Lenovo 3000 C200 Bedienungsanleitung

Le n o v o 3 000 C2 00 Hard w ar e M ain t e n a n c e Ma nu a l January 2007 This manual supports: Lenovo 3000 C200 (MT 8922)[...]

[...]

Le n o v o 3 000 C2 00 Hard w ar e M ain t e n a n c e Ma nu a l[...]

Note Before using this information and the pr oduct it supports, be sure to r ead the general information under “Notices” on page 96. Second Edition (January 2007) © Copyright Lenovo 2006, 2007. All rights reserved. U.S. GOVERNMENT USERS – RESTRICTED RIGHTS: Our products and/or services ar e provided with RESTRICTED RIGHTS. Use, duplication [...]

Contents Introduction . . . . . . . . . . . . .1 About this manual . . . . . . . . . . . .1 Important service information . . . . . . . .1 Strategy for replacing FRUs . . . . . . . . .1 Strategy for replacing a har d disk drive . . . .2 Important notice for replacing a system boar d . .2 How to use error messages . . . . . . . .2 Strategy for repla[...]

iv MT 8922[...]

Introduction About this manual This manual contains service and refer ence information for Lenovo 3000 C200 (MT 8922). Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections provide general information, guidelines, and safety information requir ed in s[...]

v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board. If you are instructed to r eplace either the processor boar d or the system board, and replacing one of them does not corr ect the problem, rein[...]

Using PC Entitlement W arehouse (PEW) v PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities for CMV products at a MT - serial number level. An example of key commodities are har d disk drives, system boards, micropr ocessors, Liquid Crystal Displays (LCDs), and memory . v Remember , All CMV produc[...]

Important information about replacing RoHS compliant FRUs RoHS, The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive (2002/95/EC) is a European Union legal requirement affecting the global electronics industry . RoHS requirements must be implemented on Lenovo products placed on the market after June 2006. Product[...]

Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety notices appear in English with a page number refer e[...]

Safety notice 2 D ANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery , recharge it, throw it into fire or water , or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery [...]

Safety notice 3 D ANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water , or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result[...]

Safety notice 4 D ANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector , disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water . Dispose of the battery as required by local ordinances or regulations. Use only the battery in the app[...]

Safety notice 5 Safety notice 6 D ANGER If the LCD breaks and the fluid fr om inside the LCD gets into your eyes or on your hands, immediately wash the affected ar eas with water for at least 15 minutes. Seek medical care if any symptoms fr om the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous[...]

Safety notice 7 D ANGER Safety notice 8 D ANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de couran[...]

Safety information The following section presents safety information with which you need to be familiar before you service a Lenovo 3000 computer . General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you [...]

Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electr ostatic discharges. Do not use this type of mat to[...]

v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures corr ect grounding of the units.) v If an electrical accident occurs: – Use caution; do not become a vic[...]

Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects. Pr otect against ESD damage by equalizing the charge so that the machine, t[...]

Laser compliance statement Some models of Lenovo 3000 computer are equipped fr om the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requir ements of the Department of Health and Hum[...]

A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: D ANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio lase[...]

General descriptions The descriptions in this chapter apply to any Lenovo 3000 model that has the PC-Doctor ® for DOS diagnostics program. Some descriptions might not apply to your particular computer . Read this first Before you go to the checkout guide, be sur e to read this section. Important notes v Only certified trained personnel should serv[...]

Following is a list of some common items that are not cover ed under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking pr oblems with the computer , determine whether the damage is covered under the warranty by r eferring to the following list: The following are not covered und[...]

Related service information This section provides information about the following: v “Service We b site” v “Restoring the factory contents by using Product Recovery discs” v “Passwords” on page 20 v “Power management” on page 22 Service We b site When the latest maintenance diskette and the system program service diskette become ava[...]

9. When prompted, insert the appr opriate Product Recovery disc and then click OK . The second phase of the recovery pr ocess begins. 10. When all of the data has been copied from the last Pr oduct Recovery disc in the set, a message is displayed prompting you to r estart the computer . Remove the disc and then click Ye s , then a message is displa[...]

How to remove the power-on password To remove a POP that you have forgotten, do the following: (A) If no SVP has been set: 1. T urn off the computer . 2. Remove the battery pack. For how to remove the battery pack, see “1010 Battery pack” on page 44. 3. Remove the DIMM slot cover . For how to remove the DIMM slot cover , see “1070 DIMM slot c[...]

How to remove the hard-disk password Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer , neither Lenovo nor Lenovo authorized servicers provide any services to r eset the user HDPs or to recover data from the har d disk drive. The hard disk drive can be replaced for a scheduled[...]

v If the battery indicator blinks orange, indicating that the battery power is low . (Alternatively , if Hibernate when battery becomes low has been selected in the “Power Management Properties” window , the computer goes into hibernation mode.) To cause the computer to return from standby mode and r esume operation, do one of the following: v [...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the Lenovo 3000 computer . Note: The diagnostic tests are intended to test only Lenovo 3000 pr oducts. The use of non-Lenovo 3000 products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1[...]

To ru n the test, do as follows: 1. Insert the PC-Doctor disk into the diskette drive; then power on the computer . If the computer cannot be powered on, go to “Power system checkout” on page 26, and check the power sources. If an error code appears, go to “Symptom-to-FRU index” on page 35. On the first screen, select the model and pr ess E[...]

Detecting system information with PC-Doctor PC-Doctor can detect the following system information: Hardware Info v System Configuration v Memory Contents v Physical Disk Drives v Logical Disk Drives v VGA Information v IDE Drive Info v PCI Information v PNPISA Info v SMBIOS Info v VESA LCD Info v Hardwar e Events Log Utility v Run External T ests v[...]

Checking the ac adapter Yo u are here because the computer fails only when the ac adapter is used. v If the power-on indicator does not turn on, check the power cor d of the ac adapter for correct continuity and installation. v If the computer does not charge during operation, go to ″ Checking operational charging. ″ To check the ac adapter , d[...]

Note: If the battery pack becomes hot, it may not be able to charge. Remove it from the computer and leave it at r oom temperature for a while. After it cools down, reinstall and r echarge it. To check the battery pack, do the following: 1. Power off the computer . 2. Remove the battery pack and measure the voltage between battery terminals 1 (+) a[...]

Lenovo 3000 C200 Product overview . . . . . . . . . . . .3 0 Specifications . . . . . . . . . . . . .3 0 Status indicators . . . . . . . . . . . .3 2 FRU tests . . . . . . . . . . . . . .3 3 Fn key combinations . . . . . . . . . .3 4 Symptom-to-FRU index . . . . . . . . . .3 5 Numeric error codes . . . . . . . . . .3 5 Error messages . . . . . . . [...]

Product overview This section presents the following pr oduct-unique information: v “Specifications” v “Status indicators” on page 32 v “FRU tests” on page 33 v “Fn key combinations” on page 34 Specifications The following table lists the specifications of the Lenovo 3000 C200: Feature Description Processor v Intel Celeron M process[...]

Feature Description CMOS RAM v 242 bytes Hard disk drive v 40 GB, 5400 rpm, 9.5 mm high, S ATA interface v 60 GB, 5400 rpm, 9.5 mm high, S ATA interface v 80 GB, 5400 rpm, 9.5 mm high, S ATA interface v 100 GB, 5400 rpm, 9.5 mm high, S ATA interface v 120 GB, 5400 rpm, 9.5 mm high, S ATA interface Supported hard disk drives ar e depend on the model[...]

Status indicators The system status indicators show the status of the computer , as follows: 1 2 3 4 5 6 7 8 Indicator Meaning 1 Caps lock Caps Lock mode is enabled. Yo u can enter all alphabetic characters (A-Z) in uppercase without pr essing the Shift key . To enable or disable Caps Lock mode, press the CapsLk key . 2 Num lock The num[...]

Indicator Meaning 7 Battery status Green: The battery is charged between 80% to 100% of the capacity , and being discharged between 0% to 80% of the capacity . Blinking green: The battery is charged between 20% to 80% of the capacity , and being charged. Orange: The battery is charged between 5% and 20% of the capacity , and being discharged.[...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . Key combination Description Fn+F1 V olume down. Fn+F2 V olume up. Fn+F3 Reserved. Fn+F4 Put the computer in standby mode. To return to normal operation, press the Fn key only , without pressing a function key . Fn+F5 Enable or disable the buil[...]

Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replacing a FRU does not solve the problem, put the [...]

Symptom or error FRU or action, in sequence 0260 System timer error 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. System board. 0270 Real time clock error 1. Charge the backup battery for more than 8 hours by connecting the ac[...]

Error messages Symptom or error FRU or action, in sequence Unsupported memory . DIMM . Make sur e to use supported memory . Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3[...]

Errors without messages Symptom or error FRU or action, in sequence Power-on indicator on, LCD blank, and no POST . 1. Make sure that every connector is connected tightly and correctly . 2. DIMM. 3. System board. Power-on indicator on, and LCD blank during POST . 1. Reseat DIMM . 2. System board. The power-on passwor d prompt appears. A power-on pa[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

FRU replacement notices This section contains notices related to r emoving and replacing parts. Read this section carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the Lenovo 3000 computer , this problem is addr essed with special nylon-coated screws that have the following characteristics: v They [...]

v “Retaining the UUID” v “Reading or writing the ECA information” Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the serial numbers of the system and all major components. These numbers need to remain the same thr oughout the life of the computer . If you re[...]

To check what ECAs have been previously applied to the machine, use the ECA Information Read/W rite function on the CE Utility Diskette for Lenovo 3000 notebooks. 1. Insert the CE Utility Diskette for Lenovo 3000 notebooks, and restart the computer . 2. From the main menu, select 6. Set ECA Information . 3. To read ECA information, select 2. Read E[...]

Removing and replacing a FRU This section presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU repla[...]

1010 Battery pack D ANGER Unlock the battery release lever 1 and holding the battery r elease lever in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 3 2 1 Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Removing and replacing a[...]

1020 Hard disk drive slot cover For access, remove this FRU: v “1010 Battery pack” on page 44 1 1 2 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) 1030 Hard disk drive For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cove[...]

1040 Bluetooth daughter card (BDC) For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 2 1 3 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (1) Black 0.245 Nm (2.5 kgfcm) When installing: Make sure that the connector is attached firmly . Re[...]

1050 PCI Express Mini Card for 802.1 1 a/b/g wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 1 1 2 3 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (2) Black 0.245 Nm (2.5 kgfcm) In step 2 , unplug the jacks by using [...]

1060 PCI Express Mini Card for 802.1 1 a/b/g/n wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 1 1 2 3 Step Screw (quantity) Color T orque 1 M2 × 4 mm, flat-head, nylon-coated (2) Black 0.245 Nm (2.5 kgfcm) In step 2 , unplug the jacks by usin[...]

1070 DIMM slot cover For access, remove this FRU: v “1010 Battery pack” on page 44 1 2 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) Removing and replacing a FRU Lenovo 3000 C200 49[...]

1080 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1070 DIMM slot cover” on page 49 1 1 2 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly , and pivot it until it snaps into the place. Make sure that it is firmly fixed in the slot and does not move easily . Removi[...]

1090 Optical drive For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1070 DIMM slot cover” on page 49 2 3 1 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) Removing and replacing a FRU Lenovo 3000 C200 51[...]

1 100 Thermal module slot cover For access, remove this FRU: v “1010 Battery pack” on page 44 1 2 1 Step Screw (quantity) Color T orque 1 M2.5 × 4 mm, flat-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) Removing and replacing a FRU 52 MT 8922[...]

111 0 Fan For access, remove this FRU: v “1010 Battery pack” on page 44 v “1 100 Thermal module slot cover” on page 52 2 3 1 1 1 Step Screw (quantity) Color T orque 1 M2.5 × 6 mm, flat-head, nylon-coated (3) Silver 0.392 Nm (4 kgfcm) When installing: Make sure that the fan connector is attached firmly . Removing and replacing a FRU L[...]

1 120 Thermal module For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1 100 Thermal module slot cover” on page 52 v “ 111 0 Fan” on page 53 1 1 1 1 2 Step Screw (quantity) Color T orque 1 CPU thermal screw , nylon-coated (4) Silver 0.392 Nm (4 kgfcm) 3 When installing: Make sure that the connector is at[...]

When installing: Before you attach a new thermal module to the computer , peel off the covering film of thermal gr ease. Then attach the thermal module to the computer . Removing and replacing a FRU Lenovo 3000 C200 55[...]

1 130 CPU For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1 100 Thermal module slot cover” on page 52 v “ 111 0 Fan” on page 53 v “1 120 Thermal module” on page 54 Attention: CPU is extr emely sensitive. When you service the CPU, avoid any kind of rough handling. Rotate the head of the screw in the dir e[...]

1 140 Cover , strip (E cover) For access, remove this FRU: v “1010 Battery pack” on page 44 2 1 3 3 Removing and replacing a FRU Lenovo 3000 C200 57[...]

1 150 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1 140 Cover , strip (E cover)” on page 57 1 1 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) In step 2 , unlatch the keyboard. 2 When installing: Make sure that the latch is attach[...]

Lift the keyboard a little in the dir ection shown by arrow 3 . Then unlock the connector 4 and detach the connector 5 . 3 4 4 5 When installing: 1. Make sure that the keyboar d connector is attached firmly . Then lock the connector . 2. Make sure that the fr ont side of the keyboard is under the frame. Removing and replacing a FR[...]

1 160 Function board For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1 140 Cover , strip (E cover)” on page 57 v “1 150 Keyboard” on page 58 1 3 2 2 1 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) Removing and replacing a FRU 60 MT 8922[...]

1 170 LCD unit For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1 140 Cover , strip (E cover)” on page 57[...]

Pull out the wireless LAN antenna cables fr om the guide hole of the system board 2 , and release them fr om the cable guides of the frame 3 . 3 2 5 4 When installing: Make sure that the connectors 4 and 5 ar e attached firmly . (continued) Removing and replacing a FRU 62 MT 8922[...]

7 7 6 6 Step Screw (quantity) Color T orque 6 M2.5 × 8 mm, flat-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) When installing: Route the antenna cables along the cable guides. When you route the cables, do not tense them. To do so, the cables may get damaged by the cable guides of the frame, and may cause a broken wir e. Make sure that yo[...]

1 180 To p cover assembly (C cover) For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1070 DIMM slot cover?[...]

4 4 Step Screw (quantity) Color T orque 4 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU Lenovo 3000 C200 65[...]

5 When installing: Make sure that the connectors ar e attached firmly . 6 6 6 6 6 6 Removing and replacing a FRU 66 MT 8922[...]

1 190 USB/Audio connector card For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1 140 Cover , strip (E cove[...]

1200 VGA connector card For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1 140 Cover , strip (E cover)” o[...]

1210 LED card For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1 140 Cover , strip (E cover)” on page 57 [...]

1220 System board, MDC, PC Card slot, and bottom cover assembly (D cover) For access, remove these FRUs, in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1030 Hard disk drive” on page 45 v “1040 Bluetooth daughter card (BDC)” on page 46 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g w[...]

2 2 2 2 3 Step Screw (quantity) Color T orque 2 M2.5 × 4 mm, flat-head, nylon-coated (4) Silver 0.392 Nm (4 kgfcm) In step 3 , detach the USB connector . 5 4 In step 4 , remove the system boar d, the MDC, and the PC Card slot together from the bottom cover , and then detach the VGA connector 5 . (continued) Removing and rep[...]

To remove the MDC, do as follows: 1 1 2 Step Screw (quantity) Color T orque 1 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) When installing: Make sure that the connector is attached to the system boar d firmly , and then fasten the screws. To remove the PC Card slot assembly , do as follows: 1 1 1 1 2 Step Screw (quantity[...]

2010 LCD front bezel (B cover) For access, remove this FRU: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1 140 Cover , strip (E cover)” on pag[...]

2020 Inverter card For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” on page 48 v “1 140 Cover , strip (E cover)” on pag[...]

2030 LCD panel, LCD cable, hinges, and LCD rear cover assembly (A cover) For access, remove these FRUs in or der: v “1010 Battery pack” on page 44 v “1020 Hard disk drive slot cover” on page 45 v “1050 PCI Express Mini Car d for 802.1 1 a/b/g wireless LAN” on page 47 v “1060 PCI Express Mini Car d for 802.1 1 a/b/g/n wireless LAN” o[...]

Remove the hinges ( a ) from the LCD panel. 4 4 a a 3 3 3 3 3 3 Step Screw (quantity) Color T orque 3 M2 × 3 mm, flat-head, nylon-coated (8) Silver 0.245 Nm (2.5 kgfcm) Remove the LCD cable assembly ( b ) from the LCD panel. 5 6 b Removing and replacing a FRU 76 MT 8922[...]

Locations Front view 1 Lenovo Care button 2 V olume control buttons 3 Keyboard 4 Fingerprint reader (for some models) 5 T ouch pad 6 T ouch pad buttons 7 System and power status indicators Note: For the description of each indicator , see “Status indicators” on page 32. 8 5-1 Digital Media Reader [...]

Rear view 1 RJ-1 1 (modem) connector 2 AC power connector 3 S-V ideo connector 4 External monitor connector 5 Optical drive 6 USB connectors 7 Microphone jack 8 Stereo headphone jack 1 2 3 4 5 7 8 6 Bottom view 1 Battery pack latch 2 Battery pack 3 Battery pack latch 4 Memory c[...]

Parts list Overall 1 2 3 4 5 6 7 10 9 a 11 12 13 15 14 16 18 19 20 21 b c 23 22 8 17 24 Parts list Lenovo 3000 C200 79[...]

v Each FRU is available for all types or models, unless specific types or models are specified. v FRU parts with specific models listed and described as xxU (where U is an example of a country designator) should be used for all models ending in U. v FRU parts with specific models listed and described as 3Dx (where 3D is an example of a unique confi[...]

No. FRU FRU no. RoHS ID CRU ID 7 LED board 41W1440 R N 8 Modem daughter card (MDC) 42T0806 R N 9 CD drive assembly , 12.7mm v 8922-27x, 2Px TSST (TS-L162C) 27R2316 R ** TEAC (CD224E-Nxx) 27R2322 R ** DVD/CD-R W combo drive assembly , 12.7 mm v 8922-23x, 29x, 2Ax, 2Fx, 2Kx, 2Wx, 35x, 3Fx, 3Hx, 42x, 44x, 45x, 46x, 49x, 4Ax, 5A, 5B, 5Cx, 5Dx,5Ex, 5Fx,[...]

No. FRU FRU no. RoHS ID CRU ID 13 S ATA hard disk drive, 80 GB, 9.5 mm, 5,400 rpm v 8922-23x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Jx, 2Mx, 2Qx, 2Sx, 2Ux, 2Zx, 35x, 3Dx, 3Lx, 48x, 49x, 4Cx, 4Dx, 4Ex, 4Fx, 4Lx, 4Mx, 56x, 58x, 5Cx, 5Ex, 5Fx, 5Gx, 5Hx, 5Kx, A1x, A2x, A4x, A8x, A9x, ACx, ADx, AFx, ALx, ANx, AZx, B7x. B8x, BDx, BGx, BJx, BKx, BLx, BQx, BRx HG[...]

No. FRU FRU no. RoHS ID CRU ID 15 Broadcom 802.1 1bg WLAN PCI-E Mini Card v 8922-27x, 28x, 29x, 2Fx, 2Gx, 2Mx, 2Px, 2Qx, 2Sx, 2Ux, 2Wx, 2Zx, 35x, 36x, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Gx, 56x, 58x, 5Ax, 5Bx, 5Cx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Nx, 5Px, A1x, A2x, A4x, A8x, A9x, AFx, AHx, ALx, ANx, A Wx, AZx, B7x, B8x, BBx, BCx, BGx, BHx, BLx[...]

No. FRU FRU no. RoHS ID CRU ID 23 PC Card slot 41W5224 R N 24 CPU assembly , Intel Celer on M processor 420 (1.6 GHz) v 8922-27x, 28x, 29x, 2Fx, 2Mx, 2Px, 2Qx, 2Sx, 2Ux, 2Wx, 2Zx 42x, 43x, 46x, 49x, 5Ax, 5Bx, 5Cx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Nx, 5Px, A8x, A9x, AW x 41W1202 R N CPU assembly , Intel Celer on M processor 430 (1.73 GHz) v 8922-2Gx, [...]

LCD FRUs 1 2 3 4 6 5 15.0-in. XGA TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel 42W21 10 R N 2 LCD panel, 15.0-in. XGA LG 13N7138 R N AUO 13N7140 R N 3 Inverter card Sumida 41W1394 R N Mitac 41W1395 R N YEC 41W1396 R N 4 LCD cable assembly 93P4357 R N 5 LCD rear cover 42W2109 R N 6 Hinges 42W21 1 1 R N Parts list Lenovo 3000 C200 85[...]

Keyboard Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 39T7368 39T7432 R N Belgian 39T7365 39T7429 Chinese, T raditional 39T7379 39T7443 Czech 39T7373 39T7437 Danish 39T7362 39T7426 Dutch 39T7359 39T7423 English, U.K. 39T7357 39T7421 English, U.S. 39T7353 39T7417 English, U.S. (International, with a Euro symbol) 39T7383 39T7447 Finnish, Sw[...]

Recovery discs Windows XP Professional CDs W indows XP Professional is pr einstalled as the operating system in the following models: v 8922-24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Px, 2Qx, 2Ux, 3Hx, 44x, 46x, 4Ax, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Kx, 4Mx, 4Nx, 58x, 5Ax, 5Dx, 5Gx, 5Hx, 5Px Language P/N RoHS ID CRU ID Arabic 43T4265 R * Chi[...]

Windows XP Home Edition CDs W indows XP Home Edition is preinstalled as the operating system in the following models: v 8922- 23x, 27x, 28x, 2Fx, 2Kx, 2Mx, 2Sx, 2Wx, 2Zx, 35x, 36x, 3Ax, 3Dx, 3Fx, 3Lx, 3Rx, 42x, 43x, 45x, 47x, 48x, 49x, 4Bx, 4Cx, 4Jx, 4Lx, 56x, 5Cx, 5Ex, 5Fx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx Language P/N RoHS ID CRU ID Arabic 43T4481 R * Chi[...]

Windows V ista Home Premium (32 bit) DVDs W indows V ista Home Premium is pr einstalled as the operating system in the following models: v 8922-AHx, A Tx, AUx, A Vx, A Yx, B2x, B3x, B4x, B6x, BHx Language P/N RoHS ID CRU ID Chinese, Simplified 43T7686 R * Chinese, T raditional 43T7687 Chinese, T raditional (Hong Kong S.A.R.) 43T7688 Czech 43T7679 D[...]

Windows V ista Home Basic (32 bit) DVDs W indows V ista Home Basic is preinstalled as the operating system in the following models: v 8922-A1x, A9x, AAx, ACx, AFx, ALx, ANx, APx, A Wx, AZx, BAx, BBx, BDx, BGx, BJx, BLx, BNx, BPx Language P/N RoHS ID CRU ID Chinese, Simplified 43T7634 R * Chinese, T raditional 43T7635 Chinese, T raditional (Hong Kon[...]

Windows V ista Business (32 bit) DVDs W indows V ista Business is preinstalled as the operating system in the following models: v 8922-A2x, A4x, A8x, ABx, ADx, AEx, AMx, B7x, B8x, BKx. BQx, BRx Language P/N RoHS ID CRU ID Arabic 43T7575 R * Chinese, Simplified 43T7581 Chinese, T raditional 43T7582 Chinese, T raditional (Hong Kong S.A.R.) 43T7583 Cz[...]

Corel software CDs Language P/N RoHS ID CRU ID English, U.S. 41X0440 R * French 41X0443 Japanese 41X0608 Portuguese, Brazilian 41X0449 Spanish 41X0446 AC adapters FRU P/N RoHS ID CRU ID 2-pin (65 W, 20 V) adapter (models xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) OP Delta 92P1 155 R * Lite-On 92P1 159 R * Astec 92P1214 R * 3-pin (65W , 20 V) a[...]

Miscellaneous parts FRU P/N RoHS ID CRU ID Screw kit (including nylon-coated scr ews): v M2 × 3 mm (silver), flat head (5) v M2 × 4 mm (black), flat head (15) v M2.5 × 3 mm (black), flat head (15) v M2.5 × 4 mm (silver), flat head (20) v M2.5 × 6 mm (silver), flat head (7) v M2.5 × 6 mm (black), flat head (6) v M2.5 × 8 mm (silver), flat hea[...]

Common parts list T ools T ool P/N T riconnector wrap plug 72X8546 Audio wrap cable 66G5180 USB parallel test cable 05K2580 Screwdriver kit 95F3598 Mini PC tool set 00P7033 1/4" drive spinner handle 1650840 1/4" Sq. to 1/4" hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P6967 Removal tool antenna RF connector 08K7159[...]

Power cords A Lenovo 3000 power cord for a specific country or r egion is usually available only in that country or region: For 2-pin power cords: Region P/N RoHS ID CRU ID Canada, U.S. (models xxF , xxL, xxS, xxU) 39M5016 R * Japan (models Exx, Jxx) 39M5040 Argentina (models xxY) 39M5020 Brazil (models xxP) 39M5056 For 3-pin power cords: Region P/[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

estimated through extrapolation. Actual r esults may vary . Users of this document should verify the applicable data for their specific environment. T rademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Lenovo Care Rescue and Recovery The following terms are trademarks of the International Bu[...]

Part Number: 42T7841 (1P) P/N: 42T7841[...]