Char-Broil 10201630 manual

Product Guide Model 10201630 T ools needed for assembly: Pliers Adjustable wrenches FOR OUTDOOR USE ONL Y CA UTION: Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook. INST ALLER/ASSEMBLER: Leave this manual with consumer . CONSUMER: Keep this manual for future reference.[...]

D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury . WARNING W ARNING: Indicates a potentially hazardous situation which, if not avo[...]

1. Brush all interior surfaces including grills and grates with vegetable cooking oil. 2. Build a small fire on the fire grate, being sure not to lay coals against the walls. 3. Close door . (Position butterfly damper and smokestack damper approximately at one quarter open.) This burn should be sustained for at least two hours, the longer the bette[...]

THE HEA T OF THE COALS seconds you can hold the palm of your hand 4 inches above the coals temperature range (Fº) visual cues HOT COALS 2 400 to 450 barely covered with gray ash; deep red glow MODERA TEL Y HOT 375 to 450 thin coating of gray ash; deep red glow MODERA TEL Y HOT COALS 4 325 to 375 significant coating of gray ash; red glow MODERA TEL[...]

GRILL MAINTENANCE Frequency of cleanup is determined by how much your smoker is used. Make sure coals are completely extinguished before cleaning inside of smoker . Inside surfaces may be cleaned with a strong solution of detergent and water applied with a scrub brush. Thoroughly rinse with water and allow to air dry before using again. HELPFUL HIN[...]

LIMITED W ARRANTY 6 SCOPE OF COVERAGE PERIOD OF COVERAGE TYPE OF F AILURE COVERAGE PERFORA TION, MANUF ACTURING, AND MA TERIAL DEFECTS ONL Y All Parts 90 days from date of purchase* This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer -purchaser only that this product shall be fr[...]

P ARTS LIST 7 A J B P G D I C C C F K L L M P ARTS LIST 7 H A L M N O E B G A A D C I J J K F P Key Qty Description B 1 Firebox Door Latch C 1 Large Porcelain Cooking Grate D 2 Small Porcelain Cooking Grate E 1 Smoke Chamber Assembly F 1 Firebox Assembly G 1 Smokestack Assembly H 2 Short Leg Assembly A 3 Wire Fire Grate I 2 Long Leg Assembly J 2 Wh[...]

ASSEMBL Y 8 1 Smoke Chamber Firebox With 2 one person on smoke chamber end, one person on firebox end, and one person holding both doors closed, roll the unit onto cardboard that was placed on the ground next to the unit. Unit should now be resting on its smoke chamber handle brackets with the leg posts pointing upward. Leg posts pointing upward Sm[...]

On 3 each short leg, slide one onto axle, followed by a wheel, then another . Slide a into the hole at the end of the axle. 1/2” flat washer 1/2” flat washer hitch pin Wheel 1/2” Flat washer Axle Short leg Hitch pin 1/2” Flat washer Hitch pin Slide 4 short legs onto posts closest to firebox, with wheels facing outward. Slide long legs onto [...]

Have 5 one person hold wood rack in position shown while another attaches rack to legs using four . Fully tighten these four bolts. 3/8-16x1” hex-head bolts Wood rack 6 roll the unit over the handle brackets and stand it up onto its legs. Once standing, fully tighten the four leg bolts. MAKE SURE THA T LEG BOL TS ARE TIGHT ENOUGH SO THA T LEGS WO[...]

7 Smoke 8 Attach chamber smokestack to end of smoke chamber by sliding stack into smokestack receiver . While holding the smokestack in a vertical position, tighten the 3 /8-16x3/4” hex-head bolt i n the nut that is welded to the smokestack receiver . Firebox Smokestack Smokestack receiver T o attach damper to firebox side door , place one onto o[...]

9 Handle bracket Hitch pin Handle Handle rod Assembly . . . W hile holding handle in position between handle brackets, slide rod into one bracket, through handle, and out through other bracket. Secure at each end of rod with . Repeat process to assemble firebox handle. hitch pins Handle 10 SS Front Attach shelf front shelf by sliding ends of shelf [...]

T emperature gauge NOTE: Doors not shown for clarity Porcelain Grates Porcelain Grate Smaller wire grates in bottom Place two of the smaller wire grates in the bottom of the smoke chamber and one in the bottom of the firebox. Place the larger porcelain grates into the smoke chamber and firebox as shown below . 12[...]

14 Slide 13 ash pan into ash pan guides. Ash pan Ash pan guides[...]

[...]

20 REGTEMP REV00[...]