Lenovo R500 Bedienungsanleitung

T hinkP a d R5 00 Hard w ar e M a i nte n a n c e M a n ua l[...]

[...]

T hinkP a d R5 00 Hard w ar e M a i nte n a n c e M a n ua l[...]

Note Before using this information and the pr oduct it supports, be sure to read the general information under “Notices” on page 215. Third Edition (September 2009) © Copyright Lenovo 2008, 2009. LENOVO products, data, computer softwar e, and services have been developed exclusively at private expense and are sold to governmental entities as c[...]

Contents About this manual .......... v Safety information .......... 1 General safety .............. 2 Electrical safety ............. 3 Safety inspection guide ........... 5 Handling devices that are sensitive to electr ostatic discharge ............... 6 Grounding r equirements .......... 6 Safety notices (multilingual translations) ..... 7 Lase[...]

Parts list ............. 1 4 1 Overall ............... 1 4 2 LCD FRUs .............. 1 7 9 Keyboard ............... 1 9 0 Miscellaneous parts ........... 1 9 2 AC adapters .............. 1 9 4 Power cords .............. 1 9 5 Recovery discs ............. 1 9 6 W indows XP Pr ofessional (32 bit) DVDs . . . 196 W indows V ista Starter Edition (32 bit[...]

About this manual This manual contains service and refer ence information for the following ThinkPad ® products. ThinkPad R500 MT 2713, 2714, 2716, 2717, 2718, 2719, 2720, 2731, 2732, 2733, 2734, 2735, 2736, and 2737 Use this manual along with the advanced diagnostic tests to troubleshoot problems. Important: This manual is intended only for train[...]

vi ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information This chapter presents following safety information that you need to be familiar with before you service a ThinkPad Notebook. v “General safety” on page 2 v “Electrical safety” on page 3 v “Safety inspection guide” on page 5 v “Handling devices that are sensitive to electr ostatic discharge” on page 6 v “Groundin[...]

General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenl[...]

Electrical safety Observe the following rules when working on electrical equipment. v Find the room emer gency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical accident occurs, you can then operate the switch or unplug the power cord quickly . v Do not work alone under hazardous conditions or near equipment that [...]

v Do not touch live electrical circuits with the r eflective surface of a plastic dental mirror . The surface is conductive; such touching can cause personal injury and machine damage. v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – B[...]

Safety inspection guide The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each machine was designed and built, requir ed safety items were installed to pr otect users and service technicians from injury . This guide addresses only those items. Y ou should use good judgment to identify potential s[...]

Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects. Pr otect against ESD damage by equalizing the charge so that the machine, t[...]

Safety notices (multilingual translations) The safety notices in this section are pr ovided in the following languages: v English v Arabic v Brazilian Portuguese v French v German v Hebrew v Japanese v Korean v Spanish v T raditional Chinese Safety information 7[...]

DANGER Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer . V erify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. DANGER Some standby batteries contain a sma[...]

DANGER T o avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. DANGER Unless hot swap is allowed for the FRU being replaced, do as follows before removing[...]

10 ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information 11[...]

PERIGO Antes de ligar o computador após a substituição da FRU, certifique-se de que todos os parafusos, molas e outras peças pequenas estejam no lugar e não estejam soltos dentro do computador . V erifique isso sacudindo o computador e procurando ouvir sons de peças soltas. Peças metálicas ou lascas de metal podem causar curto-circuito. PER[...]

PERIGO Para evitar choque elétrico, não remova a capa plástica que protege a parte inferior da placa inversora. PERIGO Embora as principais baterias possuam baixa voltagem, uma bateria em curto-circuito ou aterrada pode produzir corrente o bastante para queimar materiais de pessoal ou inflamáveis. PERIGO A menos que uma hot swap seja permitida [...]

DANGER A vant de remettre l’ordinateur sous tension après remplacement d’une unité en clientèle, vérifiez que tous les ressorts, vis et autres pièces sont bien en place et bien fixées. Pour ce faire, secouez l’unité et assurez-vous qu’aucun bruit suspect ne se produit. Des pièces métalliques ou des copeaux de métal pourraient caus[...]

DANGER Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. DANGER Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de courant pour brûler des matériau[...]

VORSICHT Bevor nach einem FRU-Austausch der Computer wieder angeschlossen wird, muß sichergestellt werden, daß keine Schrauben, Federn oder andere Kleinteile fehlen oder im Gehäuse vergessen wurden. Der Computer muß geschüttelt und auf Klappergeräusche geprüft werden. Metallteile oder-splitter können Kurzschlüsse erzeugen. VORSICHT Die Ber[...]

VORSICHT Die Leuchtstoffröhre im LCD-Bildschirm enthält Quecksilber . Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß behandelt wird oder der Computer auf den Boden fällt. W enn der Bildschirm beschädigt ist und die darin befindliche Flüssi[...]

18 ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information 19[...]

20 ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information 21[...]

22 ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information 23[...]

PELIGRO Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo agitando el sistema y escuchando los posibles ruidos que provocarían. Las piezas metálicas pueden causar cortocircuitos eléct[...]

PELIGRO Para evitar descargas, no quite la cubierta de plástico que rodea la parte baja de la tarjeta invertida. PELIGRO Aunque las baterías principales tienen un voltaje bajo, una batería cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal. PEL[...]

26 ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information 27[...]

Laser compliance statement (multilingual translations) The laser compliance statements in this section are pr ovided in the following languages: v English v Arabic v Brazilian Portuguese v French v German v Hebrew v Japanese v Korean v Spanish v T raditional Chinese Some models of ThinkPad Notebook are equipped fr om the factory with an optical sto[...]

Safety information 29[...]

Alguns modelos de computador ThinkPad são equipados na fábrica com um dispositivo de armazenamento ótico, como uma unidade de CD-ROM ou de DVD-ROM. T ais dispositivos também são vendidos separadamente como opcionais. Se uma dessas unidades estiver instalada, ela é certificada nos Estados Unidos em conformidade com os requisitos do Department [...]

Certains modèles d’ordinateur ThinkPad sont équipés d’origine d’une unité de stockage optique telle qu’une unité de CD-ROM ou de DVD-ROM. Ces unités sont également vendues séparément en tant qu’options. Si l’une de ces unités est installée, elle est certifiée conforme, aux Etats-Unis, aux normes indiquées dans le sous-chapi[...]

Einige ThinkPad-Modelle sind werkseitig mit einem CD-ROM- oder DVD-ROM-Laufwerk ausgestattet. CD- und DVD-Laufwerke können auch gesondert als Zusatzeinrichtung erworben werden. Die Laufwerke erfüllen die Anforder ungen gemäß IEC 60825-1 (International Electrotechnical Commission) und gemäß CENELEC EN 60825-1 für Laserprodukte der Klasse 1. B[...]

Safety information 33[...]

34 ThinkPad R500 Hardwar e Maintenance Manual[...]

Safety information 35[...]

Algunos modelos de sistemas ThinkPad están equipados de fábrica con un dispositivo de almacenamiento óptico, como una unidad de CD-ROM o de DVD-ROM. Estas unidades también se venden por separado como opciones. Si está instalada alguna de dichas unidades, se certifica que en los Estados Unidos cumple los requisitos del Department of Health and [...]

Safety information 37[...]

38 ThinkPad R500 Hardwar e Maintenance Manual[...]

Important service information This chapter presents following important service information that applies to all machine types supported by this manual: v “Strategy for replacing FRUs” – “Strategy for replacing a har d disk drive” on page 40 – “Important notice for replacing a system boar d” on page 40 – “How to use error message[...]

Use the following strategy to prevent unnecessary expense for r eplacing and servicing FRUs: v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board. If you are instructed to r eplace either the proces[...]

Strategy for replacing FRUs for CT O, CMV , and GA V Product definition Dynamic Configure T o Order (CTO) This provides the ability for a customer to configur e an IBM ® or a Lenovo solution from an eSite, and have this configuration sent to fulfillment, wher e it is built and shipped directly to the customer . The machine label, Product Entitleme[...]

v Business Partners using Eclaim will access PEW when performing Entitlement Lookup. Business Partners will enter Loc ID, MT and Serial, and the key commodities will be returned in the Eclaim r ecord under SYSTEM DET AILS. v Authorized IBM Business Partners can access Eclaim at the following W eb site: https://wca.eclaim.com Using eSupport For Key [...]

General checkout This chapter presents following information: v “What to do first” on page 44 v “Checkout guide” on page 45 – “Diagnostics using PC-Doctor for DOS” on page 45 – “Lenovo ThinkV antage T oolbox (Lenovo System T oolbox)” on page 48 – “PC-Doctor for W indows” on page 48 – “PC-Doctor for Rescue and Recovery?[...]

What to do first When you do return a FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: __ 1. Name and phone number of service technician __ 2. Date of service __ 3. Date on which the machine failed __ 4. Date of purchase __ 5. Failure symptoms, err or codes appearing on the displ[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the ThinkPad Notebook. Note: The diagnostic tests are intended to test only ThinkPad pr oducts. The use of non-ThinkPad products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1. Identify[...]

T esting the computer Note: The PC-Doctor diagnostic CD does not support any optical drives connected through USB devices or any others. It supports only the internal optical drive of the ThinkPad Notebook. T o run the test, do as follows: 1. T urn off the computer . 2. Make sure that the internal optical drive that is supported as a startup device[...]

The options on the test menu are as follows: Diagnostics Interactive T ests v Run Normal T est v Run Quick T est v CPU/Coprocessor v Systemboard v V ideo Adapter v Serial Ports v Parallel Ports v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v W ireless LAN v Advanced Memory T ests v Keyboard v V ideo v Internal S[...]

v DOS Shell v T ech Support Form v Battery Rundown v V iew T est Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive Lenovo ThinkV antage T oolbox (Lenovo System T oolbox) Lenovo ThinkV antage ® T oolbox (Lenovo System T oolbox in W indows V ista ® and W indows ® XP) is a diagnostic program that works thr ough the W indow[...]

v System Reports v Updates and Support PC-Doctor for Rescue and Recovery In some models of ThinkPad Notebook, the Rescue and Recovery ® workspace enables you to run the PC-Doctor pr ogram to test the hardware featur es of the computer . T o run the test, click “Run Diagnostics” on the Rescue and Recovery main scr een. General checkout 49[...]

FRU tests The following table shows the test for each FRU. T able 1. FRU tests FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard 3. If the docking station or the port replicator is attached to the ThinkPad computer , detach it. Place the computer on a horizontal surface, and run Diagnostics --&[...]

T able 1. FRU tests (continued) FRU Applicable test Memory 1. If two DIMMs are installed, r emove one of them and run Diagnostics --> Advanced Memory T ests . 2. If the problem does not r ecur , return the DIMM to its place, remove the other one, and run the test again. Fan 1. T urn on the computer and check the air turbulence at the louver near[...]

Power system checkout T o verify a symptom, do the following: 1. T urn off the computer . 2. Remove the battery pack. 3. Connect the ac adapter . 4. Check that power is supplied when you turn on the computer . 5. T urn off the computer . 6. Disconnect the ac adapter and install the charged battery pack. 7. Check that the battery pack supplies power[...]

Checking operational charging T o check whether the battery charges pr operly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer . Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let i[...]

Checking the backup battery Do the following: 1. Power off the computer , and unplug the ac adapter from it. 2. T urn the computer upside down. 3. Remove the battery pack (see “1010 Battery pack” on page 84). 4. Remove the backup battery (see “1090 Backup battery” on page 99). 5. Measure the voltage of the backup battery . See the following[...]

Related service information This chapter presents following information: v “Restoring the factory contents by using Product Recovery discs” v “Restoring the factory contents by using Recovery Disc Set” on page 56 v “Passwords” on page 57 v “Power management” on page 60 v “Symptom-to-FRU index” on page 62 Restoring the factory co[...]

8. When the recovery pr ocess is complete, the W elcome to Microsoft W indows screen is displayed. Follow the instr uctions on the screen to complete the W indows setup. Restoring the factory contents by using Recovery Disc Set When the hard disk drive is r eplaced because of a failure, no product r ecovery program is on the new har d disk. In this[...]

5. Read the license. If you agree with the terms and conditions, select I accept these terms and conditions and then click Next . If you do not agree with the terms and conditions, follow the instructions on the scr een. 6. Click Ye s in the displayed window to begin the operating system r ecovery process. 7. Insert the Applications and Drivers Rec[...]

Note: There ar e two modes for the HDP: User only and Master + User . The Master + User mode requir es two HDPs; the system administrator enters both in the same operation. The system administrator then provides the user HDP to the system user . Attention: If the user HDP has been for gotten, check whether a master HDP has been set. If it has, it c[...]

5. Select Power-On Password . 6. T ype the current SVP in the Enter Current Password field. then leave the Enter New Password field blank, and press Enter twice. 7. In the Changes have been saved window , press Enter . 8. Press F10; then, in the Setup confirmation window , select Ye s . How to remove the hard-disk password Attention: If User only m[...]

Power management T o reduce power consumption, the computer has thr ee power management modes: screen blank, sleep (standby in W indows XP), and hibernation. Screen blank mode If the time set on the “T urn off monitor” timer in the operating system expir es, the LCD backlight turns off. T o put the computer into screen blank mode, do as follows[...]

Also, in either of the following events, the computer automatically returns fr om sleep (standby) mode and resumes operation: v The ring indicator (RI) is signaled by a serial device or a PC Card device. v The time set on the resume timer elapses. Note: The computer does not accept any input immediately after it enters sleep (standby) mode. W ait a[...]

Symptom-to-FRU index This section contains following information: v “Numeric error codes” v “Error messages” on page 66 v “Beep symptoms” on page 67 v “No-beep symptoms” on page 67 v “LCD-related symptoms” on page 68 v “Intermittent problems” on page 69 v “Undetermined problems” on page 69 The symptom-to-FRU index in thi[...]

T able 2. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0187 EAIA data access error—The access to EEPROM is failed. System board. 0188 Invalid RFID Serialization Information Area. System board. 0189 Invalid RFID configuration information area—The EEPROM checksum is not corr ect. System board. 0190 Critical low-batt[...]

T able 2. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0250 System battery error—System battery is dead. 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 0251 System CMOS checksum bad— Default conf[...]

T able 2. Numeric error codes (continued) Symptom or error FRU or action, in sequence 1804 Unauthorized W AN card is plugged in—Power off and r emove the W AN car d. 1. Remove the W AN card that you installed. 2. System board. 1805 Unauthorized W ireless USB car d is plugged in—Power off and r emove the W ireless USB card. 1. Remove the W irele[...]

Error messages T able 3. Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Failing bits: nnnn. 1. D[...]

Beep symptoms T able 4. Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or flashing LCD. 1. Reseat the LCD connector . 2. LCD assembly . 3. External CR T . 4. System board. One long and two short beeps, and a blank or unreadable LCD. 1. System board . 2. LCD assembly . 3. DIMM. T wo short beeps with error[...]

LCD-related symptoms T able 6. LCD-related symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, and a blank LCD during POST . System board . v LCD backlight not working. v LCD too dark. v LCD brightness cannot be adjusted. v LCD contrast cannot be adjusted. 1. Reseat the LCD connectors . 2. LCD assembly . 3. System b[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

70 ThinkPad R500 Hardwar e Maintenance Manual[...]

Status indicators This chapter presents the system status indicators that show the status of the computer . 10 1 2 3 4 5 6 7 8 9 7 8 9 © Copyright Lenovo 2008, 2009 71[...]

T able 7. Status indicators Indicator Meaning 1 W ireless LAN status Green: The LAN wireless featur e is on, and the radio link is ready for use. Blinking green: Data is being transmitted. 2 Bluetooth status R Green: Bluetooth wireless is operational. This indicator is on when Bluetooth wireless is on and not in suspend mode. 3 Nu[...]

T able 7. Status indicators (continued) Indicator Meaning 10 Serial Ultrabay Enhanced status Green: A Serial Ultrabay Enhanced device is installed and in use. Blinking green: A Serial Ultrabay Enhanced device is in the process of being detached. T urn off: A Serial Ultrabay Enhanced device is ready to be attached or detached. Note: If you are[...]

74 ThinkPad R500 Hardwar e Maintenance Manual[...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . T able 8. Fn key combinations Key combination Description Fn+F1 Reserved. Fn+F2 Lock the computer . Fn+F3 Select a power plan (in W indows XP , power scheme) that has been created by Power Manager , or adjust the power level by using the slide[...]

T able 8. Fn key combinations (continued) Key combination Description Fn+F7 Apply a presentation scheme dir ectly , with no need to start Presentation Dir ector . T o disable this function and use the Fn+F7 key combination for switching a display output location, start Presentation Dir ector , and change the settings. Note: If the computer is a win[...]

T able 8. Fn key combinations (continued) Key combination Description Fn+F10 Reserved. Fn+F1 1 Reserved. Fn+F12 Put the computer into hibernation mode. T o return to normal operation, press the power button for less than four seconds. Note: T o use Fn+F12 for hibernation, you must have the ThinkPad PM device driver installed on the computer . Fn+Pg[...]

78 ThinkPad R500 Hardwar e Maintenance Manual[...]

FRU replacement notices This chapter presents notices r elated to removing and replacing parts. Read this chapter carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the ThinkPad Notebook, this problem is addr essed with special nylon-coated screws that have the following characteristics: v They main[...]

Retaining serial numbers This section includes the following descriptions: v “Restoring the serial number of the system unit” v “Retaining the UUID” v “Reading or writing the ECA information” on page 81 Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the [...]

The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number . When you replace the system boar d, you must set the UUID on the new system board as follows: 1. Install the ThinkPad Hardwar e Maintenance Diskette V ersion 1.73 or later , and restart the compute[...]

82 ThinkPad R500 Hardwar e Maintenance Manual[...]

Removing and replacing a FRU This chapter presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU repla[...]

1010 Battery pack DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. T able 9. Removal steps of battery pack Unlock the battery release lever 1 . Holding the battery r elease lever in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow [...]

1020 Serial Ultrabay Enhanced device T able 10. Removal steps of Serial Ultrabay Enhanced device for R61 and R61i When you release the switch in step 1 , the lever pops out. In step 2 , pull the lever a little to release the device fr om the bay . 1 2 3 Note: Serial Ultrabay Enhanced does not accept any of the following devices: v Ultra[...]

1030 Hard disk drive cover , hard disk drive, and hard disk rubber rails For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 T able 1 1. Removal steps of hard disk drive cover , hard disk drive, and hard disk rubber rails 1 Step Screw (quantity) Color T orque 1 Hard disk drive scr ew (M2 × 17 mm), flat-head, nylon-[...]

T able 1 1. Removal steps of hard disk drive cover , hard disk drive, and hard disk rubber rails (continued) 3 4 5 When installing: Make sure that the har d disk drive connector is attached firmly . 6 6 When installing: The rubber rails on the har d disk drive must be attached to the replacement drive. Otherwise the drive cannot be installed pr ope[...]

1040 Palm rest or palm rest with fingerprint reader For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 T able 12. Removal steps of palm rest 1 1 1 1 Step Icon Screw (quantity) Color T orque 1 M2 × 17 mm, flat-head, nylon-coated (4) Black 0.167 Nm (1.7 kgfcm) Note: In models with the fingerprint reader , the sensor[...]

T able 12. Removal steps of palm rest (continued) 2 2 3 When installing: When you attach the palm rest, do as follows: 1. Attach the fingerprint reader connector firmly to the system boar d. Removing and replacing a FRU 89[...]

T able 12. Removal steps of palm rest (continued) 2. Attach the palm rest so that the two pr ojections of the palm rest ( a ) firmly fit into the guide holes of the keyboard bezel as shown in this figur e. a a 3. Push the front side of the palm r est until it clicks into place. 4. Close the LCD cover and turn the computer over . Then fasten t[...]

1050 DIMM For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 T able 13. Removal steps of dimm Note: If only one DIMM is used on the computer you are servicing, the car d must be installed in SLOT -0 ( a ), but not in SLOT -1 ( b ). 1 2 a [...]

1060 Keyboard For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 T able 14. Removal steps of keyboard 1 Step Icon Screw (quantity) Color T orque 1 M2 × 17 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) Lift the keyboard a little in[...]

T able 14. Removal steps of keyboard (continued) When installing: Make sure that the keyboar d edges a are under the frame as shown in this figure. a a Removing and replacing a FRU 93[...]

1070 PCI Express Mini Card for wireless LAN For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 T able 15. Removal steps of PCI Express Mini Card for wireless LAN Full size PCI Express Mini card: . In step 1 , un[...]

T able 15. Removal steps of PCI Express Mini Card for wireless LAN (continued) 3 When installing: In models with wireless LAN car d that has two antenna connectors, plug the gray cable into the jack labeled MAIN or M on the card, and the black cable into the jack labeled AUX or A . If the computer you are servicing has thr ee cables, put the white [...]

T able 15. Removal steps of PCI Express Mini Card for wireless LAN (continued) Half size PCI Express Mini card: In step 1 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the arr ow . 2 2 1 Step Screw (quantity) Color T orque 2?[...]

T able 15. Removal steps of PCI Express Mini Card for wireless LAN (continued) When installing: Plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX . Removing and replacing a FRU 97[...]

1080 Intel T urbo Memory Minicard For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 T able 16. Removal steps of Intel T urbo Memory 1 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coate[...]

1090 Backup battery DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. For access, remove these FRUs in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 T able 17. Removal steps of [...]

1 100 Keyboard bezel and speakers For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 T able 18. Removal steps of keyboard bezel and speakers Note: Speakers are attached to the underside of the keyboar d bezel. 1 Step [...]

T able 18. Removal steps of keyboard bezel and speakers (continued) 4 4 4 3 4 4 4 In step 3 , release the wir eless antenna cables from the cable guide. Step Screw (quantity) Color T orque 4 M2 × 3 mm, flat-head, nylon-coated (6) Silver 0.167 Nm (1.7 kgfcm) In step 5 , strip the securing tapes off. Then detach the speaker connect[...]

T able 18. Removal steps of keyboard bezel and speakers (continued) In step 7 , detach the claws. Then remove the keyboar d bezel in the direction shown by arrow 8 . 7 7 7 7 8 8 When installing: Make sure that all the claws ar e attached firmly . 9 9 9 9 10 10 Step Screw (quantity) Color T orque 9 M2 × 3 mm, flat-head, nylon-coat[...]

1 1 10 Fan assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 v “1 100 Keyboard bezel and speakers” on page 100 T able 19. Removal steps of fan assembly 3 2 1 3 1 2 Step Screw (quantity) Color T orque [...]

T able 19. Removal steps of fan assembly (continued) Attention: Do not handle the fan roughly . Improper handling of the fan can cause distortion or deformation and imperfect contact with components. 4 4 4 5 Step Screw (quantity) Color T orque 4 M2 × 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) In step 5 , release the[...]

T able 19. Removal steps of fan assembly (continued) When installing: v Before you attach the fan assembly to the computer , apply thermal grease, at an amount of 0.2 grams, on the part marked a as in the following figure. Either too much or too less application of grease can cause a thermal pr oblem due to imperfect contact with a component.[...]

T able 19. Removal steps of fan assembly (continued) v Make sure that the fan connector is attached firmly . v When attaching the fan assembly to the frame, take care not to damage the heat sink ( b ) of the fan assembly . b b 106 ThinkPad R500 Hardwar e Maintenance Manual[...]

1 120 CPU For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 v “1 100 Keyboard bezel and speakers” on page 100 v “1 1 10 Fan assembly” on page 103 T able 20. Removal steps of CPU Attention: CPU is extremely se[...]

1 130 LCD assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 v “1070 PCI Express Mini Car d for wireless LAN” on page 94 v “1 100 Keyboard bezel and speakers” on page 100 T able 21. Removal steps of L[...]

T able 21. Removal steps of LCD assembly (continued) 3 3 2 4 4 4 Step Screw (quantity) Color T orque 3 M2.5 × 6.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) In step 4 , strip off the tapes securing the antenna cables, and r elease the cables from the cable guides of the frame. Removing and replacing a FRU 109[...]

T able 21. Removal steps of LCD assembly (continued) 5 5 When installing: 1. Route the antenna cables along the cable guides and secure them with the tapes. As you route the cables, make sur e that they are not subjected to any tension. T ension could cause the cables to be damaged by the cable guides, or a wire to be br oken. 2. Make sure that the[...]

1 140 Base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1020 Serial Ultrabay Enhanced device” on page 85 v “1030 Hard disk drive cover , hard disk drive, and har d disk rubber rails” on page 86 v “1040 Palm rest or palm r est with[...]

T able 22. Removal steps of base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly (continued) 3 3 4 4 Step Screw (quantity) Color T orque 3 M2 × 9.5 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) 4 M2 × 17 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) 11 2 ThinkPad R500 Hardwar e Mainte[...]

T able 22. Removal steps of base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly (continued) 5 5 6 7 8 Step Screw (quantity) Color T orque 5 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.167 Nm(1.7 kgfcm) Removing and replacing a FRU 11 3[...]

T able 22. Removal steps of base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly (continued) Attention: Before step 7 , be sur e that the Serial Ultrabay Enhanced device eject lever has not popped out. It must be housed in its position as shown in the figure a . a 7 8 b When installing: Check the position of the[...]

T able 22. Removal steps of base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly (continued) Remove the security hole bracket as in this figure. 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coated (1) Silver 0.167 Nm(1.7 kgfcm) Removing and replacing a FRU 11 5[...]

T able 22. Removal steps of base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly (continued) Remove the RJ1 1 cable a and the optical drive switch cable b as in this figure. In step 2 , strip the securing taps off. 3 3 4 5 2 2 a b Step Screw (quantity) Color T orque 3 M2 × 3 mm, flat-head, nylon-coa[...]

T able 22. Removal steps of base cover and PC Card/ExpressCard (or ExpressCard/Smart Card) bezel assembly (continued) When removing the PC Car d/ExpressCard bezel assembly , do as shown in this figure. 1 2 When removing the Expr essCard/Smart Card bezel assembly , do as shown in this figure. 1 2 Removing and replacing a FRU 11 7[...]

Applying labels to the base cover: The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover , you need to apply the following label: 1 Product label 1a Non-mercury label Note: If the computer you are servicing is an LED-backlight LCD model, you need to paste this label so that the [...]

1 150 Structure frame and IEEE 1394 sub card For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1020 Serial Ultrabay Enhanced device” on page 85 v “1030 Hard disk drive cover , hard disk drive, and har d disk rubber rails” on page 86 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “[...]

T able 23. Removal steps of structure frame and IEEE 1394 sub card (continued) Remove the ac power jack cable a . 2 3 a When installing: Make sure the connectors ar e attached firmly . 120 ThinkPad R500 Hardwar e Maintenance Manual[...]

T able 23. Removal steps of structure frame and IEEE 1394 sub card (continued) Remove the CPU support plate. 6 Step Screw (quantity) Color T orque 6 M2 × 5 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) Removing and replacing a FRU 121[...]

T able 23. Removal steps of structure frame and IEEE 1394 sub card (continued) 7 7 7 7 8 a Step Screw (quantity) Color T orque 7 M2 × 3.5 mm, bind-head, nylon-coated (4) Black 0.167 Nm (1.7 kgfcm) 8 M2 × 9.5 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) When installing: When attaching the system board to the frame, adjust[...]

T able 23. Removal steps of structure frame and IEEE 1394 sub card (continued) In step 10 , remove the system boar d and the PC Card/ExpressCar d slots assembly from the str ucture frame together . In step 11 and 12 , remove IEEE 1394 sub car d. 11 12 10 9 Step Screw (quantity) Color T orque 11 M2 × 5 mm, flat-head, nylon-c[...]

1 160 System board, PC Card/ExpressCard slots (or ExpressCard/Smart Card slots) assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1020 Serial Ultrabay Enhanced device” on page 85 v “1030 Hard disk drive cover , hard disk drive, and har d disk rubber rails” on page 86 v “1040 Palm rest or palm r est[...]

Following components soldered on the top side of the system boar d are extremely sensitive. When you service the system board, avoid any kind of r ough handling. a CPU b V ideo chip (Discrete graphics chip models only .) c MCH (Memory Controller Hub) d ICH (I/O Controller Hub) e Accelerometer chip for the HDD Active Pr[...]

T able 24. Removal steps system board, PC Card/ExpressCard slots (ExpressCard/Smart Card slots) assembly (continued) T urn the system board over , and then disconnect the PC Card/Expr essCard slots (or ExpressCar d/Smart Card slots) assembly a from the system boar d. 2 a When installing: Make sure that the connector of the PC Car d/Express Ca[...]

2010 LCD front bezel For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 T able 25. Removal steps of LCD front bezel 2 2 2 1 1 Step Screw cap Screw (quantity) Color T orque 1 M2.5 × 6.5 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) 2 M2.5 × 6.5 mm, flat-head, nylon-coated (3) Black 0.392 Nm (4 kgf[...]

2020 Inverter card or LED control card For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “2010 LCD front bezel” on page 127 T able 26. Removal steps of inverter card or LED control card 1 4 2 3 Step Screw (quantity) Color T orque 1 M2 × 2.8 mm, flat-head, nylon-coated (1) Silver 0.167 Nm (1.7 kgfcm) When in[...]

2030 Bluetooth daughter card (BDC-2.1) For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “2010 LCD front bezel” on page 127 T able 27. Removal steps of Bluetooth daughter card 1 2 Step Screw (quantity) Color T orque 1 M2 × 2.8 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) When installing: Make [...]

2040 Integrated camera For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “2010 LCD front bezel” on page 127 T able 28. Removal steps of Integrated camera Note: The part marked a is fragile and might be damaged by rough handling. When you remove the camera, do not hold that part to avoid the damage. 1 2 3 a S[...]

2050 LCD panel, LCD cable, hinges, and ALPET sheets For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 v “1070 PCI Express Mini Car d for wireless LAN” on page 94 v “1 100 Keyboard bezel and speakers” on page [...]

T able 29. Removal steps of LCD panel, LCD cable, hinges, and ALPET sheets (continued) Remove the hinges a . a a 5 5 5 6 5 6 Step Screw (quantity) Color T orque 5 M2 × 2.8 mm, flat-head, nylon-coated (4) Silver 0.167 Nm (1.7 kgfcm) Cable routing: When you install the LCD panel, make sure that the antenna cables are r outed as shown in [...]

T able 29. Removal steps of LCD panel, LCD cable, hinges, and ALPET sheets (continued) Remove the ALPET sheets, b and c . b 7 Note: The ALPET sheets are secur ed with a double-faced adhesive tape. 8 c 9 Removing and replacing a FRU 133[...]

T able 29. Removal steps of LCD panel, LCD cable, hinges, and ALPET sheets (continued) Remove the LCD cable d . d 10 11 When installing: Make sure that the connector is attached firmly . 134 ThinkPad R500 Hardwar e Maintenance Manual[...]

2060 LCD rear cover and wireless LAN antenna cables For access, remove these FRUs, in or der: v “1010 Battery pack” on page 84 v “1040 Palm rest or palm r est with fingerprint reader” on page 88 v “1060 Keyboard” on page 92 v “1070 PCI Express Mini Car d for wireless LAN” on page 94 v “1 100 Keyboard bezel and speakers” on page [...]

136 ThinkPad R500 Hardwar e Maintenance Manual[...]

Locations This chapter presents the location of ThinkPad R500 featur es and hardware. Front view 1 ThinkLight 2 Integrated camera (for some models) 3 Status indicators Note: For the description of each indicator , see “Status indicators” on page 71. 4 W ireless LAN antennas 5 Stereo speakers 6 Security key ho[...]

Rear view 1 Status indicators Note: For the description of each indicator , see “Status indicators” on page 71. 2 IEEE 1394 connector 3 PC Card/Expr essCard/Smart Card slots eject buttons 4 PC Card/Expr essCard/Smart Card slots 5 USB connector 6 RJ-45 (Ethernet) connector 7 Display Port 8 External[...]

Bottom view 1 Battery pack 2 Battery pack latch 3 Docking connector 4 W ireless radio switch 5 Stereo headphone jack 6 Microphone jack 7 7-in-1 Media Card Reader slot 8 LCD cover latch 9 Hard disk drive 1 2 3 4 5 7 8 9 6 Locations 139[...]

140 ThinkPad R500 Hardwar e Maintenance Manual[...]

Parts list This section contains following lists of the service parts. v “Overall” on page 142 v “LCD FRUs” on page 179 v “Keyboard” on page 190 v “Miscellaneous parts” on page 192 v “AC adapters” on page 194 v “Power cords” on page 195 v “Recovery discs” on page 196 v “Common service tools” on page 213 Notes: v Each[...]

Overall 1 3 4 b 5 6 7 8 9 10 11 12 13 14 e f g 15 16 17 18 19 21 20 22 23 a d 2 c 142 ThinkPad R500 Hardwar e Maintenance Manual[...]

T able 31. Parts list—Overall No. FRU FRU no. CRU ID a-g See “Miscellaneous parts” on page 192. 1 LCD unit (see “LCD FRUs” on page 179.) 2 Keyboar d bezel 44C9571 N 3 Palm r est assembly with fingerprint reader v 2713-CTO, 3Jx, 5Kx, 5Lx, 5Mx, 7Bx v 2714-CTO, 34x, 38x, 39x, 3Bx, 3Cx, 3Dx, 3Ex, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 5 ThinkPad 1 1b/g W ir eless LAN Mini PCI Express Adapter III v 2713-CTO, 5Jx, 99x v 2714-CTO, 54x, 59x, 5Ax, 5Bx, 5Cx v 2716-CTO, 5Tx, 9Ax v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO, 4Nx, 77x v 2732-CTO, 4Fx, 4Gx, 4Hx, 4Jx v 2733-CTO, 3Bx, 3Cx, 4Tx, 4Ux, 78x v 2734-CTO [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 5 Intel W iFi Link 5300 v 2713-CTO v 2714-CTO, 4Ux, 4Vx v 2716-CTO, 3Rx, 3Sx, 45x, 85x, 86x, A4x v 2717-CTO v 2718-CTO, 4Jx, 4Kx, 74x v 2719-CTO v 2720-CTO v 2731-CTO, 4Rx, 4Sx v 2732-CTO, 35x, 36x, 3Zx, 42x, 43x, 4Kx, 4Lx, 4Mx, 52x, 58x v 2733-CTO, 3Fx, 3Gx, 3Nx, 3Px, 3Qx, 5Jx, 5Px[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 5 ThinkPad 1 1b/g/n W ir eless LAN Mini-PCI Express Adapter II v 2713-CTO, 9Dx v 2714-CTO, 9Rx, A7x, AFx, ARx, B8x v 2716-CTO, 9Ex, 9Fx, 9Gx, 9Hx, 9Jx, 9Kx, 9Lx, 9Mx, A5x v 2717-CTO, A8x, ASx v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO, 79x, 7Ax v 2732-CTO, 83x v 2733-CTO, 7Bx, 7Cx,[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 80 GB, 5,400 rpm v 2713-CTO, 3Hx, 7Ax v 2714-CTO, 4Wx, 4Xx, 53x, 7Px, E2x, E7x, E8x, E9x, EAx v 2716-CTO, 3Kx, 3Tx, 5Px, 6Jx, 6Lx, 7Cx, 7Gx, 7Hx, ECx v 2717-CTO v 2718-CTO, 3Kx, 49x, 6Lx v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 27[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 160 GB, 5,400 rpm OP v 2713-CTO, 3Jx, 5Jx, 5Kx, 5Lx, 7Bx, 97x, 98x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Rx, 4Sx, 4Tx, 4Yx, 4Zx, 54x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx, 62x, 63x, 65x, 66[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 250 GB, 5,400 rpm OP v 2713-CTO, 3Gx, 5Mx v 2714-CTO, 3Bx, 4Qx, 4Ux, 4Vx, 64x, 6Ax, 6Cx, 6Dx, 6Ex, 6Hx, 7Lx, 7Mx, 7Tx, 7Ux, 7Vx, 7Wx, 7Xx, 8Lx, 8Tx, 8Ux, 96x, 9Nx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, A7x, A9x, AAx, AFx, AGx, AHx, AJx, AKx, AL[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 320 GB, 5,400 rpm OP v 2713-CTO v 2714-CTO, B5x v 2716-CTO, A Wx v 2717-CTO, A8x, ASx v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO, 4Rx, 4Sx v 2732-CTO, 3Yx, 47x, 56x, 5Cx, 5Ex, 5Gx, 6Ex, 6Fx, 75x, 76x, 7Ex, 7Fx, 7Gx, 7Hx, 7Jx, 7Kx, 7Ux, 7Yx v 2733-CTO[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 500 GB, 5,400 rpm v 2713-CTO, 99x v 2714-CTO v 2716-CTO, 9Ax v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO, 77x v 2732-CTO v 2733-CTO, 78x v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 45N7221 * 9 SA T A hard disk drive, 100 GB, 7,200 rpm OP v [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 160 GB, 7,200 rpm OP v 2713-CTO, 3Fx v 2714-CTO, 55x, 56x, 57x, 58x, 7Sx v 2716-CTO. 8Sx, A6x, ADx, AEx v 2717-CTO, 5Hx, 75x v 2718-CTO, 4Bx, 4Hx, 6Vx, 73x, 8Sx v 2719-CTO v 2720-CTO v 2731-CTO, 37x v 2732-CTO v 2733-CTO, 3Jx, 3Mx, 3Nx, 5Lx, 5Nx, 5Px,[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 200 GB , FDE, 7,200 rpm OP v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO, 4Gx, 4Jx, 72x, 74x v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO, 3Kx, 3Px v 2734-CTO v 2735-CTO, 3Tx, 3Ux, 5Sx v 2736-CTO v 2737-CTO 42T1463 * 9 SA T A hard d[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 250 GB , 9.5 mm, FDE, 7,200 rpm v 2713-CTO v 2714-CTO v 2716-CTO, 8Ax, 8Ex v 2717-CTO v 2718-CTO, 8Fx, 8Kx v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO, 6Ux v 2734-CTO v 2735-CTO, 6Zx v 2736-CTO v 2737-CTO 42T1573 * 9 SA T A hard disk drive, 320 G[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 9 SA T A hard disk drive, 500 GB, 7,200 rpm v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 45N7267 * 10 Battery pack, Li-ion (6 cell, 2.2 Ah) v 2713-CTO v 2714-CTO v 2716-CTO v[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 10 Battery pack, Li-ion (6 cell, 2.4 Ah) v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x,[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 10 Battery pack, Li-ion (6 cell, 2.4 Ah) v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x,[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 10 Battery pack, Li-ion (6 cell, 2.4 Ah) v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x,[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 10 Battery pack, Li-ion (6 cell, 2.6 Ah) v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 42T4621 * 10 Battery pack, Li-ion (6 cell, 2.6 Ah) v 2713-CTO v 2714-CTO v 2716-CTO v 27[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 10 Battery pack, Li-ion (9 cell, 2.6 Ah) v 2713-CTO v 2714-CTO v 2716-CTO, 3Mx, EBx v 2717-CTO v 2718-CTO, 3Mx v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 42T4619 * 1 1 DVD drive v 2713-CTO, 97x v 2714-CTO v 2716-CTO v 2717-CTO [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 1 1 DVD/CD-R W combo drive v 2713-CTO, 3Hx, 7Ax, 98x, 9Dx v 2714-CTO, 4Sx, 4Wx, 4Xx, 53x, 55x, 57x, 66x, 7Px, 92x, 94x, E2x, E5x, E6x, E7x, E8x v 2716-CTO, 3Kx, 3Tx, 5Px, 6Jx, 7Cx, 7Gx, 8Yx, ECx v 2717-CTO v 2718-CTO, 3Kx, 49x v 2719-CTO v 2720-CTO v 2731-CTO, 39x, 63x v 2732-CTO, 4[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 1 1 DVD-RAM/R W drive v 2713-CTO, 3Fx, 3Gx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Bx, 99x v 2714-CTO, 34x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Tx, 4Ux, 4Vx, 4Yx, 4Zx, 54x, 56x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ux, 5Wx, 5Xx, 5Yx, 5Zx, 62x, 63x, 64x, 65x, 67x, 69x[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 1 1 DVD-RAM/R W drive v 2713-CTO, 3Fx, 3Gx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Bx, 99x v 2714-CTO, 34x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Tx, 4Ux, 4Vx, 4Yx, 4Zx, 54x, 56x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ux, 5Wx, 5Xx, 5Yx, 5Zx, 62x, 63x, 64x, 65x, 67x, 69x[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 1 1 DVD-RAM/R W drive v 2713-CTO, 3Fx, 3Gx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Bx, 99x v 2714-CTO, 34x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Tx, 4Ux, 4Vx, 4Yx, 4Zx, 54x, 56x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ux, 5Wx, 5Xx, 5Yx, 5Zx, 62x, 63x, 64x, 65x, 67x, 69x[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 1 1 DVD-RAM/R W drive v 2713-CTO, 3Fx, 3Gx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Bx, 99x v 2714-CTO, 34x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Tx, 4Ux, 4Vx, 4Yx, 4Zx, 54x, 56x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ux, 5Wx, 5Xx, 5Yx, 5Zx, 62x, 63x, 64x, 65x, 67x, 69x[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 1 1 Blu-Ray disk drive v 2713-CTO v 2714-CTO, 36x, 5Vx, 68x v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO, 46x, 47x, 55x, 56x, 5Cx v 2733-CTO v 2734-CTO v 2735-CTO, 3Vx v 2736-CTO v 2737-CTO 42T2525 * 1 1 T ravel cover v 2713-CTO, xxE, xxJ v 2714-CTO, [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 14 PC Card/Expr essCard bezel assembly v 2713-CTO, 3Fx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 15 512-MB DDR3-1067 SDRAM SO-DIMM (PC3-8500) card v 2713-CTO v 2714-CTO, 4Nx, E2x, E4x, 7Px v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO, 3Cx v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 43R1775 ** 15 1-GB DDR3-1067 SDRAM SO-DIMM (PC3-8500) [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 15 2-GB DDR3-1067 SDRAM SO-DIMM (PC3-8500) card v 2713-CTO, 3Gx, 5Lx, 99x v 2714-CTO, 34x, 5Ux, 77x, 79x, 7Lx, 7Mx, 7Tx, 7Ux, 8Tx, 8Ux, 96x, 9Nx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx, 9Ux, 9Vx, 9Wx, 9Xx, A7x, A9x, AAx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx, B5x, B6x, B7x, B8x v 2716-CTO, 3Sx, 4[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 16 System board assembly , AMD M82XT 128 MB for TPM v 2731-CTO, 37x, 38x, 39x, 3Ax, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 77x, 79x, 7Ax v 2732-CTO, 32x, 33x, 34x, 35x, 36x, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Xx[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 17 CPU assembly , Intel Celer on processor900 (2.2 GHz) v 2713-CTO, 97x, 98x v 2714-CTO, 92x, 93x, 94x, 95x, ARx v 2716-CTO, A5x v 2717-CTO v 2718-CTO, 9Bx, 9Cx v 2719-CTO v 2720-CTO 43R0795 N 17 CPU assembly , Intel Celer on processor T3000 (1.8 GHz) v 2713-CTO v 2714-CTO v 2716-CT[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 17 CPU assembly , Intel Cor e 2 Duo mobile processor P8400 (2.26 GHz) v 2713-CTO, 3Hx, 3Jx, 5Jx, 5Kx, 7Ax, 7Bx v 2714-CTO, 34x, 37x, 38x, 39x, 3Ax, 3Cx, 4Lx, 4Rx, 4Sx, 4Tx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 5Dx, 5Ux, 5Wx, 5Xx, 65x, 66x, 67x, 69x, 76x, 77x, 78x, 79x v 2716-CTO, 3Kx, 3Nx,[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 17 CPU assembly , Intel Cor e 2 Duo mobile processor P8800 (2.66 GHz) v 2713-CTO v 2714-CTO, AKx, ALx v 2716-CTO, 9Zx, A2x, A3x, A6x, ADx, AEx v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO, 7Yx v 2733-CTO, 7Mx, 7Nx, 7Sx, 7Tx, 7Wx v 2734-CTO v 2735-CTO v 2736-CTO [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 17 CPU assembly , Intel Cor e 2 Duo mobile processor T6570 (2.1 GHz) v 2713-CTO v 2714-CTO, 7Xx, 8Lx, 8Tx, 8Ux, 96x, 9Px v 2716-CTO, 8Bx v 2717-CTO, 8Vx v 2718-CTO, 8Gx v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO, 6Hx, 6Jx, 6Kx, 6Lx, 7Fx, 84x v 2733-CTO, 6Wx v 2734-CTO v 2735-CTO, 7[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 17 CPU assembly , Intel Cor e 2 Duo mobile processor T9550 (2.66 GHz) v 2713-CTO v 2714-CTO v 2716-CTO, 85x, 86x, 8Ax v 2717-CTO v 2718-CTO, 8Fx v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO, 6Qx, 6Rx, 6Sx, 6Ux, 7Dx v 2734-CTO v 2735-CTO, 6Zx v 2736-CTO v 2737-CTO 42W8195 N[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 17 CPU assembly , Intel Cor e 2 Duo mobile processor T9900 (3.06 GHz) v 2713-CTO v 2714-CTO v 2716-CTO, A4x v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO, 7Px, 7Qx, 7Rx v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 42W8197 N 18 PC Card/Expr essCard slot [...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 18 ExpressCar d/Smart Card slot v 2713-CTO, 3Gx v 2714-CTO v 2716-CTO, 3Xx, 6Px v 2717-CTO v 2718-CTO, 4Dx, 6Xx v 2719-CTO v 2720-CTO v 2731-CTO, 38x v 2732-CTO v 2733-CTO, 3Jx, 3Qx, 5Lx v 2734-CTO v 2735-CTO, 3Vx v 2736-CTO v 2737-CTO 42X4992 N 18 ExpressCar d/Smart Card slot v 271[...]

T able 31. Parts list—Overall (continued) No. FRU FRU no. CRU ID 21 Thermal device and fan (Integrated graphics) v 2713-all v 2714-all v 2716-all v 2717-all v 2718-all v 2719-CTO v 2720-CTO 44C0799 N 21 Thermal device and fan (Discrete graphics) v 2731-all v 2732-all v 2733-all v 2734-all v 2735-all v 2736-CTO v 2737-CTO 44C0800 N 22 Keyboard (se[...]

LCD FRUs In R500, there ar e following types of LCDs. v 15.4-in. WXGA TFT LCD (T able 32 on page 180) v 15.4-in. WSXGA+ TFT LCD (T able 33 on page 188) 1 3 4 5 7 6 8 9 10 11 2 Parts list 179[...]

T able 32. Parts list—15.4-in. WXGA TFT No. FRU FRU no. CRU ID 1 LCD bezel assembly 44C9568 N 2 LCD cover kit 44C9567 N 3 W ir eless LAN antenna assembly 44C5397 N 3 W ir eless LAN antenna assembly 44C4058 N 4 ALPET Sheet 42X3952 N 5 LCD cable WXGA with integrated camera and Bluetooth v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, [...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 7 Integrated camera v 2713-CTO, 3Fx, 3Gx, 99x v 2714-CTO, 36x, 37x, 38x, 3Ax, 3Bx, 3Dx, 3Ex, 54x, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx, 68x, 69x, 6Ax, 6Ex, 7Nx, 7Tx, 7Ux, 8Tx, 8Ux, 96x, 9Nx, 9Sx, 9Tx, 9Vx, 9Wx, 9Xx, A7x, A9x, AAx, AFx, AGx, AHx, AJx, AKx, ALx, B5x, B6x, B7x v 2716-CTO,[...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 8 Inverter car d v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx[...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 8 LED contr ol card v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO 45M2780 N 9 Bluetooth daughter car d (BDC-2.1) v 2713-CTO, 3Fx, 3Gx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Bx, [...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 10 LCD panel, 15.4-in. WXGA v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x, 59[...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 10 LCD panel, 15.4-in. WXGA v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x, 59[...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 10 LCD panel, 15.4-in. WXGA v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x, 59[...]

T able 32. Parts list—15.4-in. WXGA TFT (continued) No. FRU FRU no. CRU ID 10 LCD panel, 15.4-in. WXGA v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 97x, 98x, 99x, 9Dx v 2714-CTO, 34x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 54x, 55x, 56x, 57x, 58x, 59[...]

T able 33. Parts list—15.4-in. WSXGA+ TFT No. FRU FRU no. CRU ID 1 LCD bezel assembly 44C9568 N 2 LCD cover kit 44C9567 N 3 W ir eless LAN antenna assembly 44C5397 N 3 W ir eless LAN antenna assembly 44C4058 N 4 ALPET Sheet 42X3952 N 5 LCD cable WSXGA+ with integrated camera and Bluetooth v 2713-CTO v 2714-CTO, 6Fx v 2716-CTO, 3Qx, 3Sx, 7Fx, 84x,[...]

T able 33. Parts list—15.4-in. WSXGA+ TFT (continued) No. FRU FRU no. CRU ID 9 Bluetooth daughter car d (BDC-2.1) v 2713-CTO v 2714-CTO, 6Fx v 2716-CTO, 3Qx, 3Sx, 7Fx, 84x, 86x, 8Ax, 9Jx, A3x, A4x, AEx v 2717-CTO v 2718-CTO, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 6Zx, 72x, 73x, 74x v 2719-CTO v 2720-CTO v 2731-CTO, 37x, 38x, 3Ax, 4Qx, 4Rx, 4Sx, 64x, 77x, 7Ax v[...]

Keyboard T able 34. Parts list—Keyboard Language P/N CRU ID Arabic 42T4005 42T4069 42T3940 ** Belgian 42T4006 42T4070 42T3941 Brazilian Portuguese 42T4033 42T4097 42T3968 Bulgarian 42T4145 42T4142 42T4138 Canadian French (058) 42T4004 42T4068 42T3939 Canadian French (Acnor) 42T4003 42T4067 42T3938 Czech 42T4007 42T4071 42T3942 Danish 42T4008 42T4[...]

T able 35. Parts list—Keyboard Language P/N CRU ID Arabic 42T3212 42T3276 42T3146 ** Belgian 42T3213 42T3277 42T3147 Brazilian Portuguese 42T3240 42T3304 42T3174 Canadian French (058) 42T321 1 42T3275 42T3145 Canadian French (Acnor) 42T3210 42T3274 42T3144 Czech 42T3214 42T3278 42T3148 Danish 42T3215 42T3279 42T3149 Dutch 42T3223 42T3287 42T3157 [...]

Miscellaneous parts T able 36. Parts list—Miscellaneous parts FRU P/N CRU ID Screw kit (including nylon-coated scr ews): v M2 × 2.7 mm (black), flat head (5) v M2 × 2.8 mm (silver), flat head (10) v M2 × 3 mm (silver), flat head (30) v M2 × 3.5 mm (black), bind head (10) v M2 × 5 mm (black), flat head (15) v M2 × 9.5 mm (black), flat head ([...]

T able 36. Parts list—Miscellaneous parts (continued) FRU P/N CRU ID System board miscellaneous parts: v Insulation sheet, battery connector v Insulation sheet, docking v Insulation sheet, front louver v Insulation sheet, PC Card slot v Insulation sheet, 7-in-1 media reader slot v Insulation sheet, front top v Insulation sheet, NB v Insulation sh[...]

AC adapters T able 37. Parts list—2-pin AC adapters FRU FRU no. CRU ID 2-pin (90 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxY , xxU) 42T4427 * 2-pin (90 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxY , xxU) 42T4431 2-pin (90 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxY , xxU) 42T4435[...]

Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region: T able 39. Parts list—2-pin power cords Country or region FRU no. CRU ID Argentina v models -CTO, xxY 42T5020 42T5105 * Brazil v models -CTO, xxP 42T5180 42T5183 Canada, U.S. v models -CTO, xxF , xxL, xxS, xxU 42T5008 42T5093 Ja[...]

Recovery discs Windows XP Professional (32 bit) DVDs W indows XP Pr ofessional (32 bit) is preinstalled as the operating system in the following models: v 2713-CTO, 97x, 98x v 2714-CTO, 5Ux, 5Vx, 5Wx, 5Xx, 5Yx, 5Zx, 62x, 63x, 64x, 65x, 66x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 79x, 7Kx, 7Mx, 7Ux, 7Yx, 8Ux, 92x, 93x, 94x, 95x, 9Sx,[...]

T able 41. Parts list—Windows XP Professional (32 bit) recovery DVDs Language P/N CRU ID Arabic 58Y1832 * Brazilian Portuguese 58Y1833 Czech 58Y1836 Danish 58Y1837 Dutch 58Y1848 English 58Y1858 English (modem-disabled) 58Y1857 Finnish 58Y1838 French 58Y1839 German 58Y1841 Greek 58Y1840 Hebrew 58Y1842 Hungarian 58Y1844 Italian 58Y1845 Japanese 58Y[...]

Windows V ista Starter Edition (32 bit) recovery DVDs W indows V ista Starter Edition (32 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO, 7Px, 7Qx v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO T able 42. Parts list—W[...]

Windows V ista Home Basic (32 bit) recovery DVDs W indows V ista Home Basic (32 bit) is pr einstalled as the operating system in the following models: v 2713-CTO, 5Jx, 99x v 2714-CTO, 54x, 5Cx, E7x, E8x, 9Rx, 9Ux v 2716-CTO, 5Tx, 9Ax v 2717-CTO v 2718-CTO, 49x, 4Ax v 2719-CTO v 2720-CTO v 2731-CTO, 4Px, 4Qx, 4Rx, 4Sx, 77x v 2732-CTO, 3Wx, 3Xx, 3Yx,[...]

T able 43. Parts list—Windows Vista Home Basic (32 bit) recovery DVDs Language P/N CRU ID Czech 58Y2022 * Danish 58Y2023 English 58Y2042 English (modem-disabled) 58Y2041 English (for India) 58Y2095 English, Finnish, and Swedish (in Sweden) 58Y2044 English, French, German, and Dutch (in Belgium and Luxembur g) 58Y2043 English, French, German, and [...]

Windows V ista Home Premium (32 bit) recovery DVDs W indows V ista Home Pr emium (32 bit) is preinstalled as the operating system in the following models: v 2713-CTO v 2714-CTO, 39x, 3Bx, 3Cx, 4Wx, 4Xx, 4Yx, 4Zx, 53x, 9Nx, 9Px, 9Qx, 9Tx, E9x, EAx v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO, 36x, 7Ex, 7Fx, 7Hx v 2733[...]

Windows V ista Business (32 bit) recovery DVDs W indows V ista Business (32 bit) is pr einstalled as the operating system in the following models: v 2713-CTO, 3Fx, 3Gx, 3Hx, 3Jx, 5Kx, 5Lx, 5Mx, 7Ax, 7Bx, 9Dx v 2714-CTO, 34x, 36x, 37x, 3Ax, 3Dx, 3Ex, 4Lx, 4Mx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Dx, 76x, 77x, 78x, 7Jx, 7Lx, [...]

T able 45. Parts list—Windows Vista Business (32 bit) recovery DVDs Language P/N CRU ID Brazilian Portuguese 58Y1913 * Czech 58Y1916 Danish 58Y1917 English 58Y1939 English (modem-disabled) 58Y1938 English (for India) 58Y2093 English, Finnish, and Swedish (in Sweden) 58Y1941 English, French, German, and Dutch (in Belgium and Luxembur g) 58Y1940 En[...]

Windows V ista Business (64 bit) recovery DVDs W indows V ista Business (64 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO T able 46. Parts list—Windows Vista Business (6[...]

Windows V ista Ultimate (32 bit) recovery DVDs W indows V ista Ultimate (32 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO, 4Ux, 4Vx, 96x v 2716-CTO, 45x, 8Sx v 2717-CTO, 8Vx v 2718-CTO, 4Kx, 8Sx v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO, 3Kx, 3Px, 3Qx v 2734-CTO v 2735-CTO, 3Ux, 3Vx v 2736[...]

T able 47. Parts list—Windows Vista Ultimate (32 bit) recovery DVDs Language P/N CRU ID Czech 58Y2048 * Danish 58Y2049 English 58Y2065 English (modem-disabled) 58Y2090 English, Finnish, and Swedish (in Sweden) 58Y2067 English, French, German, and Dutch (in Belgium and Luxembur g) 58Y2066 English, French, German, and Italian (in Switzerland) 58Y20[...]

Windows 7 Home Basic (32 bit) DVDs W indows 7 Home Basic (32 bit) is preinstalled as the operating system in the following models: v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO T able 48. Parts list—Windows 7 Home Basic (32 bit) DVDs Langua[...]

Windows 7 Home Premium (32 bit) DVDs W indows 7 Home Premium (32 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO T able 49. Parts list—Windows 7 Home Premium (32 bit) DVDs[...]

Windows 7 Home Premium (64 bit) DVDs W indows 7 Home Premium (64 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO T able 50. Parts list—Windows 7 Home Premium (64 bit) DVDs[...]

Windows Professional (32 bit) DVDs W indows Professional (32 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO, AAx, AJx, ALx, AMx, APx, B5x, B6x, B7x, B8x v 2716-CTO, ADx, AEx, A Vx, A Yx, B2x, B4x v 2717-CTO, ACx v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO, 7Ux, 83x, 84x v 2733-CTO, 7Wx, 7Xx, [...]

T able 51. Parts list—Windows 7 Professional (32 bit) DVDs Language P/N CRU ID Brazilian Portuguese 58Y3242 * Czech 58Y3245 Danish 58Y3246 English 58Y3268 English (modem-disabled) 58Y3267 English (for India) 58Y4030 English, Finnish, and Swedish (in Sweden) 58Y3270 English, French, German, and Dutch (in Belgium and Luxembur g) 58Y3269 English, Fr[...]

Windows Professional (64 bit) DVDs W indows Professional (64 bit) is pr einstalled as the operating system in the following models: v 2713-CTO v 2714-CTO v 2716-CTO v 2717-CTO v 2718-CTO v 2719-CTO v 2720-CTO v 2731-CTO v 2732-CTO v 2733-CTO v 2734-CTO v 2735-CTO v 2736-CTO v 2737-CTO T able 52. Parts list—Windows 7 Professional (64 bit) DVDs Lan[...]

Common service tools T able 53. Parts list—Common service tools T ool P/N Screwdriver kit 95F3598 1/4 ″ drive spinner handle 1650840 1/4 ″ Sq. to 1/4 ″ hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P6967 Removal tool antenna RF connector 08K7159 USB 2.0 CD-R W/DVD-ROM combo drive II 40Y8687 USB cable 40Y8704 USB floppy dis[...]

214 ThinkPad R500 Hardwar e Maintenance Manual[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

vary significantly . Some measurements may have been made on development-level systems and there is no guarantee that these measur ements will be the same on generally available systems. Furthermore, some measur ements may have been estimated through extrapolation. Actual results may vary . Users of this document should verify the applicable data f[...]

[...]

Part Number: 43Y6631_02 (1P) P/N: 43Y6631_02[...]