Desa (V)K36EP SERIES Bedienungsanleitung

NA TU RA L GA S M O D E L S ( V ) K3 6 EN S E R I E S P R O P A N E / L P G A S M O D E L S (V ) K3 6 EP S E R I E S W ARNING: Improper installation, adjust- ment, alteration, service, or maintenan ce can cause injury or property damage. Refer to this manual for correct installation and operational procedures. For assistance or ?[...]

www .desatech.com 1 1 1924-01D 2 SAFETY INFORMA TION W ARNING: This product contains and/or generates          cancer or birth defects, or other reproductive harm. IMPORT ANT : Read this owner ?[...]

www .desatech.com 1 1 1924-01D 3 12. Do not use this replace to cook food or burn paper or other objects. 13. Do not use any solid fuels (wood, coal, paper , cardboard, etc.) in this replace. Use only the gas type indicated on replace nameplate. 14. This appliance, when installed, must be electrically grounded in accordance with local code[...]

www .desatech.com 1 1 1924-01D 4 PRE-INST ALLA TION PREP ARA TION    Determine the safest and most efcient location for your DESA direct-vent replace. Make sure that rafters and wall studs are not in the way of the venting system. Choose a location wh[...]

www .desatech.com 1 1 1924-01D 5 FRAMING AND FINISHING Fig ure 4 sh ows typ ica l fr ami ng o f th is r ep lac e. F igu re 5 show s fr am - ing fo r c or ner in sta lla ti on. All mi nim um cl ear anc es mu st be met . For available accessories for this replace, see Accessories on page 32. If you are using a separate combustible mantel piece,[...]

www .desatech.com 1 1 1924-01D 6 Fixed Closed O p en a b l e Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12" (30.5 cm) minimum] B = clearance [...]

www .desatech.com 1 1 1924-01D 7 VENTING INST ALLA TION INSTR UCTIONS NOTICE: Read these instructions completely before attempting installation. These models are tested and approved for use with DESA (direct- ven t) p ip e comp one nt s and ter min at ion s as well as Simps on- Du rav en t direct-vent pipe components and terminations. The venting s[...]

www .desatech.com 1 1 1924-01D 8 Fig ure 10 - Installing Horizontal V ent Cap (Noncombustible Exterior) Wood Screw V ent Cap Apply Mastic to All Four Sides VENTING INST ALLA TION INSTR UCTIONS Continued 2. Direct vent pipe sections and components are designed with special twist-lock connections.   [...]

www .desatech.com 1 1 1924-01D 9 VENTING INST ALLA TION INSTR UCTIONS Continued Figure 1 1 - Installing Siding Standoff (Combustible Exterior) V ent Cap (Horizontal T ermination) Interior W all Surface W all Firestop Horizontal V ent Pipe Figure 12 - Connecting V ent Cap with Horizontal V ent Pipe Screw Cut Siding Away to Fit Standoff Wood Screw Sc[...]

www .desatech.com 1 1 1924-01D 10 Figure 15 - Horizontal T ermination Conguration for Corner Installation Using One 90° Elbow Square T ermination W all Firestop Not to Exceed (H) Limits As Required for (V) See Chart for Pipe Section Required 45° Elbow 90° Elbow 90° Elbow Square T ermination W all Firestop 45° Elbow 12" Minimum Not to E[...]

www .desatech.com 1 1 1924-01D 1 1 SNORKEL TERMINA TION INST ALLA TION Recommended Applications: • Installations requiring a vertical rise on building exterior • Any installation using snorkel termination to achieve one foot above ground Snorkel terminations are available for installations requiring a vertical rise on the exterior of the buildi[...]

www .desatech.com 1 1 1924-01D 12                 No t e: V er ti c al re s tr i ct or m us t b e i n st all e d in a ll ve rti c al in s ta l la tio n s. 1. Determine the route your vertical venting will take. If ceiling joists, roof raft[...]

www .desatech.com 1 1 1924-01D 13 VENTING INST ALLA TION INSTR UCTIONS Continued    Figures 21 through 24 show four dif ferent congurations for verti - cal termination. V enting with T wo 90° Elbow s V ertical (V) Horizontal (H 1 ) + Horizontal[...]

www .desatech.com 1 1 1924-01D 14 VENTING INST ALLA TION INSTR UCTIONS Continued HIGH AL TITUDE INST ALLA TION Y our DESA direct-vent replace has been CSA tested and approved for elevations from 0-2000 feet (USA) and elevations from 0-4500 feet (Canada). When installing this replace at an elevation above 2000 feet (in the USA), you may need t[...]

www .desatech.com 1 1 1924-01D 15 2. Attach green ground wire from power cord to blower housing using screw provided (see Figure 25, page 14). T ighten screws securely . 3. Place the bl ower a gainst the lo wer rea r wall of the rebox outer wrap per wit h th e ex hau st p ort direct ed upward. The blo wer wil l t inside the back opening and b[...]

www .desatech.com 1 1 1924-01D 16 FIREPLA CE INST ALLA TION Continued Figure 29 - Blower Wiring Diagram for Thermostat-Controlled Models 3. Pl ac e th e b lo we r agai ns t t he l o we r re ar wa ll o f the  re bo x ou t er wr ap pe r wit h th e ex hau st p ort di re c te d upw ar d an d the th er m od is c po si ti on ed up nea r t he re pl [...]

www .desatech.com 1 1 1924-01D 17 FIREPLA CE INST ALLA TION Continued Ins tal lat io n must inclu de an equip men t shu tof f val ve , unio n, and plu gge d 1/8" NPT tap. Loca te NPT tap with in reac h for test gaug e hoo k u p. NP T ta p m ust be u pst rea m f rom  rep lac e ( see F igu re 31) . IMPORT ANT : Install main gas valve (equipme[...]

www .desatech.com 1 1 1924-01D 18 Open FIREPLA CE INST ALLA TION Continued Figure 33 - Equipment Shutoff V alve Closed Equipment Shutoff V alve Figure 35 - Checking Gas Joints for Natural Gas Fireplace Figure 34 - Checking Gas Joints for Propane/LP Gas Fireplace Propane/LP Supply T ank Gas V alve Equipment Shutoff V alve Gas Meter Gas V alve Equipm[...]

www .desatech.com 1 1 1924-01D 19 FIREPLA CE INST ALLA TION Continued Removing Glass Door If replacement of glass is necessary , the entire assembly , glass and frame, must be replaced. If glass is broken, wear gloves and tape the remaining fragments onto the frame. 1. Remove screen assembly by pushing the rod either left or right and then down and[...]

www .desatech.com 1 1 1924-01D 20 FIREPLA CE INST ALLA TION Continued      GLOWING EMBERS Each log is marked with a number . These numbers will help you identify the log when installing. It is very important to install these logs exactly as instructed. Do n[...]

www .desatech.com 1 1 1924-01D 21 FIREPLA CE INST ALLA TION Continued 3. Activat e the rem ote hand set batt ery by re moving the insulatin g tab on the back of the handset (see Figure 46). The battery is included pre-installed. 4. Once the battery is activated the unit is ready to use. 5. Close lower louver panel. Figure 46 - Installing Battery in[...]

www .desatech.com 1 1 1924-01D 22 OPERA TING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions           damage, personal injury or los[...]

www .desatech.com 1 1 1924-01D 23 INSPECTING B URNERS Check pilot ame pattern and burner ame patterns often. PILOT ASSEMBL Y The pilot assembly is factory preset for the proper ame. Altera - tions may have occurred during shipping and handling. The pilot is located on the back right hand side of the burner . The ame must envelope 1/4&qu[...]

www .desatech.com 1 1 1924-01D 24 PILOT AND BURNERS • Remove ember material before cleaning burners and replace when cleaning is complete. • Burner and controls should be cleaned with compressed air to remove dust, dirt, or lint. • Use a vacuum cleaner or small, soft bristled brush to remove excess dust, dirt, or lint. LOGS • If you remove [...]

www .desatech.com 1 1 1924-01D 25 TR OUBLESHOO TING Note: All troubleshooting items are listed in order of operation. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control valve lter W ARNING: T urn off heater and let cool before ser- ?[...]

www .desatech.com 1 1 1924-01D 26 TR OUBLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier ’ s instructions. ?[...]

www .desatech.com 1 1 1924-01D 27 SPECIFICA TIONS (V)K36EN SERIES (V)K36EP Series Btu 19,000/27,000 Btu/hr 18,000/26,000 Btu/hr Gas T ype Natural Propane/LP Ignition Electronic Electronic Manifold Pressure 3.5" w .c. 10.0" w .c. Minimum Inlet Supply Pressure 5.5" w .c. 11.0" w .c. Dimension (HxWxD) Fireplace (Actual size of r[...]

www .desatech.com 1 1 1924-01D 28 ILL USTRA TED P ARTS BREAKDO WN MODELS (V)K36EN, (V)K36ENH, (V)K36EP AND (V)K36EPH 6 7 20 17 18 13 2 12 19 8 1 4 1 1 9 14 3 16 5 10-2 10-1 10-8 10-5 10-4 10-9 15 21 10-6 10-3 10-7[...]

www .desatech.com 1 1 1924-01D 29 P ARTS LIST MODELS (V)K36EN, (V)K36ENH, (V)K36EP AND (V)K36EPH This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 27 of this manual. K36EN K36EP VK36EN VK36EP K36ENH K36EPH VK36ENH VK36EPH ?[...]

www .desatech.com 1 1 1924-01D 30 ILL USTRA TED P ARTS BREAKDO WN BURNER ASSEMBL Y MODELS (V)K36EN, (V)K36ENH, (V)K36EP AND (V)K36EPH 7 9 8 12 12 6 1 2 12 5 1 1 12 13 14 15 10 17 19 20 21 18 3 4 5 16 22 23 24 25 26 27 28 29 30[...]

www .desatech.com 1 1 1924-01D 31 P ARTS LIST BURNER ASSEMBL Y MODELS (V)K36EN, (V)K36ENH, (V)K36EP AND (V)K36EPH This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 27 of this manual. KEY NO. P ART NO.    1 1 1[...]

www .desatech.com 1 1 1924-01D 32 A CCESSORIES           Purchase these replace accessories from your local retailer . If they can not suppl[...]

www .desatech.com 1 1 1924-01D 33 NO TES ________________________________________________________________________________________________ ________________________________________________________________________________________________ ________________________________________________________________________________________________ __________________[...]

LIMITED WARRANTY DIRECT -VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of rst purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under this warranty the Bill of Sal[...]