Shoprider XtraLite 3 TE-787NA-UL3 manual

Compact Scooters User Manual XtraLite 3 (TE-787NA-UL3) XtraLite 4 (TE-787NA-UL4) Scootie (TE-787NA) Sunrunner S (777-3/4)[...]

9/22/2004 2 Table of Contents INTRODUCTION ......................................................................................................................... 3 FEATURE GUIDE (FIG. 1-4) ..................................................................................................... 3 SAFETY ADVICE ........................................[...]

9/22/2004 3 INTRODUCTION Congratulations on your purchase of the Shoprider® scooter. This sc ooter incorporates the latest innovative designs patented and only available on a Shoprider® sc ooter. This scooter can be used in confined spaces both indoors and out. Dir ect drive transaxles and electromagnetic brakes give a safe and efficient ride. Th[...]

9/22/2004 4 Scootie (Figure 3) 1. Tiller control head 2. Detachable seat with fold down back 3. Detachable basket 4. Detachable cover with integral battery pack 5. Tiller release knob 6. Carrying stay rod 7. Seat height adjustment 8. Anti-Tip wheels 9. Puncture proof tires Sunrunner S (Figure 4) 1. Tiller control head 2. Detachable swivel seat with[...]

9/22/2004 5 SAFETY ADVICE • Do not carry passengers. • Do not exceed inclines ov er 8 degrees (14% grade). • Do not turn on steep inclines. • Do not turn suddenly at high speeds. • Do not get on or off the scooter unless the brake is on and the scooter is switched off. • Do not switch off the scooter while the scooter is moving. • Do [...]

9/22/2004 6 EMI Warning Shoprider® scooters may be susceptible to electr omagnetic interference (EMI), which is a kind of interfering electrom agnetic energy (EM) em itted from sources such as radio stations, TV stations, amateur radio (HAM) transm itters, two-way radio, and cellular phones. The interference (from radio wave sour ces) can cause th[...]

9/22/2004 7 ADJUSTMENTS Tiller Angle Adjustment (For XtraLite 4 & Sunrunner S ONLY) (Fig. 5) On the left hand side at the base of the tiller is a red lever. Push the lever in to release the pin and select the required tiller angle. Refit the pin into one of the five location holes. Folding the Tiller (For XtraLite 3 & Scootie ONLY) (Fig. 6)[...]

9/22/2004 8 Armrest Width Adjustments (Fig. 9) On the underside of the seat there are two hand knobs, one on each side. Loosening the arm rest tightening knob allows the armrest width to be adjusted or arm rests to be removed. Armrest Angle Adjustment (Fig. 10) Flip up the armrests to allow access to the adjustment screw and lock nut, unscrew the l[...]

9/22/2004 9 SCOOTER TILLER CONTROLS (FIG. 13) Speed Controls The speed control allows you to set a speed between 1 (minim um) and 10 (maximum ). Battery Level Indicator/Gauge The number of LED bars lit/where th e needle sits, shows the amount of charge left in your batteries. The amount of charge will only show at its tr ue level when the scooter i[...]

9/22/2004 10 FREE WHEEL OPERATION (FIG. 14) The free wheel release lever (red handle) is located next to the right rear wheel (Fig. 14). To disengage the motor, lift up the le ver (the scooter can now be pushe d). To re-engage the motor push down on the lever. WARNING! Always re-engage the free wheeling device after use. Failure to do so may result[...]

9/22/2004 11 Steering Steering the scooter is light and easy. Ensure when starting off you give a wide clearance when turning so that the rear wheel s clear any obstacle that you ar e passing. When steering through limited spaces such as a doorway or when turnin g around, turn the tiller ha ndles where you want to go and apply power gently. The sco[...]

9/22/2004 12 TRANSPORT / STORAGE The scooters are designed to be dismantled into sepa rate sections for trans portation and storage. Your scooter can be dismantled into the following sections: XtraLite 3 (Fig. 15) 1) Small Front Basket 2) Large Rear Basket 3) Seat 4) Seat Post & Fasteners 5) Battery Pack 6) Fold Down Frame XtraLite 4 (Fig. 16) [...]

9/22/2004 13 Dismantling 1. Remove baskets. 2. Fold down the back of the seat. 3. For Sunrunner S: pull up on the red lever under the seat and at the same time lift and twist the seat off. For XtraLite 3; XtraLite 4; Scoot ie: unscrew the tightening bolt be low the seat. Lift seat off. For XtraLite 3 & XtraLite 4 ONLY. 1. Lower tiller toward th[...]

9/22/2004 14 MAINTENANCE Lubrication At six-month intervals you should lubricate the following parts with a light oil or si m ilar lubricant: • Seat pivot post. • Seat release lever pinion. • Wheel bearings. • Axle of scooter. CAUTION – DO NOT USE WD40 TO LUBRI CATE PARTS!! DO NOT LUBRI CATE TRANSAXLE/GEAR BOX!! In th e event of any diffi[...]

9/22/2004 15 TECHNICAL SPECIFICATIONS ALL SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT PRIOR NOTICE. 1. Include the Anti-Tip w heel. 2. Driver weight may exceed weight of the unit; speed must be reduc ed when turning. 3. The actual driving range varies with the factors shown below: a) the weight of occupant b) ground surface c) battery conditions d[...]

9/22/2004 16 QUARTERLY INSPECTION For your own safety, quarterly inspection and serv ice on the product has to be performed and signed by an authorized dealer. Maintena nce records (below) should be kept at all times. The manufacturer / distributor / vendor will be inde mnified from any product liability claim if the above maintenance / service req[...]

9/22/2004 17 WARRANTY Please refer to warranty information included with unit. Serial No. DISCLAIMER Congratulations on your purchase of the Shoprider® It is not intended to be used by individuals with physical limitations that could prevent the user from operating this unit safely. Shoprider® disclaim s all responsibility for any personal injury[...]

9/22/2004 18 Notes[...]