Weber GENESIS 1300 Bedienungsanleitung

W E B E R W E B E R Serial Number Please use this number in registering your w arranty and any correspondence with the f actory . Owner’ s Manual National Association PROPANE GAS ® 92725 11/98 GENESIS ® 1300 Series LP Gas Barbecue  W ARNING 1. Do not store spare LP Cylinder within 10 feet (3m) of this appliance. 2. Do not store or use gasoli[...]

 D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injur y or death, or in a fire or an explosion causing damage to property .  W ARNINGS  Do not store a spare or disconnected LP tank under or near this barbecue.  Improper assemb ly ma y be dangerous. Please[...]

3 W eber-Stephen Products Co. (W eber) hereby warr ants to the ORIGINAL PURCHASER of this W eber Gas Barbecue that it will be free of def ects in mater ial and workmanship from the date of purchase as f ollows: Aluminum Castings , 10 years , Recycled W or k Surfaces , 10 years Cooking Grates , 3 years , Flav orizer Bars, 5 y ears, All Remaining P a[...]

© 1998 W eber . Weber , , Genesis, Fla v orizer and Crossov er are registered U .S. trademarks; P er ma-Mount, Gas Catcher , FlameCheck, Steam-N-Chips , Spider Stopper , and W ar m-Up are U .S. trademarks of W eber-Stephen Products Co ., 200 East Daniels Road, P alatine, IL 60067-6266. Printed in the U .S.A. 4 P A TENTS AND TRADEMARKS[...]

5 Contents WARNINGS ................................................................ 2 W arranty & P atents .................................................. 3-4 General Instructions .................................................... 6 Assembly ............................................................... 7-22 Operating Instructions Lighti[...]

6 General Instructions Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav or izer Bars produce that "outdoor" fla v or in the food. The W eber Gas Barbe[...]

7 Step 1 Check pac kage contents Cooking bo x (assembly) Lid (assembly) LP tank LP tank filler adapter Bottom tra y T wo cooking grates Control panel Assembl y T ools needed Regular screwdriv er Phillips screwdriv er Hammer 7/16 inch open-end or an adjustable wrench Pliers Block of w ood Supplies needed Y our LP tank is shipped empty f or saf ety .[...]

Left frame Right frame Wheel frame Caster frame T wo frame connectors W ork table Swing table assemb ly Slide bar assembly Axle T wo accessor y trays W ar ming rack W ar m-Up Basket Five long Fla vorizer Bars Eight shor t Flav orizer Bars T ank panel assembly F ront panel Catch pan holder Catch pan T wo dr ip pans Manif old brac ket Ther mometer T [...]

T wo plastic buttons (actual size) 1/4-20 keps n ut T wo 1/4-20 wing nuts (actual size) Eighteen 1/4 inch nylon w ashers T wo hair pin cotters T wo wheel hubcaps T wo 10-24 hex n ut (actual size) T wo 10-24 x 1 3/4 inch machine screws (actual size) T wo Phillips screws/washers Check contents of hardw are packs Three burner control knobs Three tool [...]

10 Figure 1 W E B E R W E B E R Figure 2 Leg tabs F rame tabs (a) (b) Right frame Left frame Step 2 Assemble wheels Y ou will need: axle, two wheel hubcaps , two wheels, wheel frame, hammer and a b lock of wood. Place one end of the axle on the bloc k of wood (or other protected surf ace). T ap on one hubcap. Put one wheel on the axle, WEBER side t[...]

11 Figure 3 Dimples to the inside Fuel scale decal Figure 4 Step 4 Continue frame assemb ly Y ou will need: caster frame, wheel fr ame, f our 1/4-20 x 1/2 inch bolts, f our nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the [...]

12 Figure 6 View from rear of barbecue Plastic buttons Figure 5 Step 7 Add front panel Y ou will need: front panel and two plastic b uttons. T ur n frame assembly right side up . Align the panel with the holes in the frame and inser t the plastic buttons through the front panel and fr ame . Figure 6. Step 6 Inser t casters Y ou will need: frame ass[...]

13 Guide screw (a) (b) (c) Wing nuts View from behind cooking bo x Figure 9 Figure 7 Burner tubes F rame brace (a) (b) Spacer brac ket K eps nut Ta b F rame cross piece Nylon washer Bolt Slide the cooking bo x to the left within the frame. Put the washer on the bolt. T ake the spacer brac ket and hold it up to the frame making sure both tabs fit un[...]

14 F rame brace Manif old brack et Figure 10 Figure 11 Figure 12 Cross brace T ank panel tabs Slots in frame brace F rame brace Step 9 Install manif old brack et Y ou will need: manif old brac ket Hook the brac ket onto the manif old at the center burner valv e. Place your hand underneath the brac ket. Lift the manif old, brac ket and cooking bo x [...]

15 Figure 13 View from front left View from front right F E F E Figure 14 Igniter lock n ut K eyhole in frame brace Small par t of keyhole in frame brace F rame brace F rame brace (a) (b) (c) Step 11 Add fuel scale assembly Y ou will need: fuel scale assembly , two 1/4-20 wing nuts and two nylon w ashers. Slip the bolts on the back of the fuel scal[...]

16 F E F E F E Figure 15 T ank lock wing nut (a) (b) Scale setting wing nut Step 13 Set LP fuel scale Y ou will need: LP tank (empty). Note - F or accuracy , the fuel scale must be set with an empty tank. W e utilize v ar ious LP tank manuf acturers. Some of the tanks we receiv e hav e differing top collar assemblies . (The top collar is the metal [...]

17 Figure 16 Figure 18 T ur n so regulator vent does not collect water Hose T ank lock wing nut Quick disconnect engaged V alve handwheel close clockwise T ank valv e Collar Male fitting Pressure relief valv e T ank Regulator Regulator vent (a) (b) (c) Figure 17 F E Step 15 Check that all b ur ner valv es are off Y ou will need: one burner control [...]

18 Figure 19 (a) Figure 20 (c) (d) (b) Step 17 Check f or gas leaks  W ARNING: Y ou should check f or gas leaks every time you disconnect and reconnect a gas fitting. Note - All f actor y made connections hav e been thoroughly check ed for gas leaks . The burners hav e been flame tested. As a saf ety precaution you should rechec k all fittings f[...]

19 Figure 24 Figure 23 Figure 25 Bottom tra y Finger grip on front edge of bottom tra y Finger grip F ront side of catch pan holder Figure 21 Figure 22 Step 18 Install Flav orizer Bars and Cooking Grates Y ou will need: five long Fla vorizer Bars, eight short Flav or izer Bars and two cooking g rates. Set the long Flav or izer Bars side to side in [...]

20 Hair pin cotter Hinge pin Figure 26 Figure 27 T ool holders Inser t in frame brace Control panel Phillips screws/ washers (a) (b) Step 20 Install Lid Y ou will need: lid, two hinge pins and two hair pin cotters . Set the lid in place. Align the hinges at the rear of the barbecue. Inser t hinge pins from the outside. Inser t hair pin cotters into[...]

21 Slot in frame (view from belo w) Inser t one end of the hinge rod into the hole in the frame. Figure 29 (a). Inser t the other end into the hole in the swing tab le end brac ket. Figure 29 (b). Hold the end br ack et at an angle so the lower tab is inside the fr ame tube. Push the br ack et into the frame. Chec k to see that the lo wer tab of th[...]

22 Step 23 Complete accessor y installation Y ou will need: W ar m-Up Basket, war ming rack, work table , accessor y rack, three tubing plugs , ther mometer and a hammer . Inser t one end of the Weber W ar m-Up Basket into the hole in the right end of the lid and the other end into the slot in the left end of the lid. Figure 32 (a). Set the warming[...]

23 6 8 5 2 7 4 3 1 Figure 1 Crosso ver Ignition System Lighting Summar y lighting instructions are on the control panel.  W ARNING: The burner control knobs m ust be in the OFF position before turning on the LP tank v alve . If they are not in the OFF position, when y ou turn on the LP tank valve, the excess flo w control will activate, limiting[...]

24 8 6 2 4 3 1 7 5 Figure 2 Manual Lighting Manual Lighting 4) T ur n the tank on by turning the tank valv e counterclockwise . 5) Str ike a match and put the flame into the matchlight hole in the front of the cooking bo x.  W ARNING: Do not lean over open barbecue. Keep your face and bod y at least one foot awa y fr om the matchlight hole when [...]

25 Cooking  W ARNING: Do not move the W eber Gas Barbecue when operating or hot. Y ou can adjust the FRONT , CENTER and BACK b ur ners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your W eber cookbook. The cookbook uses these notations to describe the settings of the FRONT , CENTER, and BA CK b ur n[...]

26 Scale setting wing nut T ank lock wing nut T ank valv e Collar (a) (b) Figure 3 Figure 4 Refilling the LP tank W e recommend that y ou refill before the scale indicator reaches "E". Note - If you run out of fuel, check the indicator setting and/or adjust the fuel scale indicator setting with the scale setting wing nut, while the tank i[...]

27 Figure 6 Male fitting Regulator Collar Quick disconnect engaged Figure 5 (a) (b) c) Connect the hose to the tank. Route the hose so it does not interf ere with the scale indicator rod. Slide back the collar of the quic k disconnect on the tank valv e. Figure 5 (a). Push the male fitting of the regulator into the quick disconnect, and maintain pr[...]

28 28 Safe handling tips f or LP Gas ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moder ate pressure, inside a cylinder , LP gas is a liquid. As the pressure is released the liquid readily vaporizes and becomes gas. ■ LP gas has an odor similar to [...]

29 Figure 8 (b) (c) (d) (a) c) V alves to manif old connections. Figure 7 (c). d) The hose to regulator connection. Figure 7 (d).  W ARNING: If there is a leak at connection (b), (c) or (d), turn OFF the gas . DO NO T OPERA TE THE B ARBECUE. Contact Weber -Stephen Customer Service . When leak checks are complete , turn gas supply OFF at the sour[...]

30 Burner inside cooking bo x Figure 11 Dark blue Light blue Tips occasionally yello wish Figure 9 V entur i Air shutter V entur i fin W eber Spider Stopper Guard Figure 10 Figure 12 Figure 13 General Maintenance W eber Spider Stopper Guards Y our W eber Gas Barbecue , as w ell as an y outdoor gas appliance, is a target f or spiders and other insec[...]

31 e) Remov e the manifold brac ket and unscrew the tw o wing nuts that hold the manif old to the cooking box. Pull the manif old and v alve assemb ly out of the burners and carefully set it down. Figure 15. f) Slide the burner assembly out from under the guide screw and w asher in the corners of the cooking box. Figure 16. View from behind cooking[...]

32 i) Reinstall the Spider Stopper Guards. Slightly rotate the Spider Stopper Guards so that the seams are in line with the V enturi fins. There should be no gaps in the seams or in the fit around the burners and valv es. Figure 19. V entur i fin Figure 19 Check fit around valv e Check fit around b ur ner Figure 20 White wire Black wire  CA UTIO[...]

33 Prob lem Burners b urn with a yello w or orange flame, in conjunction with the smell of gas. Burners do not light. -or - Burners ha ve a small flickering flame in the HIGH position. -or- Barbecue temperature only reaches 250˚ to 300˚ degrees in the HIGH position. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: [...]

34 W E B E R W E B E R 6 1 2 3 4 5 9 10 11 14 12 13 17-18 25 26 19 60 59 58 61 46 38 47 48 49 50-51 52 53 55 54 44 42 41 40 39 38 36 35 34 33 30 31 32 56-57 45 43 27 28 29 37 15 16 20 21 24 8 7 23 13, 18 22 ® ® ® ® ® ® ® ®[...]

35 1 Hair pin cotters (2) 2 Hinge pins (2) 3 Left Endcap 4 Shroud Assembly 5 Lid handle 6 W ar m-Up Basket 7 W ar ming rack 8 Shor t Flav orizer bars (8) 9 Long Flav or izer bars (5) 10 Cooking grates (2) 11 W ork table 12 T ubing plugs (5) 13 1/4-20 x 2 inch bolts (5) 14 Spacer brac ket 15 Swing table end br ack et 16 Left frame 17 1/4-20 x 1/2 in[...]

A F INAL W ORD OF T HANKS hank you for choosing a W eber Barbecue. Our family her e at W eber has worked har d to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur . Our knowledgeable C ustomer Service staff is prepar ed to help you with any problems with parts or[...]