Kenwood TK-7180 Bedienungsanleitung

© 2004-7 PRINTED IN JAPAN B51-8691-00 ( N ) 1007 VHF FM TRANSCEIVER TK- 7 1 80 SER VICE MANU AL Panel assy (A62-1094-23) Key top (K29-9312-21) Cabinet (A01-2194-11) Microphone (T91-0639-05) GENERAL .................................................................. 2 SYSTEM SET-UP ...................................................... 3 REALIGNMENT[...]

TK- 7 1 80 2 INTRODUCTION SCOPE OF THIS MANUAL This manual is intended for use by experienced techni- cians familiar with similar types of commercial grade commu- nications equipment. It contains all required service informa- tion for the equipment and is current as of this publication date. Changes which may occur after publication are covered by [...]

TK- 7 1 80 3 SERVICE This radio is designed for easy servicing. Refer to the schematic diagrams, printed circuit board views, and align- ment procedures contained in this manual. NOTE • If you do not intend to use the speaker 3.5-mm jack and the D-sub 25-pin connector, fit the supplied speaker-jack cap and D-sub cap to stop dust and sand from get[...]

TK- 7 1 80 4 1. Modes Mode Function User mode For normal use. Panel test mode Used by the dealer to check the funda- mental characteristics. Panel tuning mode Used by the dealer to tune the radio. PC mode Used for communication between the radio and PC (IBM compatible). Data programming Used to read and write frequency data mode and other features [...]

TK- 7 1 80 5 5-2. Connection procedure 1. Connect the transceiver to the personal computer with the interface cable. 2. When the POWER switch on, user mode can be entered immediately. When PC sends command the radio enter PC mode, and “PROGRAM” is displayed on the LCD. When data transmitting from transceiver, the red LED is lights. When data re[...]

TK- 7 1 80 6 3. How to enter the password with the microphone keypad; If you press a key while “CLONE LOCK” is displayed, the number that was pressed is displayed on the transceiver. Each press of the key shifts the display in order to the left. When you enter the password and press the [ ✳ ] key, “CLONE MODE” is displayed if the entered [...]

TK- 7 1 80 7 2. Radio Interface Cable (KCT-40 : Option) The KCT-40 connection cable kit is used to connect the TK-7180 transceiver to the KDS-100 (Mobile data terminal), KGP-2A (Modem GPS receiver), KGP-2B (Modem GPS con- troller) or through the KCT-36 extension cable. 2-1. Connecting the KCT-40 cable to the transceiver 1. Remove the D-sub cap on t[...]

TK- 7 1 80 8 r CN2 u t E37-1113-05 y 3. Horn Alert/P.A. Relay Unit (KAP-2 : Option) The Horn alert (max. 2A drive), Public address and External speaker function are enabled by installing the KAP-2 in the TK-7180 transceiver. 3-1. Installing the KAP-2 unit in the transceiver 1. Remove the cabinet, top packing and shielding plate of the transceiver. [...]

TK- 7 1 80 9 ■ Install the KRK-10 rear panel onto the front panel 6. Insert the flat cable attached to the interface unit (B/2) of the KRK-10 rear panel (A82-0056-01) into the connector (CN902) of the display unit of the panel ( o ). (The flat cable has been pre-inserted in the connector (CN2) of the rear panel at the time of shipping.) Note : Th[...]

TK- 7 1 80 10 5. Voice Guide & Storage Unit (VGS-1 : Option) 5-1. Installing the VGS-1 unit in the transceiver 1. Remove the cabinet, top packing and shielding plate of the transceiver. 2. Attach two cushions to VGS-1 as shown in Figure 5. ( q ) Note : Be sure not to cover the connector with the bottom cushion. 3. Insert the VGS-1 connector (CN[...]

TK- 7 1 80 11 8. GPS Receiver Connection 8-1. Installing the GPS receiver 1. Remove the cabinet, top packing and shielding plate of the transceiver. 2. Remove the front panel from the transceiver. 3. Attach two cushions to the top of the GPS receiver. 4. Attach the GPS receiver to the shield case with two cush- ions as shown in Figure 8-2. 5. Solde[...]

TK- 7 1 80 12 CN1 CN403 GPS receiver VGS-1 8-2. Installing the GPS receiver together with the VGS-1 1. Remove the cabinet, top packing and shielding plate of the transceiver. 2. Remove the front panel from the transceiver. 3. Attach a cushion to the bottom of the VGS-1 as shown in Figure 8-5. Note : Be sure not to cover the connector with the cush-[...]

TK- 7 1 80 13 ■ Removing the speaker hardware fixture (J21-8481-03) and holder (J19-5468-03) 1. Remove the speaker lead from the holder hook. ( q ) 2. Remove the speaker connector from the display unit con- nector (CN901). ( w ) 3. When removing the speaker hardware fixture, insert a flat- head screwdriver at the position shown in Figure 2-1 and [...]

TK- 7 1 80 14 ■ Top packing installation procedure 1. Place the top packing over the shielding plate. 2. Fit the convex tab of the top packing into the hollow of the chassis. ( q ) 3. Fit the chassis into the groove of the top packing. ( w ) Verify that the top packing is in close contact with the chassis. q w ■ Securing the Audio IC (IC417) wi[...]

TK- 7 1 80 15 q w Spacer Speaker Speaker holder r e ■ Installing the holder (J19-5468-03) and speaker hardware fixture (J21-8481-03) 1. Insert two tabs of the holder (J19-5468-03) into the hol- lows in the top of the panel. ( q ) 2. Push the two tabs of the holder in on the opposite side of those in step 1 above and fit them into the hollow in th[...]

TK- 7 1 80 16 1. Outline The TK-7180 is a VHF/FM transceiver designed to operate in the frequency range of 136 to 174MHz. Transmission out- put power is 30 watts. The maximum channel capacity is 512. The unit consists of receiver, transmitter, phase-locked loop (PLL) frequency synthesizer, and control circuits. 2. Receiver Circuit The receiver is d[...]

TK- 7 1 80 17 2-5. Squelch Circuit The output signal from IC172 enters FM IC again, then passed through a band-pass filter. The noise component output from IC172 is amplified by Q175 and rectified by D173 to produce a DC Voltage corre- sponding to the noise level. The DC voltage is sent to the analog port of the CPU (IC404). IC172 outputs a DC volt[...]

TK- 7 1 80 18 4. Frequency Synthesizer Unit 4-1. Frequency Synthesizer The frequency synthesizer consists of the TCXO (X301), VCO, PLL IC (IC301) and buffer amplifiers. The TCXO generates 16.8MHz. The frequency stability is 2.5ppm within the temperature range of –30 to +60 ° C. The frequency tuning and modulation of the TCXO are done to apply a [...]

TK- 7 1 80 19 6. Power Supply Circuit The block diagram of the power supply circuit is shown in Figure 6. Power is always supplied from +B to the circuit (5M, +B) that is always started and the circuits (SB, 8C, 5E, 8T, 8R, 5C, 5R) controlled by the CPU (IC404). When +B is supplied to the transceiver, Q801, D805 and IC805, regulate the voltage (5M)[...]

TK- 7 1 80 20 Pin No. Port Name I/O Function 1V R E F- +5V 2 AVCC - +5V 3 SBC O Switched B control 4 RXC O RX control 5 TXC O TX control 6P CO TX APC adjust 7 HSDO O High speed data output 8 STSW O Side tone switch 9 RTCL/EEPCL O RTC/EEPROM clock 10 HSDIN I High speed data input 11 NC - Non-connection 12 RTDT/EEPDAT I/O RTC/EEPROM data 13 BYTE - +5[...]

TK- 7 1 80 21 Pin No. Port Name I/O Function 1~4 NC - Non-connection 5 SHIFT O Beat shift 6B Y T E- +5V 7 CNVSS - GND 8,9 NC - Non-connection 10 RST I Reset 11 Xout O 14.7456MHz clock output 12 GND - GND 13 Xin I 14.7456MHz clock input 14 VCC - +5V 15 NMI - +5V 16 BLC2 O MIC backlight control 17 BLC1 O Key & LCD backlight control 18 DIMM O Dimm[...]

TK- 7 1 80 22 Display unit (X54-3480-10) Ref. No. Part Name Description IC901 IC Voltage regulator/ 5V IC902 IC Microprocessor IC903 IC LCD driver Q901,902 Transistor HOOK switch Q904 Transistor TX indication LED switch Q905 Transistor BUSY indication LED switch Q906 Transistor Dimmer switch control Q907 Transistor Dimmer switch Q909 Transistor Bac[...]

TK- 7 1 80 23 Ref. No. Part Name Description Q410,411 Transistor MIC AGC Q412 FET AF mute switch Q413,414 FET AF switch Q415 FET AF switch (Voice) Q416,417 FET MIC mute switch Q418 Transistor AF mute control switch Q419 Transistor AF mute switch Q421 Transistor MIC mute switch Q701,702 Transistor Inverter switch Q801 Transistor Voltage regulator/ 8[...]

TK- 7 1 80 24 P ARTS LIST ✽ New Parts. indicates safety critical components. Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. L : Scandinavia K : USA P : Canada Y : PX (Far East, Hawaii) T : England E : Europe Y : AAFES (Europe) X : Australia [...]

TK- 7 1 80 25 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts R927-935 RK73HB1J102J CHIP R 1.0K J 1/16W R936 RK73HB1J103J CHIP R 10K J 1/16W R939 RK73GB1J472J CHIP R 4.7K J 1/16W R940 RK73HB1J101J CHIP R 100 J 1/16W R941 RK73HB1J102J CHIP R 1.0K J 1/16W R942 R[...]

TK- 7 1 80 26 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts C175 CC73GCH1H120J CHIP C 12PF J C176-178 CK73GB1H102K CHIP C 1000PF K C181 CK73GB1H102K CHIP C 1000PF K C182,183 CK73GB1H103K CHIP C 0.010UF K C184 CK73GB1H102K CHIP C 1000PF K C185 CK73GB1H103K CH[...]

TK- 7 1 80 27 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts C406 CC73GCH1H0R3B CHIP C 0.3PF B C407 CK73GB1H103K CHIP C 0.010UF K C408,409 CC73HCH1H150G CHIP C 15PF G C410-412 CK73GB1C104K CHIP C 0.10UF K C413 CC73GCH1H102J CHIP C 1000PF J C420,421 CC73GCH1H1[...]

TK- 7 1 80 28 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts C585-587 CC73GCH1H101J CHIP C 100PF J C588 CK73GB1H102K CHIP C 1000PF K C591 CK73GB1C104K CHIP C 0.10UF K C592,593 CC73GCH1H070D CHIP C 7.0PF D C594 CK73HB1H102K CHIP C 1000PF K C595 CC73GCH1H101J C[...]

TK- 7 1 80 29 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts L701,702 L92-0140-05 FERRITE CHIP X171 L77-1762-05 CRYSTAL RESONATOR (44.395MHZ) X301 L77-1952-05 TCXO (16.8MHZ) X401 L77-1802-05 CRYSTAL RESONATOR (32768HZ) X403 L77-1965-05 CRYSTAL RESONATOR (3.68[...]

TK- 7 1 80 30 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts R310 RK73GB1J331J CHIP R 330 J 1/16W R311,312 RK73GB1J102J CHIP R 1.0K J 1/16W R313 RK73GB1J472J CHIP R 4.7K J 1/16W R314,315 RK73GB1J223J CHIP R 22K J 1/16W R316 RK73GB1J474J CHIP R 470K J 1/16W R3[...]

TK- 7 1 80 31 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts R509 RK73GB1J333J CHIP R 33K J 1/16W R511 RK73HB1J152J CHIP R 1.5K J 1/16W R512 RK73GB1J153J CHIP R 15K J 1/16W R513 RK73GB1J564J CHIP R 560K J 1/16W R514 RK73GB1J183J CHIP R 18K J 1/16W R515 RK73GB[...]

TK- 7 1 80 32 P ARTS LIST Ref. No. Address Parts No. Description Desti- nation New parts Ref. No. Address Parts No. Description Desti- nation New parts R808,809 RK73GB1J473J CHIP R 47K J 1/16W R811,812 RK73GB1J103J CHIP R 10K J 1/16W R813 RK73GB1J472J CHIP R 4.7K J 1/16W R814 RK73GB1J473J CHIP R 47K J 1/16W R815 RK73GB1J683J CHIP R 68K J 1/16W R816[...]

TK- 7 1 80 33 EXPLODED VIEW 3 2 1 B A Right Side Front Rear 1 16 23 25 22 15 24 17 27 11 12 54 10 29 8 30 42 28 4 31 7 21 26 41 20 20 20 20 105 101 103 102 106 47 2 40 51 45 43 13 IC1 Cx2 Cx2 Cx2 Cx2 Cx3 Cx3 C C C C C C C C C C B B Bx2 D TX-RX unit (B/3) TX-RX unit (C/3) Cx2 A A Display unit 701 702 703 704 705 706 103 104 x2 IC417 J901 TX-RX unit [...]

TK- 7 1 80 34 P ACKING Parts with the exploded numbers larger than 700 are not supplied. 3 2 1 D C 5 Instruction manual (B62-1766-10) 9 DC cord assy (W ater -proof) (E30-7523-05) 18 Fuse (Blade) 15A/32V (F52-0024-05) x 2 32 Inner packing case (H02-0624-03) 33 Packing fixture (Lower) (H12-3170-01) 34 Packing fixture (Upper) (H12-3171-03) 36 Protecti[...]

TK- 7 1 80 35 Controls Panel Test Mode ■ Test mode operation features This transceiver has a test mode. To enter test mode, press [A] key and turn power on. Hold [A] key until fre- quency version appears on LCD. Test mode can be inhib- ited by programming. To exit test mode, switch the power on again. The following functions are available in test[...]

TK- 7 1 80 36 • Test signaling No. RX TX 1 None None 2 None 100Hz Square Wave 3 LTR Data : LTR Data : AREA=0, GOTO=12 AREA=0, GOTO=12 HOME=12 HOME=12 ID=47, FREE=25 ID=47, FREE=25 4 QT : 67.0Hz QT : 67.0Hz 5 QT : 151.4Hz QT : 151.4Hz 6 QT : 210.7Hz QT : 210.7Hz 7 QT : 254.1Hz QT : 254.1Hz 8D QT : D023N DQT : D023N 9 DQT : D754I DQT : D754I 10 DTM[...]

TK- 7 1 80 37 ■ Flow chart Note : The “Wide 4k” can not use, please skip it. Frequency [C] Shift 1 [C] Shift 2 [C] High power [C] Low power [C] Balance Narrow [C] [C] [C] [C] [C] [A] Balance Wide 4k Balance Wide 5k Max deviation Narrow [C] [A] Max deviation Wide 4k Max deviation Wide 5k QT Narrow [C] [C] [C] [C] [C] [A] QT Wide 4k QT Wide 5k [...]

TK- 7 1 80 38 Test Equipment Required for Alignment Test Equipment Major Specifications 1. Standard Signal Generator Frequency Range 136 to 174MHz (SSG) Modulation Frequency modulation and external modulation Output 0.1 µ V to greater than 1mV 2. Power Meter Input Impedance 50 Ω Operation Frequency 136 to 174MHz or more Measurement Capability Vi[...]

TK- 7 1 80 39 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 1. Setting 1) Power supply voltage DC power supply terminal : 13.6V 2) SSG standard modulation [Wide 5k] MOD : 1kHz, DEV : 3kHz [Wide 4k] MOD : 1kHz, DEV : 2.4kHz [Narrow] MOD : 1kHz, DEV : 1.5kHz 2. VCO lock [Panel [...]

TK- 7 1 80 40 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 5. Max low 1) Adj item : [MLPWR] Power meter Rear ANT Front [ ],[ ] 15W ± 1W power Adjust : [ ✳✳✳ ] panel panel adjust 2) Adj item : [L MLPWR] → [L’ MLPWR] → [C MLPWR] → [H’ MLPWR] → [H MLPWR] Adju[...]

TK- 7 1 80 41 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 11. Max DEV 1) Adj item : [n DEV] Power meter Rear ANT Front [ ],[ ] 2.10kHz ± 0.10kHz adjust Adjust : [ ✳✳✳ ] panel panel (According to the AG : 1kHz/50mV at MIC terminal larger +, –) Deviation meter filter[...]

TK- 7 1 80 42 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 15. LTR 1) Adj item : [n LTR] Power meter Rear ANT Front [ ],[ ] 0.75kHz ± 0.10kHz deviation Adjust : [ ✳✳✳ ] panel panel adjust Deviation meter filter LPF : 3kHz Deviation Front Modular HPF : OFF meter panel [...]

TK- 7 1 80 43 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 1. Sensitivity 1) Adj item : [SENS1] SSG Rear ANT Front [ ],[ ] Enter the following Note : After replacing the adjust Adjust : [ ✳✳✳ ] panel panel adjustment values EEPROM (IC401) aline 2) Adj item : [L SENS1] [...]

TK- 7 1 80 44 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 4. Low RSSI 1) Adj item : [n LRSSI] SSG Rear ANT After input signal The following erroneous adjust Adjust : [ ✳✳✳ ] panel from SSG, press [B] performance may occur if any • Narrow SSG output : 12dB SINAD leve[...]

TK- 7 1 80 45 Item Condition Measurement Adjustment Specifications/Remarks Test- equipment Unit Terminal Parts Unit Method ADJUSTMENT 6. High RSSI 1) Adj item : [n HRSSI] SSG Rear ANT After input signal The following erroneous adjust Adjust : [ ✳✳✳ ] panel from SSG, press [B] performance may occur if any • Narrow SSG output : –70dBm AF VT[...]

TK- 7 1 80 46 Display unit (X54-3480-10) Pin No. Name Description CN901 (to internal speaker) 1 GND Ground. 2 SPO Speaker output. CN902 (to TX-RX unit B/3 CN429) 1 SPO Speaker input. 2 SPO Speaker input. 3 SPO Speaker input. 4 SPO Speaker input. 5 SPO Speaker input. 6 SPO Speaker input. 7 GND Ground. 88 C 8V input. 9S B Power input of switched powe[...]

TK- 7 1 80 47 Pin No. Name Description J701 (ACC 25-pin) 1N C Non-connenction. 2 RXD1 Serial data input 1. RS-232C level. Input voltage range : ± 30V max. L ≤ 0.4V, H ≥ 2.4V, Zi ≥ 5k Ω 3T XD1 Serial data output 1. RS-232C level. L ≤ –5V, H ≥ 5V/3k Ω load, Zo ≤ 2k Ω 4A UXI/O9 AUX input/output 9. Active low with 47k Ω pull-up t[...]

TK- 7 1 80 48 Pin No. Name Description 16 DTI Data signal input. Zin ≥ 22k Ω , 600 ± 200mVp-p 17 TCTL Speaker mute signal input. Input : L ≤ 1.0V, H ≥ 4.0V, Input voltage : 0V~5.0V 18 NC Non-connection. 19 AUDIH MIC mute signal input. 20 OPT2 Option boad I/F 2. Output : L ≤ 0.45V, H ≥ 4.7V/25k Ω load Input : L ≤ 1.0V, H ≥ 4.0V, I[...]

TK- 7 1 80 49 Pin No. Name Description 21 SB Power output of switched power supply. 22 SB Power output of switched power supply. 23 8C 8V output. 24 GND Ground. 25 SPO Speaker output. 26 SPO Speaker output. 27 SPO Speaker output. 28 SPO Speaker output. 29 SPO Speaker output. 30 SPO Speaker output. CN804 1 IGN Ignition sense input. 2 GND Ground. Sol[...]

50 J I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 CP909 CP910 CP911 Q901 Q902 Q904 Q905 Q906 Q907 B C E Q909 Q910 1 29 30 GND RXD 5C GND GND PSENS ME GND PSW SB 8C SPO SPO SPO GND TXD NC NC GND RST2 GND MIC GND NC SB GND SPO SPO SPO 2 Q911 Q913 L901 L902 L903 L904 L908 L909 R901 R903 R904 R905 R907 R909 R910 R911 R913 R914 R915 R916 R917 R918[...]

51 JKL M N O P Q R S 1 2 3 4 5 6 7 8 9 10 11 12 13 14 9 09 CP910 L905 L906 L907 TH901 R943 R947 R948 R949 R950 R951 R952 R953 R954 R955 R956 R957 R958 R959 R967 R969 C930 C931 9 33 R971 IC903 ED1 C937 D912 D913 D914 SEG31 SEG32 SEG33 SEG34 SEG35 SEG41 SEG42 SEG43 SEG44 SEG45 SEG51 SEG52 SEG53 SEG54 SEG55 SEG61 SEG62 SEG63 SEG64 SEG65 SEG71 SEG72 SE[...]

JKL M N O P Q R S I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 CP909 CP910 CP911 Q901 Q902 Q904 Q905 Q906 Q907 B C E Q909 Q910 1 29 30 GND RXD 5C GND GND PSENS ME GND PSW SB 8C SPO SPO SPO GND TXD NC NC GND RST2 GND MIC GND NC SB GND SPO SPO SPO 2 Q911 Q913 L901 L902 L903 L904 L905 L906 L907 L908 L909 R901 R90[...]

52 J I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 R706 R707 R708 R709 R710 R717 R718 R719 CN701 C705 C706 C707 C708 C709 C710 C711 C712 C713 C714 C715 C716 C717 C718 C719 C720 C721 C722 C723 D709 D710 1 30 D714 25 13 R301 CP 5C Fin GND CPGND REF R304 R319 R320 R321 R323 R325 R327 R330 R332 C309 C313 C315 C321 C322 C332 C335 C336 C340 IC301 C3[...]

53 ABCD E FGH I J 1 2 3 4 5 6 7 8 9 10 11 12 13 14 25 13 J701 Q701 Q702 L701 L702 R701 R702 R703 R704 R705 R711 R712 R713 R714 R715 R716 R720 C701 C702 C703 C704 D701 D702 D703 D704 D705 D706 D707 D708 D711 D712 D713 C299 + R300 R308 R331 IC302 J72-0930-19 A/3 J72-0930-19 C/3 14 1 26 GND 27 GND AUX I/O6 AUX I/O1 AUX I/O2 AUX I/O3 AUX I/O4 AUX I/O5 [...]

54 J I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 C20 C21 C22 R403 C23 C24 R600 R603 R604 R606 GND RXD1 TXD1 TXD2 RXD2 OPT1 OPT3 OPT4 OPT5 5E DTI TCTL TXO AUDIH OPT2 STON RXEO TXI RXEI OPT6 8C R801 R802 CN401 BATT R806 R612 CN403 R807 R613 R809 R615 1 DM GND RXD TXD NC 5C SHIFT/MODEL CLK LCDDO LCDDI LCDRST RST2 PSENS GND ME MIC GND GND PW NC [...]

55 JKL M N O P Q R S 1 2 3 4 5 6 7 8 9 10 11 12 13 14 C 20 C 22 D173 D174 R212 C26 C27 C28 C29 R217 C31 C32 R221 R222 IC172 C44 C45 C50 C53 C55 C60 C211 C212 C214 C220 C221 C222 C223 C73 C224 C74 C225 C75 C76 C226 C227 C77 C228 IC71 C229 IC72 C231 C233 C234 C235 C236 C237 CF171 NARROW CF172 WIDE C241 18 5 4 18 5 4 Q301 Q302 Q303 Q304 Q305 Q72 Q73 Q[...]

JKL M N O P Q R S I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 C20 C21 C22 D173 R403 C23 C24 D174 R212 C26 C27 C28 C29 R217 R600 R603 R604 C31 C32 R606 GND RXD1 TXD1 TXD2 RXD2 OPT1 OPT3 OPT4 OPT5 5E DTI TCTL TXO AUDIH OPT2 STON RXEO TXI RXEI OPT6 8C R221 R222 R801 R802 CN401 BATT R806 R612 CN403 R807 R613 R809[...]

56 J I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 D171 D172 R210 R601 R C30 CN200 CN201 CN202 CN203 C34 R608 C35 R609 C38 C39 R610 R611 IC171 C43 C47 C48 C49 C200 C51 C201 R819 C202 C204 C205 C206 C207 C57 C58 C208 C59 C209 C400 C210 C61 C63 C213 C64 R251 C65 C215 C216 R252 C217 R253 R254 C218 R255 C219 R256 R257 R258 C79 C230 C80 C82 C232 C8[...]

57 JKL M N O P Q R S 1 2 3 4 5 6 7 8 9 10 11 12 13 14 R401 R402 R405 R406 R407 R601 R602 R410 R411 R412 C33 R607 R608 R414 R418 R419 R803 R610 R805 R611 C40 R808 R614 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R813 R814 R815 R816 R430 R431 R432 R434 R435 R437 R820 R439 C403 C404 R440 R441 C406 R442 C407 CN427 R443 C408 R444 C409 R447 R448 R4[...]

JKL M N O P Q R S I H G F E D C B A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 D171 R401 D172 R402 R210 R405 R406 R407 R601 R602 C30 R410 CN200 R411 CN201 CN202 R412 CN203 C33 R607 C34 R608 R414 C35 R609 C38 R418 C39 R419 R803 R610 R805 R611 C40 R808 R614 R420 IC171 R421 R422 C43 R423 R424 R425 R426 C47 R427 C48 R428 C49 R429[...]

58 TK- 7 1 80 SCHEMA TIC DIAGRAM 7 6 5 4 3 2 1 A B C D E X54-348 1/2 C906 0.01u C917 0.1u C918 10u10 C912 1000p C909 100p D901 02DZ18(X,Y) R904 1k R903 470 C904 100p J901 8 7 6 5 7 3 2 1 C916 0.1u C915 1000p R901 1k D906 DA204U D904 DA204U IC901 T A78L05F 2 COM 3 IN 1 OUT C927 1000p R943 100 R939 4.7k D905 DA204U R905 4.7k R909 47k R911 47k R907 33[...]

59 SCHEMA TIC DIAGRAM TK- 7 1 80 7 6 5 4 3 2 1 J I H G F X54-348 2/2 -t C908 1000p C907 1000p S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 26 S26 27 S27 28 S28 29 S29 30 S30 31 S31 32 S32 33 S33 34 S34 35 S35 36 S36 37 S37 38 S38 39 S39 40 S40 41 S41 42 S42 43 S43 44 S44 45 S45 46 S46 47 S47 48 S48 49 S[...]

-t C906 0.01u C917 0.1u C918 10u10 C912 1000p C909 100p D901 02DZ18(X,Y) R904 1k R903 470 C904 100p J901 8 7 6 5 7 3 2 1 C916 0.1u C915 1000p R901 1k D906 DA 204U D904 DA 204U IC901 TA 78L05F 2 COM 3 IN 1 OUT C927 1000p R943 100 R939 4.7k D905 DA 204U R905 4.7k R909 47k R911 47k R907 33k C908 1000p C907 1000p Q913 DTC114EE Q906 DTC114EE C928 1000p [...]

60 TK- 7 1 80 SCHEMA TIC DIAGRAM 7 6 5 4 3 2 1 A B C D E X57-698 1/9 D D D D D ATAO U T 1000p D801 22ZR-10D AUDIH 1 VSS 2 VDD 4 3 TCTL C817 470p 1 2 4 VSS 3 NC C829 1000p C588 1000p 1000p 5M 2SC2873(Y) Q801 C490 1000p 5R R806 10k AO2 R489 0 5C 5E R574 0 8R L410 8C R487 1.8M 5M C478 100p 5M C802 1000p L411 LCDRST 100p R805 470 5E 8T R401 3.6k(D) C40[...]

61 SCHEMA TIC DIAGRAM TK- 7 1 80 J I H G F X57-698 2/9 D D D D D D D AI07 A17 D3 R407 10k AI01 AM2 R435 1k D0 R422 47k AI02 L406 TCLK/DTRDO PSW AI03 CP406 1k L403 A14 R452 1k R457 47k AI08 A13 TXD1 AIO5 R434 47k R424 1k R427 1k A12 TXD2 AFDIR R468 47k R458 470k R511 1.5k A5 RXD1INT AFDIO R430 470 R454 1k AI04 A4 5C D423 1SS388 A11 R450 1k L405 R419[...]

62 TK- 7 1 80 SCHEMA TIC DIAGRAM K L M N O X57-698 3/9 D A18 R554 56k A16 C438 0.01u C472 0.1u C446 0.01u D4 R495 4.7k C400 1u 1 2 3 4 VSS 5 6 7 8 VDD R565 0 R496 100k IC411 LMC7101BIM5 1 OUTPUT 2 V+ 3 INPUT+ 4 5 R539 39k A4 R512 15k C444 39p R540 47k C462 0.01u 1 2 3 4 VSS 5 6 7 8 VDD R545 10k R492 680k CSO R532 1k R513 560k C479 1000p C469 0.1u C[...]

63 SCHEMA TIC DIAGRAM TK- 7 1 80 T S R Q P X57-698 4/9 A A R620 220k 2SJ243 Q417 C542 1000p R606 0 R570 150k R599 180k 1 2 3 4 5 6 7 8 9 10 TCLK/DTRDO 11 TDA T A/DTRCLK 12 DI/O 13 RDF/FD 14 SCLK 15 DIR 16 XOUT 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 C513 1000p R560 390k D409 MA742 R611 10k C538 1000p R578 0 C488 12p(G) 2SJ243 Q416 C533 0.01[...]

64 TK- 7 1 80 SCHEMA TIC DIAGRAM U V W X Y X57-698 5/9 A C309 1000p R115 4.7k 8R C322 39p MB R301 C125 1000p R321 10k PLE R302 10 UL PCK 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 R325 150k CN301 1 2 3 4 5 6 C327 0.22u 2SC4116(BL) Q302 C307 1000p 2SC4116(BL) Q303 C331 1000p R320 100 L108 R309 180 R307 0 TV R333 0 C339 1000p R305 56 C335 0.0[...]

65 SCHEMA TIC DIAGRAM TK- 7 1 80 AD AC AB AA Z X57-698 6/9 R359 150 10CL R178 0 C185 0.01u Q310 DTC114EE R361 330 MOD C252 1000p L185 68n C376 1000p R355 270 C197 0.01u 8T TC301 8p D314 1SV278 C369 1000p R251 1k C384 0.01u C183 0.01u C257 1u 25 R181 330 C190 39p R257 15k R356 10k C256 0.01u C196 0.01u TC302 8p R256 120k C201 4p L319 82n C192 0.01u [...]

66 TK- 7 1 80 SCHEMA TIC DIAGRAM AE AF AG AH AI X57-698 7/9 -t R205 3.3k L189 1u C221 0.1u C207 1000p R15 220 Q178 DT A144EE C229 0.033u C209 0.01u R87 100k L187 100n 1 2 3 45 6 7 8 L2 D173 RB706F-40 R1 270 R84 100k C231 82p C218 0.01u R206 1k R193 47k C236 0.01u R8 470 C16 56p R4 33k 2SK1824 Q72 C226 1000p C33 100p R207 47k C44 120p L6 C225 270p L[...]

67 SCHEMA TIC DIAGRAM TK- 7 1 80 AN AM AL AK AJ X57-698 8/9 -t L13 9.5T R30 0 C575 47u25 CN427 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 R28 8.2k L12 5T C48 2p(B) R652 560 C574 22u16 C562 1u25 C578 47u25 R644 1k C47 0.5p(B) CN428 1 2 3 4 5 6 C547 1000p C570 1u C554 100p C583 470p C577 0.1u C582 1000p R655 0 C5[...]

68 TK- 7 1 80 SCHEMA TIC DIAGRAM 7 6 5 4 3 2 1 AO AP AQ AR AS X57-698 9/9 E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E D 2SD2114K(W) Q702 D704 DA204U D714 02DZ18(X,Y) CN701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 R707 470 C703 100p C717 1000p C713 1000p C701 1000p J701 1 2 3 4 5 [...]

E E E D E A E E E E E E E E E E E E -t E E E E E E E E D D D E D E D E A E D A E D E E E E E -t E D E D D E D D D ATAO U T C309 1000p AI07 R359 150 1000p 10CL A18 D801 22ZR-10D R178 0 AUDIH A17 C185 0.01u R205 3.3k D3 R620 220k 1 VSS 2 VDD 4 3 2SJ243 Q417 R554 56k TCTL L13 9.5T C817 470p Q310 DTC114EE R407 10k AI01 AM2 L189 1u C221 0.1u R361 330 R4[...]

TK- 7 1 80 69 CN429 (DM) GND RXD TXD NC 5C SHIFT/MODEL (CLK) (LCDDO) (LCDDI) (LCDRST) RST2 PSENS GND ME MIC GND GND PSW NC SB SB 8C GND SPO SPO SPO SPO SPO SPO CN701 AUXIO6 AUXIO7 AUXIO1 AUXIO2 RXD2 AUXIO3 TXD2 AUXIO4 AUXIO8 AUXIO5 AUXIO9 AUXO1 TXD1 AUXO2 RXD1 GND ME MI2 DEO GND 5C DI AFO SB SB SB SB SB SB NC CN902 GND GND RXD TXD 5C NC SHIFT/MODEL[...]

70 AGC MIC AMP MI2 IC414 TC75W51FU 8C MM2 MOD TX VCO RX VCO IN V SW VCXO T/R Q302,Q303,Q304 2SC4116(BL)*3 Q309 2SC4116 (GR) DISPLAY UNIT (X54-348) AVR BUSY LED RXD2 TXD2 X901 14.7456MHz SW SW 8C TX LED SW 8C SP POWER SW PSW RED 11CL LCD DRIVER IC903 LC75810T -8726 Q913,Q909 DTC114EE,12A02CH Q904 DTC114EE Q905 DTC114EE 5V, 8C Q417 2SJ243 Q416 2SJ243[...]

71 BLOCK DIAGRAM TK -718 0 DAC IC410 M62364FP AUX I/O1~ AUX I/O9 EEPROM IC401 AT24256N10SI27 Flash ROM IC405 AT29C040A-90TI RTC IC402 RV5C386A ANT SW TUNE TV D3,D4 XB15A407A2GB*2 D2: XB15A709 Q103 2SC3357 Mixer IC171 SPM5001 IC1 RA30H1317M IN V T/R T/R Q311 2SC5108(Y) Q301 2SC5108(Y) Q313 2SC5108(Y) *2 FC AM IC417 TA7252AP CD RSSI 5CL 5C +B D [0:7][...]

TK- 7 1 80 72 W: 5.0mVrms N: 6.3mV rms W: 5.0mVrms N: 6.3mV rms 21 IC414 W: 72.5mVrms N: 91.3mV rms 12 14 IC413 W: 72.5mVrms N: 91.3mV rms 26 IC415 W: 340mVrms N: 180mV rms 43 IC410 W: 140mVrms N: 70mV rms 21 IC412 Q307 W: 173mVrm s N: 86mV rms W N MIC TX VCO –122.0dBm –109.0dBm –117.0dBm –118.5dBm –108.0dBm –105.5dBm –120.0dBm BPF BP[...]

TK- 7 1 80 73 LEVEL DIAGRAM Q307 67 IC412 52 6 IC415 315mV rms 190mV rms 88mV rms 4.00Vrms 11 5 IC413 16 15 IC410 15 IC417 14 IC1 1 73mV rms 8 6mV rms W: –83.5dBm N: –83.0dBm W: –86.0dBm N: –86.0dBm –1dBm TX VCO –1.5dBm +7dBm +16dBm 30W . 0dBm 05.5dBm 200mV rms 16 35 9 CF171/ CF172 IC172 7 2 4 Ω J401 455kHz Audio Frequency SINAD are o[...]

TK- 7 1 80 74 ■ External View 1 ✽ A62-1101-01 MAIN PANEL 2 ✽ A82-0056-11 REAR PANEL 4 ✽ E30-7514-05 TRUNK CABLE 5 ✽ E37-1121-05 FLAT CABLE 7 ✽ F07-1884-03 MOLDING COVER 9 ✽ G53-1614-23 PACKING 11 ✽ H12-3163-03 PACKING FIXTURE 12 H25-0029-04 PROTECTION BAG (60/110/0.07) 13 H25-2327-04 PROTECTION BAG (100/250/0.07) 14 H25-2352-04 PROT[...]

TK- 7 1 80 75 2 Rear panel (A82-0056-11) 1 Main panel (A62-1101-01) 4 T runk cable (E30-7514-05) 4 T runk cable (E30-7514-05) 7 Molding cover (F07-1884-03) 7 Molding cover (F07-1884-03) 9 Packing (G53-1614-23) Interface unit (X46-3310-20) (A/2) Interface unit (X46-3310-20) (B/2) 5 Flat cable (E37-1121-05) B Pan head taptite screw (N80-2608-48) x 4 [...]

TK- 7 1 80 76 C41 D2 D3 D4 D5 D6 D9 D10 D11 D12 1 30 D13 D14 D15 D16 D17 D18 D19 D20 L2 L3 L5 L6 IC1 1 45 8 IC2 1 45 8 R1 1 30 SPI SPI SPI SPI SPI SPI GND 8C SB SB NC PSW GND GND MIC ME GND PSENS RST2 LCDRST LCDDI LCDDO CLK SHIFT 5C NC TXD RXD GND DM SPI SPI SPI SPI SPI SPI GND 8C SB SB NC PSW GND GND MIC ME GND PSENS RST2 LCDRST LCDDI LCDDO CLK SH[...]

TK- 7 1 80 77 ■ Schematic Diagram INTERFACE UNIT (X46-3310-20) (A/2) OPTIONAL ACCESSORIES: KRK-10 (Control Head Remote Kit: 23ft/7m) A A A A A IC1 1 G1 2 A1 3 Y2 4 GND 5 A2 6 Y1 7 G2 8 VCC IC2 1 G1 2 A1 3 Y2 4 GND 5 A2 6 Y1 7 G2 8 VCC D2 IC1 : TC7WT125FU D2 : MINISMDM075/24 D3~6 : DA204U D12~19 : AVRM1608080MAA IC2 : TC7WT125FU D9~11 : DA204U D20[...]

TK- 7 1 80 78 ■ Terminal Function Pin No. Name Description CN1 (Radio side) 1 SPI Speaker input. 2 SPI Speaker input. 3 SPI Speaker input. 4 SPI Speaker input. 5 SPI Speaker input. 6 SPI Speaker input. 7 GND Ground. 88 C 8V input. 9S B Power input of switched power supply. 10 SB Power input of switched power supply. 11 NC - 12 PSW Detection signa[...]

TK- 7 1 80 79 OPTIONAL ACCESSORIES KAP-2 (Horn Alert/P.A. Relay Unit) ■ External View KCT-40 (Radio Interface Cable) ■ External View KCT-46 (Ignition Sense Cable) ■ External View KMC-35 (Microphone) ■ External View KMC-36 (Keypad Microphone) ■ External View[...]

TK- 7 1 80 KENWOOD CORPORA TION 2967-3, Ishikawa-machi, Hachioji-shi, T okyo, 192-8525 Japan KENWOOD U.S.A. CORPORA TION P. O. BOX 22745, 2201 East Dominguez Street, Long Beach, CA 90801-5745, U.S.A. KENWOOD ELECTRONICS CANADA INC. 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8 KENWOOD ELECTRONICS DEUTSCHLAND GMBH Rembrücker Str . 15, 631[...]