Français dropdown-ico

Desa CDCFPR manuel d'utilisation

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48

Aller à la page of

Les manuels d’utilisation similaires

Un bon manuel d’utilisation

Les règles imposent au revendeur l'obligation de fournir à l'acheteur, avec des marchandises, le manuel d’utilisation Desa CDCFPR. Le manque du manuel d’utilisation ou les informations incorrectes fournies au consommateur sont à la base d'une plainte pour non-conformité du dispositif avec le contrat. Conformément à la loi, l’inclusion du manuel d’utilisation sous une forme autre que le papier est autorisée, ce qui est souvent utilisé récemment, en incluant la forme graphique ou électronique du manuel Desa CDCFPR ou les vidéos d'instruction pour les utilisateurs. La condition est son caractère lisible et compréhensible.

Qu'est ce que le manuel d’utilisation?

Le mot vient du latin "Instructio", à savoir organiser. Ainsi, le manuel d’utilisation Desa CDCFPR décrit les étapes de la procédure. Le but du manuel d’utilisation est d’instruire, de faciliter le démarrage, l'utilisation de l'équipement ou l'exécution des actions spécifiques. Le manuel d’utilisation est une collection d'informations sur l'objet/service, une indice.

Malheureusement, peu d'utilisateurs prennent le temps de lire le manuel d’utilisation, et un bon manuel permet non seulement d’apprendre à connaître un certain nombre de fonctionnalités supplémentaires du dispositif acheté, mais aussi éviter la majorité des défaillances.

Donc, ce qui devrait contenir le manuel parfait?

Tout d'abord, le manuel d’utilisation Desa CDCFPR devrait contenir:
- informations sur les caractéristiques techniques du dispositif Desa CDCFPR
- nom du fabricant et année de fabrication Desa CDCFPR
- instructions d'utilisation, de réglage et d’entretien de l'équipement Desa CDCFPR
- signes de sécurité et attestations confirmant la conformité avec les normes pertinentes

Pourquoi nous ne lisons pas les manuels d’utilisation?

Habituellement, cela est dû au manque de temps et de certitude quant à la fonctionnalité spécifique de l'équipement acheté. Malheureusement, la connexion et le démarrage Desa CDCFPR ne suffisent pas. Le manuel d’utilisation contient un certain nombre de lignes directrices concernant les fonctionnalités spécifiques, la sécurité, les méthodes d'entretien (même les moyens qui doivent être utilisés), les défauts possibles Desa CDCFPR et les moyens de résoudre des problèmes communs lors de l'utilisation. Enfin, le manuel contient les coordonnées du service Desa en l'absence de l'efficacité des solutions proposées. Actuellement, les manuels d’utilisation sous la forme d'animations intéressantes et de vidéos pédagogiques qui sont meilleurs que la brochure, sont très populaires. Ce type de manuel permet à l'utilisateur de voir toute la vidéo d'instruction sans sauter les spécifications et les descriptions techniques compliquées Desa CDCFPR, comme c’est le cas pour la version papier.

Pourquoi lire le manuel d’utilisation?

Tout d'abord, il contient la réponse sur la structure, les possibilités du dispositif Desa CDCFPR, l'utilisation de divers accessoires et une gamme d'informations pour profiter pleinement de toutes les fonctionnalités et commodités.

Après un achat réussi de l’équipement/dispositif, prenez un moment pour vous familiariser avec toutes les parties du manuel d'utilisation Desa CDCFPR. À l'heure actuelle, ils sont soigneusement préparés et traduits pour qu'ils soient non seulement compréhensibles pour les utilisateurs, mais pour qu’ils remplissent leur fonction de base de l'information et d’aide.

Table des matières du manuel d’utilisation

  • Page 1

    UNVENTED (VENT -FREE) GAS COMP A CT CLASSIC HEARTH ® DU AL BURNER FIREPLA CE OWNER’S OPERA TION AND INST ALLA TION MANU AL Sav e this manual for future reference. For more information, visit www .desatech.com THERMOST A T MODELS CDCFTNA, CDCFTP A, FDCFTN, FDCFTP , VDCFTN, VDCFTP REMOTE-READ Y MODELS CDCFNR, CDCFPR, FDCFRN, FDCFRP , VDCFRN, VDCFR[...]

  • Page 2

    www .desatech.com 1 1 1244-01F 2 W ARNING: Improper installation, adjustment, altera- tion, service, or maintenance can cause injury or prop- erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi- tional information consult a qualified installer , service agency , or the gas supplier . W ARNI[...]

  • Page 3

    www .desatech.com 1 1 1244-01F 3 W ARNI NG: D o not allow fa ns to bl ow d ire ctl y into t he fire pla ce. Avo id any d raf ts that alter bu rner flam e pa tte rns . Ce ili ng f ans ca n cre ate dra fts th at a lte r b urne r flam e patt ern s. Alt ere d burn er pat ter ns c an cau se s oot ing . Due to high temperatures, the appliance should b[...]

  • Page 4

    www .desatech.com 1 1 1244-01F 4 PRODUCT IDENTIFICA TION Ignitor Button Screen Fireplace Cabinet Log Control Knob Figure 1 - V ent-Free Compact Dual Flame Fireplace O F F P I L O T O N H I L O Hood Fireplace Cabinet Logs Ignitor Button Remote Control (Optional) Control Knob Hood SAFETY INFORMA TION Continued 1. This appliance is only for use with t[...]

  • Page 5

    www .desatech.com 1 1 1244-01F 5 OPTIONAL REMO TE CONTROL A CCESSORIES (For Remote-Ready Models Only) There are four optional remote controls that can be purchased separately for Remote-Ready Models only: • wall switch • hand-held ON/OFF remote • wall thermostat • ha nd -h el d th erm osta t r emo te See Accessories, page 44. LOCAL CODES In[...]

  • Page 6

    www .desatech.com 1 1 1244-01F 6 HOOD ASSEMBL Y WA R N I N G : A l wa y s h a v e screen in place before operat ing fireplace. This prevents exces- sive temperatures on fireplace surfaces. W ARNING: Failure to position the parts in accordance with the se diagrams or failure to use only parts specifically approved with this fireplace may result [...]

  • Page 7

    www .desatech.com 1 1 1244-01F 7 PROVIDING ADEQUA TE VENTILA TION The following are excerpts from National Fuel Gas Code, ANSI Z223.1/NFP A 54, Section 5.3, Air for Combustion and V entilation. All spaces in homes fall into one of the three fol - lowing ventilation classifications: 1. Unusually T ight Construction 2. Unconfined Space 3. Confined[...]

  • Page 8

    www .desatech.com 1 1 1244-01F 8 AIR FOR COMB USTION AND VENTILA TION Continued 4. Compare the maximum Btu/Hr the space can support with the actual amount of Btu/Hr used. _______ Bt u/ Hr (m ax im um th e sp ac e c an s up po rt ) _______ Btu/ Hr ( actua l am ount of B tu/H r use d) Example: 35,840 Btu/Hr (maximum the space can support) 40,000 Btu/[...]

  • Page 9

    www .desatech.com 1 1 1244-01F 9 CAUT ION: This firep lace c re- ates warm air currents. These currents move heat to wall sur- faces next to fir eplace. Installing fireplace next to vinyl or cloth wall coverings or operating fireplace where impurit ies (such as, but not limited to, tobacco smoke , arom atic c andles, clea n- ing flui ds, oil o[...]

  • Page 10

    www .desatech.com 1 1 1244-01F 10 INST ALLA TION ITEMS Before installing fireplace, make sure you have the items listed below . • external regulator (supplied by installer, for propane/LP units only) • piping (check local codes) • sealant (resistant to propane/LP gas) • equipment shutoff valve * • test gauge connection* • ground joint [...]

  • Page 11

    www .desatech.com 1 1 1244-01F 1 1 INST ALLA TION Continued Figure 9 - Rough Opening for Installing in Corner Figure 8 - Rough Opening for Installing in Wall 43 5 / 16 " 30 5 / 8 " 61 1 / 4 " 26 7 / 8 " 26 7 / 8 " 26 7 / 8 " 3/4" Off The Floo r Minimum 15 1 / 4 " Actual Framing Height 26" 26 7 / 8 "[...]

  • Page 12

    www .desatech.com 1 1 1244-01F 12 15" 18" 21" 23" 2 1 / 2 " 6" 8" 10" Note: A ll vertical measurements are from top of fireplace opening to bottom of mantel shelf. All measurements are in inches. INST ALLA TION Continued W ARNING: Never modify or cover the louvered slots on the front of the firebox. Mantel C[...]

  • Page 13

    www .desatech.com 1 1 1244-01F 13 INST ALLA TION Continued Figure 16 - Removing T op Louver and Opening Bottom Louver O F F P I L O T O N H I L O T op Louver Bottom Louver 1 1. Place metal trim on shoulder screws located on the side and top of the firepl ace (see Assem - bling Perimeter T rim ). Firmly snap trim over shoulder screws. Align firepl[...]

  • Page 14

    www .desatech.com 1 1 1244-01F 14 INST ALLA TION Continued Installing Blower Accessory CAUTION: Label all wires prior to disconnection when serv icin g c ontro ls. Wiri ng e rror s can ca use imp roper a nd dang er - ous operation. CAUTION: V erify proper op- eration after servicing. No te : If you are usin g a mant el with your fireplac e, use th[...]

  • Page 15

    www .desatech.com 1 1 1244-01F 15 INST ALLA TION Continued For Built-In Installation W ARNING: A licensed elec- trician must connect the wiring harness to electrical supply followi ng all local codes . Elect ri- cian mus t p rovid e a clamp on th e box cover to secure the wiring. Wir ing should be routed thr ough the bushing in the hole on the oute[...]

  • Page 16

    www .desatech.com 1 1 1244-01F 16 Installation must include an equipment shutoff valve, union, and plugged 1/8" NPT tap. Locate NPT tap within reach for test gauge hook up. NPT tap must be upstream from heater (see Figure 23). IMPORT ANT : Install equipment shutoff valve in an accessible location. The equipment shutoff valve is for turning on [...]

  • Page 17

    www .desatech.com 1 1 1244-01F 17 INST ALLA TION Continued W e recommend that you install a sediment trap in supply line as shown in Figure 23, page 16. Locate sedime nt trap where it is within reach for cleaning. Install in piping system between fuel supply and heater . Locate sediment trap where trapped mat - ter is not likely to freeze. A sedime[...]

  • Page 18

    www .desatech.com 1 1 1244-01F 18 INST ALLA TION Continued CAUTION: Make sure exter- nal regulator has been installed betwe en pro pane/LP supply and fireplace. See guidelines under Connecting to Gas Supply , page 16. PR ES SU RE T ES TIN G GA S S UPP LY P IPIN G SY ST EM T est Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect appliance with[...]

  • Page 19

    www .desatech.com 1 1 1244-01F 19 OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIES Remote-Ready Models Only (HRC100 Series & HRC200 Series) Installing Receiver 1. Disconnect wires from the control valve (see Figure 29) . 2. Locate the battery clip mounted on the back of the receiver (see Figure 30). 3. Slide 9-volt battery (not included) [...]

  • Page 20

    www .desatech.com 1 1 1244-01F 20 INST ALLA TION Continued 3. Route the 25 ft. wire to a convenient location to mount your thermostat (no outside wall). IMPORT ANT : The wire may be shortened but must not be lengthened. The thermostat should be mounted 54" above the floor in a location where there is good air circulation. A void heat sources [...]

  • Page 21

    www .desatech.com 1 1 1244-01F 21 2. Reattach screen by placing the notches in the screen fra me o ver the shoulde r sc rews and pushing down. INST ALLA TION Continued Log Shoulder Screw Screen Figure 36 - Installing Log and Screen INST ALLING BRICK LINERS AND LOG SET AND SCREEN (Models CDCFNR and CDCFPR Only) 1. Remove packaging from brick liners [...]

  • Page 22

    www .desatech.com 1 1 1244-01F 22 LIGHTING INSTRUCTIONS W ARNI NG: Y ou must o pera te this fireplace with the screen in place . Make sure firepla ce screen is installed before run- ning fireplace. NOTICE: Durin g initial op era- tion of new fireplace, burning logs will give off a paper-burn- ing smell. Open window to vent smell. Operate firep[...]

  • Page 23

    www .desatech.com 1 1 1244-01F 23 6. With control kn ob pressed in, p r ess a nd release ignitor button. This will light pilot. The pilot is attached to the fr ont burner . If needed, keep pressing ignitor button until pilot lights. Note: If pi lot doe s n ot s tay lit , ref er to T roubleshooting , page 30. Also, contact a qualified service perso[...]

  • Page 24

    www .desatech.com 1 1 1244-01F 24 OPERA TING FIREPLACE Continued Note: It is safe to operate fireplace with blower tur ned off. Howe ver , the blower hel ps distri bute heated air fr om the fireplace. Figure 44 - AUTO/OFF/ON Blower Switch AUTO/OFF/ON Switch REMOTE-READ Y MODELS FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not fol- low[...]

  • Page 25

    www .desatech.com 1 1 1244-01F 25 OPERA TING FIREPLACE Continued 6. With control kn ob pressed in, p r ess a nd release ignitor button. This will light pilot. The pilot is attached to the fr ont burner . If needed, keep pressing ignitor button until pilot lights. Note: If pilot does not stay lit, contact a qualified service person or gas supplier [...]

  • Page 26

    www .desatech.com 1 1 1244-01F 26 REMOTE OFF ON H I LO IN OUT OPERA TING FIREPLACE Continued Note: The burner may light if hand-held remote was on when selector switch was last turned off. Y ou can now turn the burner on and off with the hand-held remote contr ol unit. IM PO RT AN T: Do not leave the selector switch in the REMOTE or ON position whe[...]

  • Page 27

    www .desatech.com 1 1 1244-01F 27 OPERA TING FIREPLACE Continued Note: Do not hold the hand-held remote for a long time. Body temperature will affect its operation in the AUTO mode. Safety Features When away from home for an extended period of time or as a child safety feature to prevent accidental ignition of the fir eplace, the receiver ON/OFF/R[...]

  • Page 28

    www .desatech.com 1 1 1244-01F 28 If pilot flame pattern is incorrect, as shown in Figure 53, page 27 • tu rn fir ep lac e o ff (see T o T urn Off Gas to Appli - ance , page 23 for Thermostat-Controlled Mod - els or page 25 for Remote-Ready Models) • see T roubleshooting , page 30 Note: The pilot flame on natural gas units will have a slight[...]

  • Page 29

    www .desatech.com 1 1 1244-01F 29 Figure 56 - Injector Holder On Outlet Burner Tube Burner T ube Injector Holder Primary Air Inlet Holes 3. Blow air through the ports/slots and holes in the burner . 4. Check the injector holder located at the end of the burner tube again. Remove any large particles of dust, dirt, lint, or pet hair with a soft cloth[...]

  • Page 30

    www .desatech.com 1 1 1244-01F 30 TROUBLESHOO TING WA RNI NG : T ur n of f and un pl ug fir ep la ce an d let c oo l b ef or e s er v ic in g . On ly a qua lifi ed se rvi ce pe r so n s ho ul d s er vic e and re pa ir fire pl ace . CA UTI ON : N ev er us e a w ire , nee dl e, or si mi lar ob je ct to cl ea n O DS / pi lot . Thi s c an da mag e O[...]

  • Page 31

    www .desatech.com 1 1 1244-01F 31 POSSIBLE CAUSE 1 . Control knob not fully pressed in 2. Control knob not pressed in long enough 3. Safety interlock system has been triggered 4. Equipment shutoff valve not fully open 5. Pilot flame not touching ther - mocouple, which allows ther - mocouple to cool, causing pilot flame to go out. This problem coul[...]

  • Page 32

    www .desatech.com 1 1 1244-01F 32 TROUBLESHOO TING Continued POSSIBLE CAUSE 1. Residues from manufacturing processes and log curing 2. Not enough air 3. Gas regulator defective 1. Turning control knob to HI position when burner is cold 2. Air in gas line 3. Air passageways on fireplace blocked 4 . Dirty or partially clogged burner orifice 1 . Whe[...]

  • Page 33

    www .desatech.com 1 1 1244-01F 33 TROUBLESHOO TING Continued W ARN IN G: If yo u s mel l gas • S hu t off g as sup pl y. • D o no t t ry to li gh t a ny ap pli anc e. • Do not to uch any ele ct ric al sw it ch ; do not us e an y ph on e in you r bu ild in g. • I mm ed iat el y ca ll yo ur ga s sup pl ier fr om a ne ig hbo r’s ph on e. Fo [...]

  • Page 34

    www .desatech.com 1 1 1244-01F 34 SPECIFICA TIONS THERMOST A T MODELS: CDCFTP A, VDCFTP , FDCFTP • Rating: 17,000/26,000 Btu/Hr • Gas T ype: Propane/LP Gas Only • Ignition: Piezo • Manifold Pressure: 8" W .C. • Inlet Gas Pressure (in. of water): Maximum - 14", Minimum* - 11" • Dimensions (H x W x D) (including hood and sc[...]

  • Page 35

    www .desatech.com 1 1 1244-01F 35 SERVICE HINTS When Gas Pressure Is T oo Low • pilot will not stay lit • burners will have delayed ignition • fireplace will not produce specified heat • for propane/LP units, propane/LP gas supply may be low Yo u may feel you r gas pres sure is too low. If so, con- ta ct y ou r lo cal nat ura l o r pr opa[...]

  • Page 36

    www .desatech.com 1 1 1244-01F 36 8 8 19 19 19 19 19 19 19 1 9 9 10 10 10 16 17 10 10 14 6 3 1 1 12 13 1 1 15 16 18 16 16 16 16 16 16 2 5 16 16 16 16 7 4 ILL USTRA TED P ARTS BREAKDOWN FIREBOX MODELS CDCFTNA, CDCFTP A, VDCFTN, VDCFTP , FDCFTN, FDCFTP VDCFRN, VDCFRP , FDCFRN AND FDCFRP[...]

  • Page 37

    www .desatech.com 1 1 1244-01F 37 P ARTS LIST FIREBOX MODELS CDCFTNA, CDCFTP A, VDCFTN, VDCFTP , FDCFTN, FDCFTP VDCFRN, VDCFRP , FDCFRN AND FDCFRP This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 35 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 [...]

  • Page 38

    www .desatech.com 1 1 1244-01F 38 ILL USTRA TED P ARTS BREAKDOWN FIREBOX MODELS CDCFNR AND CDCFPR 8 10 8 14 14 14 14 14 14 14 1 9 9 10 10 19 19 20 10 16 17 10 10 6 3 1 1 12 13 21 19 22 1 1 15 16 18 16 16 16 16 16 16 16 2 5 16 16 16 16 7 4 10[...]

  • Page 39

    www .desatech.com 1 1 1244-01F 39 P ARTS LIST FIREBOX MODELS CDCFNR AND CDCFPR This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 35 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 ** Outer Casing T op 1 2 ** Baffle 1 3 ** Outer Casing 1 4 104281-0[...]

  • Page 40

    www .desatech.com 1 1 1244-01F 40 ILL USTRA TED P ARTS BREAKDOWN THERMOST A T MODELS FDCFTP , FDCFTN, VDCFTP , VDCFTN, CDCFTP A AND CDCFTNA 8 7 5 6 6 12 2 4 19 18 15 16 9 9 17 1 1 14 3 13 20 9 1 21 10[...]

  • Page 41

    www .desatech.com 1 1 1244-01F 41 KEY NO. P ART NO. DESCRIPTION QTY . 1 1 1 1069-01 Dual Burner • • • • 1 2 099056-29 Injector , LP • • 1 099056-34 Injector , NG • • 1 3 104424-04 Outlet T ube • • • • 1 4 1 1 1 124-01 Burner Retainer Spring • • • • 1 5 107486-01 ODS Pilot, LP • • 1 107485-01 ODS Pilot, NG • •[...]

  • Page 42

    www .desatech.com 1 1 1244-01F 42 ILL USTRA TED P ARTS BREAKDOWN REMOTE-READY MODELS FDCFRN, FDCFRP , VDCFRN, VDCFRP , CDCFNR AND CDCFPR O F F P I L O T O N H I L O 16 15 15 16 12 12 1 1 9 9 9 10 5 17 18 13 19 2 1 4 3 14 7 6 8 20 (FDCFTN/TP , VDCFRN/RP) 20 (CDCFNR/PR) Natural Gas Only 9 21 22[...]

  • Page 43

    www .desatech.com 1 1 1244-01F 43 P ARTS LIST REMOTE-READY MODELS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 35 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 1 1 1069-01 Dual Burner • • • • 1 2 099056-29 Injector , LP • • 1 099[...]

  • Page 44

    www .desatech.com 1 1 1244-01F 44 ACCESSORIES NOTICE: All accessories may not be available for all fireplace models. Pu rch as e the se fire pl ac e acc ess or ie s fro m your loca l dea ler. If they can not supply thes e acce sso ries , cal l DESA Heating Pro duct s at 1-8 66-67 2-60 40 for re - fe rra l info rm ati on . You can als o wri te to [...]

  • Page 45

    www .desatech.com 1 1 1244-01F 45 W ALL-MOUNT THERMOST A T SWITCH - GWMT1 (Not Shown) For all r emote-ready models. The desired com- fort setting can be selected on the wall thermostat and the fir eplace will aut omatically cycle fro m pilot to the heat setting selected. W ALL-MOUNT ON/OFF SWITCH GWMS2 (Not Shown) For all remote-ready models. Allo[...]

  • Page 46

    www .desatech.com 1 1 1244-01F 46 NO TES _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _______________________________________[...]

  • Page 47

    www .desatech.com 1 1 1244-01F 47 NO TES _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _______________________________________[...]

  • Page 48

    2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com 1 1 1244-01 Rev . F 09/05 NOT A UPC 111244 01[...]