Cal Spas LTR20101058 manual

L TR20101058, Rev . B 9/20/10[...]

Copyright 2009-2010 LMS, Inc. All rights reserved. Dupl ication without written consent is strictly prohibited. Cal Spas ® is a registered trademark. Due to continuous improvement progr ams, all models, operation, and/or specications are subject to change without prior notice. L TR20101058, R ev . B 9/20/10 100-897 Preparing for Your New Portab[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Read This First! w w w . c a l s p a s . c o m 1 Important Safety Instructions READ AND FOLLOW ALL INSTRUCTIONS. WARNING: T o reduce the risk of injury , do not permit children to use this product unless they are closely supervised at all times. DANGER -- Risk of accidental drowning: Do not allow chil[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Read This First! w w w . c a l s p a s . c o m 2 DANGER -- Risk of electric shock: Replace a damaged power cor d immediately . • Do not bury the power cord. • Connect to a grounded, grounding-type r eceptacle only . • SAVE THESE INSTRUCTIONS. WARNING: People with inf ectious diseases should not [...]

2010 Genesis Portable Spa L TR20101058, Rev . B Pr eparing for Y our Ne w P or table Spa w w w . c a l s p a s . c o m 3 Most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on property to prevent [...]

2010 Genesis Portable Spa L TR20101058, Rev . B Pr eparing for Y our Ne w P or table Spa w w w . c a l s p a s . c o m 4 Damage caused by inadequate or improper foundation support is not covered by the war- ranty. It is the responsibility of the spa owner to provide a proper foundation f or the spa. W e strongly r ecommended that you have a quali?[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Pr eparing for Y our Ne w P or table Spa w w w . c a l s p a s . c o m 5 Filling and Powering Up Your Portable Spa Once the spa has been placed on an approved 1. surface and has been correctly wired by a licensed electrician, inspect all plumbing connections in the equipment area of your spa. Ensure t[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Operating Y our Spa w w w . c a l s p a s . c o m 6 Electronic Control Operation Initial Start up When rst powered up, your spa will perform a self-diagnostic check and go into priming mode. When the control panel displays PR , IMMEDIA TEL Y do the following: Press the JETS button to turn on the 1.[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Operating Y our Spa w w w . c a l s p a s . c o m 7 Automatic Time outs Y our new spa comes equipped wi th an electric heater . Following the directions listed below will ensure the most efcient operation: NOTE: This method is only f or spa usage under two hours a week. K eep the spa’ s operating[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Operating Y our Spa w w w . c a l s p a s . c o m 8 the Up or Down button again to change the ltering cycle duration. When desired duration is selected press the Jets button to exit. The low speed pump wil l run for the duration of the ltering cycle and if an ozone system is installed it will be[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Operating Y our Spa w w w . c a l s p a s . c o m 9 Message Meaning Action Required OHH Overheat protection (spa is shut - down). One sensor has detected 118˚F (48˚C) at the heater . DO NOT ENTER THE W A TER! Remo ve the spa cover and allow spa to cool below 107˚F (42˚C). Press any button on the t[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Operating Y our Spa w w w . c a l s p a s . c o m 10 Jets Almost all of the jets in your spa are adjustable. Rotating the face of an adjustable jet to the left (counter-clockwise) will decrease the amount of water ow through the jet. Rotating the face of an adjustable jet to the right (clockwise) w[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 11 Clear Water Plan This section is intended for new spa owners with no experience with water chemistry . Everyone’ s ex- perience with maintaining water quality is different, but there are some general concepts you need to know . W ater maintenance is[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 12 Testing and Adjusting Spa Water Y ou have two types of testing methods to choose f rom: The • reagent test kit is a method which provides a high lev el of accur acy . It is av ailable in either liquid or tablet form. Test strips • are a conveni[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 13 Using Chlorine as a Sanitizer If you choose to use chlorine as a sanitizer , only use gr anulated chlorine, not liquid chlorine. W e r ecommend you use only Cal Spas “Chlorinating Gr anules” . Once a week, check the chlori ne level using either a [...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 14 Testing For: Ideal Range (ppm) Chemicals To Use: Minimum Maximum T o Raise T o Lower Chlorine level Without ozonator With ozonator 3.0 5.0 2.0 4.0 Chlorinating Granules Bromine level Without ozonator With ozonator 6.7 11.0 5.7 10.0 Go Brom Shocking th[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 15 “Bather Load” is the term used to describe the num- ber of people using a spa, combined with the length of usage, and the frequency of usage. All these fac- tors have a great effect on the spa w ater . The higher the bather load, the more chemical[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 16 W e recommend you use Cal Spas chemicals only . Other brands of chemicals may have similar names and/or usage descriptions but due to manufacturing differences, use of other chemicals can increase the likelihood of under- or over-dosing the spa chemi-[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 17 Maintenance Schedule Eachtimeyourellthespa Follow the section “Starting the Spa with Fr esh W ater” . Prior to each use T est the spa w ater using either test strips a reagent test kit. Adjust chemical levels as necessary . Once [...]

2010 Genesis Portable Spa L TR20101058, Rev . B Clear W ater Plan w w w . c a l s p a s . c o m 18 Troubleshooting Water Clarity Problems Problem Probable Causes Possible Solutions Cloudy W ater Dirty lter • Excessive oils / organic mat - • ter Improper sanitization • Suspended particles / organ- • ic matter Overused or old water • Cle[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Cleaning and Maintenance w w w . c a l s p a s . c o m 19 Cleaning and Maintenance Draining Your Portable Spa Y our spa should be drained every four to six months and relled with fresh tap water . The following is the recommended method for dr aining your spa. T urn off the power at the breaker . 1[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Cleaning and Maintenance w w w . c a l s p a s . c o m 20 Winterizing (Cold Climate Draining) In many areas of the country , the temper ature dr ops below 32˚F (0°C). W e recommend that you always have your spa full of water and running at normal spa temperatures (80˚F to 100˚F , 26.7°C to 37 .8?[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Cleaning and Maintenance w w w . c a l s p a s . c o m 21 Cleaning the Cover Vinyl and Leather Cleaner Because the cover is constantly exposed to weather , you should protect it as part of your monthly maintenance plan. Cal Spas Vinyl and Leather Cleaner is specical ly designed to protect spa cover[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Cleaning and Maintenance w w w . c a l s p a s . c o m 22 Cleaning the Shell All-Purpose Cleaner (Spa Finish Cleaning) Cal Spas All-Purpose Cleaner is an essential part of maintaining your spa’s nish. Through normal use, the spa’s nish can accumulate dirt, oil, and calcium causing a rough fe[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Appendix w w w . c a l s p a s . c o m 23 Jets EW 2” Euro Standard gra y PLU21703420 Stainless steel PLU21703621 mfw 3” Micro Flow Standard gra y PLU21703432 Stainless steel PLU21703631 OZ 2” Ozone Injector Standard gra y PLU21700818 Drain Main Drain, Super Hi Flo Suction 2” Silver PLU21400132[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Appendix w w w . c a l s p a s . c o m 24 2010 Warranty This limited warr anty is eff ective for Genesis portable spas manuf actured after November 23, 2009. Cal Spas portable spas are warranted to be f ree from defects in material and workmanship. This w arrant y starts from date of manufacture and e[...]

2010 Genesis Portable Spa L TR20101058, Rev . B Appendix w w w . c a l s p a s . c o m 25 This warranty is void if the spa has been subject to neg - ligence, alteration, misuse, abuse, repairs by non-LMS authorized personnel, incorrect electrical installation, installation by unqualied personnel, installation with - out a permit i f required by [...]

2010 Genesis Portable Spa L TR20101058, Rev . B Appendix w w w . c a l s p a s . c o m 26 Cal Spas Chemicals[...]

2009 Genesis Portable Spa L TR20091058, Rev . B w w w . c a l s p a s . c o m[...]

2009 Genesis Portable Spa L TR20091058, Rev . B w w w . c a l s p a s . c o m[...]

2009 Genesis Portable Spa L TR20091058, Rev . B w w w . c a l s p a s . c o m[...]

Locating the product serial number The serial number of your spa is located on a metal plate attached to the base of the equipment pack inside the equipment area of the spa. Y ou will need this number to properly register your spa and activate cover age. Write this inf ormation in the space provided below . Spa Model: ______________________________[...]