Heat & Glo LifeStyle 550TRSI-AUF manual

1 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Models: 550TRSI-AUF 550TRSILP-AUF Owner ’ s Manual Installation and Operation SAI Global Ref No GSCS20163 AS4553:2008 • DO NOT USE OR STORE FLAMMABLE MA TERIALS NEAR THIS APPLIANCE. • DO NOT SPRA Y AEROSOLS IN THE VICIN- ITY OF THIS APPLIANCE WHILE IT IS IN OPERA T[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 2 M O D E L S: 5 50 T RS I -A UF , 55 0T RS IL P- AU F ARE SAI GLOBAL APPROVED FOR NA TU RAL GAS, PRO P ANE OR BUT ANE AS A BALANCED FLUE HEA TER. Refer to the appliance data plates for gas consumptions and pressures. Installation of this appliance should only be carried o[...]

3 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Model Name: ___________________________________________ Date purchased/installed: __________________ Serial Number: __________________________________________ Location on replace: _____________________ Dealership purchased from: _______________________________ Dealer [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 4 FOR YOUR SAFETY This appliance is designed to operate on LPG IF YOU SMELL GAS: • T urn off as supply at bottle • Extinguish all naked  ames • Do not operate any electrical appliances • V entilate the area • Check for leaks as detailed in this manual If odor [...]

5 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury . • W ARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury . • CAUTION! Indicate[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 6  = Contains updated information. L. Install V ertical T ermination Cap . . . . . . . . . . . . . . . . . . . . 51 1 1 Gas Information A. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . 52 B . G a s C o n n e c t i o n ............................[...]

7 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 C. Limited Lifetime W arranty AUSTRALIAN W ARRANTY INFORMA TION W arranty information in the attached manual is for international markets, not Australia. For Australian warranty information, please see below . Hearth & Home T echnologies Inc (HHT) 7571 215th Street W[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 8 W arranty Period Heat & Glo Manufactured Appliances and V enting Components Covered Parts Labor Gas Wood Pellet EP A Wood Coal Electric V enting 5 years 1 years X X Castings & baf es 7 years 3 years X X X Manifold tubs HEA T & GLO chimney and termination 1[...]

9 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 • Non Heat & Glo venting components, hearth components or other accessories used in conjunction with the appliance. • Any part of a pre-existing  replace system in which an insert or a decorative gas appliance is installed. • Removal, installation, reinstall[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 10 A. Appliance Certication 1 Listing and C ode Approv al s MODELS: 550TRSI-AUF , 550TRSILP-AUF LABORA TORY : SAI Global TYPE: Gas Space Heating Appliance ST ANDARD: AS4553-2008 C. High Altitude Installations NOTICE:  If the heating value of the gas has been[...]

1 1 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 2.1 General Operating Parts B. Y our Fireplace W ARNING! DO NOT operate replace before read - ingand understandingoperating instructions. Failure to operate replace according to operating instructions could cause re or i[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 12 D. Clear Space W ARNING! DO NOT place combustible objects in front of the replace or block louvers. High temperatures may start a re. See Figure 2.2. Avoid placing candles and other heat-sensitive objects on mantel or hearth. Heat may damage these objects. F[...]

13 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 I. Lighting Instructions (IPI) 1. This appliance is equipped with an ignition device which automatically lights the burner. DO NOT try to light the burner by hand. 2. Wait ve (5) minu tes to cle ar out any gas. The n smell for gas, inclu din g near the oor . If yo[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 14 Not e: If t he module is in LOCK- OUT mode, reset ting the cir cuit br eaker to the app lianc e will al so reset t he mod ule. Not e: For unit s inst alled in Australia, the res idence’s 220/ 240 wall out let to whi ch th is appl ianc e’ s powe r co rd is c onne cte[...]

15 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 K. After Fireplace is Lit Initial Break-in Procedure • The fireplace should be run three to four hours continuously on high. • T urn the replace off and allow it to completely cool. • Remove xed glass assembly . See Section 9.E. • Cl ean xed gla ss a ss[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 16 Glass Cleaning Frequency: Seasonally By: Homeowner T ools Needed : Protective gloves, glass cleaner , drop cloth and a stable work surface. CAUTION! Handle xed glass assembly with care. Glass is breakable. • Avoid striking, scratching or slammi[...]

17 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 B. Maintenance T asks-Qualied Service T echnician The following tasks must be performed by a qualied ser- vice technician. Gasket Seal and Glass Assembly Inspection Frequency: Annually By: Qualied Service T echnician T ools needed: Protective gloves, drop cloth[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 18 A. T ypical Appliance System NOTICE:  Illustrations and photos reect typical installations and are for design purposes only . Illustrations/diagrams are not drawn to scale. Actual product may vary from pictures in manual Figure 4.1 T ypical System CEILING FIRES[...]

19 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 B. Design and Installation Considerations Heat & Glo direct vent gas appliances are designed to op - erate with all combustion air siphoned from outside of the building and all exhaust gases expelled to the outside of the building. No additional outside air source i[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 20 5 F raming and C learances A. Selecting Appliance Location Whe n sel ect ing a loca tio n for th e app lia nce it is imp ort an t to con sid er the r equ ire d c lea ra nce s t o w all s (se e F igu re 5.1). W ARNING! Risk of Fire or Burns! Provide ade[...]

21 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 B. Constructing the Appliance Chase A chase is a vertical box-like structure built to enclose the gas appliance and/or its vent system. In cooler climates the vent should be enclosed inside the chase. NOTICE: T reatment of ceiling restops and wall shield restop[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 22 * MINIMUM FRAMING DIMENSIONS Models A B C D E F G H I J DVP Pipe SLP Pipe Rough Opening (Height) **DVP Pipe SLP Pipe Rough Opening (Width) Clearance to Ceiling Combustible Floor Combustible Flooring Behind Appliance Sides of Appliance Front of Appliance Rough Opening (W[...]

23 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 D. Mantel and W all Projections W AR NI NG!  R isk  o f F ir e! Co mp ly w it h al l m in imu m cle ar - an ces a s spe ci ed. Fra min g or n i sh ing ma ter ial clo ser th an th e m in imu ms lis ted mu st be co ns tru cte d e nt ire ly of non com - b[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 24 A. V ent T ermination Minimum Clearances Figure 6.1 Minimum Height From Roo f T o Lowest Discharge Opening 6 T er mination Locations Fire Risk. Maintain vent clearance to combustibles as specied. • DO NOT pack air spac e with insul ati on or oth er materials. Fail [...]

25 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 6.3 Minimum Clearances for T ermination NOTES: 1. All distances are measured vertically or horizontally along the wall to a point in line with the nearest part of the terminal. 2. Prohibited area below electricity meter or fuse box extends to ground level. 3. See[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 26 A. Approved Pipe This appliance is approved for use with Hearth & Home T echnologies DVP and SLP venting systems. Refer to Section 16.B for vent component information. DO NOT mix pipe, ttings or joining methods from differ- ent manufacturers. The pipe is tested t[...]

27 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Example: DVP pipe 3 ft. (1 m) min. vertical = 1 1 ft. (3.35 m) max. horizontal SLP pipe 7 ft. (2.13 m) min. vertical = 1 1 ft. (3.35 m) max. horizontal Figure 7.4 T op V ent - Horizontal T ermination Fire Risk. Explosion Risk. Do NOT pack insulation or other combustible[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 28 T op V ent - Horizontal T ermination - (continued) Figure 7.5 T wo Elbows INST ALLED HORIZONT ALL Y H 1 H 2 V 1 V 1 Minimum H 1 + H 2 Maximum Elbow only Not allowed 6 in. 152 mm 1 ft. 305 mm 1 ft. 305 mm 2 ft. 610 mm 2 ft. 610 mm 4 ft. 1.22 m 3 ft. 914 mm 6 ft. 1.83 m 4[...]

29 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 7.6 Three Elbows H 2 H 1 V 2 V 1 Note: A 6 in. (152 mm) section of straight ue must be atta ched to the heate r before a 90° elbow . USE SLP SERIES COMPONENTS ONL Y V 1 Min. H 1 Max. V 2 Min. H 2 Max. 6 in. 152 mm 1 ft. 305 mm 1 ft. 305 mm 1 ft. 305 mm 1 ft. [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 30 T op V ent - V ertical T ermination This model is approved to use DVP-Series ue pipe com - ponents. A DVP-TVHW vertical Termination Cap must be used to terminate ue systems in a vertical position. Approved ue system components are labeled for identi- cation.[...]

31 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 MODEL 550TRSI-AUF 550TRSILP-AUF FLUE TERMINA TION APPROV ALS DVP-TRAP2 HORIZONT AL TERMINA TION CAP DVP-FBHT HORIZONT AL TERMINA TION CAP DVP-TVHW VERTICAL TERMINA TION CAP Flue System Approvals And Installations These models have ue starting collars on both the top [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 32 Figure 7.10 H 1 V 1 V 2 USE SLP SERIES COMPONENTS ONL Y T wo Elbows T op V ent - V ertical T ermination - (continued) V 1 H 1 Maximum V 2 V 1 + V 2 Min. Elbow only Not allowed * * * 6 in. 152 mm 2 ft. 610 mm * * * 1 f t. 305 mm 4 ft. 1.22 m * * * 2 ft. 610 mm 6 ft. 1.83[...]

33 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 7.1 1 T op V ent - V ertical T ermination - (continued) Three Elbows IN ST ALL ED HO RI ZONTALL Y H 1 H 2 V 1 V 2 USE SLP SERIES COMPONENTS ONL Y V 1 H 1 + H 2 V 2 V 1 + V 2 Minimum H 1 + H 2 Maximum Elbow only 1 ft. 305 mm * * * 1 ft. 305 mm 6 in. 152 mm 2 ft. 6[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 34 Rear V ent - Horizontal T ermination Figure 7.13 No Elbow One 45º Elbow H 1 Do not use a 45º elbow in corner installations. Use two 90º elbows instead. Figure 7.12 USE DVP SERIES COMPONENTS ONL Y USE DVP SERIES COMPONENTS ONL Y H 1 Minimum H 1 Maximum 6-1/2 in. (165 [...]

35 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Rear V ent - Horizontal T ermination - (continued) T wo Elbows Figure 7.14 Figure 7.15 Three Elbows H 1 H 2 V 1 INSTALLED HORIZONTALLY H 3 H 1 H 2 V 1 USE DVP SERIES COMPONENTS ONL Y USE DVP SERIES COMPONENTS ONL Y H 1 Maximum V 1 Minimum H 2 H 1 + H 2 Maximum 6 in. 152[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 36 Rear V ent - V ertical T ermination One Elbow Figure 7.16 T wo Elbows Figure 7.17 V 1 H 1 IN ST AL LED HO RI ZO NT AL L Y H 1 H 2 V 1 USE DVP SERIES COMPONENTS ONL Y USE DVP SERIES COMPONENTS ONL Y V 1 Minimum H 1 Maximum 1 ft. 305 mm 3 ft. 914 mm 2 ft. 610 mm 6 ft. 1.8[...]

37 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Rear V ent - V ertical T ermination - (continued) Three Elbows Figure 7.17 Three Elbows Figure 7.18 INST ALLED HORIZONT ALL Y H 3 H 1 H 2 V 1 V 2 V 1 H 2 H 1 USE DVP SERIES COMPONENTS ONL Y USE DVP SERIES COMPONENTS ONL Y H 1 H 2 H 3 V 1 Minimum H 1 + H 2 + H 3 Maximum [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 38 A. Pipe Clearances to Combustibles W ARNING!Risk ofFire! Maintain air space clearance to vent. DONOT pack insulation or other combustibles: • Between ceiling restops • Between wall shield restops • Around vent system Failure to keep insulation[...]

39 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 C. Install the Ceiling Firestop A ceiling restop MUST be used between oors and attics. • DVP pipe only - Frame an opening 10 in. x 1 0 i n. (2 54 mm b y 2 54 mm ) w he nev er th e vent penetrates a ceiling/oor (see Figure 8.3). • SLP pipe only - Frame openi[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 40 Figure 8.5 Attic Insulation Shield Figure 8.6 Heat Zone ® Knockout E. In sta ll ing t he Opt ion al Hea t-Z on e ® - 24 0V Kit • Remove the knockout from the replace and discard it (see Figure 8.6). • Center the duct collar around the exposed hole and attach it[...]

41 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 CAUTION! Risk of Cuts, Abrasions or Flying Debris. Wear protective gloves and safety glasses during instal- lation. Sheet metal edges are sharp. NOTICE: Once appliance is set up for top or rear venting, it CANNOT be changed at a later time. A.[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 42 B. Rear V ent NOTICE: Once appliance is set up for top or rear venting, it CANNOT be changed at a later time. N OT ICE : Onc e the sea l cap has be en remo ved it CAN NO T be reattached. Figure 9.8 Fold the tabs toward the center of the re plug (90º) and remov[...]

43 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 9.16 Proper Positioning and Securing of an Appliance NAILING TABS (BOTH SIDES) PILOT HOLES Figure 9.14 Non-combustible Board C. Installing the Non-combustible Board The fac tor y suppl ied non -co mbu sti ble boa rd must be used. See Fi gur e 9 .14. Figure 9.13 A[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 44 Natural Gas Propane Butane 550TRSI-AUF 1 1.13 mm N/A N/A 550TRSILP-AUF N/A Full Open Full Open Figure 9.17 Fixed Glass Assembly GLASS ASSEMBL Y LA TCHES (BOTH BOTTOM AND TOP) E. Covers Removal For Servicing Control Compartment Access Door • Lift the lower door up and [...]

45 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 1 0 Installing V ent Pipe ( D V P and SL P P ipe ) A. Assemble V ent Sections (DVP Pipe Only) Attach V ent to the Firebox Assembly Not e: T he end of the pi pe sec tio ns with the la nced tabs w ill fac e toward th e applia nce. Attach the rst pipe section to the sta[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 46 B. Assemble V ent Sections (SLP Pipe Only) T o attach the rst vent component to the starting collars of the appliance: • Lock the vent components into place by sliding the pipe section onto the collar . • Align the seam of the pipe and seam of collar to allow eng[...]

47 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 120º Figure 10.8 Securing V ertical Pipe Sections 120º Figure 10.9 Securing Horizontal Pipe Sections E. Di sa ss emb le V e nt S ect io ns • Rotate either section (see Figure 10.10) so the seams on both pipe sections are aligned as shown in Figure 10.1 1. • Pull c[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 48 10 in. (254 mm) 12 in. (305 mm) INTERIOR WALL SHIELD Figure 10.13 Flue Pipe & Firestop Figure 10.14 Hole and New Framing Members For V ertical Runs - One restop is REQUIRED at the hole in each ceiling through which the ue passes. T o install restops for ver[...]

49 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 10.15 Ceiling Firestop (Ceiling Side) Figure 10.16 Attic Firestop CEILING CEILING FIRESTOP RAFTER NAILS (4 REQUIRED) JOIST CEILING FIRESTOP CEILING NAILS (4 REQUIRED) If the area abov e the ceiling IS an attic, positi on and secure the restop on top of the pre[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 50 J. Install Metal Roof Flashing • See minimum vent heights for various pitched roofs (Figure 10.19) to determine the length of pipe to extend through the roof. • Slide the roof ashing over the pipe sections extending through the roof as shown in Figure 10.20. Figu[...]

51 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 CAULK K. Assemble and Install Storm Collar CAUTION! Risk of Cuts, Abrasions or Flying Debris. Wear protective gloves and safety glasses during instal- lation. Sheet metal edges are sharp. • Connect both halves of the storm collar with two screw[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 52 1 1 Gas Informat ion A. Gas Pressure Requirements W ARNING! Risk of Explosion! An in-line regulator MUST be installed if the gas pressure exceeds 3.7 kPa. Failure to install a regulator could damage valve. Pressure requirements for 550TRSI-AUF and 550TRSILP-[...]

53 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Figure 1 1.1 The gas is introduced to the appliance on the left hand side. See Figure 1 1.1. After the gas pipe installation is complete, check carefully all ga s conn ect ions for lea ks wit h a comm erci all y-av aila ble , noncorrosive leak check solution. Be sure to[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 54 1 2 Elec tr ical Information A. Wiring Requirements NOTICE: This appliance must be installed by a qualied electrician in accordance with the relevant national and local regulations. • Wire the appliance junction cord to 220-240 V AC. This is required for proper [...]

55 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 BLUE BROWN GREEN/ YELLOW Figure 12.2 D. Blower These heaters have a factory installed fan and electrical junction cord. These components are located behind the lower door . Use of th e fan re qui res th at the Junc tio n cord (fac tor y in- sta lle d) be conn ect ed to [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 56 Hearth & Home T echnologies disclaims any responsibility for , and the warranty will be voided by , the following actions: • Installation and use of any damaged system component. • Modication of the system component. • Installation other than as instructed [...]

57 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 5. Close the housing door . See Figure 12.7. 4. Pla ce rem ote co ntr ol in sid e h ous ing . S ee Fi gur e 1 2.6 . Figure 12.6 Remote in Housing Installation of Remote Control Housing CAUTION! Risk of Fire! DO NOT install damaged or modied components [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 58 Figure 12.7 Mounting Remote Control Housing AUX300CE Module Installation • In ser t t he 4 h ol e h ar nes s f ro m t he AUX 30 0CE mod ul e i nt o the 4 pin pl ug on th e c ont rol mo du le. S ee Fig ure 12 .8. Fan Installation • Insert the 3 prong plug from the fa[...]

59 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 FIREPLACE ST A TUS THERMOST A T THERMOST A T DESIRED TEMP SETTING FLAME HEIGHT F AN SPEED ADJUST ABLE AUXILIARY ADJUST ABLE OUTPUT (ON/OFF) TIMER DISPLA Y/FUNCTION ROOM TEMP DISPLA Y FUNCTION LEVEL INDICA TOR LOW BA TTERY INDICA TOR TRANSMISSION INDICA TOR CHILD LOCK IN[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 60 About ON Mode • All functions can be accessed when the remote control is in the ON mode. • Only active functions will be displayed when the remote control is in the ON mode. For example: if the fan is the only function that’ s active, the fan icon and ame will [...]

61 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Adjusting Thermostat • Press the MENU button to activate the menu. • Using the UP and DOWN arrows highlight the THERMO icon and press SELECT . • Use the UP and DOWN arrows to turn the THERMO ON or OFF , then press SELECT (the SET TEMP will start blinking). Using t[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 62 Frequently Asked Questions/T roubleshooting Symptom Possible Cause Corrective Action Remote control will not transmit Batteries V erify batteries are functional and installed correctly . Remote control is in Child Lock mode Disengage Child Lock mode. Buttons not being p[...]

63 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 1 3 Finis hing A. Mantel and W all Projections W AR NI NG!  R isk  o f Fir e! C om ply w ith a ll m in imu m cl ea r - an ces as sp ec ie d. Fra min g clo ser th an th e min imu ms li st - ed mu st be co nst ruc ted en ti rel y of no nco mbu sti ble ma te[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 64 A. Remove Fixed Glass Assembly See Section 9.E. B. Remove the Shipping Materials Remove shipping materials from inside or underneath the rebox. C. Clean the Appliance Clean/vacuum any sawdust that may have accumulated inside the rebox or underneath in the control [...]

65 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 E. Log Placement Instructions Log Assembly: LOGS-550TRSAUD CAUTION: Logs are fragile! Carefully remove the logs from the packaging. LOG #2 (SRV347-703): Place log #2 so that its left edge sits against the left front grate corner and its right edge rests against the tab [...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 66 LOG #4 (SR V278-705): Position log #4 between log #1 and the locating tab on the fourth grate tine. Push its left hand side back to the locating tab as the grate tine. 4 4 5 5 LOG #3 (SR V349-704): Position log #3 so that its right edge sits on log #1 as shown and it&ap[...]

67 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 LOG #7 (SRV484-703): Place log #7 on the groove in log #2 with its rear top on log #1 and front top resting on log #5. LOG #8 (SRV347-701): Hook log #8 on the right hand corner grate tine and rest its rear on log #1 as shown. 7 7 8 8 6 6 LOG #6 (SRV550-718): Place log #[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 68 1 5 T roublesho oting With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualied service technician in the diagnosis of a problem[...]

69 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 T roubleshooting (continued) Symptom Possible Cause Corrective Action 4. Pilot lights but contin- ues to spark, and main burner will not ignite. (If the pilot continues to spark after the pilot ame has been lit, ame rectication has not occurred.) A. A shorted o[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 70 1 6 Reference Materials A. Appliance Dimension Diagram Di men si on s a re a ct ua l a pp li anc e di men si on s. Us e for r ef ere nc e onl y . F or fr am in g d im en sio ns a nd cl ea ran ce s ref er t o S ec ti on 5. Figure 16.1 Appliance Dimensions Location Inches[...]

71 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 B. Maintenance T asks Inspect Maintenance T asks Doors 1. Inspect for scratches, dents or other damage and repair as necessary . 2. V erify no obstructions to airow . 3. V erify maintenance of proper clearance to combustible household objects. Gasket Seal, Glass Asse[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 72 C. V ent Components Diagrams Figure 16.3 DVP vent components Pipe Effective Length Inches Millimeters DVP4 4 102 DVP6 6 152 DVP12 12 305 DVP24 24 610 DVP36 36 914 DVP48 48 1219 DVP6A 3 to 6 76 to 152 DVP12A 3 to 12 76 to 305 DVP12MI 3 to 12 76 to 305 DVP24MI 3 to 24 76 [...]

73 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 C. V ent Components Diagrams ( continued ) Figure 16.4 DVP vent components DVP-TRAP2 DVP-TRAP2 Horizontal T ermination Cap 15-1/8 in. (384 mm) 12 in. (305 mm) 8 in. (203 mm) Max Effective Length Note: Heat shields MUST overlap by a minimum of 1-1/2 in. (38 mm). The heat[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 74 DVP-TRAPFL Flashing DVP-HRC-SS DVP-HRC-ZC-SS Horizontal T ermination Cap Fire Risk. • When using DVP-HRC-SS and DVP-HRC-ZC- SS termination caps on top vented fireplaces, a 6 inch (152 mm) minimum vert ical vent section is require d before installing first elbo w . W[...]

75 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 B. V ent Components Diagrams (continued) Figure 16.6 SLP Series V ent Components 8-3/4 in. 222 mm 6-1/2 in. 165 mm 6-5/8 in. 168 mm 6 in. 152 mm 6-1/2 in. 165 mm 6-5/8 in. 168 mm 9-7/8 in. 251 mm 6-1/2 in. 165 mm 9-1/4 in. 235 mm SLP45 45° Elbow SLP-90ST 90° Elbow Eff[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 76 B. V ent Components Diagrams (continued) Figure 16.7 SLP Series V ent Components SLP-SNKD Snorkel T ermination Cap SLP-TVHW V ertical T ermination Cap SLP-CCS-BK Cathedral Ceiling Support Box-Black SLP-DCF-BK Ceiling Firestop Black SLP-WT -BK W all Thimble-Black DVP-FBH[...]

77 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 D. Service Parts Beginning M anufacturing Date: July 2010 Ending M anufacturing Date: ______ 550TRSI-AUF , 550TRSILP-AUF Log Set Assembly IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model numbe[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 78 Service Parts Beginning M anufacturing Date: July 2010 Ending M anufacturing Date: ______ 550TRSI-AUF , 550TRSILP-AUF #19 V alve Assembly IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model numbe[...]

79 Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 Service Parts List 550TRSI-AUF , 550TRSILP-AUF IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dea[...]

Heat & Glo • 550TRSI-AUF , 550TRSILP-AUF • 2079-980 Rev . N • 5/12 80 E. Contact Information Please contact your Heat & Glo dealer with any questions or concerns. For the location of your nearest Heat & Glo dealer , please visit www .heatnglo.com. - NOTES - __________________________________________________________________________[...]