Husqvarna YTH2348 240440 manual

® YT Owner's Manual Gasoline containing up to 10% ethanol (EIO) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (EIO) will void the product warranty. 532 44 13-02[...]

SAFETY RULES Safe Operation Practices for Ride=On Mowers DANGER: THiS CUTTING MACHINE iS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT iN SERIOUS iNJURY OR DEATH. WARNING: In order to prevent accidental starting when setting up, transporting, adjusting or making repairs,[...]

SAFETY RULES Safe Operation Practices for Ride=On Mowers ill. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the machine and the mowing activity. Never assume that children will remain where you last saw them. • Keep children out ofthe mowing area and in the watchful c[...]

PRODUCT SPECiFiCATiONS Gasoline Capacity 3.0 Gallons and type: Unleaded Regular Oil Type (API-SG-SL): SAE 30 (above 32°F) SAE 5W-30 (below 32°F) Oil Capacity: W/Filter: 64 oz. W/O Filter: 60 oz. Spark Plug: Champion QC12YC (Gap: .040") Ground Speed (MPH): Forward: 0 - 5.2 Reverse: 0 - 2.9 Charging System: 16 AMPS @ 3600 RPM Battery: AMP/HR: [...]

UNASSEMBLED PARTS Steering Wheel / / ¢ f f Steering Wheel Insert t _ J Steering Wheel [ I Steering Wheel Adapter (1) Flat Washer (1) Locknut Seat (1) Seat 1) Washer (1) Hex Bolt Keys (2) Keys (1) Oil Drain Tube For Future Use Slope Sheet 5[...]

ASSEMBLY Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to ensure proper tightness. TOOLS REQUIRED FOR ASSEMBLY A socket wren[...]

ASSEMBLY Push down on seat to engage pads in slots and pull seat towards rear of tractor. • Raise seat and tighten bolt • Remove tape and discard. • Lower seat into operating Press clutch/brake pedal all position is not comfortable, securely. position and sit on seat. the way down. If operating adjust seat. TO ADJUST SEAT (See Fig. 4): Grasp [...]

OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. LOW CHOKE FAST SLOW REVERSE NEUTRAL HIGH 6 O (®) -@ ENGINE OFF REVERSE ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT OPERATION SYSTEM (ROS) FUEL BATTERY LIGHTS ON REVERSE FORWARD CRUISE CONTROL IGNITION SWITCH MOWE[...]

OPERATION KNOW YOUR TRACTOR READ THiS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. 03005 Fig, 5 Our tractors conform to the applicable safety standards of the Americ[...]

OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask worn over spectacles. HOW TO USE YOUR TRA[...]

OPERATION TO MOVE FORWARD AND BACKWARD (See Fig. 9) The direction and speed of movement is controlled by the forward and reverse drive pedals. • Start tractor and release parking brake. • Slowly depress forward (K) or reverse (L) drive pedal to begin movement. Ground speed increases the further down the pedal is depressed. Fig. 9 TO USE CRUISE [...]

OPERATION TO STOP MOWER BLADES Disengage attachment clutch control. _ CAUTION: Do not operate the mower without either the entire grass catcher, on mowers so equipped, or the deflector shield (S) in place (See Fig. 12). Fig. 12 REVERSE OPERATION SYSTEM (ROS) Your tractor is equipped with a Reverse Operation System (ROS). Any attempt by the operator[...]

OPERATION SERVICE REMINDER/HOUR METER Service reminder shows the total number of hours the engine has run and flashes to indicate that the engine or mower needs servicing. When service is required, the service reminder will flash for two hours. To service engine and mower, see the Maintenance section of this manual. NOTE: Service reminder runs when[...]

OPERATION PURGE TRANSMISSION CAUTION: Never engage or disengage freewheel lever while the engine is running. To ensure proper operation and performance, it is recom- mended that the transmission be purged before operating tractor for the first time. This procedure will remove any trapped air inside the transmission which may have devel- oped during[...]

MAINTENANCE MAINTENANCE SCHEDULE Check Brake Operation Check Tire Pressure T Check Operator Presence & ROS Systems A Check for Loose Fasteners C Check/Replace Mower Blades T Lubrication Chart 0 Check Battery Level R Clean Battery and Terminals Clean Debris Off Steering Plate Check Transaxle Cooling Check Mower Levelness Check V-Belts Check Engi[...]

MAINTENANCE TRACTOR Always observe safety rules when performing any maintenance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manua[...]

MAINTENANCE V=BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not adjustable. Replace belts if they begin to slip from wear. TRANSAXLE COOLING The transmission fan and cooling fins should be kept clean to assure proper cooling. Do not attempt to clean fan or transmission while engi[...]

MAINTENANCE MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage. IN=LINE FUEL FILTER (See Fig. 20) The fuel filter should be replaced once each season. If fuel filter becomes clogged, obstructing fuel flow to carburetor, replacement is required. • With engine cool, remove fi[...]

SERVICE AND ADJUSTMENTS o o o WARNING: TO AVOID SERIOUS iNJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: Depress brake pedal fully and set parking brake. Place attachment clutch in "DISENGAGED" position. Turn ignition key to "STOP" and remove key. = Make sure the blades and all moving parts have completely stopped. = Discon[...]

SERVICE AND ADJUSTMENTS = = ASSEMBLE FRONT GAUGE WHEEL (W) TO FRONT OF MOWER (See Fig. 26) H. FRONT MOWER BRACKET W. FRONT GAUGE WHEEL X. SHOULDER BOLT Y. 1=1/40.D. WASHER Z. 3/8=18 LOCKNUT Fig. 26 TURN STEERING WHEEL MOWER (See Fig. 27) LEFT AND POSITION Turn steering wheel to the left as far as it will go and position mower on right side of tract[...]

SERVICE AND ADJUSTMENTS 6. ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS (See Fig. 32) • Position front hole in side suspension arm (A) over pin on outside of tractor chassis and secure with large washer and large retainer spring (B). • Repeat on opposite side of tractor. ,?":_4 > j/ / / / / / A. MOWER SIDE SUSPENSION ARMS B. RETAINE[...]

SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower is not adjusted properly. VISUAL SIDE-TO-SIDE ADJUSTMENT (See Fig. 36) • With all tires properly inflated and if your lawn appears un[...]

SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 40) MOWER DRIVE BELT REMOVAL • Park tractor on a level surface. Engage parking brake. • Lower attachment lift lever to its lowest position. • Disengage belt tension rod (K) from lock bracket (L). m = I CAUTION: Belt tension rod is spring I release slowly. loaded. Have a firm [...]

SERVICE AND ADJUSTMENTS TO CHECK BRAKE If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be serviced. You may also check brake by: 1. Park tractor on a level, dry concrete or paved surface, depress brake pedal all the way down and engage parking brake. . D[...]

SERVICE AND ADJUSTMENTS REPLACING BATTERY (See Fig. 44) _ WARNING: Do notshort batterytermi= nals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc. Positive terminal must be connected first to prevent sparking from accidental groundin[...]

STORAGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNIN G: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. AIIowthe engine to cool before storing in any enclosure. TRACTOR Remove mower from tractor f[...]

TROUBLESHOOTING PROBLEM Wi[[ not start Hard to start Engine will not turn over Engine clicks but wi[[ not start Loss of power Excessive vibration CAUSE 1. Out of fuel. CORRECTION 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. 9. Loose or damaged wiring[...]

TROUBLESHOOTING PROBLEM Engine continues to run when oper- ator leaves seat with attachment clutch engaged Poor cut = uneven Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Loss of drive Engine "back- fires" when turn= ing engine "OFF" Engine dies when tractor i[...]

SCHEMATIC TRACTOR - - MODEL NUMBER YTH2348 (240440) SCH12 Uc UF HH 1 biD PTO SWITCH (MATING SIDE) IGNITION SWITCH POSITION CIRCUIT MAKE" OFF M+G+AI RUN/OVERRIDE B+AI RL"N B+AI L+A2 START B + S + AI ;I I I_) l BATTERY SOLENOID RED ] i AMMETER FLSE (JT] _ (OPTIONAL) I, ,'4_J_ if3, ! I __/ WU]TE PTO SWITCH (DISENGAGED) I IH WHITE I I D [...]

ELECTRICAL TRACTOR - - MODEL NUMBER YTH2348 (240440) TllS 22 1 26 '/_ ..... ' 33 24 27 / / 43 / With 12V Outlet Option I I With Service Minder Option 16 I I I I I / 71_ 29 -k / I I I I I i I / ! ! / I _!.._102 / _ _ 105 / 42 / / 11 / // // / ", // 3O[...]

ELECTRICAL TRACTOR - - MODEL NUMBER YTH2348 (240440) KEY PART NO. NO. DESCRIPTION 1 532 18 34-85 Battery 2 874 78 04-12 Bolt Hex Head 1/4-20 x 3/4 8 532 18 84-91 Box Battery 18 532 17 81-38 Switch Interlock Push-In 21 532 40 02-52 Harness Socket Light w/4152J 22 532 00 41-52 Bulb Light 24 532 40 02-53 Cable Brty 25 532 41 28-95 Cable Starter 28 532[...]

CHASSIS TRACTOR - - MODEL NUMBER YTH2348 (240440) 207 25 286 283 284 287 162 chassis-tex GT HUSQ II 5 rl 36 137 37 175 165 228 130 235 34 130 152 151 ._18 217 52 32[...]

CHASSIS TRACTOR - - MODEL NUMBER YTH2348 (240440) KEY NO. 3 5 14 15 18 25 34 36 37 52 88 130 137 150 151 152 181 182 185 175 178 177 180 182 183 189 191 194 PART NO. 532 43 97-52 532 43 74-71 532 44 11-77 532 43 97-33 532 43 77-62 532 43 97-32 532 19 81-25 817 06 05-12 532 44 11-78 873 68 05-00 817 49 05-08 532 41 63-58 532 40 75-90 532 43 97-74 53[...]

DRIVE TRACTOR - - MODEL NUMBER YTH2348 (240440) 207 92 206 ,125 216 171 160 26 I I 196 35 125 51 49 / / 188 52 33 230 205 183 ddve-tex K46 pedal 77 rl 29 116 2 73 163 1 34 226 153 211 208 125 < I 225 I 2 183 222 211 166 2O5[...]

DRIVE TRACTOR - - MODEL NUMBER YTH2348 (240440) KEY NO. 2 15 17 26 29 33 35 42 49 50 51 52 56 64 73 80 92 99 116 125 143 153 159 160 161 163 166 167 170 PART NO. 532 42 532 12 819 13 532 41 532 19 532 40 812 00 532 43 532 12 872 11 532 19 873 90 532 19 532 13 532 19 874 49 532 44 874 76 532 41 873 90 817 00 817 49 532 12 876 02 532 16 532 10 532 40[...]

ENGINE TRACTOR - - MODEL NUMBER YTH2348 (240440) 18 37__ 28 -_ 15 29 l SPARK ARRESTER KIT j engine-tex_bs-2cyl_64 84 82 1 81 36[...]

ENGINE TRACTOR - - MODEL NUMBER YTH2348 (240440) KEY PART NO. NO. DESCRiPTiON 1 532 43 82-01 Engine B&S Model No. 445577 2187-G1 2 532 14 97-23 Muffler 9 532 19 43-20 Keeper Belt Engine 11 532 40 00-08 Clutch Ogura 12 532 40 50-97 Pulley Engine 15 532 43 80-80 Tank Fuel 18 532 43 92-08 Cap 20 532 42 35-02 Control Throttle 21 532 41 83-58 Screw [...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) STEERING ASSEMBLY 63 19 I 60 _ 57 63 61 67 _66 steering-tex HUSQSR 20 58 ./ j i68 I 70 / 62 KEY PART NO. NO. 1 532 43 97-40 2 532 19 59-68 4 532 40 30-87 5 532 40 30-88 6 532 12 49-31 7 532 12 17-48 8 812 00 00-29 9 532 12 12-32 13 532 12 17-49 14 810 04 06-00 15 873 54 06-00 16 532 40 82-19 19 532 19 47-29[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) SEAT ASSEMBLY 8 8 7 8 41 10 21 6 2 seat-tex_6.5SL_3 3 KEY NO. 1 2 3 6 7 8 10 21 37 PART NO. DESCRIPTION 532 42 40-68 Seat 532 18 01-66 Bracket Pivot Fender 532 14 06-75 Strap, Asm Fender 873 80 06-00 Nut, Lock w/Ins. 3/8-16 unc 532 12 41-81 Spring, Seat Cprsn 532 17 18-77 Bolt 5/16-18 unc x 3/4 w/Sems 532 1[...]

MOWER DECK TRACTOR - - MODEL NUMBER YTH2348 (240440) 11 98 97 242 241 33 30 116 /" 117 120 i 49 1 48 Deck tex 22 r2 194 189 19 / 190 / / / / 187 / / 1 / 22 8 } 18 29 25 26 27 4O[...]

MOWER DECK TRACTOR - - MODEL NUMBER YTH2348 (240440) KEY PART NO. NO. 1 532 44 00-48 6 532 19 72-48 7 532 19 91-02 8 532 19 30-03 11 532 18 00-54 12 532 40 48-51 13 532 18 72-91 14 532 18 72-81 15 532 11 04-85 16 819 13 13-12 17 872 11 05-05 18 872 14 05-05 19 532 19 42-08 20 532 17 43-78 21 873 68 05-00 22 532 17 44-93 24 532 10 53-04 25 532 17 81[...]

MOWER LIFT TRACTOR - - MODEL NUMBER YTH2348 (240440) i 91 87 88 2 91 / / 97 / /////,/, / / ,/ 87 89 KEY PART NO. NO. DESCRIPTION 2 532 42 20-27 Shaft Asm., Lift 3 532 19 52-31 Lever Asm., Lift RH 7 532 41 15-55 Grip, Lever 10 532 19 63-14 Spring Torsion 87 532 19 42-09 Pin Cotter 7/16 Bow Tie Lock 88 532 41 07-10 Spring Lift Assist 89 819 19 19-12 [...]

DECALS TRACTOR - - MODEL NUMBER YTH2348 (240440) 56 11 9 8 12 13 KEY NO. 1 2 3 5 6 8 9 11 PART NO. DESCRiPTiON 532 41 16-57 Decal 532 42 91-98 Decal 532 43 86-87 Decal 532 42 38-29 Decal 532 44 14-52 Decal 532 42 95-57 Decal 532 14 50-05 Decal 532 17 05-63 Decal Operators Hood Hood Panel SD Customer Respons. Replacement Eng. HP Battery Dnge/Poi War[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) TUFFTORQ TRANSAXLE MODEL NUMBER K46BT MODEL K46BT 7A646084180 ACTUAL PARTS MAY NOT APPEAR AS SHOWN 116 I 6O 55 _m87 59 @m83 _--34 - 72 I 44[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) TUFFTORQ TRANSAXLE MODEL NUMBER K46BT KEY PART NO. NO. DESCRIPTION 7 532 41 43-95 Vent Valve 15 8 532 41 43-96 Magnet 9 532 41 43-97 Magnet Holder 10 532 41 59-23 Pump Shaft/Bearing Kit 13 532 41 43-98 Bypass Lever 15 532 41 43-99 Sealing Cap 30 16 532 41 44-00 Snap Ring C 35 19 532 41 44-01 O-Ring la Pl0a [...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) BRIGGS AND STRATTON ENGINE - MODEL NUMBER 445577, TYPE NUMBER 2187-G1 48 SHORY BI_OCK [ 1058 OPERATOR'S MANUAL ] [ 1329 REPLACEMENT ENGINE ] 1330 REPAIR MANUAL ] 121 CARBURETOR OVERHAUL KIT 10t_ _ 718 _ 250 If/:" sJ, 1027 552A (_' 552 691 I_ iJo_,, i t_ t 965 ,._ x=_--_.. _25i i227i 212 278 t[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) BRIGGS AND STRATTON ENGINE - MODEL NUMBER 445577, TYPE NUMBER 2187-G1 747 1005 23 / 352 @ 75 q_j 1119 C'_ 635<_ 789 ii:: 108/%=zJ="<;"_ iii i ,;_ ==================================== 634 _%17' l lO5@ 1124A _'_ 130 987 @ i 51A LoG:>()_° 918 1012 {@ 265 267 _ 47 1051 <&[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) BRIGGS AND STRATTON ENGINE = MODEL NUMBER 445577, TYPE NUMBER 2187=G1 1036 EMISSIONS LABEL I }_ > 1040 635 _._ F¢,: 467 9 3O4 306 _# 305A 5 305B _2 1026 _ 1026A _, 914 %I_ _45 26A 918 i J 163 i_ 'e_ 573 306 307 _ 447 _@ // J 918A 66s i42q 1 1O22 48 5_ i33_ 883 1022 36_) 1029[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) BRIGGS AND STRATTON ENGINE - MODEL NUMBER 445577, TYPE NUMBER 2187-G1 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 1 793564 Cylinder Assembly 131 499805 2 797673 Bushing!Seal Kit (Magneto Side) 133 699724 3 391086s Seal-Oil (Magneto Side) 135 699729 4 796307 Sump-Engine 137 690994 5 796231 Head-Cylinder (C[...]

TRACTOR - - MODEL NUMBER YTH2348 (240440) BRIGGS AND STRATTON ENGINE - MODEL NUMBER 445577, TYPE NUMBER 2187-G1 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 415 794903 Plug (Oil Pressure Switch Hole) 914 691127 415A 690283 Plug (intake Manifold) 918 797408 418 795912 Plate-Carburetor 918A 799160 431 798859 Elbow-intake 943 796222 445 499486s Filte[...]

Consumer Wheeled Products - Limited Warranty Husqvarna warrants to the original retail purchaser that this Husqvama® product is free from defects in material or workmanship under normal use and maintenance from the date of retail purchase for the applicable Warranty Period shown on Exhibit A. Certain components (e.g., engines and transmissions) ar[...]

c. Preventative maintenance as outlined in the operator's lnanual. In addition, you lnust cease using the product immediately upon any failure or damage. The product should be taken to an authorized Husqvarna servicing dealer prior to any further use. 4. Damages resulting from normal aging, wear and tear or neglect are NOT covered. The Limited[...]

Exhibit A Consumer Wheeled Warranty Chart 2010 Consumer (personal, Commercial (any commercial, Rental (any rental household use only) professional, institutional, usage) arigculutral, or income producing use, other than Rental Use) Product/Component Frame, Chassis, Front Axle 5 Years NO WARRANTY NO WARRANTY Engine* * * * Transmission (if made by Hu[...]

Exhibit A Consumer Wheeled Warranty Chart 2010 Consumer (personal, Commercial (any commercial, Rental (any rental household use only) professional, institutional, usage) arigculutral, or income producing use, other than Rental Use) Product/Component _Deck,,, Engine* * * * Transmission 2 Years NO WARRANTY NO WARRANTY Battery 1 Year Pro-rated NO WARR[...]

SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL LO 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees. Make turns gradually to prevent tipping or loss of control. Exercise extreme ca[...]

12.21.10 BAD/AP Husqvarna Printed in the U.S.A.[...]