Pride Mobility 1103 ULTRA manual

Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com Owner’ s Man ual[...]

SAFETY GUIDELINES Copyright © 2006 Pride Mobility Products Corp. INFMANU2429/RevC/March06 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information. It is very important for you to read them and understand them completely . WARNING! Failure to follo w designated procedur es[...]

Jazzy 1 103 Ultra www .pridemobility .com 3 I . INTRODUCTION .................................................................................................................................... 4 I I. SAFETY ..............................................................................................................................................[...]

4 www .pridemobility .com Jazzy 1 103 Ultra I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of-the- art components with safety , comfort, and styling in mind. W e are confident that these design features will provide you with the conveniences you expect during your dai[...]

Jazzy 1 103 Ultra www .pridemobility .com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product's warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride’ s web site at www .pridemobility .com.[...]

6 www .pridemobility .com Jazzy 1 103 Ultra II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the power chair to identify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely . Cor rosi v e chemicals contained in batter y . Use only AGM or Gel-Cell batteries to r educ[...]

Jazzy 1 103 Ultra www .pridemobility .com 7 II. SAFETY Prev ent per sonal injur y and equipment damage. Do not connect an e xtension cor d to the A C/DC conv er ter or the batter y c har ger . Do not remove anti-tip wheels. Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid exposur e to rain, snow , i[...]

8 www .pridemobility .com Jazzy 1 103 Ultra II. SAFETY SAFETY MAND A T OR Y! Do not operate your new pow er chair for the first time without completel y reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to b[...]

Jazzy 1 103 Ultra www .pridemobility .com 9 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity voids y our war ranty and may result in per sonal injur y and/or damage to your power c hair . Pride will not be held res[...]

1 0 www .pridemobility .com Jazzy 1 103 Ultra II. SAFETY WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications presented in this manual. Doing so could cause instability in your po wer chair , resultin[...]

Jazzy 1 103 Ultra www .pridemobility .com 1 1 II. SAFETY WARNING! Do not use your power chair in freewheel mode without an attendant present. Personal injur y may result. WARNING! Do not attempt to personally place your power chair in freewheel mode while seated on it. Personal injur y may result. Ask an attendant for assistance if necessary . WARN[...]

1 2 www .pridemobility .com Jazzy 1 103 Ultra II. SAFETY T ransfers T ransferring onto and of f of your power chair requires a good sense of balance. Always have an attendant or health care pro- fessional present while learning to properly transfer yourself. T o eliminate the possibility of injury , Pride recommends that you or a trained attendant [...]

Jazzy 1 103 Ultra www .pridemobility .com 1 3 II. SAFETY Elevators Modern elevators have a door edge safety mechanism that, when pushed, reopens the elevator door(s). ! If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact the power chair and the door will reo[...]

1 4 www .pridemobility .com Jazzy 1 103 Ultra II. SAFETY Batteries In addition to following the warnings below , be sure to comply with all other battery handling information. For more information about your power chair ’ s batteries, see VI. “Batteries and Charging.” WARNING! Po wer chair batteries are heavy . See specifi cations table. If y[...]

Jazzy 1 103 Ultra www .pridemobility .com 1 5 II. SAFETY Electromagnetic and Radio Frequency Interference (EMI/RFI) WARNING! Labor a tor y tests have sho wn tha t electr o magnetic and r adio frequenc y wa ves can have an ad ver se affect on the perf or mance of electrically-powered mobility vehicles. Electromagnetic and Radio Frequency Interferenc[...]

1 6 www .pridemobility .com Jazzy 1 103 Ultra III. YOUR POWER CHAIR Y OUR POWER CHAIR The Jazzy 1 103 Ultra has two main assemblies: the seat and the power base. See figures 5 and 6. T ypically , the seat assembly includes the armrests, seatback, and seat base. The power base assembly includes two motor/brake assemblies, two drive wheels, two anti-[...]

Jazzy 1 103 Ultra www .pridemobility .com 1 7 III. YOUR POWER CHAIR J AZZY 1103 UL TRA SPECIFICA TIONS Suspension: Active Trac Drive Wheels: 10 in. pneumatic, (10 in. solid are optional) Caster Wheels: 8 in. solid, rear-mounted Anti-tip Wheels: 5 in. solid, front-mounted Maximum S peed:¹ Up t o 4 mph Brakes: “Intelligent Braking” electronic re[...]

1 8 www .pridemobility .com Jazzy 1 103 Ultra III. YOUR POWER CHAIR Figure 6. The Jazzy 1103 Ultra P ower Base MOTOR/BRAKE ASSEMBLY ARTICULATING BEAM POWER SEAT ACTUATOR REAR SHROUD FASTENERS YELLOW FASTENER (LOCATED UNDER FRONT SHROUD) ELECTRICAL COMPONENTS The electrical components are located on the power base. The ammeter and the charger power [...]

Jazzy 1 103 Ultra www .pridemobility .com 1 9 III. YOUR POWER CHAIR Main Circuit Br eaker: The main circuit breaker is a safety feature built into your power chair . When the batteries and the motors are heavily strained (e.g., from excessive loads), the main circuit breaker trips to prevent damage to the motors and the electronics. If the circuit [...]

2 0 www .pridemobility .com Jazzy 1 103 Ultra MANU AL FREEWHEEL LEVERS Y our power chair has a manual freewheel lever on each motor . Manual freewheel levers enable you to disengage the drive motors from the gearboxes and maneuver the chair manually . WARNING! Do not use the power chair while the drive motors are disengaged! Do not disengage the dr[...]

Jazzy 1 103 Ultra www .pridemobility .com 2 1 IV . ASSEMBL Y INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation. It may also require disassembly to make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disassembled and assembled by an end [...]

2 2 www .pridemobility .com Jazzy 1 103 Ultra IV . ASSEMBL Y SEA T INST ALLA TION It may be necessary to install the seat either prior to initial operation or after transporting your power chair . Most seats are attached to the power base with the Universal Mountin g System (UMS). The UMS consists of universal parts that may be attached to any medi[...]

Jazzy 1 103 Ultra www .pridemobility .com 2 3 V . COMFORT ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair ’ s operation, you may find the need to make some adjustments to increase your comfort, such as seat height and angle, armrest angle, foot platform height and angle, and controller position. If your power chair i[...]

2 4 www .pridemobility .com Jazzy 1 103 Ultra Figure 15. Seat Mounting Holes V . COMFORT ADJUSTMENTS 10 . Reinstall the retaining clips from step 8. 11. Remove each screw from the trapeze bars and apply thread lock. 12 . Reinstall each screw into the trapeze bars and tighten. 13 . Reinstall the seat. 14. Reconnect the controller to the power pod. 1[...]

Jazzy 1 103 Ultra www .pridemobility .com 2 5 T o adjust the r ecline angle: 1. Pull up on the seatback release lever . 2. Lean forward or backward to the desired position. 3. Release the lever . Armrest W id th Adjustment Y ou can change each armrest’ s width independently of the other . NOTE: Changing the armrest width may increase the overall [...]

2 6 www .pridemobility .com Jazzy 1 103 Ultra V . COMFORT ADJUSTMENTS Foot Plat form Depth Adjustment T o adjust the foot platform depth: 1 . Remove the quick release fasteners from the foot platform bracket. See figure 17 . 2. Move the foot platform in or out to the desired depth. 3 . Reinstall the quick release fasteners into the foot platform br[...]

Jazzy 1 103 Ultra www .pridemobility .com 2 7 V . COMFORT ADJUSTMENTS T o change the contr oller position: 1. Turn of f the power to the controller . 2 . Loosen the rear shroud fasteners and remove the rear shroud. 3. Unplug the controller connectors from the power pod. 4 . Cut the wire ties that attach the controller cable to the armrest. 5. Locat[...]

2 8 www .pridemobility .com Jazzy 1 103 Ultra V . COMFORT ADJUSTMENTS T o adjust the ELR angle: 1. Push down release lever B. See figure 22. 2. Move the leg rest to the desired angle. T o adjust the ELR length: 1. Remove the two adjustment screws from the side of each leg rest extension. See figure 22. 2. Slide the leg rest up or down to the desire[...]

Jazzy 1 103 Ultra www .pridemobility .com 2 9 V . COMFORT ADJUSTMENTS NOTE: Each drive tire (pneumatic only) must be in- flated to 35 psi (2.4 bar) and the user must also be seated in the power chair in order to properly adjust the anti- tip wheels. T o adjust the anti-tip wheels: 1. Loosen bolt A. See figure 24. 2. Remove bolt B. 3 . Raise or lowe[...]

3 0 www .pridemobility .com Jazzy 1 103 Ultra Power Elevating Seat Operation If your power chair is equipped with a power elevating seat, you can change the seat height either through the controller or through a toggle switch mounted to one of the armrests. See figure 26. NOTE: For information on how to raise and lower your seat through the control[...]

Jazzy 1 103 Ultra www .pridemobility .com 3 1 VI. B A TTERIES AND CHAR GING BA TTERIES AND CHARGING Y our power chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are designed to handle a lon[...]

3 2 www .pridemobility .com Jazzy 1 103 Ultra VI. BA TTERIES AND CHARGING T o charge the batteries using the onboard charger: 1. Position the rear of your power chair close to a standard electrical outlet. 2. Be certain the controller power is turned off and the freewheel levers are in the engaged position. See III. “Y our Power Chair .” 3. Plu[...]

Jazzy 1 103 Ultra www .pridemobility .com 3 3 VI. B A TTERIES AND CHAR GING Frequently Asked Questions (F AQs) How does the charger work? The battery charger takes the standard electrical outlet voltage (alternating current) and converts it to 24 VDC (direct current). The power chair batteries use direct current to run your power chair . When the b[...]

3 4 www .pridemobility .com Jazzy 1 103 Ultra Why do my new batteries seem weak? Deep-cycle batteries employ a much different chemical technology than that used in car batteries, nickel-cadmium (nicads), or in other common battery types. Deep-cycle batteries are specifically designed to provide power , drain down their charge, and then accept a rel[...]

Jazzy 1 103 Ultra www .pridemobility .com 3 5 to mov e in an une xpected manner , immediately release the joystick. Unless the joystick is damaged, this action should stop your power c hair . VII. OPERA TION VSI ELECTRONIC CONTROLLER The electronic controller is what you use to operate your power chair . The electronic controller enables you to mov[...]

3 6 www .pridemobility .com Jazzy 1 103 Ultra VII. OPERA TION On/Off Key The on/off key turns the VSI on and off. WARNING! Unless faced with an emergency situation, do not use the on/ of f key to stop the power c hair . This will cause the pow er chair to stop abr uptly . WARNING! Always tur n the power off when you are stationar y to pr ev ent une[...]

Jazzy 1 103 Ultra www .pridemobility .com 3 7 VII. OPERA TION Actuator Keys and Actuator Light s Actuator keys and actuator lights are used for optional equipment such as power elevating seats or power elevating leg rests. For specific operation of the actuator keys and actuator lights, contact your authorized Pride Provider . Horn Key The horn key[...]

3 8 www .pridemobility .com Jazzy 1 103 Ultra VII. OPERA TION Power Seat Actuator Connector This connects the VSI to the power seat actuator . Charger Inhibit Connector The char ger inhibit connector connects the VSI to the onboard battery char ger . This connection provides an inhibit that disable s the VSI when the battery charger is on. The char[...]

Jazzy 1 103 Ultra www .pridemobility .com 3 9 VII. OPERA TION REMOTE PLUS CONTROLLER The electronic controller is what you use to operate your power chair . The electronic controller enables you to move the power chair , as well as monitor battery charge, electronic controller functions, and the condition of your electrical system. The Remote Plus [...]

4 0 www .pridemobility .com Jazzy 1 103 Ultra VII. OPERA TION Mode Key (Speed Settings) The mode key controls the speed settings. The Remote Plus speed settings range from 1 to 5. T ypically , the slowest speed setting is 1 and the fastest speed setting is 5. The settings are indicated by the number of lights that are lit on the speed setting indic[...]

Jazzy 1 103 Ultra www .pridemobility .com 4 1 VII. OPERA TION NOTE: When the batteries approach a discharged state, the first red light will begin to slowly flash, remind- ing you the batteries need to be charged immediately! Right/Left T urn Indicator Keys (Optional) The right/left turn indicator keys toggle either the left or right turn indicator[...]

4 2 www .pridemobility .com Jazzy 1 103 Ultra VII. OPERA TION Remote Plus Error Codes In addition to indicating the current state of battery charge, the battery condition meter can also indicate possible problems with your power chair ’ s electrical system. If any of the battery condition meter lights are flashing rapidly , the controller ma y be[...]

Jazzy 1 103 Ultra www .pridemobility .com 4 3 THE MICRODRIVE CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system. The electronic controller also enables you to monitor battery charge, electronic controller functions, and the condition of your electric[...]

4 4 www .pridemobility .com Jazzy 1 103 Ultra Profile and Speed Indicator The profile and speed indicator is a 5-segment illumi- nated display that indicates speed setting as well as drive profile. Actuator Indicator The actuator indicator is a 4-segment illuminated dis- play that indicates power re cline, power tilt, power leg rest, and power elev[...]

Jazzy 1 103 Ultra www .pridemobility .com 4 5 Drive Profile Selection Y our Microdrive controller may be programmed for more than one drive profile that allows the system to be custom tailored to your environment. T o select a profile setting: 1. Use the on/of f switch to power on the chair and the controller . 2. Press the mode button. 3. Move the[...]

4 6 www .pridemobility .com Jazzy 1 103 Ultra FLASHING LIGHTS DIAGNOSIS SOLUTION 10 High Battery V oltage Check batteries. 9 Solenoid Brake Fault Check motor/brake wiring. 8 Possible Controller Fault See authorized Pride Provider . 7 Possible Joystick Fault See authorized Pride Provider . 6 Inhibit Active Unplug charger . Check connections. 5 Right[...]

Jazzy 1 103 Ultra www .pridemobility .com 4 7 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our Jazzy 1 103 Ultra is a sophisticated power chair . Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from your authorized Pride Provider . Preventive maintenance i[...]

4 8 www .pridemobility .com Jazzy 1 103 Ultra VIII. CARE AND MAINTENANCE ! Check all electrical connections. Make sure they are tight and are not corroded. Batteries must sit flat within the battery tray , with the battery terminals facing inward, toward each other . Refer to the battery wiring label for the correct wiring layout. ! All wheel beari[...]

Jazzy 1 103 Ultra www .pridemobility .com 4 9 VIII. CARE AND MAINTENANCE Storage Y our power chair should be stored in a dry place, free from temperature extremes. When storing, disconnect the batteries from the power chair . See VI. “Batteries and Charging.” WARNING! If you fail to store the unit proper ly , the frame can r ust and the electro[...]

5 0 www .pridemobility .com Jazzy 1 103 Ultra VIII. CARE AND MAINTENANCE Battery Replacement A battery wiring diagram is printed on a decal located on the battery tray . See figure 35. WARNING! Prev ent injur y . Do not replace the batteries when the seat is occupied. WARNING! Batter y posts , ter minals, and related accessories contain lead and le[...]

Jazzy 1 103 Ultra www .pridemobility .com 5 1 VIII. CARE AND MAINTENANCE 17. Place a new battery in the front of the battery tray . Make sure that the terminals are facing each other . WARNING! Pr e vent injury . Use only the quick disconnect har ness supplied with y our power c hair . It has a ther mal fuse on each lead. 18. Connect the wiring har[...]

5 2 www .pridemobility .com Jazzy 1 103 Ultra When to See Y our Authorized Pride Provider for Service The following symptoms could indicate a serious problem with your power chair . If necessary , contact your authorized Pride Provider . When calling, have the model number , serial number , nature of the problem, and the error code if available. ! [...]

Jazzy 1 103 Ultra www .pridemobility .com 5 3 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of charge, any of the following parts found upon examination by an authorized representative of Pride to be defective in mate[...]

5 4 www .pridemobility .com Jazzy 1 103 Ultra IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EX CLUSIONS This warranty does not extend to those items which may require replacement due to normal wear and tear . ! ABS Plastic shrouds ! Moto[...]

Pride keeps a more detailed r epor t on file at the factory . Date Inspected Inspector Quality Control- Jazzy 1 103 Ultra In Quality Control Product Serial Number *INFMANU2429* Fit and Finish Performance Inclusion of all Parts Controller Serial Number Joystick Serial Number Left Motor Serial Number Right Motor Serial Number Thank you for making the[...]