Monessen Hearth 624WBPF Bedienungsanleitung

539042 MPL cov er Installation, Operation and Maintenance Manual for Residential Installation      ?[...]

2 624WBPF W oodbur ning Fireplace 53D9052 Y ou have chosen the finest wood burning fireplace available. Y our fireplace has been designed for years of heating and viewing enjoyment. Please take time to read this entire manual before installing or operating your fireplace.  ?[...]

3 53D9052 624WBPF W oodbur ning Fireplace 1. Read these instructions entirely before beginning any part of the installation. Save these instructions for any future repairs. 2. Use these instructions as a guide during the installation of the fireplace. 3. Be sure these instructions become the property of and are reviewed by all future users of this [...]

4 624WBPF W oodbur ning Fireplace 53D9052 When an AK4 combustion air assembly and a combustion air duct are attached to the connecting point on the left or right side of the fireplace, combustion air may enter the firebox through a dam- pered opening behind the left or right side brick. This feature is designed for your benefit to reduce the room a[...]

5 53D9052 624WBPF W oodbur ning Fireplace 36 56O ” (927 mm) 1/2” (13 mm) 30 56M ” (768 mm) 37 56M ” (946 mm) 42” (1067 mm) 45 6M ” (1 162 mm) 36” (914 mm) 38” (965 mm) 23” (584 mm) 1/2” (13 mm) 14 (6 ” (378 mm) 8 56O ” (216 mm) 12” (305 mm) 24” (610 mm) 22 6M ” (578 mm) 9” (229 mm) 12” (305 mm) 539042 MPL [...]

6 624WBPF W oodbur ning Fireplace 53D9052   This fireplace does not require any special foundation. If the fireplace is to be trimmed with large stone or brick facing, an adequate foundation is required to support these materials. Refer to Figures 1-5 as guides for selecting a location and deter[...]

7 53D9052 624WBPF W oodbur ning Fireplace  FP2345 MPL featur es Figure 3 Residential Installation Chimney Cap Roof Flashing (Flue Outlet Height) Storm Collar 14 ft. = Min. Height (No offsets) 14 ft. = Min. Height (2 30° Elbows) 21 ft. = Min. Height (4 30° Elbows) 86 ft. = Max. Height (Chimney support every 35 ft.) 1 [...]

8 624WBPF W oodbur ning Fireplace 53D9052 Survey the planned location for the fireplace for overhead plumbing or electrical wires, etc., that might complicate the installation or endanger persons installing or cleaning the chimney . Avoid a location where the chimney cap will be near abrupt changes in the roof shape, nearby wall or embankments, und[...]

9 53D9052 624WBPF W oodbur ning Fireplace  If this fireplace is installed on a combustible floor , the floor area 16 inches in front of, and 8 inches ei- ther side of the fireplace opening must be protected by an insulating noncombustible hearth extension. Figures 6 & 7 With either type hearth ext[...]

10 624WBPF W oodbur ning Fireplace 53D9052 WH36 Glass Doors (Standard) Chimney Support 11CS 30° Elbow Set 11CF30-2 Hearth Extension Kit H1652 Firestop Spacer FS2A, FS6A Flashing 8-6-12, 8-12-12 AK4 Combustion Air Assembly (AK6 for Manufactured Home Installation) Chimney Cap RLTCF11 SLTCF11 Extended Chimney Cap RLTCF11L Chimney Sections 11CF4 11CF3[...]

1 1 53D9052 624WBPF W oodbur ning Fireplace  Unpack and check the fireplace and chimney for damage. If any items have been damaged, report this to your dealer . Before beginning the installation, be sure you have the proper parts in sufficient quantity . Refer to replacement parts page for prope[...]

12 624WBPF W oodbur ning Fireplace 53D9052    FP 548b SHR 5/1 1/99 djt Angle of Chimney at Ceiling Size of Chimney V ertical 30˚ 1 1" CF 2-W all FS2A 17 56O " x 17 56O " (445 x 445 mm) FS6A 17 (6 " x 29 6 " (454 x 753 mm) CHIMNEY HOLE SIZE  ?[...]

13 53D9052 624WBPF W oodbur ning Fireplace    1. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will pass through. Unless the chimney is to be offset, the point where the center line of the chimney will pass through the ceiling and roof can[...]

14 624WBPF W oodbur ning Fireplace 53D9052  1. Determine the location and amount of of fset required, then select the combinations of chimney sections and elbows required from the offset chart. Refer to Page 15 . 2. Install the first elbow by placing the extended fl[...]

15 53D9052 624WBPF W oodbur ning Fireplace  0 0 0 0 0 3" 1 1" 1 0 0 0 0 8 Z₄ " 20" 0 1 0 0 0 1 1 Z₄ " 25 Z₄ " 2 0 0 0 0 13 Zx " 29 Z₄ " 1 1 0 0 0 16 Zx " 34 Z₄[...]

16 624WBPF W oodbur ning Fireplace 53D9052      The proper height as previously explained is important to assure proper draft and safety . The chim- ney cap extends the flue outlet four inches above the top of the last section of chimney . This should be kept in [...]

17 53D9052 624WBPF W oodbur ning Fireplace     1. Extend the regular chimney sections until the top of the chimney is 4” below the total flue height desired. Do not snap the last section of inlet air duct or largest diameter pipe in place until Step 3 is completed. 2. Remove [...]

18 624WBPF W oodbur ning Fireplace 53D9052   (continued) 1. Extremely long runs and numerous turns in the duct leading from the fireplace to the combustion air assembly should be avoided. These conditions will increase the resistance to[...]

19 53D9052 624WBPF W oodbur ning Fireplace   1 2 3 2“ App. FP1906 Duct connector 8/08 Lo op D is eng age d Cl am p A ro un d Du ct Sl ip B an d Th ro ug h Ho us in g Sn ap S cr ew Do wn a nd T ig ht en Figure 23 FP1906 [...]

20 624WBPF W oodbur ning Fireplace 53D9052       Improper installation or operation of a gas appliance in this fireplace can allow unburned gas to leak out which will cause a fire or explosion hazard, or the release of poisonous carbon monoxide int[...]

21 53D9052 624WBPF W oodbur ning Fireplace   FP2356 gas line installation 4”  When using a gas appliance, the fireplace damper must be set in fully open position. Figure 26 Outer Fireplace Wrap Inner Fireplace Wrap Side Brick 24” Max. Fireplace Firebox Hearth Brick Gas Line Access T[...]

22 624WBPF W oodbur ning Fireplace 53D9052 FP2358 finish install 1/2” Min. Air Space to Combustibles  2 x 4 Stud W allboard Corner Post Nailing Flange FP2358 Figure 27        Do not allo[...]

23 53D9052 624WBPF W oodbur ning Fireplace     If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an open position. (See additional operation information in section titled “Operation Guide- lines”.) [...]

24 624WBPF W oodbur ning Fireplace 53D9052   Y ou’ll need a minimum of three logs, preferably four , to make a good fire. Add kindling and new logs as needed to rekindle a dying fire. New logs should be added at the rear grate after raking the coals toward the front.  ?[...]

25 53D9052 624WBPF W oodbur ning Fireplace   Wood can be dried sufficiently for burning within a few weeks if protected form rain in a low humid- ity area. It is far better to cut wood and allow it to dry for a year . In all cases, the wood should be sta[...]

26 624WBPF W oodbur ning Fireplace 53D9052  At the end of each heating season or when the fireplace will not be in use for an extended time, the ashes should be removed and the hearth area should be swept as clean as is practical. The slow absorption of moisture into the ashes over a lo[...]

27 53D9052 624WBPF W oodbur ning Fireplace   1. Don’t allow other installations or operation considerations to take priority over safety considerations. 2. Don’t attempt to use the fireplace until the installation is complete. 3. Don’t use unlisted parts and accesso[...]

28 624WBPF W oodbur ning Fireplace 53D9052   1 2 3 4 5 6 7a,b,c 8 9 10 1 1 12 13a,b,c 1 1 1 539042 MPL parts      1. Panel, Front Ptd. Assy . 4 042988 2. Panel, End Ptd.Assy . 1 042990 3. Panel, End V ented Pt[...]

29 53D9052 624WBPF W oodbur ning Fireplace[...]

30 624WBPF W oodbur ning Fireplace 53D9052[...]

31 53D9052 624WBPF W oodbur ning Fireplace        (except blowers)    • [...]

APRIL 2009 53D9042 • Rev . 3  149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com[...]