Rangemaster Elan 90 Dual Fuel manual

Elan 90 Dual F uel Brita in ’ s N o . 1 Range Cooker USER GUIDE & INST ALLA TION INSTR UC TIONS[...]

RANGEMASTER C OOKW ARE Our range cookers are w ell k nown for pr oviding the best possible cooking per formance and years of faithful service. However , a great cooker alone cannot guarantee perfect results every time. The other vital ingredients ar e of course enthusiasm and quality cookware. W e oer cookware to work perfectly with all fuel typ[...]

iii 1. Before Y ou Start... 1 Impor tant! 1 Installation and Maintenance 1 P eculiar smells 1 If you smell gas 1 V entilation 1 P ersonal Safety 1 Cooker Car e 2 Cleaning 2 2. C ooker Overview 3 Hotplate Burners 3 W ok Burner 4 The W ok Cradle 5 The Griddle 5 The Glide- out Grill 6 The Ovens 7 Operating the Ovens 8 The Clock 9 Acc essories 12 Main [...]

iv[...]

1 Y our cooker should giv e you many years of tr ouble -free cooking if installed and operated correctly . It is impor tant that you read this section befor e you start, par ticularly if you have not used a dual fuel cooker bef ore. Impor tant!   CAUTION: This appliance is f or cooking purposes only . I t must not be used for other purposes, [...]

2   When the ov ens are on, DO NO T open the doors for longer than necessary to insert and remove conten ts. The con trol knobs will become hot and may cause cosmetic failur e.   When using the grill, mak e sure that the grill pan is in position and pushed fully in, otherwise the control knobs ma y become very hot.   DO NO T use h[...]

3 The 90 dual fuel cooker (F ig. 2.1) has the f ollowing features: A. 5 hotplate burners including a wok burner B. Control P anel C. Glide -out Grill D. Main Multifunction O ven E. T all F an Oven Hotplat e Burners The drawing b y each of the central knobs indicates which burner that knob controls. Each burner has a Flame Supervision Device (FSD) t[...]

4 ArtNo.31 1-0002 Pan with rim If, when y ou let go of the control knob, the burner goes out, then the FSD has not been bypassed. T urn the control knob to the OFF position and wait for one minut e before you try again, this time making sure to hold in the control knob for slightly longer . Adjust the ame height to suit b y turning the k nob cou[...]

5 ArtNo.215-0003 - Elan griddle on hotplate ArtNo.215-0006 - Elan griddle - Wrong ArtNo.31 1-0006 Correct wok sizes The W ok Cradle The wok cradle is desig ned to t a 35 cm wok. If you use a dieren t wok, make sure that it ts the cradle. Woks vary very widely in size and shape. It is impor tant that the wok sits down on the pan support –[...]

6 The Glide -out Grill Open the door and pull the grill pan carriage forward using the handle (Fig . 2.15) . The grill has two elements that allo w either the whole area of the pan to be heated or just the right-hand half . Adjust the heat to suit b y turning the control knob. T o heat the whole grill, turn the contr ol k nob clockwise (Fig . 2.16)[...]

7 F an Oven This function operates the fan and the heating element around it. An ev en heat is produced throughout the ov en, allowing you to cook lar ge amounts quickly . F an oven c ooking is par ticularly suitable for bak ing on several shelves at one time and is a good ‘all-r ound’ function. It may be necessary to reduce the temperatur e by[...]

8 Browning Element This function uses the element in the top of the oven only . It is a useful func tion for the bro wning or nishing of pasta dishes, vegetables in sauc e, shepherds pie and lasagne , the item to be browned being already hot befor e switching to the top element. Base Heat This function uses the base element only . It will crisp [...]

9 ArtNo.301-0007 2BC Stopping the oven 1 D A B E C ArtNo.300-0006 2BC minute minder setting 2 D E C A B ArtNo.300-0006 2BC minute minder setting 2 A B The C lock Y ou can use the clock to turn the left-hand oven on and o . The clock must be set to the time of day bef ore the oven will work. Setting the Clock The 2-button L CD clock can only disp[...]

10 ArtNo.301-0008 2BC Stopping the oven 2 G A B T o Stop the Multifunction Oven at a Specific T ime of Day Y ou have set the r equired temperatur e and function mode for the Multifunction O ven and you w ould like the Multifunction Oven to automatically stop . T OP TIP Make a note of the current time so you do not f orget. 1. T urn the T imer (A) [...]

11 ArtNo.301-0012 2BC Activating the key lock 2 A B C ArtNo.301-0007 2BC Stopping the oven 1 A B C ArtNo.301-0008 2BC Stopping the oven 2 H A B ArtNo.301-0008 2BC Stopping the oven 2 G A B T o Start and Stop the Multifunc tion Oven The Multifunction Oven allows you to automa tically star t and stop by a combination of the length of the c ook ing ti[...]

12 Ac cessor ies Oven Shelv es – Left-hand (Main) Oven The oven shelv es (Fig . 2.37) are retained when pulled forward but can be easily remov ed and retted. Pull the shelf f or ward until the back of the shelf is stopped b y the shelf stop bumps in the oven sides (F ig. 2.38) . Lift up the front of the shelf so the back of the shelf will pass[...]

T ips on C ooking with the T imer If you want to cook mor e than one dish, choose dishes that require appr oximately the same cooking time. How ever , dishes can be ‘ slowed do wn ’ slightly by using small containers and covering them with aluminium f oil, or ‘speeded up ’ slightly by cooking smaller quantities or placing them in larger con[...]

14 4. C ooking T able ArtNo.050-0007 Oven shelf positions Oven Shelf Positions T op (T) Centre (C) Base (B) The oven contr ol settings and cooking times given in the table below are intended to be used AS A GUIDE ONL Y . Individual tastes may r equire the temperature to be altered t o provide a preferred result. F ood is cooked at lower temper atur[...]

15 ArtNo.31 1-0032 Burn er layout FSD A B C D E ArtNo.31 1-0033 Wok burner details FSD A B C D E ArtNo.31 1-0016 Fitting the burner inner head A B A – Cap, B – Head , C – Notch, D – Base, E – Electrode A – Inner burner cap , B – Outer burner cap, C – Inner burner head , D – Outer burner head, E – W ok burner base A – Electrode[...]

16 ArtNo.331-0001Grill pan pulled forwards ArtNo.331-0003 Grill frame out, no pan ArtNo.331-0004 Removing the grill frame ArtNo.331-0005 Removing the grill rail ArtNo.331-0006 Grill pan plan The Griddle Always clean the g riddle af ter use. Allo w it to cool completely before r emoving. Immerse the griddle plate in hot soap y water . Use a soft clo[...]

17 Ovens ‘ Cook & Clean ’ Panels The main oven has panels which ha ve been coated with a special enamel that partly cleans itself. This does not stop all marks on the lining, but helps to r educe the amount of manual cleaning needed. The ‘Cook & Clean ’ panels work better above 200 °C. If you do most of your cooking below this temp[...]

18 Cleaning T able Cleaners listed (T able 5.1) are available from supermarkets or electrical retailers as stated. F or enamelled sur faces use a cleaner that is approv ed for use on vitreous enamel. Regular cleaning is recommended. F or easier cleaning, wipe up any spillages immediately . Hotplate Part Finish Recommended Cleaning Method Hob top (i[...]

19 Hotplate ignition or hotplat e burners faulty Is the power on? Is the clock illuminat ed? If not, there maybe something wrong with the po wer supply . Are the sparker (ignition electrode) or burner slots blocked by debris? Are the burner trim and caps correctly located? See the section on ‘Cleaning’ . Hotplate burners will not light Make sur[...]

20 An ov en light is not working The bulb has probably burnt out. Y ou can buy a replacement bulb (which is not c overed under the warranty) from a good electrical shop. Ask f or a 15 W – 230 V lamp, FOR OVENS. It must be a special bulb, heat resistant to 300 °C (Fig . 6.1) . T urn o the power at the cir cuit breaker . Before r emoving the ex[...]

21 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. Dear Installer Before y ou star t your installation, please complete the details below , so that, if y our customer has a problem relating to your installation, they will be able to c ontact you easily . Safety Requirements and Regula tions   Th[...]

22 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. Checking the Parts: Location of C ook er The cooker may be installed in a kitchen/kitchen diner but NOT in a r oom containing a bath or show er . This appliance is designed f or domestic cooking only . Use for an y other purpose could inv alidate any [...]

23 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. ArtNo.090-0030 - 90 Elan Door clearances 130 mm min ArtNo.090-0009 - 90 2BC cooker min spacings 75 mm min 75 mm min 650 mm min 905 mm min 930 mm max P ositioning the C ooker Fig . 7.1 and Fig . 7.2 show the minimum recommended distance from the cooker[...]

24 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. ArtNo.010-0004 Moving the cooker Low ering the T wo Rear Rollers T o adjust the height of the rear of the cooker , rst t a 13 mm spanner or socket wrench onto the hexagonal adjusting nut (Fig . 7.5) . Rotate the nut – clockwise to raise – co[...]

25 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. C onv ersion to A nother Gas If the appliance is to be conv er ted to another gas do the conv ersion at this point. See the conv ersion sec tion of these instructions. Lev elling Y ou are rec ommended to use a spirit level on a shelf in one of the ove[...]

26 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. ArtNo.090-0027 - 90 Elan gas connections 300 100 240 A 100 All dimensions in millimetres Gas inlet Gas Connection This must be in accor dance with the relevant standar ds. The exible hose (not supplied with the cooker) must be in accordanc e with t[...]

27 INST ALLA TION Check the appliance is electrically safe and gas sound when you ha ve nished. ArtNo.281-0026 - Front plinth Elec trical C onnec tion The cooker must be installed by a qualied electrician, in accordanc e with all relevant British Standards/C odes of Practice (in particular BS 7671), or with the relevant na tional and local re[...]

W ARNING – SERVICING TO BE CARRIED OUT ONL Y BY AN A UTHORISED PERSON Disconnect from electricity and gas before servicing. Check appliance is safe when y ou have nished . 28 28 A B C ArtNo.31 1-0010 Injectors A – Jet, B – Internal injector , C – External injector Art No 215-0028 - Handrail fascia fixings Check the ‘ T echnical Data ?[...]

W ARNING – SERVICING TO BE CARRIED OUT ONL Y BY AN A UTHORISED PERSON Disconnect from electricity and gas before servicing. Check appliance is safe when y ou have nished . 29 29 Stick on Label Stick the LP gas label over the natur al gas par t of the appliance data label. Pressur e T esting Connect the appliance to the gas supply . Check the a[...]

30 P028728 6 P6 5 P5 4 P4 7 P7 8 P8 2 P2 1 P1 3 P3 a b e f c d 1 2 P095199 1 2 P2 P1 E 1 2 1 2 w w w b b b b b b b b b b b b b b b or or or or gr w y y y v v v v v v r r r r br br r b r br br br br br br w v v b v w w w w b b b bk b br bk bk br b b w b br b br b b b br bk b v A1 A2 B1 B2 B3 B4 B5 B6 B7 C D1 D2 D3 D4 F1 F2 G1 G2 H H H I I I H Key Th[...]

31 10. T echnical Data THE C OOKER IS CA TEGORY : CatII 2H3+. It is supplied set for group H natural gas . A conversion kit from NG to LP is a vailable for the cooker . INST ALLER: Please leave these instructions with the user . DA T A BADGE L OCA TION: Cooker back, serial number repeater badge below ov en door opening. C OUNTRY OF DESTINA TION: GB[...]

32 Hotplat e Efficiency Brand Rangemaster Model Identication Elan Size 90 T ype Dual F uel T ype of Hob GAS Number of gas burners 5 Auxiliary / Small Burner (EE gas burner) - Semi Rapide / Medium Bur ner (EE gas burner) 58% Semi Rapide / Medium Bur ner (EE gas burner) 58% Rapide / Large Burner (EE gas burner) 56% Rapide / Large Burner (EE gas bu[...]

33 Oven Da ta Brand Rangemaster Model identication Elan T ype of oven Electric Mass kg 117 Number of cavities 2 Left-hand Eciency F uel type Electric Cavity type Multifunction Po wer - conv entional 2.2 Po wer - for ced air convection 2.5 V olume Litres 73 Energy consumption (electricity) - conventional kWh / cycle 1.08 Energy consumption (el[...]

34 Notes[...]

C ONSUMER SERVICE If you have an y product enquiries, or in the event of a problem with your appliance once it has been installed , please telephone: 0800 804 6261 or depending on your mobile network tari you can call free on 0370 789 5107 . C ONSUMER SERVICE LINES OPEN: Monday to Thursday 8am–6pm Frida y 8am–5pm Saturday 9am–1pm W ARR ANT[...]

Britai n ’ s N o . 1 Range Cooker Clarence Str eet Royal Leamingt on Spa W ar wickshire CV31 2AD England T el: +44 (0) 1926 457400 F ax: +44 (0)1926 450526 E-mail: consumers@rangemaster .co .uk Consumer Ser vices T el: +44 (0) 800 804 6261 ww w .rangemaster .co .uk F or ROI Enquiries T el: 1850 302 502 Registered in England and Wales. Registra ti[...]