England's Stove Works 50SVL17 manuel d'utilisation

TRANQUILITY  WOOD  STOVE   INSTALLATION  &  OPERATION  MANUAL  17 ‐ VL,  50 ‐ SVL17  &  50 ‐ TVL17   CAUTION Please  read  this  entire  manual  before  installation  and  use  of  this  wood  fuel ‐ burning  appliance.  Keep  child[...]

Page | 2 Retain  for  your  files  Model  Number________________________  Date  of  Purchase_______________________  Date  of  Manufacture____________________  Serial  Number_________ ________________   *  This  information  can  be  found  on  the  safety  ta g  attached ?[...]

Page | 3 TABLE  OF  CONTENTS   Introduction  • Introduction  .................................  4   Specifications  • Heating  Specifications  ..................  5  • Dimensions  ...................................  5  • EPA  Compliance  ...........................  5   Inst[...]

Page | 4 INTRODUCTION   Thank  you  for  purchasing  this  fine  product  from  England’s  Stove  Works!   England’s  Stove  Works  was  started,  and  is  still  owned  by,  a  family  that  believes  strongly  in  a  “Do  It  Yourself”  s[...]

Page | 5 SPECIFICATIONS   Heating  Specifications  • Maximum  Heat  Output  ......................................................................  40,000  BTU/hr  • Maximum  Burn  Time**  ................................................................................  6  hours  • Approximate ?[...]

Page | 6 INSTALLATION  Installation  Overview  When  choosing  a  location  for  your  new  stove,  there  are  a  multitude  of  factors  that  should  be  taken  into  account  before  beginning  the  installation.   1. Traffic  Patterns  –  To  help[...]

Page | 7 • INSTALLATION  Clearances  to  Combustibles   Parallel  Wall  Installation           Corner  Installation       Unit  to  Side  Wall  Chimney  Connector  to  Side  Wall  Chimney  Connector  to  Rear  Wall  Unit  to  Re[...]

Page | 8  INSTALLATION   Venting  Introduction  This  wood  stove  operates  on  a  natural  draft  system,  in  which  the  chimney  system  pulls  air  through  the  stove.  This  unit  must  be  installed  in  accordance  with  the  following ?[...]

Page | 9 INSTALLATION   Additional  Venting  Information  • Do  not  mix  and  match  components  from  different  pipe  manufacturers  when  assembling  your  venting  system  (i.e.  Do  NOT  use  venting  pipe  from  one  manufacturer  and  a  thimble ?[...]

Page | 10 INSTALLATION   Wall  Pass ‐ Throughs  In  Canada,  the  installation  must  conform  to  CAN/CSA ‐ B365  when  passing  through  combustible  construction.[...]

Page | 11 INSTALLATION Approved Venting Method 1 : Through the Wall Factory Built Chimney Please Note: Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each indivi dual installation. Please follow all venting system requirements, ma intain the required clearances to combustibles, an[...]

Page | 12 INSTALLATION Approved Venting Method 2 : Through the Ceiling Please Note: Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each indivi dual installation. Please follow all venting system requirements, ma intain the required clearances to combustibles, and follow all local [...]

Page | 13 INSTALLATION Approved Venting Method 3 : Internal or External Masonry Chimney System Please Note: Installation diagrams are for reference purposes only and are not drawn to scale, nor meant to be used as plans for each indivi dual installation. Please follow all venting system requirements, ma intain the required clearances to combustible[...]

Page | 14 INSTALLATION  Mobile  Home  Installation  • The  wood  stov e  MUST  be  se cur ed  to  the  floor  of  the  mobile  home  using  lag  bolts  and  the  holes  provided  in  the  bottom  of  the  unit  for  this  purpose.  • The  wood [...]

Page | 15 FLOOR  PROTECTION • This  wood  stove  requires  a  non ‐ combustible  floor  protector  if  the  stove  is  to  be  installed  on  a  combustible  floor.  If  the  floor  the  stove  is  to  be  installed  on  is  already  non ‐ combu[...]

Page | 16 FLOOR  PROTECTION R  Value  Calculation  An  easy  means  of  determining  if  a  proposed  alternate  floor  protector  meets  requirements  is  to  follow  this  procedure:  1) Convert  specification  to  R ‐ value:  i R ‐ value  is  given  – ?[...]

Page | 17 OPERATION  Break ‐ In  Fires  • This  wood  burning  unit  is  constructed  of  heavy  gauge  steel  and  cast  iron  and  is  built  to  last  a  long  time.  However,  in  order  to  ensure  no  excessive  thermal  stresses  are [...]

Page | 18  OPERATION  • England’s  Stove  Works,  Inc.  always  recommends  the  use  of  a  mag netic  stove  thermometer,  so  that  the  temperature  of  the  unit  can  be  monitored.  When  using  a  magnetic  stove  thermometer,  locate  the[...]

Page | 19 OPERATION  Additional  Safety  Guidelines  • The  installation  of  smoke  detectors  is  highly  recomm ended  when  installing  this  or  any  other  solid  fuel  burning  appliance.  Smoke  detectors  should  be  located  near  or  in  every [...]

Page | 20  MAINTENANCE  Daily  Maintenance  • Inspect  the  firebox  for  ash  accumulation;  remove  excess  ash  and  follow  instructio ns  below  regarding  disposal.  Ash  should  not  be  allowed  to  accumulate  in  the  stove  to  the  point ?[...]

Page | 21 MAINTENANCE  Inspecting  Gaskets  An  airtight  seal  at  the  door  opening  is  crucial  to  proper  stove  performance.  Any  air  leakage  at  this  area  can  cause  an  over ‐ fire  situation  and  is  therefore  a  serious  safety ?[...]

Page | 22 REPLACING  COMPONENTS  Glass  This  unit  has  a  ceramic  glass  panel  (Part  No.  AC ‐ G40)  in  the  viewing  door;  self  adhesive  window  gasket  is  included  with  replacement  windows  purchased  directly  from  England’s  Stove  Wor[...]

Page | 23 TROUBLESHOOTING  Issue  Cause  Solution(s) Stove  smokes  into  room  1.  Weak  Draft 1.1  Be  certain  chimney  is  sufficiently  tall  to  meet  the  10 ‐ 3 ‐ 2  rule.   1.2  Add  additional  height  to  the  chimney.  2.  Negative  Press[...]

Page | 24 REPLACEMENT PARTS LIST Diagram  No.  Description  Part  No.  Per  Unit  1  Air  Control  Slider AC ‐ 17ACS 1 2  Outside  Air  Adapter AC ‐ 17OAA 1 3  Right  Vermiculite  Panel AC ‐ 17RBR 1 4  Left  Vermiculite  Panel AC ‐ 17RBL 1 5  Rear  Vermiculite  Panel AC ‐ 1[...]

Page | 25  ILLUSTRATED  PARTS  DIAGRAM  3 4  7  5  5 6  1 2 Cast Iron Door Assembly Welded  Steel  Stove  Body  12 8  10  9 11  11  Window  Retaining  Screws  13  15  14 [...]

Page | 26 You may write your unit’s Ma nufacture Date and Serial Number in the blank spaces on this sample tag, for future reference. This sample tag also shows the safety info. such as UL testing standard, etc. for your local officials, or anyone else who may need reference information.[...]

Page | 27 LIMITED  FIVE  (5)  YEAR  WARRANTY  From  the  date  of  purchase  to  the  original  owner   The  manufacturer  extends  the  following  warrantie s:  Five  Year  Period:  1. Carbon  steel  and  welded  sea ms  in  the  firebox  are  covere[...]

Page | 28 Procedure   Purchaser  must  give  notice  of  claim  of  defect  within  the  warranty  period  and  pay  transportation  to  and  from  a  service  center  designated  by  the  manufacturer.  The  dealer  from  which  the  unit  was [...]

Page | 29 WARRANTY REGISTRATION for England’s Stove Works® Purchaser Information I. Purchased By (Name) ______ ___________________________________ II. Address ____________________ __________________ ______________ III. City________________ _______State________Zip Code ____________ IV. Telephone Number ________ ____________________ ______________[...]

Page | 30 Important Notice This registration information MUST be on file for this warranty to be valid. Please mail this information within thirty (30) days from the original date of purchase. Use any of these three easy ways to send your warranty information in! Mailing Address England’s Stove Works, Inc. Technical Support Department P.O. Box 20[...]