Frigidaire Grill with Electronic Ignition manual

READ AND SA VE THESE INSTRUCTIONS Use & Care Manual Assembly Instructions Included F l i i g a d l i e F l i g i d a l i e W elcome/Product Registration ............ 2 General Safety Instructions .................. 3 Grill Features and Components ...... 4-12 Grill Assembl y ................................ 13-14 Gas Requirements Pre-Operation L[...]

2 W elcome & Congratulations Please retain this manual f or future reference © 2004 Electrolux Home Products, Inc All rights reser v ed Questions? 1-800-Frigidaire Congratulations on y our purchase of a new g rill! W e at Electrolux Home Products are very proud of our product and we are completely committed to providing y ou with the best ser [...]

3 General Safety Instructions IMPOR T ANT SAFETY INFORMA TION - Read this manual carefully bef ore using your g rill to reduce the r isk of fire, burn hazard or other injury . - Extreme care should be used because of the high temperatures produced by this appliance. CHILDREN SHOULD NOT BE LEFT UNA TTENDED IN AN AREA WHERE THE GRILL IS BEING OPERA T[...]

4 Grill Features: FD27 1. Control knob: Main burner 2. Control knob: Rear infrared burner 3. Control knob: Main burner 4. Electronic igniter : Main and rear infrared b urner 5. Control panel 6. Control knob: Main burner 7. Hood handle 8. W ar ming shelf 9. Rear infrared b ur ner 10. T ool bar 11. Electronic igniter : side b ur ner 12. Control knob:[...]

13 Grill Assembl y SIDE SHELF A TT A CHMENT 1. Remov e the side burner together with the gas hose from the front door . Make sure the hose is in good condition bef ore installing the side burner (See Fig. 1) 2. The screws used to attach the side shelf and side b ur ner are already screw ed into the two side panels. Remov e the screws from the side [...]

14 Grill Assembl y SIDE B URNER HANDLE ASSEMBL Y 1. T o assemble the side b ur ner lid handle, open the lid then cut off the plastic tie in the scre w hole. Install the handle in the lid as shown. (See Fig. 3) 2. Remov e the two screws from the handle . Align with the holes in the side burner, then re-attach into the holes on the stand of the handl[...]

15 Gas Requirements GENERAL INFORMA TION Never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire. V erify the type of gas supply to be used – either Natural Gas (N.G.) or Liquid Propane (L.P .) – and make sure the serial plate agrees with that of the supply . Conversion kits [...]

16 Gas Requirements INST ALLA TION OF NA TURAL GAS REGULA T OR 1. The Natural Gas regulator has been attached to the manif old. Attach the gas hose to the regulator as shown. (See Fig. 5) 2. Put the gas hose through the hole on the back of the cart panel. (See Fig. 6) 3. Link a quick-connect fitting to the hose b y hand. Quick-connect fitting not i[...]

17 Gas Requirements Collar Shutoff V alve LP hose/ regulator supplied with grill. (T ype 1 connector) L.P . GAS INST ALLA TION F r igidaire Gas Gr ills that are set to operate with L.P . gas come with a high capacity hose and regulator assembly . (Note: Only use the pressure regulator and hose assemb ly supplied with the grill or a replacement pres[...]

18 Gas Requirements CONNECTION: Y our gr ill is equipped with gas supply orifices for use only with liquid propane gas . It is also equipped with a high capacity hose/regulator assembly f or connection to a standard 20 lb . L.P . cylinder (18-1/4" high, 12-1/4" diameter). T o connect the L.P . gas supply cylinder : (See Fig.8). 1. Make su[...]

19 Pre-Operation Leak T esting GENERAL INFORMA TION Although all gas connections on the grill are leak tested pr ior to shipment, a complete gas tightness check must be perf or med at the installation site due to possible shifting during shipment, installation or e xcessiv e pressure unknowingly being applied to the unit. P eriodically check the wh[...]

20 Lighting the Grill BEFORE LIGHTING Important! Before Lighting... Check the gas supply line f or cuts, wear or abrasion. Alwa ys keep your f ace and body as f ar aw ay from the g rill as possible when lighting. GRILL B URNER LIGHTING Lighting the Grill with the Electronic Igniter 1. Make sure all control knobs are in the “OFF” position. 2. Op[...]

21 Lighting the Grill MA TCH LIGHTING 1. If the bu r ner will not light after sev eral attempts then the burner can be match lit. 2. If you ha ve already attempted to light the burner with the igniter , allow 5 minutes f or any accumulated gas to dissipate. Keep y our face and hands as f ar a wa y from the grill as possible . Inser t a lit extended[...]

22 Using the Grill GRILL LOCA TION Do not use the grill in garages, breeze wa ys, sheds or an y enclosed area or under ov erhead combustib le constr uction. Ne ver oper ate the grill in enclosed areas as this could lead to a carbon monoxide b uildup, which could result in injury or death. Place the grill on a lev el surface . A void mo ving the gri[...]

23 Using the Rotisserie & Side Burner s (Optional RO TISSERIE KIT to use with bac k infrared burner must be purchased separately) NO TE: The rotisserie spit r od is centered between the grill hood and the burner s. It may be necessary to remove the grates and fla v or grids when cooking larger portions of meat on the rotisserie. This is by desi[...]

24 Using the Rotisserie & Side Burner s Fig. 11 Fig. 10 R O TISSERIE LIGHTING Open the lid. Push and tur n the control knob f or the rotisser ie counterclockwise to the “HIGH” position. W ait 5 seconds. Then press and hold the electronic igniter button. Y ou should Hear a snapping sound. If the burner does not light in 4 seconds, tur n the [...]

25 Care & Maintenance DRIP TRA Y The drip tra y located below the grill, inside the car t, should be cleaned per iodically to prev ent hea vy buildup of debris. NO TE: Allo w the drip tray to cool bef ore attempting to clean. Important: Do not leave the grill outside during inc lement weather unless it is covered (co ver sold separately). Rain [...]

26 T roub leshooting Y our Grill GENERAL TR OUBLE SHOO TING Y ou should inspect the burners at least once a year or immediately if any of the f ollowing conditions occur: • The smell of gas. • Flames appearing mostly yellow . (Some yellow at the tips is OK) • The grill will not get hot enough. • Burners make a snapping noise. • The grill [...]

27 T roub leshooting Y our Grill PROBLEM Grill will not light with a match or lo w heat with dial set to “High” position. Flame is erratic Flare-ups Burner flame is mostly yello w or orange, possib ly in conjunction with smell of gas. Cart door does not align properly with cart SOLUTION • Is your gas supply fully turned on? • If this is an [...]

28 W arranty LIMITED ONE YEAR W ARRANTY * LIMITED 3 YEAR W ARRANTY ON ST AINLESS STEEL BURNERS * LIMITED LIFETIME W ARRANTY ON ST AINLESS P ANELS * W ARRANTY PERIOD: One year from original purchase date 2nd through 3rd years from original purchase date From original date of purchase THROUGH OUR A UTHORIZED SER VICERS, WE WILL: P ay all costs f or r[...]