Lennox Hearth C310 Bedienungsanleitung

INST ALLA TION AND OPERA TION MANUAL W ARNINGS • Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will retain heat for a while after shutting off the appliance. Severe burns may result. • Carefully supervise children in the same room as appliance. Save These Instructions For Future Reference A F ren c[...]

2 CO N GR A TU LA TI O NS ! When you purchased your new wood-burning fireplace insert, you joined the ranks of thousands of individuals whose answer to their home heating needs reflects their concern for aesthet- ics, efficiency and our environment. We extend our continued support to help you achieve the maximum benefit and enjoyment available [...]

3 1. Wh en th is ro om he at er i s n ot pr op er ly i nst al le d, a ho us e fi re m ay res ult . T o reduc e the risk of fire, foll ow the inst all at ion inst ruc - tio ns. C ont act l oca l b ui ldi ng or fir e o ffi cia ls ab out re st ric tio ns and in st all ati on in spe cti on re qui re men ts in yo ur are a. 2. Wear gloves during inst[...]

The appliance is merely one component of a larger system. The other equally important component is the venting system. This is necessar y for achieving the required flow of combustion air to the fire chamber and for safely removing unwanted combustion by-products from the appliance. If the venting system’ s design does not promote these ends, t[...]

5 Dry , seasoned wood is that which has been cut, split and allowed to dry under a covered area where air is free to flow and circulate under and around the wood (not under a tarp or plastic). Make sure wood is not stacked directly on the ground, it may absorb moisture from the ground. It should be allowed to dry in these conditions for a minimum [...]

6 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. C anyon ™ C310 CAUTION: Wear gloves during brick installation in case of sharp edges behind the stove. Note: Installation of the baffle boards and baffle blankets are easier when you can still access the flue outlet, (before connecting the flue vent). Be sure the baffle blankets are pla[...]

** Figure 5 Figure 6 8” Ø Flue Collar Mantel T rim Maximum Mantel Depth = 9” (229mm) COMBUSTIBLE MANTEL T op Facing / T rim Side Facing Material SIDE WALL C Insert D B A E (USA) E (Canada) Hearth Protection M F G J H 9” 229mm Hearth Protection 7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W AR NI NG : BE ABSO LU TE L Y SU RE THE DI[...]

8 The hearth and/or floor protection must be a thermally rated non-com- bustible hearth/floor protector meeting or exceeding a thermal rating of k=.84 or equivalent with a listed thickness of 3/4" (19mm) minimum in USA and Canada. The covering must extend 24” (610mm) in front of the heater and 8” (200mm) to either side (measured from doo[...]

9 The Canyon™ C310 inserts are approved for use in masonr y fireplaces built to UBC Chapter 37 or equivalent with a minimum 30-1/2” (775) width opening at the front of the fireplace. The Canyon™ C310 inserts may be installed using 6” chimney in vertical installations utilizing a 8” to 6” reducer (cat. # 71134) at the flue collar . If[...]

10 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A positive flue connection is providing a seal between the vent pipe or liner and the existing fireplace chimney for the purpose of preventing room air passage to the chimney cavity of the fireplace. There are differ - ent approved methods to achieve this. See Direct Connect Positive Flue [...]

11 Install the two 3” (76 mm) long bolts (with the head up) through the nuts attached to the insert on the lower rear corner of each side. This will allow you to level the insert when placed into the fireplace. Measure from the front of the top surround mount to the center of the flue. Determine if there is an alignment problem in connecting a [...]

12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 1. Burn only dr y , well-seasoned wood for maximum heat output. In some states it is illegal to burn wet wood or anything other than clean, dry wood products. 2. Y our fireplace insert is designed to operate with the door closed! Operate only with the door shut tightly at all times except wh[...]

13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNINGS The blower must be plugged directly into a properly grou nded thr ee-p rong re cept acle , 12 0 V AC, 60 Hz, sin gle phase. Do not cut or remove the grounding prong from this plug. Do not route power cord under or in front of appliance. Installation must be in accordance with Nation[...]

14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. It is important to know that for high, combustion efficient, clean burns, you will need to have sufficient temperatures inside the firebox for thorough combustion . The best method for determining if you have suf- ficient temperatures is to watch the brick lining in your firebox. When yo[...]

15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. DOO R HIN GE S: If do or hing es ne ed lubr ica tin g, use an anti -s eiz e com pou nd (never use oil) available from your Lennox Hearth Products dealer . DOOR LA TCH: If your door latch fails to latch tightly and the gasket is in good condition, place a length of pipe (cheater bar) over the [...]

16 Problem Solution POOR DRAFT : Extend chimney in length or have the chimney realigned to the proper size flue. Oversized chimneys nor - mally have poor drafts. Remember , the stoves’ draft depend solely on the natural draft of the chimney (See Drafting section on Page 4 ) . If your stove is not drafting properly , your chimney is the problem. [...]

17 DO NOT : Install or operate this stove before reading this manual. DO NOT : Close the draft beyond the point at which the flames are completely extinguished. DO NOT : Open the stove door without fully opening the draft first. DO NOT : Burn driftwood or wood that has been in salt water . This includes some mill ends and scrap lumber that has be[...]

Contact an Authorized Lennox Hearth Products dealer to obtain any of these parts. Never use substitute materials. Use of non-approved parts can result in poor performance and safety hazards. FRONT DOOR P ARTS LIST Item # Ca t . N o De s c ri p ti on 1 H5639 Door Rope Kit, 7/8” Dia. (6’ 2”) 2 H5629 Upper Hinge Pin 3 H5626 Upper Hinge Pin E-Cli[...]

REPLACEMENT P AR TS - MODEL C310 33 34 36 36 37 37 46 47 48 35 40 40 38 38 38 41 38 38 38 38 38 38 38 38 38 38 39 39 39 39 42 44 42 43 38 38 43 40 40 41 38 38 38 45 19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE.[...]

REPLACEMENT P AR TS - MODEL C310 7 11 10 6 9 5 4 4 1 8 2 3 16 29 17 15 32 18 19 Blower Parts Door Parts 20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE.[...]

SU R R OU N D P AN E L S / T OP A ND S ID E S ( R E QU I R ED ) Ca t . N o . Mo d e l Des c ri pti o n 29 ” x 4 0” : 71 0 3 8 WF PT 0 7 40 - L T op S ur rou n d 7 - 1/ 2 ” x 4 0” 71 0 3 1 WF PS 0 6 21 S id e Su r r ou n ds 6” x 2 1 -5 / 8 ” 29 ” x 4 8” : 71 0 3 9 WF PT 0 7 48 - L T op S ur rou n d 7 - 1/ 2 ” x 4 8” 71 0 3 2 WF P[...]

SAFETY / LISTING LABEL 22[...]

23 NOTES[...]

Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A. © 2007 by Lennox Hearth Products P/N 775,213M REV . B 02/2010 24 Y our Appliance?[...]