Char-Broil 42804468 manuale d’uso

FOR OUTDOOR USE ONL Y If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your appliance online at www .charbroil.com/register 1-800-241-7548 CA UTION: Read and follow all warnings and instructions before assembling and using the appliance. INST ALLER/ASSEMBLER: L[...]

D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury . WARNING W ARNING: Indicates an potentially hazardous situation which, if not av[...]

WARNING CALIFORNIA PROPOSITION 65 1. Combustible by-products produced when using this product contains chemicals known to the State of California to cause cancer , birth defects, or other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer , birth defects or othe[...]

Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry . Separate: Separate raw meats and poultry from ready-to-eat foods to avo[...]

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death. • If you s[...]

WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto . (Refer to assembly section.) 2. T urn all control knobs to the OFF position. 3. T urn LP cylinder OFF by turning hand-wheel clockwise [...]

6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: If you cannot complete the connection, discon[...]

24” 3 ft. 3 ft. WARNING CA UTION • Putting out grease fires by closing the lid is not possible. This a ppliance is well ventilated for safety reasons. • Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off. • Do not leave appliance unattended while burning off food residue.[...]

CA UTION If ignition does NOT occur in 5 seconds, turn the control knob OFF , wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury . T urn control knob and LP cylinder OFF when not in use. WARNING Ignitor Light[...]

Cleaning the Burner Assembly (Continued) 9. Clean inner burner as recommended below , shown E . We suggest three ways to clean the burner tube. Use the one easiest for you. (A) Bend a stiff wire (a light weight coat hanger works well) into a small hook. Run hook through burner tube several times. (B) Use a narrow bottle brush with a flexible handle[...]

This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer-pur chaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*. The m[...]

P ARTS DIAGRAM Key Qty Description A 1 Outer Body B 1 Inner Body C 1 Body T op Ring D 1 Burner E 1 Heat Shield F 1 Ignition Kit G 1 Logo Plate H 1 Cooking Chamber I 1 Roaster Basket J 2 Side Handles K 3 Handle Springs L 1 Control Panel Key Qty Description M 1 Ignitor Knob N 1 Control Knob O 1 T op Lid P 4 Leg Assembly Q 1 Grease T ray R 2 Grease T [...]

ASSEMBL Y 2 1 T ools required for assembly: Phillips Screwdriver (Not Supplied); Small Adjustable W rench (Not Supplied) • Carefully turn the unit upside down. Slide Heatshield into place over the exposed burner tube. • Align hole in Heat Shield with end of Burner T ube Heat Shield in Position • While holding the Heat Shield in place, slide t[...]

Ignitor Wire The windshield is held in place once the legs are attached. 3 • The ignitor wire is factory installed to the ignitor . Pass the loose end of the wire through the hole in the body , shown Figure A • Place Windshield inside the bottom of the body . NOTE: Fasteners are not required for the windshield. . Figure B Grease T ray Rail Wind[...]

4 • Install legs by engaging leg tabs over bottom edge of the appliance body . • • Slide the grease tray into the rear of the unit. • Once the leg is in place, attach two #10-24x1" screws through the leg and into the appliance body . • Repeat for the remaining legs. When all four legs are securely installed, carefully turn the unit u[...]

Page 16 Qty: 8 #10-24x3/8" Screw Qty: 4 #10-24 Keps Nut Qty: 8 Fiber W asher 7 • Attach the hinges to the lid inserting a #10-24x3/8" screw into hinge, install a fiber washer onto screw , align lid onto screw , install fiber washer from inside the lid, and finally secure with a #10-24 Keps nut. Repeat for opposite hinge. Shown A . #10-2[...]

Accessory Use and Storage Cooking Basket NOTE: Before cooking on your appliance for the first time, refer to the separate Cooking Guide on how to prepare the appliance for cooking. It is recommended that you season your appliance prior to cooking . • Once seasoning is complete, the appliance is now ready for use. The cooking chamber will continue[...]

Half Rack Storage Accessory Use and Storage Accessory storage Accessory items such as the cooking grate, smoker box and half racks can be stored on board the Smoker , Roaster, & Grill as shown. Hanging hooks Hole Cooking Grate Storage Smoker Box Storage Slot Smoker Box The Smoker Box has a clip that secures it into one of the four vent holes on[...]

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Grease fire or cont[...]

T roubleshooting ( continued ) Possible Cause • Rotary knob rotates without clicking. • Sparking between ignitor and electrode. • See “GAS ISSUES:” on previous page. • Match will not reach. • Improper method of match-lighting. • Out of gas. • Excess flow valve on regulator tripped. • V apor lock at coupling nut/LP cylinder conne[...]

Notes Page 21[...]

Notes Page 22[...]

[...]

REGTEMP REV00 Page 24[...]