Alliance Laundry Systems UX OPL manuale d’uso

www .comlaundry .com CFS462N Par t No. 9001900 December 2005 Ser vice W asher -Extractor Cabinet Freestanding HX, SX and UX OPL Models Refer to P age 8 for Model Numbers[...]

[...]

9001900 1 © Copyr ight 2005, A lliance Laundry Systems LLC All righ ts reserv ed. No part of the con tents of this book may be reprod uced or transm itted in an y form or b y any m eans withou t the expressed writ ten consent of the pu blisher . © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Table of Contents Section 1[...]

2 9001900 © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT[...]

9001900 3 © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Section 1 Safety Information Throughout this manua l and on mach ine decals, yo u will f ind preca utionary statements ( “CA UTION, ” “W ARNING, ” and “D ANGER”) fol lo wed by specif ic in structions . These prec autions are intended f or the pe rsonal[...]

4 9001900 Section 1 Sa fety Inf ormation © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Alwa ys contac t your dea ler , distrib utor , service a gent or the man ufact urer about any problems or conditi ons you do not u nderstand. Important Safety Instructions 1. Read all instruc tions before using the washer-ex tractor.[...]

9001900 5 Section 1 Sa fety Inf ormation © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 6. Do not al low chil dren to p lay on or in a washer -extrac tor. Close su pervisio n of chi ldren is necessary when the washer-e xtracto r is used near childre n. 7. Before t he washer-ext ractor is r emoved from ser vice or disca [...]

6 9001900 Section 1 Sa fety Inf ormation © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Locating an Auth orized Service r Allianc e Laundry Sys tems is not r esponsibl e for persona l injury or proper ty damage re sulting fr om improper servic e. Re vie w all ser vice inf ormation b efore be ginnin g repairs . W arranty[...]

9001900 7 © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Section 2 Introduction Customer Service Allianc e Laundry Syste ms is not r esponsible f or personal injury or propert y damage re sulting fro m impro per service. Re vie w all s ervice i nformation befo re beginn ing repairs . If li teratu re o r rep lace men t p[...]

8 9001900 Section 2 I ntroducti on © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Model Identification Infor ma tion in thi s man ual is app lica ble to the se wa she r-extracto rs. HX18PVQM6 HX18PVQU6 HX18PVXM6 HX18PVXU6 HX25PVQM6 HX25PVQU6 HX25PVXM6 HX25PVXU6 HX35PVQM6 HX35PVQU6 HX35PVXM6 HX35PVXU6 HX55PVNU6 HX55PVQU6[...]

9001900 9 T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when applicab le) bef ore servicing it. • Ne ver start the washer-e xtractor with an y guar ds/panels remo ved.[...]

10 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 1. WE-8 CONTROL HAS NO VISIBLE DISPLAY (P AND N-VOLTAGE MODELS) Is there voltage (200-240 Volts) out of the control transformer? Is there voltage (3 8 0-4 8 0 Volts) into the control transformer? The WE- 8 control has no visible displ[...]

9001900 11 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

12 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT WE-8 Cont rol Has No Vis ible Display (P and N-V o ltage M odels) (She et 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne. 7 6 5 4 4 3 2 1[...]

9001900 13 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT WE-8 Cont rol Has No Vis ible Display (P and N-V o ltage M odels) (She et 2 of 2) CFD3 S 063787600D[...]

14 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 2. WE-8 CONTROL HAS NO VISIBLE DISPLAY (Q AND X-VOLTAGE MODELS) Is there Voltage (120 Volts) into and out of the 3.15 Amp fuse? NO YES NO Reset and return (either by pulling or by twisting and pulling) the E-stop switch. If, after res[...]

9001900 15 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

16 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT WE-8 Co ntrol Has No Visible Dis play (Q and X-V oltage Models ) (Sheet 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne. 6[...]

9001900 17 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT WE-8 Co ntrol Has No Visible Dis play (Q and X-V oltage Models ) (Sheet 2 of 2) CFD5 S 3 3.15 A 4 5 3 1 2[...]

18 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 3. NO FILL ANALYSIS CFD18 S NO NO Check the wiring between the main board and the water valve that has been programmed to turn on. Repair or replace the wiring as needed. Note: There may be a modular connector between the wire and the[...]

9001900 19 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

20 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Fill Analysis (Sheet 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne.[...]

9001900 21 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Fill Analysis (Sheet 2 of 2) CFD1 9S 1 Hot Fill X18 - 75 3 2 2 3 3 3 3 3 1 Cold Fill X18 - 75 1 Hot Fill X100 - 135 1 Cold Fill X100 - 135[...]

22 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 4. WATER RUNS CONTINUOUSLY INTO THE WASHER-EXTRACT OR CFD20 S 1 T urn the main power to the machine off. Does the water shut off? 2 YES Clean the valve or install a repair kit inside the valve if av ailable. If a repair kit isn ’ t [...]

9001900 23 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

24 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT W ater Runs Cont inuously into the Washer-Extractor (S heet 1 of 2 ) NOTE: Refer to the wiring diagram supplied wi th your machi ne.[...]

9001900 25 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT W ater Runs Cont inuously into the Washer-Extractor (S heet 2 of 2 ) CFD21 S 2 1 1[...]

26 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 5. DOOR LOCK SWITCH ANALYSIS: DISPLAY SHOWS “DOOR ERROR” CFD1 99 3 S 1 The display reads “door error”. Check the wiring from the door terminal on the main board to the mole x plug (75-165 models only) and from the mole x plug [...]

9001900 27 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

28 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Door Lock Swit ch Analysis: Display Sh ows “Door Er ror” (Sheet 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne.[...]

9001900 29 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Door Lock Swit ch Analysis: Display Sh ows “Door Er ror” (Sheet 2 of 2) CFD1 99 4 S UX75 1 2 3[...]

30 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 6. DOOR LOCK SWITCH ANALYSIS: DISPLAY READS “PLEASE CLOSE DOOR” YE S 1 The display reads “ Please Close Door ” . Is the door closed? 2 Close the door . NO Check the orange/white and white/brown wires fr om the door terminal on[...]

9001900 31 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

32 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Door Lock Switch Analysis: Displa y Reads “Please Close Door” (Sheet 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne.[...]

9001900 33 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Door Lock Switch Analysis: Displa y Reads “Please Close Door” (Sheet 2 of 2) CFD1 99 6 S UX75 1 1 2[...]

34 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 7. DOOR LOCK SWITCH ANALYSIS: “DOOR WO N’T UNLOCK” 1 The display reads “ Please Open the Door ” , but the door can't be opened. 2 NO Check the black and white wires from the door terminal on the main board, through the [...]

9001900 35 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

36 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Door L ock Switch Analysis: “Door W on’t Unlock” (She et 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne.[...]

9001900 37 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Door L ock Switch Analysis: “Door W on’t Unlock” (She et 2 of 2) CFD1 99 8 S UX75 1 1 3 2 3[...]

38 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 8. NO OUTPUT VOLTAGE TO COMPONEN TS Figure 1 Component V oltage Reading P oints V oltage Reading Wa t e r Flush A Clear wire to Blue wire 220 V olts AC Hard Fill White/Black wire to Blue wire 220 V olts AC Hot Fill Red wire to Blue wi[...]

9001900 39 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

40 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Ou tput V olta ge to Co mpon ents ( She et 1 of 2 ) NOTE: Refer to the wiring diagram supplied wi th your machi ne. 1 2 2 2 2 1[...]

9001900 41 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Ou tput V olta ge to Co mpon ents ( She et 2 of 2 ) CFD2001 S UX75 2 2 2 2 2 2 2 1 1 1 1[...]

42 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 9. NO MOTOR OPERATION WITH NO AC DRIVE FAULT CFD2002 S 1 The motor does not operate and there are no apparent A C drive faults present. For single-phase models, is there volta ge (200 V olts AC) from L1 to L2 on the A C drive? For 3-p[...]

9001900 43 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

44 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Motor Operation With No A C Drive F ault (Sheet 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne. 1 1 1 2 2 2[...]

9001900 45 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Motor Operation With No A C Drive F ault (Sheet 2 of 2) CFD2003 S UX75 3 3[...]

46 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 10. NO MOTOR OPERATION WITH AC DRIVE FAULT NO Symptom: The Motor Is Not Running And There Is An Apparent AC Drive Fault Present. YES Install a parameter unit and find the AC drive fault present. Refer to the “no motor operation (wit[...]

9001900 47 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT No Motor Operation W ith AC Drive Fault Operation Pane l Indication Name Description an d NO TES Check point Correctiv e action Overcurrent shut-off during accele ration When the in verter output cu rrent reaches o r exceeds app roxim[...]

48 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Brak e tra nsis tor alarm dete ction If a brake transistor fault occu rs due to excessiv ely large reg enerativ e energy from the motor, for example , that fa ult is dete cted to stop the in ver ter output. In this case, th e in verte[...]

9001900 49 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Output ph ase failure prote ction This func tion stops the in verter output if o ne of the three phases (U, V , W) on the inv erter's outpu t side (load side) results in open p hase. • Check the wiring (Check the motor for a fa[...]

50 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 11. THE MOTOR IS RUNNING, BUT AT AN ABNORMAL SPEED Prelimina ry Checks: a. Check all elec trical connect ions betw een the “FREQ” plug on the mai n board and the AC drive . Refer to the schema tic supplie d with the machine for wi[...]

9001900 51 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 12. NO SPIN NO NOTE: While performing this check, make sure that the washer-extractor is running with a normal-size load. YES When the WE- 8 computer is engaged in a high-speed extract (e.g., spin 1, spin 2, spin 3 or spin 4), is the [...]

52 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 13. MACHINE DID NOT FILL ALARM ANALYSIS CFD1 9 8 9S 1 Is there water coming in through the water supply lines? IS there volta ge (220 V olts) at the respective water valve that should be turning on? Check the main water v alve shut-of[...]

9001900 53 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

54 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Machine Did No t Fill Alar m Analysis (Sh eet 1 of 2 ) NOTE: Refer to the wiring diagram supplied wi th your machi ne. 2 1 1 3 3 4 2[...]

9001900 55 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Machine Did No t Fill Alar m Analysis (Sh eet 2 of 2 ) CFD1990 S 063787600D[...]

56 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 14. EMPTY ALARM ANALYSIS CFD1 99 1 S 1 Check the drain v alve and drain plumbing for bloc kage. The display reads “ DID NO T EMPTY . ” Is there volta ge (220 V olts) at the drain valve? Is there volta ge (220 V olts) between the b[...]

9001900 57 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Please refer to the f ollowing 2 pa ges for wiring diagram inf ormation.[...]

58 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Empty Alarm Analysis (She et 1 of 2) NOTE: Refer to the wiring diagram supplied wi th your machi ne. 1 1[...]

9001900 59 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Empty Alarm Analysis (She et 2 of 2) CFD1992 S 063787600D[...]

60 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 15. AUTOMATIC SUPPLY D ISPENSER ANALYSIS Run P rog ram 38 . Run the cycl e and, with the respec tive suppl y on the main disp lay, refer to the foll owing chart for the functi on that sh ould be occ urring: Cycle 38 Suppl y Setup Cycl[...]

9001900 61 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT During ea ch step, t est for volt age (220 Vol ts) betwe en each respe ctive sup ply termin al and the common term inal on the supp ly t ermin al b oard . Term in al 14 i s th e com mon termi nal for t he pum ps. The suppl y terminal [...]

62 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 16. NO KEYPAD BOARD FUNCTIONS Does the display change, indicating that the computer has gone into the cycle that has been selected (e.g., does the “NEXT09” display change to “STEP 01 CYCLE09” “HOT LOW”)? YES Press the star[...]

9001900 63 Section 3 T ro ubleshooti ng © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 17. EXCESSIVE CYCLE TIME When exper iencing exces sive cycl e time, there a re three mai n causes whic h are as follo ws: a. Fill Ti me: (1) C heck for exc essively long fil l times. Refer to the “F ill Alarm An alysis” fl owchart[...]

64 9001900 Section 3 T roub leshootin g © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 18. EXCESSIVE VIBRATION AND/OR NOISE DURING SPIN When exper iencing exces sive vibra tion and/or noi se during a s pin cycle, there are t hree main cau ses, whic h ar e as fo llo ws : a. Improper Loadi ng: (1) Alw ays m ake sure tha t[...]

9001900 65 T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when applicab le) bef ore servicing it. • Ne ver start the washer-e xtractor with an y guar ds/panels remo ved[...]

66 9001900 Section 4 Se rvice Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when [...]

9001900 67 Section 4 Service Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT Cycle 39 — T est Program Step Description Min:sec Step Definitio n Corrective Action 1 Cold Fill to High Le vel 0:30 The machine s hould fill with cold water to high lev el within 30 seconds and, when it does, a b uzzer will sound.[...]

68 9001900 Section 4 Se rvice Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT 21 Auxiliary 1 0:05 N/A N/A 22 Auxiliary 2 0:05 N/A N/A 23 Auxiliary 3 0:05 N/A N/A 24 150° F Fill to High Le vel 5:00 The water shou ld reach 150°F and the machine should fill to high lev el within 5 minutes and, when it d oes, a[...]

9001900 69 Section 4 Service Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when a[...]

70 9001900 Section 4 Se rvice Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when [...]

9001900 71 Section 4 Service Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when a[...]

72 9001900 Section 4 Se rvice Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when [...]

9001900 73 Section 4 Service Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when a[...]

74 9001900 Section 4 Se rvice Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when [...]

9001900 75 Section 4 Service Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when a[...]

76 9001900 Section 4 Se rvice Pr ocedures © Copyright, Alliance Laundr y S ystems LLC – DO NO T COPY or TRAN S MIT T o reduce the risk of electrical shoc k, fire, e xplosion, serious inj ury or death: • Disconnect electrica l power to the washer -extractor bef ore servicing it. • Close the gas shut- off valve to the washer -e xtractor (when [...]