Desa (V)V36EP-B manual

N A T U R A L G A S M O D E L S ( V )V 3 6E N -B AN D V V 36 E NC 1 S E RI E S P R O P A N E / L P G A S M O D E L S ( V ) V 3 6 E P - B A N D V V 3 6 E P C 1 S E R I E S W ARNING: Improper installation, adjust- ment, alteration, service, or mai ntenance can cause injury or property damage. Refer to this manual for correct installation and operatio[...]

www .desatech.com 1 1 1253-01F 2 SAFETY INFORMA TION W ARNING: This product contains and/or generates          cancer or birth defects, or other reproductive harm. IMPORT ANT : Read this owner ?[...]

www .desatech.com 1 1 1253-01F 3 12. Do not use this replace to cook food or burn paper or other objects. 13. Do not use any solid fuels (wood, coal, paper, cardboard, etc.) in this replace. Use only the gas type indicated on replace nameplate. 14. This appliance, when installed, must be electrically grounded in accordance with local codes[...]

www .desatech.com 1 1 1253-01F 4 PRE-INST ALLA TION PREP ARA TION    Determine the safest and most efcient location for your DESA direct-vent replace. Make sure that rafters and wall studs are not in the way of the venting system. Choose a location wh[...]

www .desatech.com 1 1 1253-01F 5 C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 W all FRAMING AND FINISHING Fig ure 4 s hows typic al fr aming of th is re plac e. Fig ure 5 shows fram - ing for cor ner i nsta llat ion. All m inim um c leara nces mus t be met . For available accessories for this replace, see Accessories on page 32. If you [...]

www .desatech.com 1 1 1253-01F 6 Figure 7 - Minimum Clearances for T ermination Cap L OCA TION OF TERMINA TION CAP Fixed Closed O p en ab le Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grad[...]

www .desatech.com 1 1 1253-01F 7 VENTING INST ALLA TION INSTR UCTIONS       attempting installation. These models are tested and approved for use with DESA (direct- ven t) pipe co mpo nent s a nd term[...]

www .desatech.com 1 1 1253-01F 8 Fig ure 10 - Installing Horizontal V ent Cap (Noncombustible Exterior) Wood Screw V ent Cap Apply Mastic to All Four Sides VENTING INST ALLA TION INSTR UCTIONS Continued 2. Direct vent pipe sections and components are designed with special twist-lock connections.   [...]

www .desatech.com 1 1 1253-01F 9 VENTING INST ALLA TION INSTR UCTIONS Continued Figure 1 1 - Installing Siding Standoff (Combustible Exterior) V ent Cap (Horizontal T ermination) Interior W all Surface W all Firestop Horizontal V ent Pipe Figure 12 - Connecting V ent Cap with Horizontal V ent Pipe Screw Cut Siding Away to Fit Standoff Wood Screw Sc[...]

www .desatech.com 1 1 1253-01F 10 Figure 15 - Horizontal T ermination Conguration for Corner Installation Using One 90° Elbow Square T ermination W all Firestop Not to Exceed (H) Limits As Required for (V) See Chart for Pipe Section Required 45° Elbow 90° Elbow 90° Elbow Square T ermination W all Firestop 45° Elbow 12" Minimum Not to E[...]

www .desatech.com 1 1 1253-01F 1 1 SNORKEL TERMINA TION INST ALLA TION Recommended Applications: • Installations requiring a vertical rise on building exterior • Any installation using snorkel termination to achieve one foot above ground Snorkel terminations are available for installations requiring a vertical rise on the exterior of the buildi[...]

www .desatech.com 1 1 1253-01F 12              No te : V er ti ca l re st ri ct or mu st b e in st al le d in al l ve rt ic al i ns ta ll ati on s. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters, or[...]

www .desatech.com 1 1 1253-01F 13 VENTING INST ALLA TION INSTR UCTIONS Continued    Figures 21 through 24 show four different congurations for verti - cal termination. V enting with T wo 90° Elbow s V ertical (V) Horizontal (H 1 ) + Horizontal [...]

www .desatech.com 1 1 1253-01F 14 VENTING INST ALLA TION INSTR UCTIONS Continued HIGH AL TITUDE INST ALLA TION Y our DESA direct-vent replace has been CSA tested and approved for elevations from 0-2000 feet (USA) and elevations from 0-4500 feet (Canada). When installing this replace at an elevation above 2000 feet (in the USA), you may need t[...]

www .desatech.com 1 1 1253-01F 15 2. Attach green ground wire from power cord to blower housing using screw provided (see Figure 25, page 14). T ighten screws securely . 3. Place the blow er against the lower rear wall of th e rebox out er wrap per wi th the exhau st por t dire cted upward. The blowe r will t inside the back opening and be he[...]

www .desatech.com 1 1 1253-01F 16 FIREPLA CE INST ALLA TION Continued Figure 29 - Blower Wiring Diagram for Thermostat-Controlled Models 3. Pl ace th e blo wer a gai nst t he low er re ar wa ll of th e  reb ox ou ter wr app er wi t h th e ex ha us t po rt di re cte d u pw ard an d th e th e rm od is c po sit ion ed up nea r the r epl ace bott[...]

www .desatech.com 1 1 1253-01F 17 FIREPLA CE INST ALLA TION Continued Ins tall atio n must inc lude an equip ment sh utof f valv e, unio n, and plu gged 1/8" NPT tap . Loc ate NPT tap wit hin reach for tes t gau ge hoo k up . NP T t ap m ust be u pstre am f rom rep lace (see Fig ure 31). IMPORT ANT : Install main gas valve (equipment shutof[...]

www .desatech.com 1 1 1253-01F 18 Open FIREPLA CE INST ALLA TION Continued Figure 33 - Equipment Shutoff V alve Closed Equipment Shutoff V alve Figure 35 - Checking Gas Joints for Natural Gas Fireplace Figure 34 - Checking Gas Joints for Propane/LP Gas Fireplace Propane/LP Supply T ank Gas V alve Equipment Shutoff V alve Gas Meter Gas V alve Equipm[...]

www .desatech.com 1 1 1253-01F 19 FIREPLA CE INST ALLA TION Continued Removing Glass Door If replacement of glass is necessary , the entire assembly , glass and frame, must be replaced. If glass is broken, wear gloves and tape the remaining fragments onto the frame. 1. Remove screen assembly by pushing the rod either left or right and then down and[...]

www .desatech.com 1 1 1253-01F 20 FIREPLA CE INST ALLA TION Continued       GLOWING EMBERS Each log is marked with a number . These numbers will help you identify the log when installing. It is very important to install these logs exactly as instructed. Do [...]

www .desatech.com 1 1 1253-01F 21 FIREPLA CE INST ALLA TION Continued Figure 47 - Installing the WRC Remote Receiver Fireplace Receptacle Remote Control Receiver Extension Cord Ignition Module Plug 3. Activat e the remote han dset battery by removing the in sulating tab on the back of the handset (see Figure 48). The battery is included pre-install[...]

www .desatech.com 1 1 1253-01F 22 OPERA TING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions           damage, personal injury or los[...]

www .desatech.com 1 1 1253-01F 23 INSPECTING B URNERS Check pilot ame pattern and burner ame patterns often. PILOT ASSEMBL Y The pilot assembly is factory preset for the proper ame. Altera - tions may have occurred during shipping and handling. The pilot is located on the back right hand side of the burner . The ame must envelope 1/4&qu[...]

www .desatech.com 1 1 1253-01F 24 PILOT AND BURNERS • Remove ember material before cleaning burners and replace when cleaning is complete. • Burner and controls should be cleaned with compressed air to remove dust, dirt, or lint. • Use a vacuum cleaner or small, soft bristled brush to remove excess dust, dirt, or lint. LOGS • If you remove [...]

www .desatech.com 1 1 1253-01F 25 TR OUBLESHOO TING Note: All troubleshooting items are listed in order of operation. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control valve lter W ARNING: T urn off heater and let cool before ser- ?[...]

www .desatech.com 1 1 1253-01F 26 TR OUBLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’s phone. Follow the gas supplier ’ s instructions. [...]

www .desatech.com 1 1 1253-01F 27 SPECIFICA TIONS (V)V36EN(S)(H)-B SERIES (V)V36EN(S)(H)-B SERIES     Rating 21,700/31,000 Btu/hr 21,000/30,000 Btu/hr Gas T ype Natural Propane/LP Ignition Electronic Electronic Mani[...]

www .desatech.com 1 1 1253-01F 28 ILL USTRA TED P AR TS BREAKDOWN   [...]

www .desatech.com 1 1 1253-01F 29 P ARTS LIST    This list con[...]

www .desatech.com 1 1 1253-01F 30 ILL USTRA TED P AR TS BREAKDOWN    ?[...]

www .desatech.com 1 1 1253-01F 31 P ARTS LIST    ?[...]

www .desatech.com 1 1 1253-01F 32 A CCESSORIES           Purchase these replace accessories from your local retailer . If they can not suppl[...]

www .desatech.com 1 1 1253-01F 33 NO TES ________________________________________________________________________________________________ ________________________________________________________________________________________________ ________________________________________________________________________________________________ __________________[...]

LIMITED WARRANTY DIRECT -VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of rst purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under this warranty the Bill of Sal[...]