC pipe is NOT approved?[...]

USSC 1 1 How your stove works Y our King/Ashley  stove utilizes a inclined auger fuel feed system that is operated by a microprocessor controlled digital circuit board.  The digitalcircuit board allows the inclinedauger fuel feed system torun in[...]

12 USSC Control Panel Overview ON/OFF Pressing the “ON” button on the control panel will begin the start-up sequence for the heater .  Fuel will begin to feed through the auger feed system after 3 minutes.  Pressing and holding the “ON”?[...]

USSC 13 UNIT PREP ARA TION After care fully unpac king and readi ng the instruc tions for inst alling your  stove, you will need to perform the followin g steps: Attachtheincludedspringhandletothedoorhandlebyscrewingitoninarespectivelocation. Attac[...]

14 USSC SHUT DOWN PROCEDURE Pressthe “OFF” buttononthecontrolpad toputthestovein shutdownmode. Atthistime,the redlightabove thepad willilluminate.Oncethis isdone,theaugerwillstop feedingpellets,butthedistribution blowerande[...]

USSC 15 Maintenance Operation DAIL Y OPERA TION             ?[...]

16 USSC INTERIOR CHAMBERS Periodicallyremove andclean theburnpot andthe area insidethe burnpothousing. In particularit is advisableto clean out the holes in the burnpot to remove any build up that may prevent air from moving through [...]

USSC 17 Trouble Shooting                     ?[...]

18 USSC Error Code Err1 Err2 Err3 Err4 Err5 Err6 Err7 Err8 Error Descrption Thehighlimittemperaturesensor hastripped. Stoveranoutoffuelduringnormal operation. The stove was unable to reach the  RoomFan Ontemperature withinthe startuptime. The power failed while?[...]

USSC 19 13 5 11 10 1 10 12 10 6 12 7 8 2 4 3 9 9 9 Parts Diagram/List models 5500, 5500M & 5500XL 11 3 2 1 5 6 4 7 9 8 10 12      1 25490 DoorWeldment 1 2 891 166 CeramicGlass 1 3 891 188 GlassRetainer ,T op 1 4 891 186 GlassR[...]

20 USSC Parts Diagram model 5500, 5500M and 5500XL Note: All repair parts (other than Cabinet Sides, Hopper Assy., and Door Assy.) are same for models 5500, 5500M and 5500XL.[...]

USSC 21 Parts List model 5500/5500M/5500XL      1 86624 Burnpot Assembly 1 2 86625 Housing Assy ,Burnpot 1 3 86628 Weldment,ExhaustDuct 1 4 86633 Weldment,Igniter Tube 1 5 80481 IgniterCartridge 1 6 25506?[...]

22 USSC Wiring Diagram GRAY BLACK[...]

USSC 23 Notes[...]

24 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SER- VICE FROM YOUR KING OR ASHLEY, AND ENABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFERENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOW[...]