Lenovo V100 manuel d'utilisation

Le n o v o 3 000 V1 00 an d V2 00 Hard w ar e M ain t e n a n c e Ma nu a l May 2007 This manual supports: Lenovo 3000 V100 and V200 (MT 0763 and 0764)[...]

[...]

Le n o v o 3 000 V1 00 an d V2 00 Hard w ar e M ain t e n a n c e Ma nu a l[...]

Note Before using this information and the pr oduct it supports, be sure to r ead the general information under “Notices” on page 1 17. First Edition (May 2007) © Copyright Lenovo 2007. All rights reserved. U.S. GOVERNMENT USERS – RESTRICTED RIGHTS: Our products and/or services ar e provided with RESTRICTED RIGHTS. Use, duplication or disclo[...]

Contents Introduction . . . . . . . . . . . . .1 About this manual . . . . . . . . . . . .1 Important service information . . . . . . . .1 Strategy for replacing FRUs . . . . . . . . .1 Strategy for replacing a har d disk drive . . . .2 Important notice for replacing a system boar d . .2 How to use error messages . . . . . . . .2 Strategy for repla[...]

iv MT 0763 and 0764[...]

Introduction About this manual This manual contains service and refer ence information for Lenovo 3000 V100 and V200 (MT 0763 and 0764). Use this manual along with the advanced diagnostic tests to troubleshoot pr oblems. The manual is divided into sections as follows: v The common sections provide general information, guidelines, and safety informa[...]

v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board. If you are instructed to r eplace either the processor boar d or the system board, and replacing one of them does not corr ect the problem, rein[...]

Using PC Entitlement W arehouse (PEW) v PEW is the primary source for identifying FRU part numbers and FRU descriptions for the key commodities for CMV products at a MT - serial number level. An example of key commodities are har d disk drives, system boards, micropr ocessors, Liquid Crystal Displays (LCDs), and memory . v Remember , all CMV produc[...]

Important information about replacing RoHS compliant FRUs RoHS, The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive (2002/95/EC) is a European Union legal requirement affecting the global electronics industry . RoHS requirements must be implemented on Lenovo products placed on the market after June 2006. Product[...]

Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety notices appear in English with a page number refer e[...]

Safety notice 2 D ANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery , recharge it, throw it into fire or water , or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery [...]

Safety notice 3 D ANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water , or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result[...]

Safety notice 4 D ANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector , disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water . Dispose of the battery as required by local ordinances or regulations. Use only the battery in the app[...]

Safety notice 5 Safety notice 6 D ANGER If the LCD breaks and the fluid fr om inside the LCD gets into your eyes or on your hands, immediately wash the affected ar eas with water for at least 15 minutes. Seek medical care if any symptoms fr om the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous[...]

Safety notice 7 D ANGER Safety notice 8 D ANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de couran[...]

Safety information The following section presents safety information with which you need to be familiar before you service a Lenovo 3000 computer . General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you [...]

Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electr ostatic discharges. Do not use this type of mat to[...]

v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures corr ect grounding of the units.) v If an electrical accident occurs: – Use caution; do not become a vic[...]

Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects. Pr otect against ESD damage by equalizing the charge so that the machine, t[...]

Laser compliance statement Some models of Lenovo 3000 computer are equipped fr om the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requir ements of the Department of Health and Hum[...]

A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: D ANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio lase[...]

General descriptions The descriptions in this chapter apply to any Lenovo 3000 model that has the PC-Doctor ® for DOS diagnostics program. Some descriptions might not apply to your particular computer . Read this first Before you go to the checkout guide, be sur e to read this section. Important notes v Only certified trained personnel should serv[...]

Following is a list of some common items that are not cover ed under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking pr oblems with the computer , determine whether the damage is covered under the warranty by r eferring to the following list: The following are not covered und[...]

Related service information This section provides information about the following: v “Service We b site” v “Restoring the factory contents by using Product Recovery discs” v “Passwords” on page 20 v “Power management” on page 22 Service We b site When the latest maintenance diskette and the system program service diskette become ava[...]

9. When prompted, insert the appr opriate Product Recovery disc and then click OK . The second phase of the recovery pr ocess begins. 10. When all of the data has been copied from the last Pr oduct Recovery disc in the set, a message is displayed prompting you to r estart the computer . Remove the disc and then click Ye s , then a message is displa[...]

How to remove the power-on password To remove a POP that you have forgotten, do the following: (A) If an SVP is not known by the servicer: 1. T urn off the computer . 2. Remove the battery pack. For how to remove the battery pack, see “1010 Battery pack” on page 46. 3. Remove the backup battery . For how to remove the backup battery , see “10[...]

10. Select Ye s in the Setup Configuration window . Both user HDP and master HDP will have been removed. Power management Note: Power management modes are not supported for APM operating system. To reduce power consumption, the computer has three power management modes: screen blank, sleep (standby), and hibernation. Screen blank mode If the time s[...]

To cause the computer to enter hibernation mode, do any of the following: v Press the Fn+F12 keys. v If you are using the ACPI operating system and have defined one of the following actions as the event that causes the system to go into hibernation mode, perform that action. – Closing the lid. – Pressing the power button. Also, the computer goe[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the Lenovo 3000 computer . Note: The diagnostic tests are intended to test only Lenovo 3000 pr oducts. The use of non-Lenovo 3000 products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1[...]

To run the test, do as follows: 1. Insert the PC-Doctor disk into the diskette drive; then power on the computer . If the computer cannot be powered on, go to “Power system checkout” on page 26, and check the power sources. If an error code appears, go to “Symptom-to-FRU index” on page 36. On the first screen, select the model and pr ess En[...]

Detecting system information with PC-Doctor PC-Doctor can detect the following system information: Hardware Info v System Configuration v Memory Contents v Physical Disk Drives v Logical Disk Drives v VGA Information v IDE Drive Info v PCI Information v PNPISA Info v SMBIOS Info v VESA LCD Info v Hardwar e Events Log Utility v Run External T ests v[...]

Checking the ac adapter Yo u are her e because the computer fails only when the ac adapter is used. v If the power-on indicator does not turn on, check the power cor d of the ac adapter for correct continuity and installation. v If the computer does not charge during operation, go to ″ Checking operational charging. ″ To check the ac adapter , [...]

Note: If the battery pack becomes hot, it may not be able to charge. Remove it from the computer and leave it at r oom temperature for a while. After it cools down, reinstall and r echarge it. To check the battery pack, do the following: 1. Power off the computer . 2. Remove the battery pack and measure the voltage between battery terminals 1 (−)[...]

Lenovo 3000 V100 and V200 Product overview . . . . . . . . . . . .3 0 Specifications . . . . . . . . . . . . .3 0 Status indicators . . . . . . . . . . . .3 3 FRU tests . . . . . . . . . . . . . .3 4 Fn key combinations . . . . . . . . . .3 5 Symptom-to-FRU index . . . . . . . . . .3 6 Numeric error codes . . . . . . . . . .3 6 Error messages . . .[...]

Product overview This section presents the following pr oduct-unique information: v “Specifications” v “Status indicators” on page 33 v “FRU tests” on page 34 v “Fn key combinations” on page 35 Specifications The following table lists the specifications of the Lenovo 3000 V100 and V200: Feature Description Processor v Intel ® Core [...]

Feature Description Graphic memory chip v Intel 915GM/PM v Intel 945GM v Intel 965GM Display v 12.1-inch wide, 16M colors, WXGA (1280 × 768 resolution) TFT color LCD Standard memory v 256-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card × 1 v 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card × 1 v 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card × 2 v 1-GB D[...]

Feature Description Internal modem v 56.6 Kbps Audio v Built-in stereo speakers v Software contr ol volume Ethernet (on the system board) v 10/100 Ethernet Mini PCI adapter v Intel PRO W ireless 3945ABG Mini-PCI Expr ess Adapter v Broadcom 802.1 1ag WLAN PCI-E Mini Card v Broadcom 802.1 1bg WLAN PCI-E Mini Card v ThinkPad ® 1 1a/b/g/n W ireless LA[...]

Status indicators The system status indicators show the status of the computer , as follows: 1 2 4 3 5 9 8 7 6 Indicator Meaning 1 Caps lock Caps Lock mode is enabled. Yo u can enter all alphabetic characters (A-Z) in uppercase without pr essing the Shift key . To enable or disable Caps Lock mode, press the CapsLk key . 2 Num lock The n[...]

Indicator Meaning 7 Battery status Green: The battery is charged between 80% to 100% of the capacity , and being discharged between 0% to 80% of the capacity . Blinking green: The battery is charged between 20% to 80% of the capacity , and being charged. Orange: The battery is charged between 5% and 20% of the capacity , and being discharged.[...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . Key combination Description Fn+F1 V olume down. Fn+F2 V olume up. Fn+F3 Reserved. Fn+F4 Put the computer in sleep (standby) mode. To return to normal operation, press the Fn key only , without pressing a function key . Fn+F5 Enable or disable [...]

Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replacing a FRU does not solve the problem, put the [...]

Symptom or error FRU or action, in sequence 0260 System timer error 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. System board. 0270 Real time clock error 1. Charge the backup battery for more than 8 hours by connecting the ac[...]

Error messages Symptom or error FRU or action, in sequence Unsupported memory . DIMM . Make sur e to use supported memory . Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3[...]

No-beep symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, LCD blank, and no POST . 1. Make sure that every connector is connected tightly and correctly . 2. DIMM. 3. System board. No beep, power-on indicator on, and LCD blank during POST . 1. Reseat DIMM . 2. System board. The power-on passwor d prompt appears. A [...]

LCD-related symptoms Important The TFT LCD for the notebook computer contains many thin-film transistors (TFT s). The presence of a small number of dots that ar e missing, discolored, or always lighted is characteristic of TFT LCD technology , but excessive pixel problems can cause viewing concerns. The LCD should be r eplaced if the number of miss[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

FRU replacement notices This section contains notices related to r emoving and replacing parts. Read this section carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the Lenovo 3000 computer , this problem is addr essed with special nylon-coated screws that have the following characteristics: v They [...]

v “Retaining the UUID” v “Reading or writing the ECA information” Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the serial numbers of the system and all major components. These numbers need to remain the same thr oughout the life of the computer . If you re[...]

To check what ECAs have been previously applied to the machine, use the ECA Information Read/W rite function on the CE Utility Diskette for Lenovo 3000 notebooks. 1. Insert the CE Utility Diskette for Lenovo 3000 notebooks, and restart the computer . 2. From the main menu, select 6. Set ECA Information . 3. To read ECA information, select 2. Read E[...]

Removing and replacing a FRU This section presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU repla[...]

1010 Battery pack D ANGER Unlock the battery release lever 1 and holding the battery r elease lever in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 1 2 3 Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Removing and replacing a[...]

1020 Hard disk drive slot cover and hard disk drive For access, remove this FRU: v “1010 Battery pack” on page 46 Attention v Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock. Impr oper handling can cause damage and permanent loss of data. v Before r emoving the drive, have th[...]

4 3 5 When installing: Make sure that the har d disk drive connector is attached firmly . Removing and replacing a FRU 48 MT 0763 and 0764[...]

1030 DIMM slot cover For access, remove this FRU: v “1010 Battery pack” on page 46 Note: Loosen the screws 1 , but do not r emove them. 1 2 1040 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1030 DIMM slot cover” 1 1 2 When installing: Insert the notched end of the DIMM into the socket. Press th[...]

1050 Backup battery D ANGER For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1030 DIMM slot cover” on page 49 1 2 When installing: Make sure that the battery connector is attached firmly . Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Removing and [...]

1060 PCI Express Mini Card slot cover and PCI Express Mini Card for 802.1 1 a/b/g wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 Note: Loosen the screws 1 , but do not r emove them. 1 2 4 3 5 3 4 In step 3 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick[...]

1070 PCI Express Mini Card slot cover and PCI Express Mini Card 802.1 1 a/b/g/n wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 Note: Loosen the screws 1 , but do not r emove them. 1 2 (continued) Removing and replacing a FRU 52 MT 0763 and 0764[...]

For MT 0763 4 3 3 4 5 In step 3 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the arr ow . Step Screw (quantity) Color T orque 4 M2 × 4 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) When installing: Plug the g[...]

For MT 0764 4 3 4 5 In step 3 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the arr ow . Step Screw (quantity) Color T orque 4 M2 × 4 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) When installing: Plug the gra[...]

1080 Optical drive For access, remove this FRU: v “1010 Battery pack” on page 46 3 1 2 Step Screw (quantity) Color T orque 1 M2.5 × 5 mm, pan-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) 1090 Middle cover For access, remove this FRU: v “1010 Battery pack” on page 46 4 4 4 4 2 1 3 Removing and replacing a FRU Lenovo 3000 V100 and [...]

1 100 Function board For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1090 Middle cover” on page 55 3 2 1 1 Step Screw (quantity) Color T orque 1 M2 × 4 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) Removing and replacing a FRU 56 MT 0763 and 0764[...]

111 0 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1090 Middle cover” on page 55 1 Step Screw (quantity) Color T orque 1 M2.5 × 7 mm, pan-head, nylon-coated (1) Black 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU Lenovo 3000 V100 and V200 57[...]

2 3 3 4 Lift the keyboard a little in the dir ection shown by arrow 2 . Then unlock the connector 3 and detach the connector 4 . When installing: 1. Make sure that the keyboar d connector is attached firmly . Then lock the connector . 2. Make sure that the fr ont side of the keyboard is under the frame. Removing and replacing a FR[...]

1 120 Hinge covers, keyboard bezel, 5-1 Digital Media Reader card, BDC, and fingerprint reader card For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1060 PCI Express Mini Car d slot cover and PCI Express Mini Card for 802.1 1 a/b/g wireless LAN” on page 51 v “1070 PCI Express Mini Car d slot cover and PCI Expre[...]

Remove the hinge cap L 3a and the hinge cap R 3b . 3b 3a Note: Steps 4 and 5 are only for MT 0763. 5 5 5 4 (continued) Removing and replacing a FRU 60 MT 0763 and 0764[...]

Release the antenna cables from the cable guides of the frame. In step 6 , take care not to damage the cables when you pull out them fr om the guide hole. 6 7 7 7 When installing: Route the antenna cables along the cable guides. When you route the cables, do not tense them. To do so, the cables may get damaged by the cable guides of the frame[...]

8 8 8 8 8 When installing: Make sure that all the connectors ar e attached firmly . 9 9 9 Step Screw (quantity) Color T orque 9 M2.5 × 5 mm, pan-head, nylon-coated (3) Silver 0.392 Nm (4 kgfcm) (continued) Removing and replacing a FRU 62 MT 0763 and 0764[...]

10 11 Removing and replacing a FRU Lenovo 3000 V100 and V200 63[...]

To remove the 5-1 Digital Media Reader card, do as follows: 1 2 1 a Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) 4 3 3 When installing: Make sure that all the connectors ar e attached firmly . Removing and replacing a FRU 64 MT 0763 and 0764[...]

To remove the BDC, do as follows: 1 1 2 3 Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) When installing: Make sure that the connector is attached firmly . Removing and replacing a FRU Lenovo 3000 V100 and V200 65[...]

To remove the fingerprint reader car d, do as follows: 2 1 1 1 3 3 3 Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (3) Silver 0.245 Nm (2.5 kgfcm) When installing: Make sure that the connector is attached firmly . Removing and replacing a FRU 66 MT 0763 and 0764[...]

1 130 LCD unit For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1060 PCI Express Mini Car d slot cover and PCI Express Mini Card for 802.1 1 a/b/g wireless LAN” on page 51 v “1070 PCI Express Mini Car d slot cover and PCI Express Mini Card 802.1 1 a/b/g/n wireless LAN” on page 52 v “1090 Middle cover” on [...]

4 3 4 5 3 Step Screw (quantity) Color T orque 3 M2.5 × 5 mm, pan-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) 4 M2 × 4 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) When installing: Make sure that the LCD connector 5 is attached firmly . (continued) Removing and replacing a FRU 68 MT 0763 and 0764[...]

6 6 When installing: When you attach the LCD unit, make sure that you do not pinch the antenna cable. Removing and replacing a FRU Lenovo 3000 V100 and V200 69[...]

1 140 Heat sink assembly , CPU, MDC, ExpressCard slot, and system board For access, remove these FRUs, in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover and har d disk drive” on page 47 v “1030 DIMM slot cover” on page 49 v “1040 DIMM” on page 49 v “1060 PCI Express Mini Car d slot cover and PCI Expres[...]

4 5 Remove the heat sink as follows: 1 3 2 2 2 Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (1) Silver 0.245 Nm (2.5 kgfcm) Note: Loosen the screws 2 , but do not r emove them. (continued) Removing and replacing a FRU Lenovo 3000 V100 and V200 71[...]

When installing: Before you attach a new thermal module to the computer , peel off the covering film of thermal gr ease. Then attach the thermal module to the computer . For MT 0763 a For MT 0764 a (continued) Removing and replacing a FRU 72 MT 0763 and 0764[...]

Remove the CPU as follows: Attention: CPU is extr emely sensitive. When you service the CPU, avoid any kind of rough handling. Rotate the head of the screw in the dir ection shown by arrow 1 to release the lock; then remove the CPU in the dir ection shown by arrow 2 . 1 2 b a When installing: Place the CPU on the CPU socket a , an[...]

Remove the MDC as follows: For MT 0763 1 1 2 Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) 4 3 When installing: Make sure that the connector on the underside of the car d is attached to the system board firmly , and then fasten the screws. (continued) Removing and replacing a FRU 74[...]

For MT 0764 2 3 1 1 Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) When installing: Make sure that the connector on the underside of the car d is attached to the system board firmly , and then fasten the screws. (continued) Removing and replacing a FRU Lenovo 3000 V100 and V200 75[...]

Remove the ExpressCar d slot as follows: 1 1 1 1 Step Screw (quantity) Color T orque 1 M2 × 2.5 mm, pan-head, nylon-coated (4) Silver 0.245 Nm (2.5 kgfcm) T urn over the system board, and disconnect the Expr essCard slot assembly . 2 When installing: Make sure that the connector is attached firmly , and then fasten the screws. Removing and r[...]

1 150 Fan and base cover (with speakers) For access, remove these FRUs, in or der: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover and har d disk drive” on page 47 v “1030 DIMM slot cover” on page 49 v “1040 DIMM” on page 49 v “1060 PCI Express Mini Car d slot cover and PCI Express Mini Card for 802.1 1 a/b/g w[...]

Note: Applying labels to the bottom cover When you replace the base cover , you need to stick some labels on the new base cover . Some of the labels have been shipped with the new base cover , and some may need to be reused fr om the old base cover . Following labels are the typical labels stuck on the bottom side of the computer when it is shipped[...]

2010 LCD front bezel For access, remove this FRU: v “1010 Battery pack” on page 46 1 1 1 1 Step Screw cap Screw (quantity) Color T orque 1 M2.5 × 5 mm, pan-head, nylon-coated (4) Black 0.392 Nm (4 kgfcm) 2 Removing and replacing a FRU Lenovo 3000 V100 and V200 79[...]

2020 Inverter card For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “2010 LCD front bezel” on page 79 1 4 3 2 1 Step Screw (quantity) Color T orque 1 M2 × 4 mm, pan-head, nylon-coated (2) Silver 0.245 Nm (2.5 kgfcm) When installing: Make sure that connectors 3 and 4 ar e attached firmly . Cable [...]

2030 Integrated camera For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “2010 LCD front bezel” on page 79 Note: The part marked a is fragile and might be damaged by rough handling. When you remove the camera, do not hold that part to avoid the damage. 1 1 3 2 a Step Screw (quantity) Color T orque 1 M2 [...]

2040 LCD panel, LCD cable, and hinges For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1060 PCI Express Mini Car d slot cover and PCI Express Mini Card for 802.1 1 a/b/g wireless LAN” on page 51 v “1070 PCI Express Mini Car d slot cover and PCI Express Mini Card 802.1 1 a/b/g/n wireless LAN” on page 52 v “1[...]

5 4 3 When installing: Make sure that the camera connector is attached firmly . Remove the hinges from the LCD panel. 6 6 6 7 7 6 Step Screw (quantity) Color T orque 6 M2 × 3 mm, pan-head, nylon-coated (4) Silver 0.245 Nm (2.5 kgfcm) Remove the LCD cable assembly from the LCD panel. 8 Removing and replacing a FRU Lenovo 3000 V100 and V200 83[...]

2050 Wireless LAN antenna cables For access, remove these FRUs in or der: v “1010 Battery pack” on page 46 v “1060 PCI Express Mini Car d slot cover and PCI Express Mini Card for 802.1 1 a/b/g wireless LAN” on page 51 v “1070 PCI Express Mini Car d slot cover and PCI Express Mini Card 802.1 1 a/b/g/n wireless LAN” on page 52 v “1090 M[...]

For the antennas with three cables 2 2 3 4 2 1 1 2 Step Screw (quantity) Color T orque 2 M2 × 4 mm, pan-head, nylon-coated (4) Silver 0.245 Nm (2.5 kgfcm) Cable routing: Route the cables as shown in the following figure. Removing and replacing a FRU Lenovo 3000 V100 and V200 85[...]

Locations Front view 1 Integrated camera (for some models) 2 Power switch 3 Lenovo Care button 4 Instant on button 5 V olume control buttons 6 Keyboard 7 Fingerprint reader (for some models) 8 T ouch pad 9 T ouch pad buttons 10 System and power status indicators Note: For the description o[...]

Rear view 1 USB connector 2 AC power connector 3 USB connector 4 RJ-45 (Ethernet) connector 5 RJ-1 1 (modem) connector 6 Optical drive 7 W ireless radio switch 8 5-1 Digital Media Reader 1 2 3 4 5 6 7 8 Bottom view 1 Battery pack latch 2 Battery pack 3 PCI Express Mini car d slot [...]

Parts list v Each FRU is available for all types or models, unless specific types or models are specified. v FRU with specific models listed and described as xxU (where U is an example of a country designator) should be used for all models ending in U. v FRU with specific models listed and described as 3Dx (where 3D is an example of a unique config[...]

Overall 1 3 2 4 5 6 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 b c 8 9 a 7 Parts list Lenovo 3000 V100 and V200 89[...]

No. FRU FRU no. RoHS ID CRU ID a - c See “Miscellaneous parts” on page 1 14. 1 LCD unit (see “LCD FRUs” on page 101.) 2 Hinge caps 41W6375 R N 3 Middle cover 41W6374 R N 4 Keyboard (see “Keyboar d” on page 103.) 5 Launch board for MT 0763 41W1333 R N Launch board for MT 0764 41R7645 R N 6 Keyboard bezel assembly without a fingerprint r [...]

No. FRU FRU no. RoHS ID CRU ID 8 Bluetooth daughter card (BDC) v 0763-22x, 23x, 25x, 26x, 27x, 29x, 34x, 36x, 38x, 43x, 44x, 46x, 49x, 62x, 64x, 66x, 68x, 69x, 82x, 83x, 84x, 86x, 88x, 89x, 99x, A2x, A3x, A4x, A5x, A6x, A8x, B3x, C2x, C4x, C6x, C7x, C8x, C9x, E2x, E3x, E4x, E5x, E6x, E8x, G2x, J8x, J9x, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Px, 2Qx, 2Rx, [...]

No. FRU FRU no. RoHS ID CRU ID 10 System board assembly , 12W integrated v 0763- 2Lx, 2Mx, 2Ux, 2Vx, 2Wx 2Xx, 3Lx, 3Mx, 3Nx, 4Jx, 4Kx, 4Nx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 5Kx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 5Wx, 5Xx, 5Yx, 5Zx, 6Jx, 6Kx 42W7671 R N System board assembly , 12W integrated v 0764-22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x[...]

No. FRU FRU no. RoHS ID CRU ID 14 Intel PRO W ireless 3945ABG Mini-PCI Expr ess Adapter v 0763-22x, 23x, 25x, 26x, 27x, 29x, 36x, 38x, 43x, 44x, 46x, 49x, 62x, 64x, 66x, 68x, 69x, 82x, 83x, 84x, 86x, 88x, 89x, 97x, 99x, A2x, A3x, A4x, A5x, A6x, A8x, B3x, B7x, C2x, C3x, C4x, C6x, C7x, C8x, C9x, E2x, E3x, E4x, E5x, E8x, G2x, G3x, G7x, J5x, J7x, 2Px, [...]

No. FRU FRU no. RoHS ID CRU ID 14 ThinkPad 1 1a/b/g/n W ireless LAN Mini-PCI Express Adapter v 0763-2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Sx, 4Cx, 4Hx, 5Dx, 5Fx, 6Cx, 6Ex, 6Fx, 6Hx, 7Dx, 7Fx, 7Gx, 2Vx, 3Nx, 4Kx, 4Tx, 4Ux, 4Vx, 4Xx, 4Yx, 4Zx, 5Mx, 5Nx, 5Qx, 5Rx, 5Sx, 5Tx, 5Ux, 6Jx xxA, xxB, xxF , xxG, xxH, xxL, xxM, xxP , xxQ, xxS, xxU, xxY 42T0825 R ** xx[...]

No. FRU FRU no. RoHS ID CRU ID 16 S ATA hard disk drive, 60 GB, 9.5 mm, 5,400 rpm, T oshiba v 0763-36x, 65x, 69x, 82x, 99x, A3x, B3x, C3x, C6x, C8x, E4x, E6x, J5x, 2Gx, 4Bx, 2Xx 27R2389 R ** S ATA hard disk drive, 60 GB, 9.5 mm, 5,400 rpm, HGST v 0763-36x, 65x, 69x, 82x, 99x, A3x, B3x, C3x, C6x, C8x, E4x, E6x, J5x, 2Gx, 4Bx, 2Xx v 0764-22x 27R2381 [...]

No. FRU FRU no. RoHS ID CRU ID 16 S ATA hard disk drive, 100 GB, 9.5 mm, 5,400 rpm v 0763-27x, 29x, 43x, 44x, 46x, 64x, 68x, A2x, A6x, A8x, G2x, J9x, 2Cx, 2Dx, 2Ex, 2Fx, 3Cx, 3Dx, 5Cx, 5Dx, 5Gx, 5Hx, 5Jx, 6Cx, 6Fx, 4Rx, 4Sx, 4Vx, 4Xx, 4Zx, 5Zx HGST 27R2385 R ** T oshiba 27R2393 R ** S ATA hard disk drive, 100 GB, 9.5 mm, 5,400 rpm, Fujitsu v 0763-2[...]

No. FRU FRU no. RoHS ID CRU ID 19 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card OP v 0763-22x, 23x, 25x, 26x, 27x, 33x, 34x, 36x, 38x, 46x, 49x, 59x, 62x, 64x, 65x, 66x, 68x, 69x, 77x, 82x, 83x, 84x, 85x, 86x, 88x, 89x, 93x, 97x, 99x, A2x, A3x, A4x, A5x, A6x, A8x, B3x, C2x, C3x, C4x, C5x, C6x, C7x, C8x, C9x, D5x, D9x, E2x, E3x, E4x, E5x, E6x,[...]

No. FRU FRU no. RoHS ID CRU ID 22 Battery pack, Li-ion (6 cell), Sony v 0763-27x, 29x, 34x, 36x, 38x, 43x, 44x, 49x, 62x, 64x, 66x, 68x, 69x, 77x, 82x, 83x, 85x, 86x, 88x, 93x, A2x, A3x, A5x, A6x, A8x, B7x, C2x, C4x, C6x, E4x, E8x, G2x, G7x, G9x, J3x, J5x 92P1222 R * Battery pack, Li-ion (6 cell), Sanyo v 0763-27x, 29x, 34x, 36x, 38x, 43x, 44x, 49x[...]

No. FRU FRU no. RoHS ID CRU ID 24 CPU assembly , Intel Cor e Solo processor T1300 (1.66 GHz) (667 MHz) v 0763-33x, 34x, 36x, 59x, 77x, 93x, 97x, 99x, B3x, B7x, D9x, F3x 41W1 140 R N CPU assembly , Intel Cor e Duo processor T2050 (1.6 GHz) (667 MHz) v 0763-J8x 41W1461 R N CPU assembly , Intel Cor e Duo processor T2250 (1.73 GHz) (667 MHz) v 0763-J9x[...]

No. FRU FRU no. RoHS ID CRU ID 24 CPU assembly , Intel Cor e 2 Duo processor T7100 (1.83 GHz) v 0764-22x, 23x, 26x, 28x, 29x, 2Bx, 2Lx, 2Mx, 42x, 43x, 44x, 45x, 46x, 4Cx, 4Dx, 4Ex, 4Fx, 4Jx, 4Lx, 4Mx, 4Px, 4Qx, 4Rx, 4Tx, 4Ux 42W7654 R N CPU assembly , Intel Cor e 2 Duo processor T7200 (2.0 GHz) v 0763-2Hx, 2Rx, 3Dx, 4Ax, 4Cx, 5Jx, 5Dx, 7Dx, 7Ex, 2U[...]

LCD FRUs 1 2 3 4 6 7 8 5 Parts list Lenovo 3000 V100 and V200 101[...]

12.1-in. WXGA TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel 41W6369 R N 2 LCD panel, 12.1-in. WXGA AG, Samsung 13N7184 R N LCD panel, 12.1-in. WXGA AG, AUO 13N7182 R N LCD panel, 12.1-in. WXGA AG, CMO 13N7180 R N 3 Inverter card 41W1322 R N 4 LCD cable assembly , for no-camera v 0763-23x, 25x, 27x, 29x, 33x, 43x, 49x, 59x, 65x, 69x, 77x, 83x[...]

Keyboard Keyboard for MT 0763 Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 39T7368 39T7432 R N Belgian 39T7365 39T7429 Chinese, T raditional 39T7379 39T7443 Czech 39T7373 39T7437 Danish 39T7362 39T7426 Dutch 39T7359 39T7423 English, U.K. 39T7357 39T7421 English, U.S. 39T7353 39T7417 English, U.S. (International, with a Euro symbol) 39T738[...]

Keyboard for MT 0764 Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 42T3353 42T3418 R N Belgian 42T3350 42T3415 Chinese, T raditional 42T3364 42T3429 Czech 42T3358 42T3423 Danish 42T3347 42T3412 Dutch 42T3344 42T3409 English, U.K. 42T3342 42T3407 English, U.S. 42T3338 42T3403 English, U.S. (International, with a Euro symbol) 42T3368 42T3433[...]

Recovery discs Windows XP Professional CDs W indows XP Professional is pr einstalled as the operating system in the following models: v 0763-22x, 23x, 27x, 29x, 43x, 44x, 46x, 49x, 84x, 88x, 89x, A3x, A6x, B3x, C4x, D5x, E5x, E8x, F3x, G2x, J3x, J5x, J7x, 2Dx, 2Fx, 2Hx, 2Rx, 3Dx, 3Fx, 3Hx, 4Ax, 4Cx, 4Ex, 4Fx, 4Hx, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Gx, 5Jx,[...]

Windows XP Home Edition CDs W indows XP Home Edition is preinstalled as the operating system in the following models: v 0763-25x, 26x, 33x, 34x, 36x, 38x, 59x, 62x, 64x, 65x, 66x, 68x, 69x, 77x, 82x, 83x, 85x, 86x, 93x, 99x, A2x, A4x, A5x, A8x, B7x, C2x, C5x, C6x, C7x, C9x, D9x, E3x, E4x, E6x, E7x, E9x, G7x, G9x, J8x, J9x, 2Cx, 2Ex, 2Gx, 2Px, 2Qx, [...]

Windows V ista Home Premium (32 bit) DVDs for MT 0763 W indows V ista Home Premium is pr einstalled as the operating system in the following models: v 0763-2Lx, 3Nx, 4Jx, 4Nx, 4Vx, 4Zx, 5Wx, 5Xx, 5Zz Language P/N RoHS ID CRU ID Chinese, T raditional 43T7173 R * Chinese, T raditional (Hong Kong S.A.R.) 43T7174 Czech 43T7166 Danish 43T7909 Dutch 43T7[...]

Windows V ista Home Premium (32 bit) DVDs for MT 0764 W indows V ista Home Premium is pr einstalled as the operating system in the following models: v 0764-24x, 2Ax, 2Bx, 43x, 46x, 49x, 4Dx, 4Rx Language P/N RoHS ID CRU ID Bulgarian 44Y0027 R * Chinese, Simplified 44Y0004 Chinese, T raditional 44Y001 1 Chinese, T raditional (Hong Kong S.A.R.) 44Y00[...]

Windows V ista Home Basic (32 bit) DVDs for MT 0763 W indows V ista Home Basic is preinstalled as the operating system in the following models: v 0763-2Xx, 3Lx, 4Sx, 4Tx, 4Ux, 4Xx, 4Yx, 5Kx, 5Px, 5Sx, 5Tx Language P/N RoHS ID CRU ID Chinese, T raditional 43T7127 R * Chinese, T raditional (Hong Kong S.A.R.) 43T7128 Czech 43T7120 Danish 43T7903 Dutch[...]

Windows V ista Home Basic (32 bit) DVDs for MT 0764 W indows V ista Home Basic is preinstalled as the operating system in the following models: v 0764-22x, 44x, 48x, 4Cx, 4Fx, 4Hx, 4Jx, 4Lx, 4Px, 4Ux Language P/N RoHS ID CRU ID Chinese, Simplified 44Y0069 R * Chinese, T raditional 44Y0076 Chinese, T raditional (Hong Kong S.A.R.) 44Y0079 Czech 44Y00[...]

Windows V ista Business (32 bit) DVDs for MT 0763 W indows V ista Business is preinstalled as the operating system in the following models: v 0763-2Mx, 2Ux, 2Vx, 2Wx, 3Mx, 4Kx, 4Rx, 5Mx, 5Nx, 5Qx, 5Rx, 5Ux, 5Yx, 6Jx, 6Kx Language P/N RoHS ID CRU ID Chinese, T raditional 43T7081 R * Chinese, T raditional (Hong Kong S.A.R.) 43T7082 Czech 43T7074 Dani[...]

Windows V ista Business (32 bit) DVDs for MT 0764 W indows V ista Business is preinstalled as the operating system in the following models: v 0764-23x 26x, 27x, 28x, 29x, 2Cx, 2Lx, 2Mx, 32x, 42x, 45x, 47x, 4Ax, 4Bx, 4Ex, 4Mx, 4Nx, 4Qx, 4Tx, 4Zx Language P/N RoHS ID CRU ID Bulgarian 44Y0059 R * Chinese, Simplified 44Y0037 Chinese, T raditional 44Y00[...]

Windows V ista Ultimate (32 bit) DVDs W indows V ista Ultimate is preinstalled as the operating system in the following models: v 0764-25x, 2Dx, 4Gx, 4Kx Language P/N RoHS ID CRU ID Chinese, Simplified 44Y0095 R * Chinese, T raditional 44Y0101 Chinese, T raditional (Hong Kong S.A.R.) 44Y0104 Czech 44Y01 10 Danish 44Y0102 Dutch 44Y0106 English, (UD)[...]

Corel software CDs Language P/N RoHS ID CRU ID English, U.S. 41X0440 R * French 41X0443 Japanese 41X0608 Portuguese, Brazilian 41X0449 Spanish 41X0446 Miscellaneous parts FRU P/N RoHS ID CRU ID Screw kit, (including nylon-coated scr ews) for MT 0763: v M2 × 2 mm (silver), pan-head (4) v M2 × 2.5 mm (silver), pan-head (13) v M2 × 3 mm (silver), p[...]

AC adapters FRU P/N RoHS ID CRU ID 2-pin (65 W, 20 V) adapter (models xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) OP Delta 92P1 155 R * Lite-On 92P1 159 R * Astec 92P1214 R * 3-pin (65W , 20 V) adapter (models xxA, xxB, xxC, xxG, xxH, xxK, xxM, xxQ, xxR, xxT , xxV) OP Delta 92P1 153 R * Lite-On 92P1 157 R * Astec 92P1212 R * Common parts [...]

Power cords A Lenovo 3000 power cord for a specific country or r egion is usually available only in that country or region: For 2-pin power cords: Region P/N (Longwell) P/N (V olex) RoHS ID CRU ID Argentina 42T5020 42T5105 R * Brazil 42T5026 42T51 1 1 Canada, U.S. 42T5008 42T5093 Japan 42T5014 42T5099 For 3-pin power cords: Region P/N (Longwell) P/[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

estimated through extrapolation. Actual r esults may vary . Users of this document should verify the applicable data for their specific environment. T rademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Lenovo Care Rescue and Recovery ThinkPad The following terms are trademarks of the Interna[...]

T rademarks Lenovo 3000 V100 and V200 11 9[...]

Part Number: 42X3554 (1P) P/N: 42X3554[...]