Weed Eater WE12542F manuel d'utilisation

OWNER'S MANUAL MODEL NO. WE12542F 12.5 HP 42 Inch Lawn T ractor For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For T echnical Assistance: call 1-800-829-5886 174193 1.28.00 RD PRINTED IN U.S.A. ®[...]

2 I . GENERAL OPERATION • Read, understand, and follow all instructions in the manual and on the machine before starting. • Only allow responsible adults, who are familiar with the instructions, to operate the machine. • Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade. • Be sure th[...]

3 Look for this symbol to point out important safety precautions. It means CAUTION!!! BECOME ALERT!!! YOUR SAFETY IS IN- VOLVED. CAUTION: In order to prevent accidental starting when setting up, transporting, ad- justing or making repairs, always discon- nect spark plug wire and place wire where it cannot contact spark plug. • Be sure the area is[...]

4 PRODUCT SPECIFICA TIONS GASOLINE CAPACITY 1.25 GALLONS AND TYPE: UNLEADED REGULAR OIL TYPE (API-SF/SG/SH): SAE 30 (above 32°F) SAE 5W-30 (below 32°F) OIL CAPACITY: 3 PINTS SPARK PLUG: CHAMPION RJ19LM or J19LM (GAP: .030") VALVE CLEARANCE: INTAKE: .005" - .007" EXHAUST: .009" - .011" GROUND SPEED (MPH): FORWARD: 1st 1.1 [...]

5 UNASSEMBLED P ARTS Steering Wheel Steering Wheel Insert (1) Large Flat Washer (1) Locknut 5/16-18 (1) Hex Bolt 5/16-18 x 1-1/4 (1) Hex Bolt 3/8-16 x 1 (1) Lockwasher 3/8 Steering Boot Steering Extension Shaft Steering Wheel Adapter (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge Seat (1) Shoulder Bolt 5/16-18 (2) Keys Slope Sheet Keys (1) Lock Wash[...]

6 ASSEMBL Y TOOLS REQUIRED FOR ASSEMBL Y A socket wrench set will make assembly easier. Standard wrench sizes are listed. (1) 5/16" wrench Pliers (2) 7/16" wrenches Tire pressure gauge (2) 1/2" wrenches Utility knife (1) 9/16" wrench When right or left hand is mentioned in this manual, it means when you are in the operating posi[...]

7 ASSEMBL Y TO ROLL TRACTOR OFF SKID (See Operation section, page 10, for location and function of controls) • Press lift lever plunger and raise attachment lift lever to its highest position. • Release parking brake by depressing clutch/brake pedal. • Place gearshift lever in neutral (N) position. • Roll tractor forward off skid. • Remov[...]

8 ASSEMBL Y CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton. ✓ Battery is properly prepared and charged. (Mi[...]

9 OPERA TION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED REVERSE NEUTRAL HIGH LOW ATTACHMENT CLUTCH ENGAGED MOWER LIFT DAN[...]

10 OPERA TION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Our tractors conform to the safety standards of the American National Standard[...]

11 OPERA TION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. IMPORTANT: LEAVING T[...]

12 OPERA TION TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. • Select desired height of cut. • Start mower blades by engaging attachment clutch control. • TO STOP M[...]

13 OPERA TION MOWING TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are[...]

14 CUST OMER RESPONSIBILITIES BEFORE EACH USE T R A C T 0 R Adjust Motion Drive Belt(s) Tension Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean Battery and Terminals FILL IN DATES AS YOU COMPL[...]

15 CUST OMER RESPONSIBILITIES BLADE REMOVAL (See Fig. 8) • Raise mower to highest position to allow access to blades. • Remove hex bolt, lock washer and flat washer securing blade. • Install new or resharpened blade with trailing edge up towards deck as shown. IMPORTANT: TO ENSURE PROPER ASSEMBLY, CENTER HOLE IN BLADE MUST ALIGN WITH STAR ON [...]

16 CUST OMER RESPONSIBILITIES ENGINE LUBRICATION Only use high quality detergent oil rated with API service classification SF, SG, or SH. Select the oil’s SAE viscosity grade according to your expected operating temperature. TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE SAE VISCOSITY GRADES -20° 0° 30° 40° 80° 100° -30° -20° 0° 20[...]

17 CUST OMER RESPONSIBILITIES AIR FILTER (See Fig. 13) Your engine will not run properly using a dirty air filter. Clean the foam pre-cleaner after every 25 hours of operation or every season. Service paper cartridge every 100 hours of operation or every season, whichever occurs first. Service air cleaner more often under dusty conditions. • Remo[...]

18 CUST OMER RESPONSIBILITIES MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage. SPARK PLUGS Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark plug type and gap setting are shown in “PRODUCT SPEC[...]

19 SER VICE AND ADJUSTMENTS CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key “OFF” and remove key. • Make sure the blades and all moving parts have[...]

20 FIG. 20 SER VICE AND ADJUSTMENTS TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See “PROD- UCT SPECIFICATIONS” section of this manual). If tires are over or underinflated, you will not properly adjust your mower. SIDE-TO-SIDE ADJUSTMENT (See Figs. 16 and 17)[...]

21 SER VICE AND ADJUSTMENTS TO ADJUST BRAKE (See Fig. 21) Your tractor is equipped with an adjustable brake system which is mounted on the right side of the transaxle. If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. • Depress clutch/brake pedal and engage parking brake. • [...]

22 SER VICE AND ADJUSTMENTS INTERLOCKS AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO REPLACE FUSE Replace with 15 amp automotive-type plug-in fuse. The fuse holder is located behind the dash. TO REMOV[...]

23 SER VICE AND ADJUSTMENTS GOVERNOR CONTROL LEVER GOVERNOR CONTROL PLATE THROTTLE CABLE HOLES “A” FIG. 28 TO ADJUST CARBURETOR The carburetor has been preset at the factory and adjust- ment should not be necessary. However, minor adjustment may be required to compensate for differences in fuel, temperature, altitude or load. If the carburetor [...]

24 STORAGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure. TRACTOR Remove mower from tracto[...]

25 TROUBLESHOOTING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/replace air filter. 6. Dirty fuel filter. 6[...]

26 TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Engine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not when operator leaves corrected, contact an authorized service center/ seat with attachment department. clutch engaged Poor cut - uneven 1. Worn, bent or loose blade. 1. Repla[...]

27 TRACT OR - - MODEL NUMBER WE12542F SCHEMA TIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED BLACK ORANGE BLACK BROWN BLACK BLACK BLACK STARTER M SEAT SWITCH (NOT OCCUPIED) GROUNDING CONNECTOR ATT'MENT CLUTCH (CLUTCH OFF) CLUTCH / BRAKE (PEDAL UP) SOLENOI[...]

28 28 29 26 24 42 43 27 27 25 41 27 27 40 33 30 8 2 1 27 48 16 16 22 21 REP AIR P ARTS TRACT OR - - MODEL NUMBER WE12542F ELECTRICAL 52[...]

29 1 144925 Battery 12 Volt 25 Amp 2 74760412 Bolt Hex Hd 1/4-20unc X 3/4 8 156417 Case Battery Mech Hiinge 1 6 153664 Switch Interlock Push-In 2 1 166181 Harness Asm Light W/4152j 2 2 4152J Bulb Light #1156 2 4 4799J Cable Battery 6 Ga 11"red 2 5 146147 Cable Battery 2 6 166180 Fuse 15 AMP 2 7 73510400 Nut Keps Hex 1/4-20 Unc 2 8 4207J Cable [...]

30 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F CHASSIS 3 2 35 3 26 35 3 26 33 10 34 1 208 11 17 29 28 208 13 12 51 57 53 52 54 55 24 26 25 26 25 3 31 24 30 3 8 3 6 16 9 15 209 209 5 5 58 145 37 37 18 206 3 3 38 38 212[...]

31 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F CHASSIS KEY P ART N O . NO . DESCRIPTION NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm. 1 169831 Chassis 2 169061 Drawbar, Stretch 3 17060612 Screw 3/8-16 x 3/4 5 155272 Bumper, Hood/Dash 6 155924X011 Saddle Silkscreen Flt Sdl 8 155138 Clip Retainer Slide-On 9 168347X011 Das[...]

32 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F DRIVE 29 28 112 14 41 42 40 38 42 39 57 51 42 51 74 75 78 76 77 25 19 24 2 53 35 34 37 36 35 62 36 64 65 59 56 51 72 55 63 116 70 77 61 22 27 26 6 113 18 51 5 18 6 52 30 32 32 30 52 11 204 170 21 4 3 13 10 8 12 12 7 61 61 1 145 96 26 79 52 66 27 51 150 48 151 202 49 26 47 50 51[...]

33 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F DRIVE KEY P ART N O . NO . DESCRIPTION KEY P ART N O . NO . DESCRIPTION 1 - - - - - - - Transaxle Peerless Model 205-544c (Order parts from transaxle manufacturer) 2 146682 Spring Return Brake 3 123666X Pulley Transaxle 18"tires 4 12000028 Ring Retainer # 5100-62 5 121520X Strap Torque 30 Deg[...]

34 62 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 18 19 22 27 23 40 66 29 25 79 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 17 26 30 28 1 41 42 37 36 37 38 63 11 39 11 80 68 67 67 67 13 65 85 85 68 15 15 15 29 29 82 REP AIR P ARTS TRACT OR - - MODEL NUMBER WE12542F STEERING[...]

35 1 140044 Wheel Steering Ayp/P/L Blk 2 154427 Axle Asm 3 169840 Spindle Asm LH 4 169839 Spindle Asm RH 5 6266H Bearing Race Thrust Harden 6 121748X Washer 25/32 X 1-5/8 X 16 Ga 7 19272016 Washer 27/32 X 1-1/4 X 16 Ga 8 12000029 Ring Klip #t5304-75 9 3366R Bearing Col Strg Blk 1 0 169832 Link Drag 1 1 10040600 Washer Lock Hvy Hlcl Spr 3/8 1 3 1365[...]

36 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 44 46 32 31 33 37 33 40 62 13 4 72 78 81 3 14 38 15 16 78 23 45 REP AIR P ARTS TRACT OR - - MODEL NUMBER WE12542F ENGINE[...]

37 KEY P ART N O . NO . DESCRIPTION 1 140310 Control Th/ch Flag 2 17720410 Screw Hex Thd Cut 1/4-20x5/8 T 3 - - - - - - - - Engine, B&S 289707 (Order parts from engine manufacturer) 4 137348 Muffler Exhaust B&S Lc 1 3 165291 Gasket Eng 1 313 Id Tin Plated 1 4 13280324 Nipple Pipe 3/8 Npt X 3" 1 5 13200300 Elbow Std 90 Degree 3/8-18 Npt[...]

38 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F SEA T KEY P ART N O . NO . DESCRIPTION 1 127426X Seat 2 140551 Bracket Seat Pivot 3 71110616 Bolt Hex 3/8 - 16 X 1 4 19131610 Washer 13/32 X 1 X10Ga. 5 145006 Clip Push-In Hinged 6 73800600 Nut Lock Hex w/Ins 3/8 - 16 7 124181X Spring Seat Cprsn 2 250 Blk Zi 8 17000616 Screw 3/8-16 x 1.5 9 1913161[...]

39 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F DECALS 5 7 12 17 14 5 16 6 15 3 KEY P ART N O . NO . DESCRIPTION 1 101892X Decal, Clutch/Brake Eng/Fr 3 170839 Decal, Engine HP 4 137259 Decal Warning 5 162458 Decal, Pnl Sd 6 157140 Decal, Fender Danger English 7 162398 Decal Ins Str Wh 9 171448 Decal Fender 1 0 162391 Decal, Deck Grasseater 1 1 [...]

40 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F MOWER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13[...]

41 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F MOWER LIFT 1 159460 Wire Asm Inner/Sprg w/plunger 2 159471 Shaft Asm Lift RH 3 105767X Pin Groove 1 500 Zinc 4 12000002 E Ring #5133-62 5 19211621 Washer 21/32 X 1 X 21 Ga 6 120183X Bearing Nylon Blk 629 Id 7 109413X Grip Handle Bicycle Matte Blk 8 124526X Button Plunger Black 1 1 139865 Link Lift[...]

42 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F MOWER DECK 15 14 12 128 13 11 10 9 8 16 68 37 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 35 49 50 51 54 52 53 55 56 34 1 46 44 21 22 24 25 26 27 2 28 29 23 21 21 21 18 18 20 2 48 59 19 4 3 5 6 21 40 143 36 40 37 40 159 152 151 153 154 157 158 67 153 156 155[...]

43 REP AIR P ARTS TRACTOR - - MODEL NUMBER WE12542F MOWER DECK KEY P ART N O . NO . DESCRIPTION KEY P ART N O . NO . DESCRIPTION 1 165892 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460 Bracket Asm Deck 42" Sway Bar 5 4939M Retainer Spring 6 130832 Arm, Suspension, Rear 8 850857 Bolt 3/8-24 x 25 Gr[...]

44 SER VICE NOTES[...]

45 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materials and workmanship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacin[...]

46 T E C U M S E H ® Issued January 1980 Revised January 1991 T E C U M S E H ® P O L I C Y LIMITED WARRANTIES FOR NEW PEERLESS GEAR POWER TRAIN COMPONENTS A. Products Warranted Peerless Gear and Machine Division of Tecumseh Products Company (“Tecumseh”), subject to the limitations contained below, will, at its option, repair or replace, with[...]

47 15° MAX. SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. CUT OUT ON DOTTED LINES THIS IS A 15° SLOPE SIGHTING GUIDE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION Operate your Tractor up and down the face of slopes (not greater than 15°), never across the face. Make turns gradu- ally to pre[...]

®[...]