Norcold 1200XX manual

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual. For assis- tance or additional information, contact a qualified installer, service agency, or the gas supplier. FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquid in the vicinity of[...]

Owner’s Manual 2 Table of Contents Gas Absorption 3 Y ear Limited W arranty Policy ......................... 2 Gas Absorption Warranty Information ........................................ 3 Gas Absorption W arranty Questions .......................................... 3 Safety Awareness .............................................................[...]

Owner’s Manual 3 Gas Absorption W arranty Information 2. IN NO EVENT AND UNDER NO CIRCUMST ANCES SHALL NORCOLD BE RESPONSIBLE UNDER THIS LIMITED W AR- RANTY FOR ANY OTHER CHARGE WHA TSOEVER, INCLUDING BUT NOT LIMITED TO CHARGES OR CLAIMS FOR LABOR, LOST BUSINESS, LOST TIME, LOST PROFITS, LOSS OF USE, OR ANY KIND OF INCIDENT AL OR CONSEQUENTIAL DA[...]

Owner’s Manual 4 - Do not spray liquids near electrical outlets, connec- tions, or the refrigerator components. Many liquids are electrically conductive and can cause a shock hazard, electrical shorts, and in some cases fire. - The refrigerator cooling system is under pressure. Do not try to repair or to recharge a defective cooling system. The c[...]

Owner’s Manual 5 Food compartment: S tart up the refrigerator (see “Operating the Refrigerator Controls”)and let it cool for eight hours before loading with food. If the refrigerator does not start to cool down after about two hours, contact your dealer or a Norcold authorized service center . For the best cooling performance: - Let air move [...]

Owner’s Manual 6 T emperature control system: Although the refrigerator is not frost -free, it is made to limit frost on the cooling fins. At regular intervals, the temperature control system automatically melts most of the frost from the cooling fins. The water from the cooling fins drains into a collection cup that is attached to the back of th[...]

Owner’s Manual 7 Operating the Refrigerator Controls AC Operation 120 volts AC (108 volts min.-132 volts max.) Propane gas operation: Propane gas (1 1 inches water column pressure) 12 volts DC - control voltage (10.5 volts min. - 15.4 volts max.) The refrigerator operates on these energy sources. Operation out of these limits can damage the refri[...]

Owner’s Manual 8 Effect s of High Altitude on Prop ane Gas Operation When you operate the refrigerator on propane gas at altitudes higher than 5500 feet above sea level: - Y ou may experience reduced cooling performance of the refrigerator . - Y ou may experience burner outages. T o avoid these possible problems, Norcold recommends that you opera[...]

Owner’s Manual 9 Ice Maker (Optional) The ice maker is assembled to the refrigerators at the factory as optional equipment. If the refrigerator does not have a factory installed ice maker , one cannot be added to the refrigerator at a later time. The ice maker is fully automatic and will operate in ambient temperatures as low as 0° F . T o allow[...]

Owner’s Manual 10 Interior: A good time to clean the refrigerator is just after you defrost it. Clean the inside of the refrigerator as often as necessary to avoid food odors: - Remove all food from the refrigerator . NOTE: Do not use abrasive cleaners, chemicals, or scouring pads because they can damage the interior of the refrigerator . Cleanin[...]

Owner’s Manual 11 Door Sealing Check the seal of the doors (See Art00980). If either door does not seal correctly, excess frost will collect inside the refrigerator. Make sure the doors seal correctly: - Close each door on a piece of paper that is about the size and thickness of a dollar bill. - Gently pull the paper. - You should feel a slight d[...]

Owner’s Manual 12 Refrigerator Maintenance Gas flame appearance: While in LP GAS operation, examine the appearance of the gas flame: - Push the TEMP SET button until the number “9” appears in the center display . - Open the lower intake vent. CAUTION: The burner box cover can be hot. Wear gloves to avoid burns. - Look at the gas flame [75] (S[...]

Owner’s Manual 13 Reinstall the Refrigerator Y our dealer or Norcold authorized service center must do this procedure. W ARNING: Make sure the combustion seal is not broken, is completely around the refrigerator mounting flanges, and is between the mounting flanges and the wall of the enclosure. If the combustion seal is not complete, exhaust fum[...]

Owner’s Manual 14 Wiring Diagram and Pictorial The parts of the ice maker wiring pictorial and diagram are (See Art01500): 1 0 9 ..................................................... 120V AC Hot / smooth 1 1 0 ................................................. 120 V AC Neutral / ribbed 1 1 1 ........................................................[...]

Owner’s Manual 15 Fault Codes s e d o C t l u a Fg n i n a e M e d o C t l u a Fs n o i t c A e v i t c e r r o C o N . y a l p s i d s i e g a t l o v C D e h t o t e l b a l i a v a n u l o r t n o c r o t a r e g i r f e r e h t r o l e n a p . F F O s i r o t a r e g i r f e r : k c e h C . N O s i r o t a r e g i r f e r e h t t a h T - . l [...]

Owner’s Manual 16[...]

Art00990 Art00992 54 41[...]

[...]

Art01769 GND 12VDC AC_HT_HI F2 P2 1 10 2 L1 L2 YL/JN BK/NR YL/JN BK/NR AC_HT_LO 120 V AC 120 VCA } 3 TEMP T1 - 12 VDC/VCD P1 4 1 2 3 + 12 VDC/VCD WH/BC WH/BC WH/BC WH/BC OR/OR POWER BOARD / P ANNEAU DALIMENT ATION ON-OFF OVERLA Y/REV ˚ TRMENT MODE DISPLA Y BOARD/CARTE DAFFICHAGE 5 AMP AC_HT_LO AC_HT_HI 1 2 3 4 5 6 LIMIT_IN LIMIT_OUT RD-WH/RG[...]

Ar t0 177 0 5 L1 L2 P1 1 7 5 OVERLA Y/REV ˚ TRMENT DISPLA Y BOARD/ CARTE DAFFICHAGE POWER BOARD/ P ANNEAU DALIMENT ATION +12VDC/VCD G G 4 P2 T1 S 5 AMP 5 AMP AC_HT_HI LIMIT_IN LIMIT_OUT AC_HT_LO AC_HT_HI AC_HT_LO GND 12VDC T B B A 11 T 8 -12VDC/VCD H 7 M L K J N R P Q O 1 6 2 D C 3 2 4 1 1 E U F F 6 1 10 1 F V T F2 F1[...]