Pride Mobility Jazzy 1105 manual

Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com Owner ’ s Manual A TTENTION: Please read the content of your o wners manual before oper ating your pow er chair .[...]

2 www .pridemobility .com Jazzy 1 105/RevH/Feb03 SAFETY GUIDELINES Please read and follow all instructions in this owner  s manual before attempting to operate your power chair for the first time. If there is anything in this manual you do not understand, or if you require additional assistance for set-up, contact your authorized Pride provider [...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 3 CONTENTS I. INTRODUCTION ........................................................................................................................ 4 II. SAFETY ......................................................................................................................................... 6 II[...]

4 www .pridemobility .com Jazzy 1 105/RevH/Feb03 I. INTRODUCTION INTRODUCTION W elcome to Pride Mobility Products Corporation (Pride). Congratulations on the purchase of your new Pride Power Chair . The Pride Power Chair design combines the most advanced state-of-the-art components with modern, attractive styling. W e are certain that the design fe[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 5 I. INTRODUCTION Pride Owners Club As an owner of a Pride product, you are invited to register your product s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed registration card or by visiting Pride s web site at www .pridemobility .com. As a[...]

6 www .pridemobility .com Jazzy 1 105/RevH/Feb03 II. SAFETY SAFETY WARNING! Do not operate your new power chair for the fir st time without completely reading and under standing this owner s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to b[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 7 II. SAFETY Perform the following inspections prior to using your power chair: n Check for proper tire inflation. Maintain 30-35 psi in each tire (if equipped with pneumatic tires). n Check all electrical connections. Make sure they are tight and not corroded. n Check all controller connections to the[...]

8 www .pridemobility .com Jazzy 1 105/RevH/Feb03 II. SAFETY Figure 1. Maximum Safe Angle (Ascending and Descending) When climbing an incline, try to keep your power chair moving. If you must stop, start up again slowly and then accelerate cautiously . When driving down an incline, set your power chair to the slowest setting and drive in the forward[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 9 II. SAFETY Cornering Information While your power chair is equipped with rear caster wheels in back and anti-tip wheels in front, excessively high cornering speeds can still create the possibility of tipping. Factors which af fect the possibility of tipping include, but are not limited to: cornering [...]

10 www .pridemobility .com Jazzy 1 105/RevH/Feb03 II. SAFETY Figure 2. Curb Approach (Correct and Incorrect) WARNING! Do not a ttempt to hav e y our pow er chair c limb or descend an obstac le tha t is higher than two inches unless you hav e the assistance of an attendant. WARNING! Do not attempt to hav e your power chair proceed backward down an y[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 11 II. SAFETY Elevators Modern elevators have a door edge safety mechanism that, when pushed, reopens the elevator door(s). n If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact the power chair and the door will[...]

12 www .pridemobility .com Jazzy 1 105/RevH/Feb03 II. SAFETY Positioning Belt s Y our authorized Pride provider, therapist(s), and other healthcare professionals are responsible for determining your requirement for a positioning belt in order to operate your power chair safely . WARNING! If you requir e a positioning belt to safely operate y our po[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 13 II. SAFETY WARNING! Batter y posts, ter minals, and r elated accessories contain lead and lead compounds. Wash hands after handling. WARNING! Alw ays protect the batteries from freezing and nev er charge a fr ozen batter y . Charging a frozen batter y may result in personal injur y and/or damage to [...]

14 www .pridemobility .com Jazzy 1 105/RevH/Feb03 Laboratory tests performed by the Food and Drug Administration (FDA) have shown that radio waves can cause unintended motion of power chairs. Radio waves are a form of electromagnetic energy (EM). When this energy adversely affects the operation of an electronic device, it is called Electr omagnetic[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 15 offers greater protection. In other words, a power chair with a high immunity level is less likely to be affected by a strong radio source than one with a low immunity level. W hat is the FDA doing about the problem? The FDA has written power chair manufacturers and requested that they test their ne[...]

16 www .pridemobility .com Jazzy 1 105/RevH/Feb03 IV . THE JAZZY 1105 SEATBACK JOYSTICK CONTROLLER ARMRESTS BODY SHROUD ANTI-TIP WHEELS DRIVE WHEEL REAR CASTER WHEEL Figure 1. T he Jazzy 1105 POWER BASE ASSEMBLY SEAT ASSEMBLY FOOTREST FREEWHEEL LEVER THE JAZZY 1105 Y our Jazzy 1 105 has two main assemblies: the seat and the power base. See figure 1[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 17 IV . THE JAZZY 1105 Figure 2. Jazzy 1105 Disassembled Figure 3. Jazzy W iring Har nesses FOOT PLATE SEAT POWER BASE (FULLY COLLAPSED) JOYSTICK/ CONTROLLER BATTERY CASES CONTROLLER HARNESS CONNECTOR MOTOR HARNESS CONNECTOR MOTOR HARNESS CONNECTOR CHARGER HARNESS CONNECTOR[...]

18 www .pridemobility .com Jazzy 1 105/RevH/Feb03 IV . THE JAZZY 1105 FREEWHEEL LEVERS For convenience, your Jazzy 1105 is equipped with two freewheel levers. These levers allow you to disengage the drive motors and maneuver the chair manually . WARNING! Do not use your Jazzy w hile the drive motor s ar e disenga ged unless you are in the presence [...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 19 IV . THE JAZZY 1105 SPECIFICA TIONS Suspension: Limited Drive Wheels: 14 in. Rear Casters: 9-in. solid, rear articulating Anti-tip: 6-in. solid tires, front mounted Max. Speed: 4.5 mph Brakes: Intelligent Braking electronic regenerative, disc park brake Ground Clearance: 3.25 in. T urning Radi[...]

20 www .pridemobility .com Jazzy 1 105/RevH/Feb03 Normally , your Jazzy is shipped fully assembled for your convenience. However , some seatbacks are removed for shipping purposes. The following is a set of instructions to help you quickly and easily prepare your Jazzy 1 105 for immediate use. Y ou will need a Phillips head screwdriver and a 3/16-i[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 21 After you have had your Jazzy for an extended period of time, you may find the need to make a few adjustments. Some of these adjustments may degrade your Jazzy s performance by changing its center of gravity . SEA T HEIGHT AND SEA T ANGLE Y ou can change the seat height by raising or lowering the[...]

22 www .pridemobility .com Jazzy 1 105/RevH/Feb03 ARMREST ANGLE Y ou can adjust the armrest angle to fit your specific needs. T o change the armrest angle: 1. Lift the armrest straight up so that it is perpendicular to the floor . 2. Use a 5/32-in. hex wrench to loosen the hex screw . See figure 10. 3. T urn the screw counterclockwise to raise the [...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 23 FOOT PLA TFORM ANGLE Y ou can adjust the angle of the foot platform with a 3/16-in. hex wrench. See figure 12. T o adjust the foot platform angle: 1. T urn the set screw clockwise to raise the front of the footrest. 2. T urn the set screw counterclockwise to lower the front of the footrest. SWING-AW[...]

24 www .pridemobility .com Jazzy 1 105/RevH/Feb03 Figure 13. Anti-tip Wheel Adjustment ANTI-TIP ADJUSTMENT NUT ANTI-TIP WHEEL ADJUSTMENT The anti-tip wheels are designed to give the Jazzy increased stability on rough surfaces. The anti-tip wheels are preset at the factory to a ground clearance height of 3/4-in. This setting is only for smooth surfa[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 25 VII. DISASSEMBL Y Y ou can disassemble your Jazzy 1 105 into five pieces, including a folding power base. T o disassemble your Jazzy 1 105: 1. T urn power of f. 2. Make sure the unit is not in freewheel. See IV The Jazzy 1 105. 3. Unplug the controller harness from behind the seat. See figure [...]

26 www .pridemobility .com Jazzy 1 105/RevH/Feb03 VII. DISASSEMBL Y Figure 21. Car r ying the J azzy P ower Base Figure 20. Foot Pla te Remo val Figure 19. Safety Bar Figure 17. Ba tter y Case Str aps Figure 18. Rigidizing Screw[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 27 VIII. OPERA TION JOY STICK AND CONTROLLER Y our Jazzy is operated by the joystick and controller . The Jazzy 1 105 is currently available with one controller option: Pilot controller . See figure 22. T o operate your Jazzy: 1. T urn the power on (push the on/of f key). The battery condition meter li[...]

28 www .pridemobility .com Jazzy 1 105/RevH/Feb03 PIL OT CONTROLLER The Pilot controller is an integral controller . This means that the joystick is housed in the same enclosure as the controller module. See figure 23. This assembly is mounted on the seat arm. The Pilot controller is connected to the motors, the bat- teries, and the battery charger[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 29 VIII. OPERA TION B ARS DIA GNOSIS SOLUTI ON 10 G ree n H i g h B at t ery V ol t ag e C h eck B at te ri es 9 G ree n Sol en oi d B ra ke F au l t Ch eck M otor /B r ake W i ri n g 8 G ree n Possi bl e Co n tr ol l er Fau l t See A u th ori z ed Pr ov i der S er v i ce Cen t er 7 Y el l ow Poss i bl[...]

30 www .pridemobility .com Jazzy 1 105/RevH/Feb03 BA TTERIES Y our Jazzy 1 105 uses two long-lasting, 12-volt batteries. These batteries are sealed, maintenance free, deep-cycle batteries. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep- cycle batteries are designed to handle a longer and deeper dischar ge. Thou[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 31 If your Jazzy is equipped with an off-board charger , follow these instructions: 1. Position your Jazzy next to a standard wall outlet. 2. Be certain the controller power is turned off. 3. Remove the run plug located on the utility tray . This activates the inhibit function. 4. Plug the 3-pin extens[...]

32 www .pridemobility .com Jazzy 1 105/RevH/Feb03 IX. B A TTERIES AND CHARGING B A TTERIES AND CHARGINGFREQUENTL Y ASKED QUESTIONS (F AQS) How does the char ger wo rk? The battery char ger takes the standard wall outlet voltage of 120 V AC (alternating current) and converts it to 24 VDC (direct current). The Jazzy 1 105 batteries use direct curr[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 33 IX. BA TTERIES AND CHAR GING W hat type of ba ttery should I use? W e recommend deep-cycle batteries that are sealed and maintenance free. Both sealed lead-acid (SLA) and gel cell are deep-cycle batteries that are similar in performance. Use these specifications to reorder deep-cycle batteries: W hy[...]

34 www .pridemobility .com Jazzy 1 105/RevH/Feb03 How should I store my Jazzy 1105 and its batteries? If you do not use your Jazzy 1 105 regularly , we recommend maintaining battery vitality by charging the batteries at least once a week. If you do not plan on using your Jazzy 1 105 for an extended period, fully charge the batteries prior to storag[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 35 R OUTINE MAINTENANCE Y our Jazzy is a sophisticated power chair . Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from an authorized Pride provider . Preventive maintenance is very important. If you follow the m[...]

36 www .pridemobility .com Jazzy 1 105/RevH/Feb03 X. CARE AND MAINTENANCE n Use a rubber conditioner on the tire sidewalls to help preserve them. WARNING! Ne ver use a rub ber conditioner on the tread area of the tires; doing so may mak e the tires slipper y and cause your Jazzy to skid. n The body shroud has been sprayed with a clear sealant coati[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 37 n Check the rear casters for wear . Replace them as neces- sary . n Check the rear forks for damage or fluttering which indi- cates that they may need to be adjusted or have the bear - ings replaced. See an authorized Pride provider for re- pair . n Keep your Jazzy clean and free of foreign material[...]

38 www .pridemobility .com Jazzy 1 105/RevH/Feb03 X. CARE AND MAINTENANCE 7. Slide the wheel back onto the shaft. 8. Install the drive wheel nut into the center hub and tighten. 9. Inflate the tire to 30  35 psi. BA TTER Y REPLACEMENT The following are instructions for replacing batteries. T o replace the batteries: 1. Disconnect the controller [...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 39 23. Place the top cover back onto the bottom cover . Make sure that the battery terminals are opposite of the battery char ger . See figure 33. WARNING! If you do not position the batter y ter minals on the opposite side of the charger , you r un the risk of shor ting out the batteries and se verely[...]

40 www .pridemobility .com Jazzy 1 105/RevH/Feb03 X. CARE AND MAINTENANCE Figure 28. Motor Har nesses Figure 29. Batter y Connector Figure 30. Batter y Cases Figure 31. Ba tter y Case Strap Figure 32. Batter y W ires Figur e 33. Batter y T er minals[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 41 CORRECTIVE MAINTEN ANCE If the battery indicator gauge does not light up when you turn on the power: n Check the harness connections. Make sure they are tight. n Check the circuit breaker . Reset it if necessary . n Check the battery connections. If the above conditions prove normal, you can load te[...]

42 www .pridemobility .com Jazzy 1 105/RevH/Feb03 Figure 37. Oxygen T ank Holder Figure 36. Positioning Belt The following accessories are available from your authorized Pride provider . POSITIONING BEL T WARNING! The positioning belt is not designed f or use as a seat belt in a motor vehic le. Nor is your Jazzy 1105 suitable for use as a seat in a[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 43 XI. OPTIONAL ACCESSORIES REAR BASKET The rear basket is mounted to the accessory bracket. It has a handle that can be used when removing the basket from your Jazzy 1 105. See figure 40. CUP HOLDER (NOT SHOWN) The cup holder is mounted to the armrest. Figure 39. W alker Holder Figure 38. Cane And Cru[...]

44 www .pridemobility .com Jazzy 1 105/RevH/Feb03 LIFETIME LIMITED WARRANTY For the lifetime of your Jazzy 1 105, from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of char ge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material an[...]

Jazzy 1 105/RevH/Feb03 www .pridemobility .com 45 XII. WARRANTY WARRANTY EX CL USIONS n ABS plastic body shrouds and footrest covers (wear items are not warranted) n Batteries (battery manufacturer provides a six-month limited warranty) n T ires and tubes n Upholstery and seating n Repairs and/or modifications made to any part without specific prio[...]

46 www .pridemobility .com Jazzy 1 105/RevH/Feb03 NO TES[...]

Thank you for making the Jazzy 1105 your choice in power chairs. W e have thoroughly inspected your Jazzy 1 105. The following checkmarks indicate that it has been test driven and inspected. Quality Control - Model 1 105 #1 In Quality Control Pride keeps a mor e detailed r eport on file at the factory . Date Inspected Inspector Pilot Controller Fit[...]