Opel Astra (2011) manual

0 - 1 VAUXHALL Astra VAUXHALL Astra Owner’s Manual Model Year 2011 Edition: August 2010 TS 1680-A-11[...]

Introduction .................................... 2 In brief ............................................ 6 Keys, doors and windows ............ 18 Seats, restraints ........................... 34 Storage ........................................ 52 Instruments and controls ............. 81 Lighting ...................................... 116 Climate[...]

2 Introduction Introduction[...]

Introduction 3 Vehicle specific data Please enter your vehicle's data on the previous page to keep it easily accessible. This information is available in the sections "Service and maintenance" and "Technical data" as well as on the identification plate. Introduction Your vehicle is a designed combination of advanced technol[...]

4 Introduction 9 Warning Text marked 9 Warning provides information on risk of accident or injury. Disregarding this information may lead to injury. Caution Text marked Caution provides information on possible damage to the vehicle. Disregarding this information may lead to vehicle damage. Symbols Page references are indicated with 3 . 3 means &quo[...]

Introduction 5[...]

6 In brief In brief Initial drive information Vehicle unlocking Press button c to unlock the doors and load compartment. Open the doors by pulling the handles. To open the tailgate, push the touchpad switch below the handle. Radio remote control 3 19, Central locking system 3 20, Load compartment 3 23. Seat adjustment Seat positioning Pull handle, [...]

In brief 7 Seat backrests Pull lever, adjust inclination and release lever. Allow the seat to engage audibly. Seat position 3 35, Seat adjustment 3 36. Seat height Lever pumping motion up = seat higher down = seat lower Seat position 3 35, Seat adjustment 3 36. Seat inclination Lever pumping motion up = front end higher down = front end lower Seat [...]

8 In brief Head restraint adjustment Press the button, adjust height and engage. Head restraints 3 34. Seat belt Pull out the seat belt and engage in belt buckle. The seat belt must not be twisted and must fit close against the body. The backrest must not be tilted back too far (maximum approx. 25 °). To release belt, press red button on belt buck[...]

In brief 9 Exterior mirrors Select the relevant exterior mirror and adjust it. Convex exterior mirrors 3 27, Electric adjustment 3 27, Folding exterior mirrors 3 27, Heated exterior mirrors 3 28. Steering wheel adjustment Unlock the lever, adjust the steering wheel, then engage the lever and ensure it is fully locked. Do not adjust the steering whe[...]

10 In brief[...]

In brief 11 Instrument panel overview 1 Light switch ........................ 116 Headlight range adjustment ......................... 117 Front fog lights ................... 121 Rear fog light ...................... 121 Instrument illumination ....... 122 2 Side air vents ...................... 131 3 Turn and lane-change signals, headlight flash,[...]

12 In brief Exterior lighting Turn light switch AUTO = automatic light control: Headlights are switched on and off automatically m = activation or deactivation of the automatic light control 7 = off 8 = sidelights 9 = headlights Press light switch > = front fog lights r = rear fog light Lighting 3 116. Headlight flash, high beam and low beam hea[...]

In brief 13 Turn and lane-change signals lever up = right turn signal lever down = left turn signal Turn and lane-change signals 3 121, Parking lights 3 122. Hazard warning flashers Operated with the ¨ button. Hazard warning flashers 3 120. Horn Press j .[...]

14 In brief Washer and wiper systems Windscreen wiper 2 = fast 1 = slow P = timed interval wiping or automatic wiping with rain sensor § = off For a single wipe when the windscreen wiper is off, press the lever down. Windscreen wiper 3 83, Wiper blade replacement 3 163. Windscreen and headlight washer systems Pull lever. Windscreen and headlight w[...]

In brief 15 Push lever. Washer fluid is sprayed on the rear window and the wiper wipes a few times. Climate control Heated rear window, heated exterior mirrors The heating is operated by pressing the Ü button. Heated rear window 3 31. Demisting and defrosting the windows Press button V . Set the temperature control to the highest level. Cooling n [...]

16 In brief Transmission Manual transmission Reverse: with the vehicle stationary, depress the clutch pedal, press the release button on the selector lever and engage the gear. If the gear does not engage, set the lever to neutral, release the clutch pedal and depress again; then repeat gear selection. Manual transmission 3 140. Automatic transmiss[...]

In brief 17 Starting the engine ■ Turn key to position 1 ■ move the steering wheel slightly to release the steering wheel lock ■ operate clutch and brake ■ automatic transmission in P or N ■ do not operate accelerator pedal ■ diesel engines: turn the key to position 2 for preheating and wait until control indicator ! goes out ■ turn k[...]

18 Keys, doors and windows Keys, doors and windows Keys, locks ................................... 18 Doors ........................................... 23 Vehicle security ............................ 24 Exterior mirrors ............................ 27 Interior mirrors ............................. 28 Windows ...................................... [...]

Keys, doors and windows 19 Radio remote control Used to operate: ■ Central locking system ■ Anti-theft locking system ■ Anti-theft alarm system ■ Power windows ■ Sunroof The radio remote control has an approximate range of up to 65 ft. It can be restricted by external influences. The hazard warning flashers confirm operation. Handle with [...]

20 Keys, doors and windows Key with foldaway key section Extend the key and open the unit. Replace the battery (battery type CR 2032), paying attention to the installation position. Close the unit and synchronise. Radio remote control synchronisation After replacing the battery, unlock the door with the key in the driver's door lock. The radio[...]

Keys, doors and windows 21 flap, press button c once. To unlock all doors, press button c twice or ■ press button c once to unlock all doors, load compartment and fuel filler flap The setting can be changed in the menu Settings in the Info-Display. Vehicle personalisation 3 111. The setting can be saved for the key being used. Memorised settings [...]

22 Keys, doors and windows Press the e button to lock. Press the c button to unlock. Fault in radio remote control system Unlocking Manually unlock the driver's door by turning the key in the lock. Switch on the ignition and press the central locking button c to unlock all doors, load compartment and fuel filler flap. By switching on the ignit[...]

Keys, doors and windows 23 The settings can be saved for the key being used 3 20. Child locks 9 Warning Use the child locks whenever children are occupying the rear seats. Using a key or suitable screwdriver, turn the child lock in the rear door to the horizontal position. The door cannot be opened from the inside. For deactivation turn the child l[...]

24 Keys, doors and windows Central locking system 3 20. Closing Use one of the interior handles. Do not push the touchpad switch below the handle whilst closing as this will unlock the tailgate again. Central locking system 3 20. General hints for operating tailgate 9 Warning Do not drive with the tailgate open or ajar, e.g. when transporting bulky[...]

Keys, doors and windows 25 Activating Press e on the radio remote control twice within 15 seconds. Anti-theft alarm system The anti-theft alarm system is combined with the central locking system. It monitors: ■ Doors, tailgate, bonnet ■ Passenger compartment including adjoining load compartment ■ Vehicle inclination, e.g. if it is raised ■ [...]

26 Keys, doors and windows 1. Close tailgate, bonnet, windows and sunroof. 2. Press button o . LED in the button o illuminates for a maximum of 10 minutes. 3. Close doors. 4. Activate the anti-theft alarm system. Status message is displayed in the Driver Information Center. Status LED Status LED is integrated in the sensor on top of the instrument [...]

Keys, doors and windows 27 If the control indicator d flashes when the ignition is on, there is a fault in the system; the engine cannot be started. Switch off the ignition and then repeat the start attempt. If the control indicator continues flashing, attempt to start the engine using the spare key and seek the assistance of a workshop. Note The i[...]

28 Keys, doors and windows Electric folding Turn control to 7 , then push the control down. Both exterior mirrors will fold. Push the control down again - both exterior mirrors return to their original position. If an electrically folded mirror is manually extended, pressing down the control will only electrically extend the other mirror. Heated Op[...]

Keys, doors and windows 29 Automatic anti-dazzle Dazzle from following vehicles at night is automatically reduced. Windows Manual windows The door windows can be opened or closed with the window winders. Power windows 9 Warning Take care when operating the power windows. Risk of injury, particularly to children. If there are children on the rear se[...]

30 Keys, doors and windows Safety function If the window glass encounters resistance above the middle of the window during automatic closing, it is immediately stopped and opened again. Override safety function In the event of closing difficulties due to frost or the like, pull and hold the switch. The window moves up without safety function enable[...]

Keys, doors and windows 31 Initialising the power windows If the windows cannot be closed automatically (e.g. after disconnecting the vehicle battery), a warning message or a warning code is displayed in the Driver Information Center. Vehicle messages 3 102. Activate the window electronics as follows: 1. Close doors. 2. Switch on ignition. 3. Pull [...]

32 Keys, doors and windows Roof Sunroof 9 Warning Take care when operating the sunroof. Risk of injury, particularly to children. Keep a close watch on the movable parts when operating them. Ensure that nothing becomes trapped in them as they move. Switch on ignition to operate the sunroof. Open or close Press p or r gently to the first detent: sun[...]

Keys, doors and windows 33 Closing sunroof from outside The sunroof can be closed remotely from outside the vehicle. Press and hold e button to close the sunroof. Release the button to stop the movement. Initialising of the roof If the sunroof cannot be operated (e.g. after disconnecting the vehicle battery), activate the sunroof electronics as fol[...]

34 Seats, restraints Seats, restraints Head restraints ............................ 34 Front seats ................................... 35 Rear seats ................................... 39 Seat belts ..................................... 39 Airbag system .............................. 42 Child restraints ............................. 46 Head restrai[...]

Seats, restraints 35 Note Approved accessories may only be attached, if the seat is not in use. Head restraints on rear seats Height adjustment Pull the head restraint upwards or press the catch to release and push the head restraint downwards. Removal Press both catches, pull the head restraint upwards and remove. Front seats Seat position 9 Warni[...]

36 Seats, restraints ■ Adjust the lumbar support so that it supports the natural shape of the spine. Seat adjustment 9 Danger Do not sit nearer than 25 cm from the steering wheel, to permit safe airbag deployment. 9 Warning Never adjust seats while driving as they could move uncontrollably. Seat positioning Pull handle, slide seat, release handle[...]

Seats, restraints 37 Seat height Lever pumping motion up = seat higher down = seat lower Seat inclination Lever pumping motion up = front end higher down = front end lower Lumbar support Adjust lumbar support using the four- way switch to suit personal requirements. Moving support up and down: push switch up or down. Increasing and decreasing suppo[...]

38 Seats, restraints Adjustable thigh support Pull the lever and slide the thigh support. Armrest The armrest can be slid forwards by 4 inches. Under the armrest there is a storage compartment. Armrest storage 3 54. Heating Adjust heating to the desired setting by pressing the ß button for the respective seat one or more times with the ignition on[...]

Seats, restraints 39 Rear seats Armrest Fold armrest down. The armrest contains cupholders and a storage box. Seat belts The seat belts are locked during heavy acceleration or deceleration of the vehicle holding the occupants in the sitting position. Thereby the risk of injury is considerably reduced. 9 Warning Fasten seat belt before each trip. In[...]

40 Seats, restraints 9 Warning Incorrect handling (e.g. removal or fitting of belts) can trigger the belt pretensioners. Deployment of the belt pretensioners is indicated by continuous illumination of control indicator v 3 92. Triggered belt pretensioners must be replaced by a workshop. Belt pretensioners can only be triggered once. Note Do not aff[...]

Seats, restraints 41 Height adjustment 1. Pull belt out slightly. 2. Press button. 3. Adjust height and engage. Adjust the height so that the belt lies across the shoulder. It must not lie across the throat or upper arm. Do not adjust while driving. Removing To release belt, press red button on belt buckle. Seat belts on the rear seats The seat bel[...]

42 Seats, restraints Using the seat belt while pregnant 9 Warning The lap belt must be positioned as low as possible across the pelvis to prevent pressure on the abdomen. Airbag system The airbag system consists of a number of individual systems depending on the scope of equipment. When triggered the airbags inflate within milliseconds. They also d[...]

Seats, restraints 43 Front airbag system The front airbag system consists of one airbag in the steering wheel and one in the instrument panel on the front passenger side. These can be identified by the word AIRBAG . There are also warning labels on both sides of the sunblind on the front passenger side. Furthermore there is a warning label on the s[...]

44 Seats, restraints The side airbag system consists of an airbag in each front seat backrest. This can be identified by the word AIRBAG . The side airbag system is triggered in the event of a side impact of a certain severity. The ignition needs to be switched on. The inflated airbags cushion the impact, thereby reducing the risk of injury to the [...]

Seats, restraints 45 Airbag deactivation The front passenger airbag system has to be deactivated if a child restraint system is to be fitted on this seat. The side airbag and curtain airbag systems, the belt pretensioners and all driver airbag systems will remain active. The front passenger airbag system can be deactivated via a key- operated switc[...]

46 Seats, restraints Status remains until the next change. Control indicator for airbag deactivation 3 93. Child restraints Child restraint systems We recommend the Vauxhall child restraint system which is tailored specifically to the vehicle. When a child restraint system is being used, pay attention to the following usage and installation instruc[...]

Seats, restraints 47 are restraint systems that comply with ECE 44-03 or ECE 44-04. Since a proper position of the belt is rarely possible with a child that is smaller than 5 ft, we strongly advise the use of an appropriate child restraint system, even though this might, due to the age of the child, no longer be legally binding. Ensure that the chi[...]

48 Seats, restraints Child restraint installation locations Permissible options for fitting a child restraint system Weight and age class On front passenger seat On rear outboard seats On rear centre seat activated airbag deactivated airbag Group 0: up to 10 kg or approx. 10 months X U 1 U 2 U Group 0+: up to 13 kg or approx. 2 years X U 1 U 2 U Gr[...]

Seats, restraints 49 Permissible options for fitting an ISOFIX child restraint system Weight class Size class Fixture On front passenger seat On rear outboard seats On rear centre seat Group 0: up to 10 kg E ISO/R1 X IL X Group 0+: up to 13 kg E ISO/R1 X IL X D ISO/R2 X IL X C ISO/R3 X IL X Group I: 9 to 18 kg D ISO/R2 X IL X C ISO/R3 X IL X B ISO/[...]

50 Seats, restraints ISOFIX size class and seat device A – ISO/F3 = Forward-facing child restraint system for children of maximum size in the weight class 9 to 18 kg. B – ISO/F2 = Forward-facing child restraint system for smaller children in the weight class 9 to 18 kg. B1 – ISO/F2X = Forward-facing child restraint system for smaller children[...]

Seats, restraints 51 ISOFIX child restraint systems Fasten vehicle-approved ISOFIX child restraint systems to the ISOFIX mounting brackets. Specific vehicle ISOFIX child restraint system positions are marked in the table by IL. ISOFIX mounting brackets are indicated by a label on the backrest. Top-tether fastening eyes Top-tether fastening eyes are[...]

52 Storage Storage Storage compartments ................ 52 Load compartment ....................... 64 Roof rack system ......................... 78 Loading information ..................... 79 Storage compartments Glovebox The glovebox features a pen holder, a credit card holder and a coin holder. The intermediate shelf can be removed. The gloveb[...]

Storage 53 Depending on the version, cupholders are located under a cover in the centre console. Slide cover backwards. Bottles can be stowed after folding up the intermediate shelf 3 55. Additional cupholders are located in the rear armrest. Fold down the armrest. Front storage A storage compartment is located next to the steering wheel. Sunglasse[...]

54 Storage Underseat storage Press button in the recess and pull out drawer. Maximum load: 3 kg. To close, push in and engage. Depending on the version, the tyre repair kit is stowed in the drawer. Armrest storage Storage under the front armrest Press button to fold up the armrest. The armrest must be in rearmost position. Storage in the rear armre[...]

Storage 55 Centre console storage Front console The storage container can be used to store small items. Depending on the version, a storage compartment is located under a cover. Slide cover backwards. Press button to remove the frame of the cupholder. The frame can be stowed in the glovebox. A further storage compartment is located under the interm[...]

56 Storage Rear carrier system The rear carrier system (Flex-Fix system) allows bicycles to be attached to a pull-out carrier integrated into the vehicle floor. The maximum load of the rear carrier system is 40 kg. The maximum load per bicycle is 20 kg. If not in use, the carrier system can be slid back into the vehicle floor. A multifunction box i[...]

Storage 57 Install the tail lamps First remove the rear ( 1 ), then the front ( 2 ) tail lamp from the recesses. Open out the lamp support on the back of the tail lamp completely. Push the clamping lever down and push the lamp support into the retainer until it engages. Perform this procedure for both tail lamps. Check the cable and lamp position t[...]

58 Storage Lock the rear carrier system Swivel the right clamping lever ( 1 ) first, followed by the left clamping lever ( 2 ), until a resistance is noticeable. The rear carrier system is locked when the clamping levers are swivelled by approx. 50°. Otherwise safe functionality is not guaranteed. Note Close the tailgate. Unfold pedal crank recess[...]

Storage 59 Remove the pedal crank mounts from the pedal crank recesses. Adapting the rear carrier system to a bicycle Press the release lever and withdraw the wheel recesses. Push the release lever on the strap retainer and remove the strap retainer.[...]

60 Storage Prepare the bicycle for attachment Rotate the left pedal (without a chain cog) vertically downwards. The pedal on the left pedal crank must be horizontal. The front bicycle must have its front wheel facing left. The rear bicycle must have its front wheel facing right. Attaching a bicycle to the rear carrier system With the rotary lever o[...]

Storage 61 Put on the bicycle. The pedal crank here must be placed in the pedal crank recess opening as shown in the illustration. Caution Make sure that the pedal does not touch the surface of the rear end carrier. Otherwise the crankset might be damaged during the transport. Insert pedal crank mount into outer rail of each pedal crank recess from[...]

62 Storage Align the bicycle in the longitudinal direction of the vehicle: Slightly loosen the pedal mount. Place the bicycle upright using the rotary lever on the pedal crank recess. If the two bicycles obstruct one another, the relative positions of the bicycles can be adapted by adjusting the wheel recesses and the rotary lever on the pedal cran[...]

Storage 63 Insert the strap retainer and pull tightly downwards as far as possible. Press release lever and slide in wheel recesses all the way as far as they will go. Disengage the locking lever on the diagonal support and fold both pedal crank recesses down. 9 Warning Risk of pinching. Swivel first the left clamping lever ( 1 ), followed by the r[...]

64 Storage Push the clamping lever down and pull both lamp supports out of the recesses. Fold in the lamp supports on the backs of the tail lamps. First place the front ( 1 ) tail lamp, then the rear ( 2 ) tail lamp in the recesses and push down as far as possible. Push cables all the way into all guides in order to prevent damage. Open the tailgat[...]

Storage 65 Guide the seat belts through side supports to protect them against damage. When folding the backrests, pull the seat belts along with them. Pull the release lever on one or both sides and fold down the backrests onto the seat cushion. If the vehicle is to be loaded via a rear door, take the seat belt out of the seat backrest guide and pu[...]

66 Storage Load compartment extension, Estate Folding down rear backrests Remove the load compartment cover if necessary. Press and hold the catch, then push the head restraints down. Fold up the rear armrest. Guide the seat belts through side supports to protect them against damage. When folding the backrests, pull the seat belts along with them. [...]

Storage 67 To fold up, raise the backrests and guide them into an upright position until they engage audibly. Ensure that the seat belts of the outboard seats are placed in the corresponding belt guides. The backrests are properly engaged when the red marks on both sides near the release lever are no longer visible. 9 Warning Only drive the vehicle[...]

68 Storage Remove the seat cushion Push both levers forward and remove seat cushion to extend the loading area. To attach, apply seat cushion as shown in the illustration and engage both levers. Open the pass-through in the rear centre backrest Fold down the rear armrest. Pull the grip and open the cover. Suitable for loading long, narrow objects. [...]

Storage 69 The closed cover can be secured from the side of the load compartment. Turn the knob 90°: knob horizontal = cover secured from the side of the passenger compartment knob vertical = cover not secured Load compartment cover Do not place any objects on the cover. Saloon/Hatchback Removing Unhook retaining straps from tailgate. Lift cover a[...]

70 Storage Opening cover Pull the handle at the end of the cover to the rear and downwards. It rolls up automatically. Cover in upper position Push the handle at the end of the cover downwards.The rear of the cover is guided upwards automatically. Removing cover Open the load compartment cover. Pull the release lever on the right side up and hold i[...]

Storage 71 The removed cover can be stored under the rear floor cover like shown in the graphic. Rear floor storage cover 3 71. Installing cover Insert the left side of the load compartment cover in the recess, pull the release lever up and hold it, insert the right side of the load compartment cover and engage. Rear floor storage cover Rear floor [...]

72 Storage Lifting To lift the cover to a higher level, pull the loop backwards and lift the rear edge of the cover onto the corresponding supports. Lowering To lower the cover, pull the strap backwards and push down the front center of the cover at the same time. Caution Do not lower the height adjustable cover to position 1 in vehicles equipped w[...]

Storage 73 Rear floor cover, Estate Lift the rear floor cover by pulling the handle. Fold and place the cover behind the rear seats. The storage compartment below the rear floor cover can be divided by a bar. Insert the bar into the recesses at the sidewalls. Caution Insert the bar into the rearmost recess when transporting heavy objects in the loa[...]

74 Storage ■ hooks, ■ service box, ■ strap set. The components are fitted in rails on both side panels using adapters and hooks. Installation of adapters in the rails Fold open the handle plate, insert the adapter into the upper and lower groove of the rail and move to the required position. Turn the handle plate upwards to lock the adapter. [...]

Storage 75 Installation of hooks in the rails Insert the hook in the desired position first in the upper groove of the rail and then press in the lower groove. To remove, first pull out of the upper groove. Service box Install two hooks in the upper rail. Insert the upper brackets of the box from above into the hooks. Alternatively install both hoo[...]

76 Storage Strap set Insert the adapters of the strap set in a rail. Make sure that the belt is not twisted. The strap set has two locks to open. The belt can be tightened. Safety net The safety net is available on the Estate and can be installed behind the rear seats or, if the rear seat backrests are folded and the seat cushions raised, behind th[...]

Storage 77 Behind front seats Attach strap to eyes underneath the rear seat cushion. Fold backrests forward. To get a flat load bay, first fold seat cushion before attaching the safety net. Load compartment 3 64. Removal Detach straps from the eyes. Unhook the safety net rods from the brackets in the roof frame. Roll up the net and secure with a st[...]

78 Storage First aid kit Saloon/Hatchback Stow the first aid kit in the stowage compartment behind the warning triangle. Before first use, press in the interior trim at the top and at the sides of the perforation. Then fold the trim outward to gain access to the stowage compartment. Estate Fold down strap. Stow the first aid kit in the space behind[...]

Storage 79 Detach the cover from each mounting point by using a coin. Estate with roof railing To fasten the roof rack, insert the mounting bolts in the holes indicated in the figure. Loading information ■ Heavy objects in the load compartment should be placed against the seat backrests. Ensure that the backrests are securely engaged. If objects [...]

80 Storage ■ Do not allow the load to protrude above the upper edge of the backrests. ■ Do not place any objects on the load compartment cover or the instrument panel, and do not cover the sensor on top of the instrument panel. ■ The load must not obstruct the operation of the pedals, parking brake and gear selector lever, or hinder the freed[...]

Instruments and controls 81 Instruments and controls Controls ....................................... 81 Warning lights, gauges and indicators ..................................... 87 Information displays ..................... 98 Vehicle messages ...................... 102 Trip computer ............................. 109 Vehicle personalisation ....[...]

82 Instruments and controls Heated steering wheel Activate heating by pressing * button. Activation is indicated by the LED in the button. The recommended grip areas of the steering wheel are heated quicker and to a higher temperature than the other areas. Horn Press j .[...]

Instruments and controls 83 Windscreen wiper/washer Windscreen wiper 2 = fast 1 = slow P = interval wiping § = off For a single wipe when the windscreen wiper is off, press the lever down. Do not use if the windscreen is frozen. Switch off in car washes. Adjustable wiper interval Wiper lever in position P . Turn the adjuster wheel to adjust the de[...]

84 Instruments and controls Adjustable sensitivity of the rain sensor Turn the adjuster wheel to adjust the sensitivity: low sensitivity = turn adjuster wheel downwards high sensitivity = turn adjuster wheel upwards Keep the sensor free from dust, dirt and ice. Windscreen and headlight washer Pull lever. Washer fluid is sprayed onto the windscreen [...]

Instruments and controls 85 Rear window wiper/washer Press the rocker switch to activate the rear window wiper: upper position = continuous operation lower position = intermittent operation middle position = off Push lever. Washer fluid is sprayed onto the rear window and the wiper wipes a few times. Do not use if the rear window is frozen. Switch [...]

86 Instruments and controls Additionally a warning message is displayed in the Driver Information Center with Uplevel-Display. 9 Warning The road surface may already be icy even though the display indicates a few degrees above 0 °C. Clock Date and time are shown in the Info-Display. Set date and time Press the CONFIG button. The menu Settings is d[...]

Instruments and controls 87 Power outlets A 12 Volt power outlet is located in the front console. A further 12 Volt power outlet is located in the rear console. Fold the cover downwards. Estate: A 12 Volt power outlet is located at the left side wall in the load compartment. Do not exceed the maximum power consumption of 120 watts. With ignition of[...]

88 Instruments and controls Odometer The bottom line displays the recorded distance. Trip odometer The top line displays the recorded distance since the last reset. To reset, hold the reset knob depressed for a few seconds with the ignition on. Tachometer Displays the engine speed. Drive in a low engine speed range for each gear as much as possible[...]

Instruments and controls 89 Engine coolant temperature gauge Displays the coolant temperature. left area = engine operating temperature not yet reached central area = normal operating temperature right area = temperature too high Caution If engine coolant temperature is too high, stop vehicle, switch off engine. Danger to engine. Check coolant leve[...]

90 Instruments and controls Turn the adjuster wheel to select Remaining Oil Life . The system must be reset every time the engine oil is changed to allow proper functionality. Seek the assistance of a workshop. Press the SET/CLR button to reset while applying the brake pedal. Thereby the ignition must be switched on, with the engine not running. Wh[...]

Instruments and controls 91 Control indicators in the instrument cluster[...]

92 Instruments and controls Control indicators in the centre console Turn signal O illuminates or flashes green. Illuminates briefly The parking lights are switched on. Flashes A turn signal or the hazard warning flashers are activated. Rapid flashing: failure of a turn signal light or associated fuse, failure of turn signal light on trailer. Bulb [...]

Instruments and controls 93 9 Warning Have the cause of the fault remedied immediately by a workshop. Belt pretensioners, airbag system 3 39, 3 42. Airbag deactivation V illuminates yellow. The front passenger airbag is activated. * illuminates yellow. The front passenger airbag is deactivated 3 45. 9 Danger Risk of fatal injury for a child using a[...]

94 Instruments and controls 9 Warning Stop. Do not continue your journey. Consult a workshop. Operate pedal - illuminates or flashes yellow. Illuminates Brake pedal needs to be operated to release the electrical parking brake 3 142. Flashes Clutch pedal needs to be operated to start the engine 3 134. Electrical parking brake m illuminates or flashe[...]

Instruments and controls 95 Power steering c illuminates yellow. Illuminates with power steering reduced Power steering is reduced due to overheating of the system. Control indicator goes out when the system has cooled down. Illuminates with power steering disabled Failure in the power steering system. Consult a workshop. Lane departure warning ) i[...]

96 Instruments and controls Preheating ! illuminates yellow. Preheating is activated. Only activates when outside temperature is low. Diesel particle filter % illuminates or flashes yellow. The diesel particle filter requires cleaning. Continue driving until % goes off. If possible do not allow engine speed to drop below 2000 rpm. Illuminates The d[...]

Instruments and controls 97 9 Warning When the engine is off, considerably more force is needed to brake and steer. Do not remove key until vehicle is stationary, otherwise the steering wheel lock could engage unexpectedly. Check oil level before seeking the assistance of a workshop 3 160. Low fuel i illuminates yellow. Level in fuel tank is too lo[...]

98 Instruments and controls Washer fluid 3 162. Cruise control m illuminates white or green. Illuminates white The system is on. Illuminates green A certain speed is stored. Cruise control 3 147. Door open h illuminates red. A door or the tailgate is open. Information displays Driver Information Center The Driver Information Center (DIC) is located[...]

Instruments and controls 99 Selecting menus and functions The menus and functions can be selected via the buttons on the turn signal lever. Press the MENU button to switch between the menus or to return from a submenu to the next higher menu level. Turn the adjuster wheel to highlight a menu option or to set a numeric value. Press the SET/CLR butto[...]

100 Instruments and controls ■ Remaining Oil Life : 3 89 ■ Coolant Temperature : Display of engine coolant temperature 3 89 ■ Relearn Remote Key : Relearn after battery replacement ■ Battery Voltage : Display of battery voltage ■ Speed Warning : If exceeding the preset speed, a warning chime will be activated ■ Language : Displayed lang[...]

Instruments and controls 101 Graphic-Info-Display indicates: ■ time 3 86 ■ outside temperature 3 85 ■ date 3 86 ■ Infotainment system, see description in the infotainment manual ■ settings for vehicle personalisation 3 111 Colour-Info-Display The Colour-Information-Display indicates in colour: ■ time 3 86 ■ outside temperature 3 85 ?[...]

102 Instruments and controls Selecting with the Infotainment system Select a function via the Infotainment system buttons. The menu of the selected function is displayed. The multifunction knob is used to select an item and to confirm. Multifunction knob The multifunction knob is the central control element for the menus: Turn ■ To mark a menu op[...]

Instruments and controls 103 Vehicle messages on the Midlevel-Display The vehicle messages are displayed as code numbers. No. Vehicle message 1 Change engine oil 2 No radio remote control detected, depress clutch pedal for a restart 3 Engine coolant level low 4 Air conditioning off No. Vehicle message 5 Steering wheel is locked 6 Depress brake peda[...]

104 Instruments and controls No. Vehicle message 48 Clean side blind zone alert system 49 Lane departure warning unavailable 50 Activated pedestrian protection system, reset bonnet 51 Compass unavailable 53 Tighten gas cap 54 Water in diesel fuel filter 55 Diesel particle filter is full 3 136 56 Tyre pressure imbalance on front axle 57 Tyre pressur[...]

Instruments and controls 105 Vehicle messages on the Uplevel-Display The vehicle messages are displayed as text. Follow the instructions given in the messages. The system displays messages regarding the following topics: ■ Fluid levels ■ Anti-theft alarm system ■ Brakes ■ Drive systems ■ Ride control systems ■ Cruise control ■ Object [...]

106 Instruments and controls Traffic sign assistant Functionality The traffic sign assistant system detects designated traffic signs via a front camera and displays them in the Driver Information Center. Traffic signs, which will be detected, are ■ speed limit ■ no passing ■ end of speed limit ■ end of no passing Speed limit signs are displ[...]

Instruments and controls 107 Display indication Traffic signs are displayed on the page Traffic sign detection in the Trip/ Fuel Information Menu , chosen via the adjuster wheel on the turn signal lever 3 98. When another function on the Driver Information Center menu was selected and then Traffic sign detection page is chosen again, the last recog[...]

108 Instruments and controls Pop-up function The pop-up function can be selected by pressing the SET/CLR button on the turn signal lever. Activation will be indicated by the icon in the display. Pop-up indication is displayed for approx. 8 seconds in the Driver Information Center. Fault The traffic sign assistant system may not operate correctly wh[...]

Instruments and controls 109 1. Switch off immediately electrical consumers which are not required for a safe ride, such as seat heating, heated rear window or other main consumers. 2. Charge the battery by driving continuously for a while or by using a charging device. The warning message or warning code will disappear after the engine has been st[...]

110 Instruments and controls The information of the two trip computers can be reset separately, making it possible to display different trip distances. To reset, press the reset knob or press the SET/CLR button for a few seconds. Range Range is calculated from current fuel tank content and current consumption. The display shows average values. Afte[...]

Instruments and controls 111 Vehicle personalisation The vehicle's behaviour can be personalised via changing the settings in the Info-Display. Some of the personal settings for different drivers can be memorised individually for each vehicle key. Memorised settings 3 20 Depending on vehicle equipment and country-specific regulations some of t[...]

112 Instruments and controls Sport mode settings The driver can select the functions which will be activated in Sport mode 3 145. ■ Sport suspension : Damping becomes harder. ■ Sport powertrain performance : Accelerator pedal and gear change characteristics become more responsive. ■ Sport steering : Steering support is reduced. ■ Swap backl[...]

Instruments and controls 113 Park assist : Activate or deactivate the ultrasonic parking assist. ■ Exterior ambient lighting Exterior lighting by unlocking : Activate or deactivate the welcome lighting. Duration upon exit of vehicle : Activate or deactivate and change the duration of exit lighting. ■ Remote locking, unlocking, starting Remote u[...]

114 Instruments and controls Sport mode settings The driver can select the functions which will be activated in Sport mode 3 145. ■ Sport suspension : Damping becomes harder. ■ Sport powertrain performance : Accelerator pedal and gear change characteristics become more responsive. ■ Sport steering : Steering support reduced. ■ Swap backligh[...]

Instruments and controls 115 Park assist : Activate or deactivate the ultrasonic parking assist . ■ Exterior ambient lighting Exterior lighting by unlocking : Activate or deactivate the welcome lighting. Duration upon exit of vehicle : Activate or deactivate and change the duration of exit lighting. ■ Lock / Unlock / Start Remote unlock feedbac[...]

116 Lighting Lighting Exterior lighting .......................... 116 Interior lighting ........................... 122 Lighting features ........................ 124 Exterior lighting Light switch Turn light switch: AUTO = automatic light control: Headlights are switched on and off automatically depending on external lighting conditions. m = acti[...]

Lighting 117 Automatic light control Automatic light control function When the automatic light control function is switched on and the engine is running, the system switches between daytime running light and headlight depending on the lighting conditions. Daytime running light Daytime running light increases visibility of the vehicle during dayligh[...]

118 Lighting 0 = front seats occupied 1 = all seats occupied 2 = all seats occupied and load compartment laden 3 = driver's seat occupied and load compartment laden. Dynamic automatic headlight levelling 3 118. Headlights when driving abroad The asymmetrical headlight beam extends visibility at the edge of the road at the passenger side. Howev[...]

Lighting 119 Playstreet lighting Activated automatically at low speed up to approx. 20 mph. The light beam is turned at an angle of 8° to the roadside. Town lighting Activated automatically at a speed range between approx. 25 and 34 mph and when street lights are detected by the light sensor. The light range is reduced by an extended light distrib[...]

120 Lighting It switches to low beam when: ■ the camera in the windscreen detects the lights of oncoming or preceding vehicles ■ the vehicle speed is slower than 12 mph ■ it is foggy or snowy ■ driving in urban areas If there are no restrictions detected, the system switches back to high beam. The green control indicator l illuminates conti[...]

Lighting 121 Turn and lane-change signals lever up = right turn signal lever down = left turn signal If the lever is moved past the resistance point, the turn signal is switched on constantly. When the steering wheel moves back, the turn signal is automatically deactivated. For three flashes, e.g. when changing lanes, press the lever until resistan[...]

122 Lighting Parking lights When the vehicle is parked, the parking lights on one side can be activated: 1. Switch off ignition. 2. Move turn signal lever all the way up (right parking lights) or down (left parking lights). Confirmed by a signal and the corresponding turn signal control indicator. Reversing lights The reversing lights come on when [...]

Lighting 123 On vehicles with light sensor, the brightness can only be adjusted when the exterior lights are on and the light sensor detects night conditions. Interior lights During entry and exit of the vehicle, the front and rear courtesy lights automatically switch on and then off after a delay. Note In the event of an accident with airbag deplo[...]

124 Lighting Lighting features Centre console lighting Spotlight incorporated in the interior lighting comes on when headlights are switched on. Entry lighting Welcome lighting Headlights, tail lights, reversing lights, number plate lights, instrument panel light, interior lights and puddle lights are switched on for a short time by unlocking the v[...]

Lighting 125 Exit lighting is switched off immediately if the turn signal lever is pulled while the driver's door is open. Activation, deactivation and duration of this function can be changed in the menu Settings in the Info-Display. Vehicle personalisation 3 111. The settings can be saved for the key being used 3 20. Battery discharge protec[...]

126 Climate control Climate control Climate control systems ............. 126 Air vents ..................................... 131 Maintenance .............................. 132 Climate control systems Heating and ventilation system Controls for: ■ Temperature ■ Air distribution ■ Fan speed ■ Demisting and defrosting Heated rear window Ü 3 [...]

Climate control 127 Air conditioning system In addition to the heating and ventilation system, the air conditioning system has: n = cooling 4 = air recirculation Heated seats ß 3 38, Heated steering wheel * 3 82. Cooling n Operated with the n button and is functional only when the engine and fan are running. The air conditioning system cools and d[...]

128 Climate control ■ Switch cooling n on. ■ Set temperature control to warmest level. ■ Switch on heated rear window Ü . ■ Open side air vents as required and direct them towards the door windows. Electronic climate control system The dual zone climate control allows different climatisation temperatures for driver and front passenger side[...]

Climate control 129 Automatic mode AUTO Basic setting for maximum comfort: ■ Press AUTO button, the air conditioning is activated automatically. ■ Open all air vents. ■ Set the preselected temperatures for driver and front passenger using the left and right rotary knob to 22 °C. The fan speed regulation in automatic mode can be changed in th[...]

130 Climate control Press lower button to decrease or upper button to increase fan speed like shown in the graphic. The fan speed is indicated by the number of segments in the display. Pressing the lower button longer: fan and cooling are switched off. Pressing the upper button longer: the fan runs at maximum speed. To return to automatic mode: Pre[...]

Climate control 131 Activation is indicated by the LED in the button. Basic settings Some settings can be changed in the menu Settings in the Info-Display. Vehicle personalisation 3 111. Auxiliary heater Air heater Quickheat is an electric auxiliary air heater which automatically warms up the passenger compartment more quickly. Air vents Adjustable[...]

132 Climate control 9 Warning Do not attach any objects to the slats of the air vents. Risk of damage and injury in case of an accident. Fixed air vents Additional air vents are located beneath the windscreen and door windows and in the foot wells. Maintenance Air intake The air intake in front of the windscreen in the engine compartment must be ke[...]

Driving and operating 133 Driving and operating Driving hints ............................... 133 Starting and operating ............... 133 Engine exhaust .......................... 136 Automatic transmission .............. 137 Manual transmission .................. 140 Brakes ........................................ 141 Ride control systems .....[...]

134 Driving and operating Ignition switch positions 0 = Ignition off 1 = Steering wheel lock released, ignition off 2 = Ignition on, for diesel engine: preheating 3 = Starting Retained power off These vehicle accessories can be used for up to 10 minutes after the engine is turned off: ■ Infotainment system ■ Power windows ■ Sunroof ■ Power [...]

Driving and operating 135 Starting the vehicle at low temperatures The start of the engine without additional heaters is possible down to -25 °С for diesel engines and -30 °C for petrol engines. Required is an engine oil with the correct viscosity, the correct fuel, performed services and a sufficiently charged battery. With temperatures below -[...]

136 Driving and operating Engine exhaust 9 Danger Engine exhaust gases contain poisonous carbon monoxide, which is colourless and odourless and could be fatal if inhaled. If exhaust gases enter the interior of the vehicle, open the windows. Have the cause of the fault rectified by a workshop. Avoid driving with an open load compartment, otherwise e[...]

Driving and operating 137 Cleaning takes place quickest at high engine speeds and loads. The control indicator % extinguishes as soon as the self-cleaning operation is complete. Catalytic converter The catalytic converter reduces the amount of harmful substances in the exhaust gases. Caution Fuel grades other than those listed on pages 3 151, 3 205[...]

138 Driving and operating Selector lever P = park position, wheels are locked, engage only when the vehicle is stationary and the parking brake is applied R = reverse gear, engage only when the vehicle is stationary N = neutral D = automatic mode with all gears The selector lever is locked in P and can only be moved when the ignition is on and the [...]

Driving and operating 139 Manual mode Move selector lever out of position D towards the left and then forwards or backwards. < = Shift to a higher gear. ] = Shift to a lower gear. If a higher gear is selected when vehicle speed is too low, or a lower gear when vehicle speed is too high, the shift is not executed. This can cause a message in the [...]

140 Driving and operating Interruption of power supply In the event of an interruption of power supply, the selector lever cannot be moved out of the P position. The ignition key cannot be removed from the ignition switch. If the battery is discharged, start the vehicle using jump leads 3 193. If the battery is not the cause of the fault, release t[...]

Driving and operating 141 Caution It is not advisable to drive with the hand resting on the selector lever. Brakes The brake system comprises two independent brake circuits. If a brake circuit fails, the vehicle can still be braked using the other brake circuit. However, braking effect is achieved only when the brake pedal is depressed firmly. Cons[...]

142 Driving and operating Fault 9 Warning If there is a fault in the ABS, the wheels may be liable to lock due to braking that is heavier than normal. The advantages of ABS are no longer available. During hard braking, the vehicle can no longer be steered and may swerve. Have the cause of the fault remedied by a workshop. Parking brake Manual parki[...]

Driving and operating 143 Before leaving the vehicle, check the electrical parking brake status. Control indicator m 3 93. Releasing Switch on ignition. Keep foot brake pedal depressed and then push switch m . Drive away function Depressing clutch pedal (manual transmission) or engaging drive gear (automatic transmission) and then depressing the ac[...]

144 Driving and operating Ride control systems Traction Control system The Traction Control system (TC) is a component of the Electronic Stability Control. TC improves driving stability when necessary, regardless of the type of road surface or tyre grip, by preventing the drive wheels from spinning. As soon as the drive wheels starts to spin, engin[...]

Driving and operating 145 9 Warning Do not let this special safety feature tempt you into taking risks when driving. Adapt speed to the road conditions. Control indicator b 3 95. Deactivation For very high-performance driving ESC can be deactivated: hold button b depressed for approx. 7 seconds. Control indicator n illuminates. ESC is reactivated b[...]

146 Driving and operating SPORT mode The settings of the systems are adapted to a sportier driving style: ■ Damping of shock absorbers reacts more stiffly to provide better contact with the road surface. ■ The engine reacts more quickly to the accelerator pedal. ■ Steering support is reduced. ■ Shift points of automatic transmission occur l[...]

Driving and operating 147 Cruise control The cruise control can store and maintain speeds of approx. 20 to 120 mph. Deviations from the stored speeds may occur when driving uphill or downhill. For safety reasons the cruise control cannot be activated until the foot brake has been operated once. Activating in first gear is not possible. Do not use t[...]

148 Driving and operating ■ selector lever in N , ■ the Traction Control system or electronic stability control is operating. Resume stored speed Turn thumb wheel to RES/+ at a speed above 20 mph. The stored speed will be obtained. Switching off Press rocker switch m at the lower end, control indicator m extinguishes. The stored speed is delete[...]

Driving and operating 149 An obstacle is indicated by a buzzing sound. The interval between the sounds becomes shorter as the vehicle gets closer to the obstacle. When the distance is less than 1 ft, the buzzing is continuous. Deactivation Deactivate the system by pressing the r button. The LED in the button will go out and Park Assist Off will be [...]

150 Driving and operating Note The parking assist system automatically detects factory-fitted towing equipment. It is deactivated when the connector is plugged in. The sensor may detect a non- existing object (echo disturbance) caused by external acoustical or mechanic disturbances. Lane departure warning The lane departure warning system observes [...]

Driving and operating 151 Fault The lane departure warning system may not operate properly when: ■ the windscreen is not clean ■ there are adverse environmental conditions like heavy rain, snow, direct sunlight or shadows ■ no lane marking can be detected If the lane departure warning system detects one of these conditions, the control indica[...]

152 Driving and operating Refuelling 9 Danger Before refuelling, switch off engine and any external heaters with combustion chambers. Switch off any mobile phones. Follow the operating and safety instructions of the filling station when refuelling. 9 Danger Fuel is flammable and explosive. No smoking. No naked flames or sparks. If you can smell fue[...]

Driving and operating 153 The fuel filler cap can be retained in the bracket on the fuel filler flap. Caution Wipe off any overflowing fuel immediately. Fuel filler cap Only use genuine fuel filler caps. Diesel-engined vehicles have special fuel filler caps. Fuel consumption - CO 2 - Emissions The determination of fuel consumption is regulated by E[...]

154 Driving and operating For trailers with low driving stability and caravan trailers with a permitted gross vehicle weight of more than 1300 kg the use of a stabiliser is strongly recommended when driving above 50 mph. If the trailer starts snaking, drive more slowly, do not attempt to correct the steering and brake sharply if necessary. When dri[...]

Driving and operating 155 Stowage of coupling ball bar The bag with the coupling ball bar is stowed in the rear stowage compartment on the floor. Place the strap through the lashing eye, wrap around twice and tighten the strap to secure the bag. Fitting the coupling ball bar Press fastenings inward and remove cover. Disengage and fold down the sock[...]

156 Driving and operating Otherwise, the coupling ball bar must be tensioned before being inserted: ■ Unlock coupling ball bar by turning key to position c . ■ Pull out rotary knob and turn clockwise as far as it will go. Inserting the coupling ball bar Insert the tensioned coupling ball bar in the opening and push firmly upwards until it audib[...]

Driving and operating 157 ■ The coupling ball bar must be firmly engaged in the opening. ■ The coupling ball bar must be locked and the key removed. 9 Warning Towing a trailer is permitted only when a coupling ball bar is fitted correctly. If the coupling ball bar does not engage correctly, seek the assistance of a workshop. Dismounting the cou[...]

158 Vehicle care Vehicle care General Information ................... 158 Vehicle checks ........................... 159 Bulb replacement ....................... 164 Electrical system ........................ 173 Vehicle tools .............................. 179 Wheels and tyres ....................... 180 Jump starting .............................[...]

Vehicle care 159 ■ Fill up the washer fluid reservoir. ■ Check the engine oil level. ■ Check the coolant level. ■ Fit the number plate if necessary. End-of-life vehicle recovery Information on end-of-life vehicle recovery centres and the recycling of end-of-life vehicles is available on our website. Only entrust this work to an authorised r[...]

160 Vehicle care Push the safety catch to the right and open the bonnet. Secure the bonnet support. Closing Before closing the bonnet, press the support into the holder. Lower the bonnet and allow it to drop into the catch. Check that the bonnet is engaged. Engine oil Check the engine oil level manually on a regular basis to prevent damage to the e[...]

Vehicle care 161 When the engine oil level has dropped to the MIN mark, top up engine oil. We recommend the use of the same grade of engine oil that was used at last change. The engine oil level must not exceed the MAX mark on the dipstick. Caution Overfilled engine oil must be drained or suctioned out. Capacities 3 215. Fit the cap on straight and[...]

162 Vehicle care the coolant concentration checked and have the cause of the coolant loss remedied by a workshop. Washer fluid Fill with clean water mixed with a suitable quantity of windscreen washer fluid which contains antifreeze. For the correct mixing ratio refer to the washer fluid container. Caution Only washer fluid with a sufficient antifr[...]

Vehicle care 163 Only use high-performance brake fluid approved for the vehicle. Brake and clutch fluid 3 200. Battery The vehicle battery is maintenance- free provided that the driving profile allows sufficient charging of the battery. Short-distance-driving and frequent engine starts can discharge the battery. Avoid the use of unnecessary electri[...]

164 Vehicle care Wiper blade on the rear window Lift wiper arm. Disengage wiper blade as shown in illustration and remove. Attach the wiper blade slighty angled to the wiper arm and push until it engages. Lower wiper arm carefully. Bulb replacement Switch off the ignition and switch off the relevant switch or close the doors. Only hold a new bulb a[...]

Vehicle care 165 2. Rotate the bulb holder anticlockwise to disengage. Withdraw the bulb holder from the reflector. 3. Detach the bulb from the bulb holder and replace the bulb. 4. Insert the bulb holder, engaging the two lugs into the reflector and rotate clockwise to secure. 5. Fit the cap and rotate clockwise. High beam 1. Rotate the cap 2 antic[...]

166 Vehicle care 2. Press latches together and withdraw the bulb holder from the reflector. 3. Remove the bulb from the socket and replace the bulb. 4. Insert the bulb holder into the reflector. Fit the cap and rotate clockwise. Front turn signal The bulbs are accessible from beneath the vehicle. 1. Disengage the spring clip and then swivel it back[...]

Vehicle care 167 3. Disengage the bulb holder from the plug connector by pressing the retaining lug. 4. Remove and replace the bulb holder with bulb. 5. Attach the plug connector. 6. Insert the bulb holder into the reflector. 7. Swivel the spring clip forwards and engage. Xenon headlights 9 Danger Xenon headlights work under extremely high electric[...]

168 Vehicle care Tail lights Saloon/Hatchback 1. Release the cover and remove it. 2. Unscrew the plastic securing nut from the inside by hand. 3. Carefully withdraw the light assembly from retaining pins and remove. Make sure that the cable duct remains in position. 4. Detach the cable from the retainer. 5. Detach the wiring plug from the bulb carr[...]

Vehicle care 169 Tail lights ( 1 ) Brake light ( 2 ) Turn signal light ( 3 ) 8. Insert the bulb carrier into the tail light assembly and screw into place. Connect the wiring plug and press the cable into the retainer. Fit light assembly onto retaining pins and tighten the securing nut. Close the cover and engage. 9. Switch on the ignition, operate [...]

170 Vehicle care Estate 1. On left-hand side, fold down the blind and remove. 2. Remove cover. 3. Unscrew two plastic securing nuts from the inside by hand. 4. Carefully remove tail light assembly. Take care that the cable duct remains in position. Detach wiring plug from bulb holder. 5. Remove and replace the bulb. Tail lights ( 1 + 2 ) Turn signa[...]

Vehicle care 171 7. Switch on the ignition, operate and check all lights. Tail light in the tailgate 1. Open the tailgate and remove the covers. 2. Unscrew the screws and remove. 3. Remove the tail light assembly. 4. Remove and replace the bulb. 5. Install the tail light assembly in the tailgate and tighten the screws. Attach the covers. 6. Switch [...]

172 Vehicle care 2. Remove and replace the rear fog light bulb. 3. Close cover. For replacing reverse light bulb on the right side of the tailgate, proceed in the same way. Side turn signal lights Have bulbs replaced by a workshop. Number plate light 1. Insert screwdriver in recess of the cover, press to the side and release spring. Remove cover. 2[...]

Vehicle care 173 Electrical system Fuses Data on the replacement fuse must match the data on the defective fuse. There are three fuse boxes in the vehicle: ■ in the front left of the engine compartment, ■ in the interior behind the storage compartment, or, in right-hand drive vehicles, behind the glovebox, ■ behind a cover on the left side of[...]

174 Vehicle care Place the fuse extractor on the various types of fuse from the top or side, and withdraw fuse. Engine compartment fuse box The fuse box is in the front left of the engine compartment. Disengage the cover, lift it upwards and remove.[...]

Vehicle care 175 No. Circuit 1 Engine control module 2 Lambda probe 3 Fuel injection, ignition system 4 Fuel injection, ignition system 5 – 6 Mirror heating 7 Fan control 8 Lambda probe, engine 9 Rear window sensor 10 Battery sensor 11 Trunk release 12 Adaptive forward lighting module 13 – 14 Rear window wiper 15 Engine control module 16 Starte[...]

176 Vehicle care No. Circuit 50 Headlamp levelling 51 Air shutter 52 Auxiliary heater, diesel engine 53 Transmission control module, Engine control module 54 Wiring monitoring After having changed defective fuses close the fuse box cover and press until it engages. If the fuse box cover is not closed correctly, malfunction may occur. Instrument pan[...]

Vehicle care 177 No. Circuit 1 Displays 2 Exterior lights 3 Exterior lights 4 Radio 5 Infotainment system 6 Power outlet front 7 Power outlet rear seat 8 Left low beam 9 Right low beam No. Circuit 10 Door locks 11 Interior fan 12 – 13 – 14 Diagnostic connector 15 Airbag 16 – 17 Air conditioning system 18 – 19 Brake lights, tail lights, inte[...]

178 Vehicle care Estate The fuse box is on the left side of the load compartment behind a cover. Fold down the blind and remove. Remove the cover. Fuse assignments[...]

Vehicle care 179 No. Circuit 1 Trailer module 2 Trailer outlet 3 Parking assist 4 – 5 – 6 – 7 – 8 Anti-theft alarm system 9 – 10 – 11 Trailer module, Trailer socket 12 – 13 Trailer outlet 14 – 15 – 16 – 17 – No. Circuit 18 – 19 Steering wheel heating 20 Sunroof 21 Seat heating 22 – 23 – 24 – 25 – 26 – 27 – 28 –[...]

180 Vehicle care Vehicles with spare wheel, variant 1 The jack, the tools and a strap for securing a damaged wheel are in a storage compartment below the spare wheel in the load compartment. Spare wheel 3 190. Vehicles with spare wheel, variant 2 The jack and the tools are in a storage compartment below the spare wheel in the load compartment. The [...]

Vehicle care 181 Speed code letter: Q = up to 100 mph S = up to 112 mph T = up to 118 mph H = up to 130 mph V = up to 150 mph W = up to 168 mph Tyre pressure Check the pressure of cold tyres at least every 14 days and before any long journey. Do not forget the spare wheel. This also applies to vehicles with tyre pressure monitoring system. Unscrew [...]

182 Vehicle care Press the MENU button to select the Vehicle Information Menu . Turn the adjuster wheel to select the tyre pressure monitoring system. System status and small pressure differences are displayed by a warning message with the corresponding tyre flashing in the Driver Information Center. Furthermore considerable pressure differences be[...]

Vehicle care 183 If problems occur during the relearn process a warning message is displayed in the Driver Information Center. Temperature compensation Cold tyres decrease the tyre pressure, warm tyres increase the tyre pressure. The tyre pressure monitoring system considers this effect for the warning messages. The tyre pressure value displayed in[...]

184 Vehicle care If the wheel covers and tyres used are not factory approved, the tyres must not have a rim protection ridge. Wheel covers must not impair brake cooling. 9 Warning Use of unsuitable tyres or wheel covers could lead to sudden pressure loss and thereby accidents. Tyre chains Tyre chains are only permitted on the front wheels. Always u[...]

Vehicle care 185 The tyre repair kit is in a compartment under the floor cover in the load compartment or in the underseat storage compartment 3 54. 1. Take the tyre repair kit from the compartment. 2. Remove the compressor. 3. Remove the electrical connection cable and air hose from the stowage compartments on the underside of the compressor. 4. S[...]

186 Vehicle care 10. Set the rocker switch on the compressor to I . The tyre is filled with sealant. 11. The compressor pressure gauge briefly indicates up to 6 bar whilst the sealant bottle is emptying (approx. 30 seconds). Then the pressure starts to drop. 12. All of the sealant is pumped into the tyre. Then the tyre is inflated. 13. The prescrib[...]

Vehicle care 187 If tyre pressure is more than 1.3 bar, set it to the correct value. Repeat the procedure until there is no more loss of pressure. If the tyre pressure has fallen below 1.3 bar, the vehicle must not be used. Seek the assistance of a workshop. 18. Stow away tyre repair kit in load compartment. Note The driving characteristics of the [...]

188 Vehicle care ■ Never crawl under a jacked-up vehicle. ■ Do not start the vehicle when it is raised on the jack. ■ Clean wheel nuts and thread with a clean cloth before mounting the wheel. 9 Warning Do not grease wheel bolt, wheel nut and wheel nut cone. 1. Disengage wheel nut caps with a screwdriver and remove. Pull off the wheel cover wi[...]

Vehicle care 189 3. Ensure the jack is correctly positioned under the relevant vehicle jacking point. 4. Variant 1: Set the jack to the necessary height. Position it directly below the jacking point in a manner that prevents it from slipping. Attach jack handle and with the jack correctly aligned rotate handle until wheel is clear of the ground. Va[...]

190 Vehicle care Attach wheel wrench and with the jack correctly aligned rotate wheel wrench until wheel is clear of the ground. 5. Unscrew the wheel nuts. 6. Change the wheel. 7. Screw on the wheel nuts. 8. Lower vehicle. 9. Install the wheel wrench ensuring that it locates securely and tighten each nut in a crosswise sequence. Tightening torque i[...]

Vehicle care 191 The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres could affect driveability. Have the defective tyre replaced as soon as possible. The spare wheel is located in the load compartment beneath the floor covering. It is secured with a wing nut. The spare wheel well is not designed for al[...]

192 Vehicle care ■ Install the hexagon key of the wheel wrench ensuring that it locates securely on the bolt. ■ Turn the wheel wrench anticlockwise to loosen the bolt. Remove the bolt. ■ Take the long bolt from the tool box and screw it in hand-tight using the wheel wrench. ■ Store the tool box and the damaged wheel and secure it by turning[...]

Vehicle care 193 Jump starting Do not start with quick charger. A vehicle with a discharged battery can be started using jump leads and the battery of another vehicle. 9 Warning Be extremely careful when starting with jump leads. Any deviation from the following instructions can lead to injuries or damage caused by battery explosion or damage to th[...]

194 Vehicle care 3. Connect the black lead to the negative terminal of the booster battery. 4. Connect the other end of the black lead to a vehicle grounding point, such as the engine block or an engine mounting bolt. Connect as far away from the discharged battery as possible, however at least 2 ft. Route the leads so that they cannot catch on rot[...]

Vehicle care 195 Screw in the towing eye as far as it will go until it stops in a horizontal position. Attach a tow rope – or better still a tow rod – to the towing eye. The towing eye must only be used for towing and not for recovering the vehicle. Switch on ignition to release steering wheel lock and to permit operation of brake lights, horn [...]

196 Vehicle care Screw in the towing eye as far as it will go until it stops in a horizontal position. The lashing eye at the rear underneath the vehicle must never be used as a towing eye. Attach a tow rope – or even better a tow bar – to the towing eye. The towing eye must only be used for towing and not for recovering a vehicle. Caution Driv[...]

Vehicle care 197 If using a vehicle wash, comply with the vehicle wash manufacturer's instructions. The windscreen wipers and rear window wiper must be switched off. Remove antenna and external accessories such as roof racks etc. If you wash your vehicle by hand, make sure that the insides of the wheel housings are also thoroughly rinsed out. [...]

198 Vehicle care Paintwork damage Rectify minor paintwork damage with a touch-up pen before rust forms. Have more extensive damage or rust areas repaired by a workshop. Underbody Some areas of the vehicle underbody have a PVC undercoating while other critical areas have a durable protective wax coating. After the underbody is washed, check the unde[...]

Service and maintenance 199 Service and maintenance General information ................... 199 Recommended fluids, lubricants and parts .................................... 200 General information Service information In order to ensure economical and safe vehicle operation and to maintain the value of your vehicle, it is of vital importance that a[...]

200 Service and maintenance Make sure that the Service and Warranty Booklet is completed correctly as continuous proof of service is essential if any warranty or goodwill claims are to be met, and is also a benefit when selling the vehicle. Service interval with remaining engine oil life duration The service interval is based on several parameters [...]

Service and maintenance 201 Alternative qualities if GM-LL-A-025 or GM-LL-B-025 are not available: ACEA-A3/B3 or A3/B4 = Petrol engines ACEA-A3/B4 = Diesel engines without Diesel Particle Filter (DPF) ACEA-C3 = Diesel engines with DPF Topping up engine oil Engine oils of different manufacturers and brands can be mixed as long as they comply with th[...]

202 Service and maintenance Brake fluid should be stored in a sealed container to avoid water absorption. Ensure brake fluid does not become contaminated.[...]

Technical data 203 Technical data Vehicle identification .................. 203 Vehicle data ............................... 205 Vehicle identification Vehicle Identification Number The Vehicle Identification Number is visible through the windscreen. Identification plate The identification plate is located on the front left door frame.[...]

204 Technical data Information on identification label: 1 = Manufacturer 2 = Type approval number 3 = Vehicle Identification Number 4 = Permissible gross vehicle weight rating 5 = Permissible gross train weight 6 = Maximum permissible front axle load 7 = Maximum permissible rear axle load 8 = Vehicle-specific or country specific data Identification[...]

Technical data 205 Vehicle data Engine data Sales designation 1.4 1.4 1.4 1.4 1.6 1.6 Engine identifier code A14XEL A14XER A14NEL A14NET A16XER A16LET Number of cylinders 4 4 4 4 4 4 Piston displacement [cm 3 ] 1398 1398 1364 1364 1598 1598 Engine power [kW] 64 74 88 103 85 132 at rpm 6000 6000 4200-6000 4900-6000 6000 5500 Torque [Nm] 130 130 200 [...]

206 Technical data Sales designation 1.3 1.7 1.7 2.0 2.0 Turbo Engine identifier code A13DTE A17DTJ A17DTR A20DTR A20DTH Number of cylinders 4 4 4 4 4 Piston displacement [cm 3 ] 1248 1686 1686 1) 1956 Engine power [kW] 70 81 92 1) 118 at rpm 4000 3800 4000 1) 4000 Torque [Nm] 190 260 280 1) 350 at rpm 1750-3250 1700-2550 2000-2700 1) 1750-2500 Fue[...]

Technical data 207 Performance Saloon/Hatchback Engine A14XEL A14XER A14NEL A14NET A16LET A16XER Maximum speed 2) [mph] Manual transmission 105 3) 111 3) 120 126 138 118 Automatic transmission – – – 125 132 114 Engine A13DTE A17DTJ A17DTR A20DTR A20DTH Maximum speed 2) [mph] Manual transmission 109 113 122 4) 134 Automatic transmission – ?[...]

208 Technical data Estate Engine A14XER A14NEL A14NET A16LET A16XER Maximum speed 5) [mph] Manual transmission 109 119 125 138 116 Automatic transmission – – 124 131 113 Engine A13DTE A17DTJ A17DTR A20DTH Maximum speed 5) [mph] Manual transmission 108 113 120 133 Automatic transmission – – – 129 Fuel consumption - CO 2 - emissions Saloon/[...]

Technical data 209 Manual transmission / automatic transmission. Engine A14XEL A14XER A14NEL A14NET A16XER A16LET urban [l/100 km] 7.1/– 7.1/– 8.0/– 8.0/9.6 8.4/9.9 8.9/9.9 extra-urban [l/100 km] 4.6/– 4.6/– 4.7/– 4.7/5.5 5.2/5.7 5.6/5.7 total [l/100 km] 5.5/– 5.5/– 5.9/– 5.9/6.9 6.4/7.2 6.8/7.3 CO 2 [g/km] 129/– 129/– 139/–[...]

210 Technical data Estate Manual transmission / automatic transmission. Engine A14XER A14NEL A14NET A16XER A16LET urban [l/100 km] 7.6/– 8.2/– 8.2/9.6 8.6/9.9 8.8/10.1 extra-urban [l/100 km] 5.1/– 4.9/– 4.9/5.5 5.3/5.7 5.6/5.8 total [l/100 km] 5.9/– 6.1/– 6.1/7.0 6.6/7.2 6.8/7.4 CO 2 [g/km] 139/– 144/– 144/164 154/169 159/174 Engine[...]

Technical data 211 Vehicle weight Kerb weight, basic model without any optional equipment Saloon/Hatchback Engine Manual transmission Automatic transmission without/with air conditioning [kg] A14XEL 1373/1388 – A14XER 1373/1388 – A14NEL 7) – A14NET 1393/1408 –/1453 A16LET –/1490 –/1503 A16XER 1393/1408 –/1443 A13DTE 1393/1408 – A17D[...]

212 Technical data Kerb weight, basic model with all optional equipment Saloon/Hatchback Engine Manual transmission Automatic transmission without/with air conditioning [kg] A14XEL –/1545 – A14XER –/1545 – A14NEL 7) – A14NET –/1611 –/1613 A16LET –/1613 –/1665 A16XER –/1578 –/1613 A13DTE –/1571 – A17DTJ –/1684 – A17DTR [...]

Technical data 213 Kerb weight, basic model without any optional equipment Estate Engine Manual transmission Automatic transmission without/with air conditioning [kg] A14XER 1393/1408 – A14NEL 1471/1486 –/1503 A14NET 1471/1486 –/1503 A16LET –/1503 –/1550 A16XER 1437/1452 –/1503 A17DTJ 1503/1518 – A17DTR 1503/1518 – A20DTH –/1571 ?[...]

214 Technical data Kerb weight, basic model with all optional equipment Estate Engine Manual transmission Automatic transmission without/with air conditioning [kg] A14XER –/1571 – A14NEL –/1664 –/1664 A14NET –/1664 –/1664 A16LET –/1664 –/1701 A16XER –/1613 –/1664 A17DTJ –/1733 – A17DTR –/1733 – A20DTH –/1733 –/1733 V[...]

Technical data 215 Hatchback Estate Length of load compartment with folded rear seats [mm] 1549 1835 Load compartment width [mm] 1027 1026 Load compartment height [mm] 554 8) Wheelbase [mm] 2685 2685 Turning circle diameter [m] 11.5 11.5 Capacities Engine oil Engine A14XEL A14XER A14NEL A14NET A16LET A16XER including Filter [l] 4.0 4.0 9) 4.0 4.5 4[...]

216 Technical data Engine A13DTE A17DTJ A17DTR A20DTH A20DTR ecoFlex including Filter [l] 3.2 5.4 5.4 4.5 9) between MIN and MAX [l] 1.0 1.0 1.0 1.0 9) Fuel tank Petrol/diesel, nominal capacity [l] 56 9) Value was not available at time of printing.[...]

Technical data 217 Tyre pressures Hatchback/Estate Comfort with up to 3 people ECO with up to 3 people With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A14XER, A14XEL 205/55 R16, 220/2.2 (32) 220/2.2 (32) 270/2.7 (39) 270/2.[...]

218 Technical data Comfort with up to 3 people ECO with up to 3 people With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A16LET 205/65 R16 11)10) , 230/2.3 (33) 230/2.3 (33) 270/2.7 (39) 270/2.7 (39) 240/2.4 (35) 280/2.8 (41)[...]

Technical data 219 Comfort with up to 3 people ECO with up to 3 people With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A17DTJ 205/65 R16 11)10) , 230/2.3 (33) 230/2.3 (33) 270/2.7 (39) 270/2.7 (39) 240/2.4 (35) 280/2.8 (41)[...]

220 Technical data Comfort with up to 3 people ECO with up to 3 people With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A17DTR 205/65 R16 11)10) , 230/2.3 (33) 230/2.3 (33) 270/2.7 (39) 270/2.7 (39) 240/2.4 (35) 280/2.8 (41)[...]

Technical data 221 Comfort with up to 3 people ECO with up to 3 people With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A20DTH 205/65 R16 11)10) , 230/2.3 (33) 230/2.3 (33) 270/2.7 (39) 270/2.7 (39) 240/2.4 (35) 280/2.8 (41)[...]

222 Technical data Comfort with up to 3 people ECO with up to 3 people With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A20DTR 205/65 R16 11)10) , 250/2.5 (36) 230/2.3 (33) 270/2.7 (39) 270/2.7 (39) 260/2.6 (38) 300/3.0 (43)[...]

Technical data 223 Towing hitch installation dimensions[...]

224 Customer information Customer information Vehicle data recording and privacy ....................................... 224 Vehicle data recording and privacy Event data recorders The vehicle has a number of sophisticated systems that monitor and control several vehicle data. Some data may be stored during regular operation to facilitate repair of[...]

Customer information 225[...]

226 Index A Accessories and vehicle modifications .......................... 158 Adaptive forward lighting ..... 97, 118 Adjustable air vents ................... 131 Airbag and belt tensioners ........... 92 Airbag deactivation ................ 45, 93 Airbag system .............................. 42 Air conditioning regular operation ...............[...]

227 Cupholders .................................. 52 Curtain airbag system .................. 44 D Danger, Warnings and Cautions ... 3 Daytime running light .................... 97 Diesel fuel system bleeding ....... 163 Diesel particle filter ............... 96, 136 Door open .................................... 98 Driver Information Center ......[...]

228 Instrument panel illumination ..... 172 Instrument panel illumination control .................................... 122 Instrument panel overview ........... 11 Interactive driving system ........... 145 Interior care ............................... 198 Interior lights ...................... 123, 172 Interruption of power supply ...... 140 Intro[...]

229 Service ............................... 132, 199 Service display ............................ 89 Service information .................... 199 Service vehicle soon .................... 93 Side airbag system ...................... 43 Side turn signal lights ................ 172 Spare wheel ............................... 190 Speedometer .........[...]

230[...]