Kenmore TANNIN 625.348261 Bedienungsanleitung

OWNER'S MANUAL MODEL NO. 625.348261 Caution: Read and Follow All Safety Rules and Operating Instructions Before First Use of This Product. If you have questions when installing, operating or main- taining your filter, and when setting the timer, call this toll-free number... 1-800-426-9345 (M - F, 7 am - 8 pm, CST) For repair or replacement pa[...]

I_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_iii_ _ WARRANTY _i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_i_ W A R R A N T Y SEARS RESIDENTIAL WATER FILTER FULL ONE YEAR WARRANTY ON FILTER For one year from the date of purchase, when this filter is installed and maintained in accordance with our instructions, Se[...]

TABLE OF CONTENTS T A B O F C O N T E N SECTION 1 A. B. C. D. WATER FILTER START UP PAGE NO. Safety Guides ........................................ 1-1 Check List of All Step-By-Step Guides to Install ......... 1-2 Program the Timer ................................... 1-3 & 1-4 Sanitizing the Water Filter ............................. 1-5 SECTI[...]

SECTION1 WATER FILTER START UP A. SAFETY GUIDES S C T N • Read all steps, guides and rules carefully before installing and using your new water filter. Follow all steps exactly to correctly install. Failure to follow them could cause personal injury or property damage. Reading this book will also help you to get all of the benefits from your wate[...]

SECTION1 WATER FILTER START UP B. CHECK LIST OF ALL STEP-BY-STEP GUIDES TO INSTALL Refer to the Installation Manual, part number 7146611, for step-by-step guides. To be sure you have done all the steps to install the filter, read the following list. Page numbers referred to are in the Installation Manual. Is the house water flow going INTO the filt[...]

SECTION1 WATER FILTER START UP C. PROGRAM THE TIMER I I;l[_lJ;l=lP;I g_, _Mtt F'ittratMn display / / A UP button DOWN button SELECT button RECHARGE button When the transformer is plugged into the electri- cal outlet a model code is displayed for a few sec- onds followed by a test number (example: J1.1). Then, 12:00 PM and the words PRESENT TIM[...]

SECTION1 WATER FILTER START UP C. PROGRAM THE TIMER 2. SET DAYS TO RECHARGE 3. SET RECHARGE TIME This setting is the number of days the filter will go between recharges. The default setting is 2 days, with a maximum setting of 99. The filter is factory set to begin recharge at 12:00 AM. If a different recharge time is desired, or needed, do the fol[...]

SECTION1 WATER FILTER START UP D. SANITIZING THE WATER FILTER Care is taken at the factory to keep your water fil- ter clean and sanitary. Materials used to make the filter will not infect or contaminate your water suppl)5 and will not cause bacteria to form or grow. However, during shipping, storage, instal- ling and operating, bacteria could get [...]

I SECTION 2 HOW YOUR WATER FILTER WORKS A. FACEPLATE TIMER FEATURES I ;l [_lJ ;] =l[_] S C T RECHARGE NOW For times you expect to use more water than usual, use the RECHARGE NOW feature. Press the RECHARGE button and hold in for three seconds. "RECHARGE NOW" begins to flash in the display and a re- charge starts right away. You will have [...]

I SECTION 2 HOW YOUR WATER FILTER WORKS A. FACEPLATE TIMER FEATURES The default settings for fill (6:00 minutes), brine draw (80 minutes), backwash (12 minutes) and fast rinse (8 minutes) cycles of regeneration are factory set for maximum performance of the filter. Use the following procedures to check for correct cycle times, or to change if desir[...]

I SECTION 2 HOW YOUR WATER FILTER WORKS B. FILTERED WATER, SERVICE AND REGENERATION IMPORTANT: Sears water filters are sometimes installed alone in the water system, but most often other water treating equipment is needed. Always be sure to have your water tested by a qualified testing labo- ratory. If you need help, ask at your Sears store, or cal[...]

I SECTION 2 HOW YOUR WATER FILTER WORKS B. FILTERED WATER, SERVICE AND REGENERATION BRINE RINSE: After a premeasured amount of brine is used, the brine valve closes. Water flow continues as during brining, except for the brine draw. Tannin particles and brine are flushed from the resin tank to the drain. FAST RINSE: Backwash is followed by as fast [...]

I SECTION 3 CARE OF YOUR FILTER A. CHECKING THE SALT STORAGE LEVEL AND REFILLING S C T N Brine (salt dissolved in water) is needed for each and every re- generation. The water for mak- ing brine is metered into the salt storage tank by the filter. How- ever, you must keep salt in the tank. WHEN TO REFILL WITH SALT: Check the salt level a few weeks [...]

I SECTION 3 CARE OF YOUR FILTER C. CLEANING THE FILTER RESIN BED To keep the tannin resin bed clean and working efficientlN do the following at least once each month. thoroughly stirred, pour the solution directly into the brinewell (see key no. 25, page 6-2). Use one gallon of luke warm water (do not use hot water) to fully dissolve 1 cup of soda [...]

SECTION 3 CARE OF YOUR FILTER E. KEEP THE FILTER FROM FREEZING If the filter is installed where it could freeze (sum- mer cabin, lake home, etc.) you must drain all wa- ter from it to stop possible damage caused by freezing. To drain the filter- Ii Close the shutoff valve on the house main wa- ter pipe, near the water meter or pressure tank. 2. Ope[...]

I SECTION 3 CARE OF YOUR FILTER F. BEFORE YOU CALL FOR SERVICE... HELPFUL HINTS CHECKLIST PROBLEM CAUSE CORRECTION NO FILTERED WATER No salt, or salt bridged, in storage tank. FILTER RECHARGES, BUT FILTERED WATER SOMETIMES CONTAINS TANNINS Plumbing bypass valve(s) in "bypass" 3osition. Transformer unplugged at wall outlet, 3ower cable dis[...]

I_ SECTION 4 _ OTHER THINGS TO KNOW Ill [ _'J'llJ-'| =!li_] S C T N A. DIMENSIONS / SPECIFICATIONS BYPASS VALVES SINGLE-PLASTIC PULL STEM J OUTWARD / FOR / Push /" _ Inward / " For _f" Bypass / / o=Iet_ Va I'o_ _ 3-VALVE ._ERVICE Close Bypass Valve Open inlet & Outlet Valves BYPASS Open Bypass Valve Close Inle[...]

I_ SECTION 4 _ OTHER THINGS TO KNOW A. DIMENSIONS / SPECIFICATIONS Pretreatment Needed For Higher Amounts Supply Water Limits Listed MAX, WATER HARDENSS: .............................. 10 gpg Water Softener Water Softener and/or MAX, CLEAR WATER IRON: ............................. 2 ppm Iron Filter MAX, CHLORINE*: ..................................[...]

I_ SECTION 5 _ __ SERVICE TECH. INFORMATION A. WIRING SCHEMATIC S C T N 24VAC TRANSFORMER I r -m POSITION SWITCH IMPORTANT: KEEP THIS MANUAL WITH YOUR WATER FILTER. IF REPAIRS ARE NEEDED, THE SER- VICE TECHNICIAN MUST HAVE THE INFORMATION ON THE FOLLOWING PAGES. 5-1 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

I_ SECTION 5 SERVICE TECH. INFORMATION B. TROUBLESHOOTING ALWAYS MAKE THESE INITIAL CHECKS FIRST 1. Does the time display show the correct time of day? ...If display is blank, check power source to the filter. ...If time is flashing, power was off for over two days. The filter resumes normal operation but re- charges occur at the wrong time. 2. Plu[...]

I_ SECTION 5 SERVICE TECH. INFORMATION B. TROUBLESHOOTING MANUAL ADVANCE DIAGNOSTICS Use the following procedures to advance the filter valve through the regeneration cycles to check op- eration. Remove the top cover to observe cam and switch operation during valve rotation. DISPLAY MUST SHOW TIME AND DAY 1. Press and hold the RECHARGE button for 3[...]

I_ SECTION 5 SERVICE TECH. INFORMATION C. ROTARY VALVE SERVICE IMPORTANT: Before working on the valve, turn off the water supply and disconnect from electrical power• To relieve pressure: •.. THREE VALVE BYPASS: Close the inlet and open a filtered water faucet• Then close the outlet valve and open the bypass valve. •.. SEARS SPECIAL BYPASS:[...]

I_ SECTION 5 _ __ SERVICE TECH. INFORMATION D. WATER FLOW THROUGH THE FILTER VALVE SERVICE CYCLE VALVE OUTLET (FILTERED WATER) INLET (UNFILTERED WATER) TOP DISTRIBUTOR POSITION SWITCH RESIN __ TANK RESIN _BED s 4_ _ 4_,S # kX BOTTOM DISTRIBUTOR Unfiltered water enters the vane inlet port. Internal valve porting routes the water down and out the top[...]

I_ SECTION 5 _ __ SERVICE TECH. INFORMATION D. WATER FLOW THROUGH THE FILTER VALVE BRINING AND BRINE RINSE CYCLES VALVE OUTLET (BYPASS UNFILTERED WATER) ROTOR & DISC VENTURI . NOZZLE DRAIN ; INLET : (UNFILTERED WATER) BRINE FROM SALT STORAGE TANK After fill, timer/switch action allows the motor to turn the rotor and disc into BRINING position.[...]

I_ SECTION 5 _ __ SERVICE TECH. INFORMATION D. WATER FLOW THROUGH THE FILTER VALVE FAST RINSE CYCLE ROTOR & DISC POSITION SWITCH OUTLET DRAIN INLET TOP DISTRIBUTOR ## "'-'_ BOTTOM DISTRIBUTOR POSITION SWITCH During FAST RINSE, the rotor & disc is positioned so water flow enters the resin tank through the top distributor, and [...]

I_ SECTION 6 REPAIR PARTS Kenmore MODEL NO. 625.348261 S C T N 22 26 ----19 20 27 f 28 ._,_ 29 30 31 21 39 ,/ I 32 / 33 37 34 35 36 6-1 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

I_ SECTION 6 REPAIR PARTS Kenmore MODEL NO. 625.348261 KEY PART KEY PART DESCRIPTION NO, NO. NO, NO, 1 7275907 Transformer 22 7180437 2 7259927 Wire Harness 23 0500283 3 7285677 Rep'l Faceplate Timer 24 7082150 4 0900300 Screw, #4 x 1/4" (2 req'd.) 25 7100819 5 7128566 Power Cable Wire Harness 26 7003847 6 7144449 Cover, Controller 2[...]

I_ SECTION 6 REPAIR PARTS Kenmore MODEL NO. 625.348261 17 18 41 40 3O 47 46 / X 43 42 44 19 2O 21 6-3 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

SECTION 6 REPAIR PARTS Kenmore MODEL NO. 625.348261 KEY PART DESCRIPTION NO, NO. 1 7070412 Screw, #4 - 24 x 1 - 1/8 in. 2 7117816 Spacer 3 7030713 Switch 4 7077472 Expansion Pin 5 7074123 Screw, #10 14 x 2 in. (5 req'd) 6 7085263 Valve Cover 7 7082087 Wave Washer 8 7199232 Rotor & Disc 9 7199729 Cap 10 7170262 O-ring Seal, 1-1/8 in. x 1-3/[...]

SECTION 6 REPAIR PARTS NOTES 6-5 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

SECTION 6 REPAIR PARTS NOTES 6-6 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

Your Home For repair-in your home-of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner's manuals that you need to do-it-yourself For Sears professional installation of home appliances and items like garage door op[...]