Zanussi GAS COOKER ZCG 640 manual

GAS COOKER ZCG 640 ZCG 641 INSTRUCTION BOOKLET Please read this instruction booklet before using the appliance GB[...]

2 Import ant Safety Information Y ou MUST read these warnings carefully before installing or using the hob. If you need assistance, contact our Customer Care Department on 08705 727727 Inst allation • This appliance must be installed and serviced by a competent person as stated in the Gas Safety ( Installation and Use) Regulations Current Edition[...]

3 Content s For the User For the Inst aller Important Safety Information 2 Control Panel 4 The Gas Hob Controls 5 The Gas Oven and Electric Grill Control 5 Before the First Use of the Cooker 6 Using the Oven 6 The Minute Minder 7 Using the Gas oven 7 Gas Oven Cooking Chart 8 Grilling 9 Maintenance and Cleaning 10 Cleaning the Oven 10 Something Not [...]

4 Control Panel The Oven Cavity Electric Grill Oven Light 1. Electric ignition button 2. Oven Light button 3. Back left burner control knob (semi-rapid) 4. Front left burner control knob (rapid) 5. Front right burner control knob (auxiliary) 6. Back right burner control knob (semi-rapid) 7. Gas Oven and Electric Grill control knob 8. Minute Minder [...]

5 The Gas Hob Controls To light a burner: - Push the electric ignition button which is marked with a little spark ( ). - At the same time push in and turn the relevant control knob anticlockwise to maximum position. - Then adjust the flame as required. If the burner does not ignite, turn the control knob to zero, and try again. When switching on th[...]

6 Always cook with the oven door closed. S tand clear when opening the drop down oven door . Do not allow it to fall open - support the door using the door handle, until it is fully open. The oven has four shelf levels, and is supplied with two shelves. The shelf positions are counted from the bottom of the oven as shown in the diagram. It is impor[...]

7 Cookware • Use any oven proof cookware which will withstand temperatures of 250°C. • Baking trays, oven dishes, etc. should not be placed directly against the grid covering the fan at the back of the oven, or placed on the oven base. • Do not use baking trays larger than 30 cm x 35 cm (12 in x 14 in) as they will restrict the circulation o[...]

8 SHELF COOKING POSITION TIME PUDDINGS Milk puddings 170 2 1½ - 2 hours Baked sponge pudding 210 2 45-60 minutes Baked custard 190 2 50-60 minutes CAKES Rich Fruit Cake 170 3 2¼ hours Christmas Cake 170 3 3½ - 4½ hours Victoria Sandwich 210 2 or 3 20-30 minutes Madeira Cake 210 2 or 3 1 hour Small Cakes 225 3 15-25 minutes Plate tart 240 2 50 m[...]

9 Grilling Grilling must be carried out with the oven door closed. The grill pan handles must be removed from the pan. How to Use the Grill 1. T urn the oven control function knob to . The grill pilot light will come on. 2. Adjust the grid and grill pan runner position to allow for different thicknesses of food. Position the food close to the eleme[...]

10 Cleaning materials Before using any cleaning materials on your oven, check that they are suitable and that their use is recommended by the manufacturer . Cleaners that contain bleach should NOT be used as they may dull the surface finishes. Harsh abrasives should also be avoided. External cleaning Regularly wipe over the control panel, oven door[...]

11 Oven Shelves T o clean the oven shelves, soak in warm soapy water and remove stubborn marks with a well wetted soap impregnated pad. Rinse well and dry with a soft cloth. Oven Cavity The enamelled oven cavity is best cleaned whilst the oven is still warm. Wipe the oven over with a soft cloth soaked in warm soapy water after each use. From time t[...]

12 If the appliance is not working correctly , please carry out the following checks, before contacting your local Service Force Centre. IMPORT ANT : If you call out an engineer to a fault listed below , or to repair a fault caused by incorrect use or installation, a charge will be made even if the appliance is under guarantee. SYMPTOM  There is[...]

13 Zanussi guarantee conditions W e, Zanussi, undertake that if, within 12 months of the date of the purchase, this Zanussi appliance or any part thereof is proved to be defective by any reason only of faulty workmanship or materials, we will, at our option, repair or replace the same FREE OF ANY CHARGE for labour , materials or carriage on conditi[...]

14 Hob Rear left burner (semi-rapid) 2000 W Front left burner (rapid) 3000 W Rear right burner (semi-rapid) 2000 W Front right burner (auxiliary) 1000 W Oven Electric Grill 1650 W Gas Oven burner 2700 W Oven light 25 W Total Electric Rating 1675 W Supply voltage (50 Hz) 230 V T echnical Dat a Appliance Class 2 sub class 1 and Class 1 APPLIANCE CATE[...]

15 11 5 780 420 A B C D E Inst allation Fig. 1 1. Positioning the Appliance (Fig. 1) Note A: The appliance is designed to be flush fitted with 2mm clearance at each side to allow for it to be pulled forward for cleaning etc. Note B: The hotplate side trims should be flush with the cabinets and must not be below. Adjustable levelling feet at the fro[...]

16 Fig. 3 Fitting the St ability Bracket (Not supplied) If the cooker has to be installed with a flexible supply pipe, it is necessary that a stability device is fitted. (See "Important Safety Requirements"). The stability bracket is to be fitted by the installer and these instructions should be read in conjunction with the leaflet packed[...]

17 Electrical connections Any electrical work required to install this cooker should be carried out by a qualified electrician or competent person, in accordance with the current regulations. THIS COOKER MUST BE EARTHED. The manufacturer declines any liability should these safety measures not be observed. This cooker is designed to be connected to [...]

18 Conversion from Natural to LPG Gas IMPORTANT The replacement/conversion of the appliance should only be undertaken by a registered engineer or competent person. It is important to note that this model is designed for use with natural gas but can be converted for use with butane or prop ane gas providing the correct injectors are fitted. The gas [...]

19 Replacement of gas oven burner nozzle T o replace the gas oven nozzle, follow this procedure: 1. Remove the bottom plate of the oven cavity (“A”) ; 2. Undo the two fixing screws (“C”) which keep the oven gas burner in place 3. Gently slide the oven gas burner of f the injector support (“D”) and slowly move it to the left hand side, t[...]

Grafiche MDM - Forlì 35687-5441 06/04 CUSTOMER CARE Zanussi-Electrolux Cornwall House 55-77 High S treet Slough Berkshire SL1 1DZ 08705 727727 (*) © Electrolux plc 2004 From the Electrolux Group. The world’ s No.1 choice. The Electrolux Group is the world’s largest producer of powered appliances for kitchen, cleaning and outdoor use. More tha[...]