Sears 625.348241 Bedienungsanleitung

_ARS OWNER'S MANUAL MODEL NOS. 625.348234 Clarifier 625.348241 Neutralizer 625.348251 Taste & Odor Caution: Read and Follow All Safety Rules and Operating Instructions Before First Use of This Product. If you have questions when installing, operating or main- taining your filter, and when setting the timer, call this toll-free number... 1-[...]

WARRANTY I I SEARS RESIDENTIAL WATER FILTER FULL ONE YEAR WARRANTY ON FILTER For one year from the date of purchase, when this water filter is installed and maintained in accordance with our instructions, Sears will repair, free of charge, defects in materials or workmanship in this water filter. FULL FIVE YEAR WARRANTY AGAINST LEAKS For five years[...]

TABLE OF CONTENTS [ I SECTION 1 FILTER START UP A. SAFETY GUIDES B. CHECK LIST OF STEP-BY-STEP GUIDES TO INSTALL C. SANITIZING THE WATER FILTER D. PROGRAM THE TIMER PAGE NO. 4 5 6 7-8 SECTION 2 HOW YOUR WATER FILTER WORKS A. FACE PLATE TIMER FEATURES 9-10 B. FILTER APPLICATIONS 11 C. FILTERED WATER SERVICE, AND BACKWASH 12 SECTION 3 CARE OF YOUR FI[...]

SECTION 1 I 1A, SAFETY GUIDES • Read all steps, guides and rules carefully before installing and using your new water filter. Follow all steps exactly to correctly install. Fail- ure to follow them could cause personal injury or property damage. Reading this book will also help you to get all of the benefits from your water filter. • Your water[...]

SECTION 1 WATER FILTER START-UP I I lB. CHECK LIST OF ALL STEP BY STEP GUIDES TO INSTALL Refer to the Installation Manual, part no. 7146611, for step-by-step guides. To be sure you have done all the steps to install the filter, read the following list. Page numbers referred to are in the Installation Manual. Is the house water flow going INTO the f[...]

SECTION 1 WATER FILTER START-UP I 10. 1 SANITIZING THE WATER FILTER Care is taken at the factory to keep your water filter clean and sanitary. Materials used to make the filter will not infect or contaminate your water supply, and will not cause bacteria to form or grow. However, during shipping, storage, installing and operating, bacteria could ge[...]

SECTION 1 WATER FILTER START-UP I 1D. PROGRAM THE TIMER I I, display ] Q PRESENT TIME AND DAY _ BACKWASH TIME _ BACKWASH DAY _ SETICLEAR ON/OFF VACATION V_,_.:J _ BACKWASH NOW buttons When the transformer is plugged into the electrical outlet, 12:00 AM, SUnday began to flash in the time display. Set the time of day, present day of week, and days/ti[...]

SECTION 1 1 D. PROGRAM THE TIMER WATER FILTER START-UP I 3. SET DAYS OF BACKWASH IF YOU HAVE A WATER SOFTENER OR OTHER AUTOMATIC FILTER, .. A good water flow rate is needed for proper recharging and/or backwashing of all water conditioners. To help assure good water flow, you should offset the timers on each conditioner so recharges do not occur on[...]

SECTION 2 HOW YOUR WATER FILTER WORKS I 2A. I FACE PLATE TIMER FEATURES BACKWASH NOW For times you expect to use more water than usual, use the BACKWASH NOW feature. Press the BACHWASH NOW-HOLD button [] and hold in for 3 seconds. RCHG begins to flash in the display and a backwash starts right away. You will have filtered water when the backwash is[...]

SECTION 2 2A. HOW YOUR WATER FILTER WORKS I FACE PLATE TIMER FEATURES TIMER "POWER-OUTAGE MEMORY" -- If electri- cal power to the timer goes off, the "memory" built into timer circuitry keeps all settings for 5 hours (mini- mum) or more. The display is blank and the filter will not backwash. When electrical power comes on, 1 of [...]

SECTION 2 L__ 2B. HOW YOUR WATER FILTER WORKS i FILTER APPLICATIONS IMPORTANT: Sears water filters are sometimes installed alone in the water system, but most often other water treat- ing equipment is needed. Always be sure to have your water tested by a qualified testing laboratory. If you need help, ask at your Sears store, or call Sears Water Li[...]

SECTION 2 HOW YOUR WATER FILTER WORKS I I 20. FILTERED WATER SERVICE, AND BACKWASH SERVICE CLARIFIER FILTER During service (FIG. 5) water goes into the filter and DOWN through the bed of mineral. The mineral takes the dirt, sand, silt, clay and other sediments out of the water and holds it in the bed. Clear, clean water goes out of the filter and i[...]

SECTION 3 CAR,: OF YOUR R,TER I 3A. KEEP THE FILTER FROM FREEZING If the filter is installed where it could freeze (summer cabin, lake home, etc.), you must drain all water from it to stop possible freeze damage. To drain the filter -- • = = m 5. Close the shut-off valve on the house main water pipe, near the water meter or pressure tank. Open a [...]

SECTION 3 CARE OF YOUR FILTER I 3B. ADDING MINERAL.. I • NEUTRALIZER FILTER The neutralite mineral is slowly dissolved to neutral- ize acid in the water (see page 12). If the filter was never serviced, all the mineral would dissolve. How fast it dissolves depends on how much water is used, the pH of the water, and other supply conditions. Add new[...]

SECTION 3 CARE OF YOUR FILTER I 3B. I ADDING MINERAL... NEUTRALIZER FILTER 6. Remove the o-rings (3) and top distributor from the top of the tank. 7. To make room for the new mineral, use a hose to siphon water from the tank. 8. Using a large neck funnel, add new mineral into the tank. IMPORTANT: DO NOT ADD MINERAL INTO THE Bo'n'OM DISTRI[...]

SECTION 3 CARE OF YOUR FILTER [ I 3C. REPLACING MINERAL... TASTE & ODOR FILTER Average life of the activated carbon mineral bed is about 1 year (see page 12). It's time to replace the bed when the tastes and/or odors begin to return in the water supply. Do the following. STEPS TO REPLACE MINERAL = = Press the face plate BACKWASH NOW button[...]

SECTION 3 CARE OF YOUR FILTER I I 3D. BEFORE YOU CALL FOR SERVICE . . . HELPFUL HINTS CHECKLIST PROBLEM FILTER WILL NOT BACKWASH LOW WATER PRESSURE AT HOUSE FAUCETS FILTERED WATER CONTAINS SEDI- MENTS, IRON, DIRT, SAND, ETC. NEUTRALIZER FILTER ONLY: FILTER WATER IS ACID OR PARTLY ACID NOTE: Trace plumbing to be sure faucet(s) is on filtered water s[...]

SECTION 4 OTHER THI.GS TO K.OW I 4A. I DIMENSIONS/SPECIFICATIONS BYPASS VALVES SINGLE-PLASTIC PULL STEM OUTWARD FOR SERVICE Push Inward For Bypass 3-VALVE SERVICE Close Bypass Valve Open Inlet & Outlet Valves BYPAS_ Open Bypass Valve Close Inlet & Outlet Valves II IIjBypass Outlet__ Valve Vat_e',_ (_! .,let ._Jl _ Valve 55" 139.6 [...]

SECTION 5 [ 5A. SERVICER'S TECH. INFORMATION ] ELECTRICAL CONNECTIONS IMPORTANT: KEEP THIS MANUAL WITH YOUR WATER FILTER. IF REPAIRS ARE NEEDED, THE SERVICE TECHNI- CIAN MUST HAVE THE INFORMATION ON THE FOLLOWING 6 PAGES, WIRING SCHEMATIC CIRCUIT BOARD NC POSITION SWITC H"O_'_O o NO M 110 VAC FACE PLATE TIMER I { } Q PRESENT TIME AND[...]

SECTION 5 SERVICER'STECH. INFORMATION I I 5B. BACKWASH CYCLE TIMES Factory set cycle times are: BACKWASH... 25 min., FAST RINSE... 5 min. Do the following to check for correct cycle times. NOTE: NOTE: Removing from electrical power (varies from 6 to 15 hours) resets timer to factory programming. DISPLAY MUST SHOW TIME AND 1. Press and hold [] [...]

SECTION 5 50. SERVICER'S TECH. INFORMATION I DIAGNOSTICS AUTOMATIC ELECTRONIC DIAGNOSTICS The face plate has a self-diagnostic function for the electrical system (except input power). The face plate monitors the electronic components and circuits for correct operation. If a malfunc- I ] tion occurs, an error code ap- E- 3 pears in the face pla[...]

SECTION 5 SERVICER'S TECH. INFORMATION 5D. I "QUICK-CHECK" TROUBLESHOOTING NEUTRAUZER RLTER FILTERED WATER IS ACID (LOW phi NEEDS REFILL OF NEUTRALITE MINERAL ALL RLTERS FILTERED WATER CONTAINS SEDIMENTS, (SAND, SILT,, DIRT, ETC.) OR IRON 1 I IRON IN WATER REQUIRES 1 OTHER WATER CONDITIONING I (HAVE WATER ANALYZED) VISUAL CHECKS 1. I[...]

SECTION 5 5E. SERVICER'S TECH. INFORMATION I ROTARY VALVE SERVICE BEFORE WORKING ON THE VALVE, TURN OFF THE WATER SUPPLY AND DISCONNECT FROM ELECTRICAL POWER, TO RELIEVE PRESSURE... ... 3 VALVE BYPASS: Close the inlet valve and open a filtered water faucet. Then close the outlet valve and open the bypass valve. ... SEARS SPECIAL BYPASS: Slide [...]

SECTION 5 SERVICER'S TECH. INFORMATION I I 5F. WATER FLOW THROUGH THE FILTER VALVE SERVICE CYCLE POSITION SWITCH VALVE OUTLET' (FILTERED WATER ,VALVE INLET (UNFILTERED WATER) TOP DISTRIBUTOR MINERAL TANK INERAt BED • DISTRIBUTOR Hard, unfiltered water enters the valve inlet port. Internal valve porting routes the water down and out the [...]

SECTION 6 REPAIR PARTS I I ""_ 21 "_ 22// _.. 2O SEARS WATER FILTERS Clarifier, Model No. 625.348234 Neutralizer, Model No. 625.348241 Taste & Odor, Model No. 625.348251 KEY PART NO. NUMBER 1 7105047 2 7092202 3 7088855 4 7170270 5 7170254 6 7170296 7 7088033 8 7176292 9 0900300 10 7146093 11 7084330 12 7118333 13 7095373 14 7144[...]

SECTION 6 REPAIR PARTS I I 63 62 58 _ 38 39 40 I 54 53 51 J 50 49 47 43 44 45 46 66 65 67 26[...]

SECTION 6 REPAIR PARTS I I SEARS WATER FILTERS Clarifier, Model No. 625.348234 Neutralizer, Model No. 625.348241 Taste & Odor, Model No. 625.348251 PARTS LIST KEY PART NO. NUMBER 3O 7131755 31 7133008 32 0900857 33 7117808 34 0503288 35 7113927 36 7142942 37 7030585 38 0509537 39 7170327 40 7141239 41 7116713 42 0507369 43 0507615 44 7170335 45[...]

_ARS OWNER'S MANUAL MODEL NOS. 625.348234 Clarifier 625.348241 Neutralizer 625.348251 Taste & Odor The model number of your water filter is found on the rating decal. This decal is on the backside of the top cover. When requesting service or ordering parts, always provide the following in- formation: • Product Type • Model Number • P[...]