Bloomfield 9104A manual

663 OWNERS MANUAL for SA TELL ITE COFFEE BREWER wit h ELECTRO-MECH ANICA L CONTROL and EXTERNALLY HEATED SATELLITE SERVER MODEL : 9102A 9104A Includes: Installation Operation Use & Care Servicing Instructio ns Model 9102A Satellite Brewer with 9105SS Satellite PRINTED IN UNITED STATES OF A MERIC A p/n 76061 Rev. B ECN-12868 M663 05 0616 cps[...]

NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged b y skilled personnel before le aving the factory. Upon acceptance of this shipm ent, the transportation company assumes full responsibility for its safe delivery. IF SHIPMENT ARRIVES DAMAGED: 1. VISIBLE LOSS OR DAMAGE: Be certain that any v [...]

TABLE OF CONTENTS Thank You for pu rchasing this Bloomfield Industries appliance. Proper installation, professional operation and consistent maintenance of this appliance w ill ensure that it gives you the very best performance and a long, economical service life. This ma nual contains the information needed to properly install this appliance, and [...]

FE AT U R E S AN D O P E R AT I N G CO N T R O L S 2 Fig 1. SS-1 Satellite Brewing System Features & Operating Controls 663 76061 Owners Manual for 9102A Single Satellite Bre wer[...]

FEATURES AND OPER ATING CONTROLS (continued) Brewer Adjustable Legs Connector Hot W ater Faucet Name plate Control Panel Start Brew Sw itch Ready to Brew Indicator Stop Brew Swit ch War me r Sw itch Tank Heat Sw itc h Volume Selector Sw itch Brew Chamber Brew Chamber Wire Rack Satellite Brew-Thru Lid Handles Serving Faucet Sight Glass Drip Tray (op[...]

This appliance is inten ded for use in commer cial establishmen ts only. This appliance is inten ded to brew hot beverage, specif ically coffee, for human consumption. No other use is recommended or autho rized by the manufacturer or its agents. Operators of this appliance must be familiar with the appliance use, limitation s and assoc iated res tr[...]

5 INSTALLATION INSTRUCTIONS INSTALL LEGS The brewer is provided with adjustable legs. Be sure all f our legs are securely screwed into the base of the brewer. LEVEL THE UNIT The adjustable legs allow the brewer to be leveled. Set the brewer in its ultimate operating location and check for level with a spirit level Adjust the brew er for level from [...]

INSTALLATION INSTRUCTIONS (continued) 6 CA UTIO N: Electric Shock Hazard Brewer must be properly grounded to a reliable earth ground to prevent p ossible shock hazard. Do not assume a plumbing line will provide such a ground. Electrical shock may cause serious injury. IMPORTANT: Initial set-up must be performed by a qualified installer or qualified[...]

7 OPERATING INSTRUCTIONS Fig. 5 Control Panel Fig. 6 Brew Basket IMPORTANT: To avoid overflows, DO NOT start the brew cycle unless an EMPTY satellite is in place under the brew chamber. NOTE: The brew can be cancelled at any time by pressing the STOP sw it ch. NOTE: DO NOT change the VOLUME SELECT switch during a brew. This will disrupt the brew cy[...]

OPERATING INSTRUCTIONS (continued) 8 Fig. 7 W ater Fl ow Diagr am BREW & BY P ASS This brewer is a standard displacement brew er with pour-over optio n. For 9102A there is no bypass. Water admitted into the hot water tank by the BREW SOLENOID will displace a like amount of heated water through the brew head, bre w chamber and into the satellite[...]

9 CLEANING INSTRUCTIONS CLEANING INSTRUCTIONS PROCEDURE: Clean Coffee Brewer PRECAUTIONS: Turn POWER SW ITCH OFF. Allo w brewer to cool. FREQUENCY: Dail y TOOLS: Mild Detergent, Clean So ft Cloth or S ponge Bristle Brush 1. Turn POWER SWITCH OFF . Allow brewer to cool. 2. Remove satellite. 3. Remove and empty brew chamber. 4. Remove spray disk and [...]

10 CLEANING INSTRUCTIONS (continued) PROCEDURE: Clean Satellite PRECAUTIONS: Drain Satellite before Cleaning FREQUENCY: T wice Weekly TOOLS: Sight Glas s Brush, Sanitizer Soft Clean Cloth, Bucket 1. Remove and drain satellite. 2. Place 1 packe t of Sanitize r into 2-1/ 2 gallons of warm tap water. Pour approximately 1 gallon of sanitiz er solution [...]

TROUBLESHOOTING SUGGESTIONS SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Will not heat or brew (no lights) Brewer not plugg ed in or circuit breaker tripped Reconnect brewer to electric power Reset circuit break er Main power switch off or damag ed Che ck. Tur n ma in pow er sw itch on. Replace if needed Will not brew Brew switch dam aged Check. Replace[...]

12 SERVICING IN STRUCTIONS CA UTION : SHOCK HAZARD Disconnect brewer from electric power before opening any access panel. Note position of any wires or hoses before removing them from a panel. Wrench for Faucet Tubing ACCESS PANELS TOP PANEL is attached with two screws at the rear and a lip at the front. TOP REAR PANEL is attached with four screws.[...]

13 CAUTION: SHOCK HAZARD Live electrical circuits are exposed during this procedure. Use care to avoid uninsulated electrical connectors. Adjustments to be performed by qualified technician only. NOTE: 1/8 turn = approx 10ºF (5.5ºC) TEMPERATURE A DJUSTMENT PRECAUTIONS: Disconnect br e wer from electric power. Allow brewer to cool. FREQUENCY: As r[...]

SERVICING IN STRUCTIONS (continued ) 14 Adjustm ents to be perform ed by qualified te chnic ian only. NOTE: Brewer is pre-adjusted to deliver 1/2, 1 and/or 1-1/2 gallons of coffee at a wate r pressure of 50 p.s.i. Use this procedure to adjust the delivered volume to suit local conditions. Adjust only in small increments to avoid large volume variat[...]

SERVICING INSTRUCTIONS (continued) 15 CA UTION : SHOCK HAZARD Disconnect brewer from electric power before opening the top panel. The bre wer is shipped f rom th e fact or y pre-set f or 25% bypass. This adjus tment mu st never be made unless the br ewer is installed on a soft w ater li ne, or a change in coffee strength is required. Bypass Gauge S[...]

CA UTIO N: CH EMICA L BURN HA ZA RD Deliming chem icals are caustic. W ear ap pr op riate pr ote ct ive gloves and goggles during this procedure. Never siphon deliming chemicals or solutions by mou th . This operation should only be perfo rm e d by qualifie d an d ex- perienced service personnel. IMPORT ANT: DO NOT spill, splash or pour water or de[...]

SERVICING INSTRUCTIONS (continued) 17 10. Reinstall tank lid assembl y into hot w ater tank. Make sure th e lid gasket is properly in place, then reinstall the hold- dow n clamp. 11. Remove spray disks and gaskets. Rinse both brew heads w ith clean water. Us ing a stiff brush, scrub spray disk to remove any lime or calcium build-up. Reinstall gaske[...]

EXPLODED VIEW 18 PLUMBING COMPONENTS 663 76061 Owners Manual for 9102A Single Satellite Bre wer[...]

EXPLODED VIEW (continued) 19 ELECTRICAL COMPONENTS 663 76061 Owners Manual for 9102A Single Satellite Bre wer[...]

EXPLODED VIEW ((continued) 20 CABINET & RELATED COMP ONENT S 663 76061 Owners Manual for 9102A Single Satellite Bre wer[...]

EXPLODED VIEW (continued) 21 SATELLITE A SSEMBLY 9105SS 663 76061 Owners Manual for 9102A Single Satellite Bre wer[...]

22 SERVICE KITS 663 76061 Owners Manual for 9102A Single Satellite Bre wer F AUCET REP AIR COMPONENTS 8268 0 Hex L o ck Nu t 85 5 1- 1 00 B 7 /1 6“ Lo ck Washe r 8268 1 Wash er 8255 6 Fauc et A ssemb ly 8257 3 Han dle 8257 5 Seat C up 8257 6 Fauc et Rep air K it (Inc lude s Handle , S eat Cu p, S pring, Stem, Pin & Bonn et 8268 2 Reta iner C [...]

23 WIRING DIA GRAMS 663 76061 Owners Manual for 9102A Single Satellite Bre wer[...]

Blo omfi eld In dus trie s, Inc. Divisio n of Carri er Com m erci al Refrigerat i on In US and Canada T elephone: 775 -698- 5700 Fa x: 8 88 -492 -278 3 Fa x: 8 00 -356 -514 2 () website: www . wells bl oomfi el d.c om for order s onl y PRINTED IN UNITED STATES OF A MERIC A[...]