United States Stove 6039T инструкция обслуживания

USSC 1 851621B CORN & PELLET MUL TIFUEL ST OVE 6039, 6039T OWNER’S MANUAL Installation - Operation - Maintenance Instructions - Repair Parts READ THIS ENTIRE MANUAL , THOROUGHL Y , BEFORE A T TEMPTING TO INST ALL AND/OR BURN YOUR NEW AMERICAN HARVEST CORN AND PELLET MUL TI-FUEL ST OVE. F AILURE T O FOLLOW THESE INSTRUCTIONS MA Y RESUL T IN PR[...]

2 USSC Heat Input, Maixmum 52,200 BTU/HR Heat Output, Maximum , , , , , 48,280 BTU/HR Heating Capacity 1,200 Sq. Ft 0 Fuel Storage Capacity 60 Lbs. Width 29 in./737mm Height 31 in./787mm Depth 28 in./711mm SPECIFICATIONS United States Stove Company ( manufacturer of the American Harvest Multifuel Pellet Stove ) reserves the right to alter products,[...]

USSC 3 6039&6039T ASSEMBLY Assembly 1. Unpack unit and make sure all components are included; (4) Legs, (2) Ash Pan Guide Rails and all hardware for installation. 2. Inside the unit are two(2) Ash Dump Covers located to the left and right of the burnpot. Remove these for leg and guiderail assembly . (See pg. 15 for ash dump cover desciption) 3.[...]

4 USSC Ashes will have to be R emoved from the stov e periodical ly . See cleaning procedure. Y our American Harvest sto v e, due to the natur e of sol id f uels, wi l l r equir e brief periodic at tention. Please do not expect to light your stove and walk away from it. A few moments of adjustment and cleaning from time to time is an important part[...]

USSC 5 FLOOR PROTECTION The American Harvest Multifuel Stove may be installed on a combustible floor , with proper floor protection, or on a masonry hearth. The hearth or noncombustible floor protector must extend a minimum of (6) inches (152mm)in front and (6) inches (152mm) from each side of the ash remo val door . INSTALLATION REQUIREMENTS SHELL[...]

6 USSC CLEARANCES TO COMBUSTIBLES The stove must be installed with the following minimum clearances to side and back wall combustible materials. NOTE: These are minimum clearances to combustible walls established by the testing lab. The amount of room needed on the left side of the unit to access the electrical panel is (6) six inches (152mm). PARA[...]

USSC 7 GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN • • • • • • • • A UL listed 3” or 4” type “PL ” pellet vent exhaust system must be used f or installation and attached to the pipe connector provided on the back of the sto ve. Use a 3” to 4” adapter for 4” pipe. A cap must be used at the termination of type “L ”[...]

8 USSC For installations with horizontal through-the-wall exhaust, it is strongly recommended that the stove combustion air be connected to the outside. If the home is newer or has been tightly insulated it is required to install outside combustion air . Connection to outside the house is REQUIRED for mobile home installations. W e strongly urge us[...]

USSC 9 Locate proper position f or the type “PL ” wall thimble (F). Use a saber saw or keyhole saw to cut a 7 1/4-inch diameter hole through the wall (E) for a 3-inch pipe. For a 4-inch pipe, cut an 8 1/4-inch hole. Install the wall thimble (F)in the hole. The size of hole opening will vary with brand of wall thimble. P osition stove approximat[...]

10 USSC Note: Always check dimensions on unit before cutting hole in wall 3’ Minimum V ertical Pipe Dimensional tolerance ±0.25” 12 1/8 11 3/4 10 1/16 EXHAUST OULET 3" DIA. COMB USTION AIR INTAKE 1 7/8" DIA. 10 1/16 11 5/8 12 E XHAUST OUTLET 3' DIA COMBUSTION AIR INTAKE 1 7/8" DIA 6039 - PEDEST AL UNIT 6039T - LEG UNIT[...]

USSC 11 T ermination Cap Clean Out Cover Te e Wall Thimble 6” Min. Non Combustible Hearth Plate Support Bracket 9” Min. THROUGH THE WALL, VER TICAL PIPE INST ALLA TION WITH TERMINA TION CAP The Hearth Pad is not required under the unit if the floor is noncombustible but is required 6 inches (152mm) beyond the front of the unit and 6 inches (152[...]

12 USSC Y our American Harvest Corn/Pellet Stove comes to you with the glass door installed in place, ready for use. The glass is surrounded on the edges with a gasket and seated in a glass channel. It is held in place with four (2) clips. REMOVAL OF BROKEN OR DAMAGED CERAMIC GLASS Open the door and lift off of hinges. If the door is tight, tap gen[...]

USSC 13 LIGHTING INSTRUCTIONS CAUTION: DO N OT USE CHEMICALS OR FLUIDS TO ST ART THE FIRE HOT WHILE IN OPERA TION. KEEP CHILDREN, CLO THING AND FURNITURE AW AY . CONT ACT MA Y CAUSE SKIN BURNS. • • • • • • • • • Before lighting your American Harvest for the first time, make sure that all items are out of the hopper , ash pan and f[...]

14 USSC SPECIAL CLEANING/OPERATIONAL INSTRUCTIONS: After cleaning or when operating the stove, you need to make sure that “both” clean-outs are in their proper position. If left out or placed incor- rectly , the combustion air is eff ected greatly and the stove will not burn properly . MAINTENANCE INSTRUCTIONS • • • • Surfaces on the fr[...]

USSC 15 FUEL ADDITIVE Chicken Scratch for my Corn Burner? Y es - Cr azy as it may sound, ground Oyster Shells, (calcium carbonate) same as fed to chickens, is the ideal additiv e to promote clean burning, especially when the Corn Fuel is extra high in starch. And it’s available at your local Feed and Seed. The “aver age” mixture is 1/2 pound [...]

16 USSC COMPONENT OPERA TION ST ART OPERA TION END CIRCUIT BOARD FUNCTIONS ST ART -UP SEQUENCE OF EVENTS Once the control panel is turned to on, a timer begins that will start, stop and continue operation of the American Harvest as a preset temperature is achieved. Exhaust Blower Agitator Auger Room Fan Automatic Shutdown Normal Operation S tarts I[...]

USSC 17 Exhaust Blower Agitator Auger Room Fan Automatic Shutdown COMPONENT SHUTDOWN OPERA TION END CIRCUIT BOARD FUNCTIONS continued... SHUTDOWN SEQUENCE OF EVENTS Once the AMERICAN HARVEST has reached the normal operating temperature and switched to the “OFF” position, the unit will continue to operate on a much lower setting for 10 minutes. [...]

18 USSC TROUBLE SHOOTING Unplug stove before performing any maintenance PROBLEM CAUSE: T oo rich air/fuel mixture ? Fire burns with a lazy , orange flame and/or fuel builds up in the firepot. Glass may become dirty . ? Fire goes out or stove shuts down. Fuel may stop feeding. ? Fire goes out or stove shuts down. Fuel may stop feeding. Make sure gla[...]

USSC 19 WIRING DIAGRAM LIMIT[...]

20 USSC REPAIR PARTS DIAGRAM-6039 42 41 4 7 6 51 52 53 50 2 47 22 25 24 23 13 17 18 19 21 20 34 36 37 38 39 40 45 43 44 30 32 26 27 54 16 15 12 55 14 28 29 35 5 3 11 8 9 10 8 48 46 1 31 49 33[...]

USSC 21 K EY PAR T # DESCRIPTION QTY. 1 69516 Feed Door Assembly 1 2 25080MB Latch, Door 1 3 25409MB Pedestal (6039) 1 4 69508MB Pedestal Bottom Weldment (6039) 1 5 25451MB Pedestal Back (6039) 1 6 69478MB Ash Pan Weldment (6039) 1 7 891138 Handle, Brass 1 8 25493 Corner , T rim (6039) 2 9 25468MB P edestal T rim, Front (6039) 1 10 25471MB P edesta[...]

22 USSC K e y Part No. Descritption Qty. 1 25523 Leg, Cast Iron 4 1 a 891216 Leg, Steel (alternate to item 1) - 2 25425 Guide Rail, Ash Pan 2 3 69483B Ash Pan Weldment 1 4 891138 Handle, Brass 1 1 3 2 4 5 6 7 9 10 8 11 2 3 1 6 4 5 K e y Part No. Descritption Qty. 7 83278 #10 Flat Washer 4 8 25465 R etainer , Bottom Glass 1 9 25464 R etainer , T op [...]

USSC 23 Notes[...]

24 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPEND- ABLE SERVICE FROM YOUR AMERICAN HARVEST, AND EN- ABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFER- ENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE [...]