Desa (V)K42EN manuale d’uso

NA TURAL GAS MODEL (V)K42EN SERIES PROP ANE/LP GAS MODEL (V)K42EP SERIES *Aftermarket: Completion of sale, not f or purpose of resale, fr om the manufacturer . Save this manual for future reference. Save this manual for future reference. For more information, visit www.desatech.com For more information, visit www.desatech.com DIRECT -VENT FIREPLACE[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 2 SAFETY INFORMA TION 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases unless a certified kit is used. 2. For propane/LP fireplace, do not place propane/[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 3 3 5. This fireplace reaches high temperatures. Keep children and adults away from hot surfaces to avoid burns or clothing igni- tion. Fireplace will remain hot for a time after shutdown. Al- low surfaces to cool before touching. 6. Carefully super[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 4 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent fireplace: • The venting system may be routed to the outside of your home in several ways. It may vent through the roof (vertical) or it may vent to [...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 5 5 CLEARANCES Minimum clearances to combustibles for the fireplace are as follows: Back, and sides 0"/mm Perpendicular walls 6" (152mm) Floor 0"/mm Ceiling to louver opening 42" (1067mm) Front 36" (914mm) Top 0"/mm Ven[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 6 Fixed Closed Openable Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porc[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 7 7 These models are tested and approved for use with DESA (direct- vent) pipe components and terminations. The venting system must terminate on the outside of the structure and can not be attached to a chimney or flue system serving a separate soli[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 8 INSTALLATION PLANNING There are two basic types of direct-vent installation: • Hor iz ontal T er mina tion • V er tical T er mina tion Horizontal Termination Installation IMPORTANT: Horizontal square terminations require only inner portion of [...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 9 9 WARNING: Do not recess vent termination into any wall. This will cause a fire hazard. 6. Noncombustib le Exterior Wall: Position the horizontal vent cap in the center of the 8 1 / 2 " round hole and attach to the exte- rior wall with four w[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 10 V ertical (V) Horizontal (H) 36 3 / 4 " 17" max. Horizontal High Wind Square Termination Wall Firestop 45 ° Elbow Figure 14 - Horizontal Termination Configuration for Square or Round Termination 45 ° Elbow Wall Firestop Horizontal Rou[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 11 11 Required V ertical (V) V ertical Pipe Horizontal (H) *46 1 / 4 " min. None 30" max. 57 1 / 4 " min. 1 ft. 48" max. 69 1 / 4 " min. 2 ft. 60" max. 81 1 / 4 " min. 3 ft. 84" max. 93 1 / 4 " min. 4 ft.[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 12 V enting with T wo 90 ° Elbo ws Horizontal (H 1 ) + V ertical (V) Horizontal (H 2 ) 5' min. 6' max. 6' min. 12' max. 7' min. 18' max. 8' min. 20' max. 20' max. 20' max. 45 ° Elbow V enting with [...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 13 13 INSTALLATION FOR VERTICAL TERMINATION Note: Vertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters, or other framing will obstruct the ventin[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 14 VENTING INST ALLA TION INSTRUCTIONS Continued Vertical Termination Configurations Figures 21 through 24 show four different configurations for verti- cal termination. Figure 21 - Vertical Venting Configuration Using Two 90 ° Elbows with Two Hori[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 15 15 VENTING INST ALLA TION INSTRUCTIONS Continued V er tical V enting V = 40' max. Figure 24 - Vertical Venting Configuration With No Horizontal Run (Vertical Round High Wind Termination Shown) HIGH ALTITUDE INSTALLATION Your DESA direct-vent[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 16 CAUTION: Never touch the blower wheel while in operation. 4. Be certain that all wire terminals are securely attached to ter - minals on blower motor and that the screw retaining the green ground wire is tight. 5. Mount speed control box to switc[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 17 17 V a r i a b l e F a n S w i t c h W h i t e W h i t e B la c k G re e n O n 1 1 0 / 1 1 5 V . A . C . Blower Motor B l a c k B l a c k B la c k O f f Figure 27 - Location of Wiring Diagram Decal (Model May Vary From Illustration) Wiring Diagra[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 18 Figure 29 - Blower Wiring Diagram for Thermostat-Controlled Models Blower Wiring Diagram CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation af[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 19 19 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Installing Gas Piping to Fireplace Location (Cont.) Connecting Fireplace to Gas Supply Checking Gas Connections WARNING: Use pipe joint sealant that is resistant to liquid petroleum (LP[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 20 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Checking Gas Connections (Cont.) Removing/Replacing Glass Door Test Pressures Equal To or Less Than 1/2 PSIG (3.5 kPa) 1. Close equipment shutoff valve (see Figure 33). 2. Pressurize suppl[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 21 21 FIREPLACE INST ALLA TION Continued FIREPLACE INSTALLATION Removing/Replacing Glass Door (Cont.) Installing Optional Brick Liner Models BL42DA(SA), BL42DHA(SA) Removing Glass Door If replacement of glass is necessary, the entire assembly, glass[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 22 WALL SWITCH INSTALLATION The installation of a wall switch allows you to activate the gas control valve and turn the fireplace on and off. The wall switch is to be connected to the incoming 120 volt regular household wiring that supplies the elec[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 23 23 OPTIONAL REMOTE CONTROL INSTALLATION (Model WRC) Note: If using optional wireless hand-held remote control, the wall switch must be in the ON position to be operational. The remote control then becomes the switching mechanism for fireplace ope[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 24 OPERA TING FIREPLACE OPERATING FIREPLACE For Your Safety Read Before Lighting Lighting Instructions To Turn Off Gas To Appliance Optional Remote Operation Figure 47 - Turning Equipment Shutoff Valve to the OFF Position TO TURN OFF GAS TO APPLIANC[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 25 25 OPERATING FIREPLACE Operating Optional Blower Accessory INSPECTING BURNERS Pilot Assembly Burner Flame Pattern OPERA TING FIREPLACE Continued OPERATING OPTIONAL BLOWER ACCESSORY Locate the blower controls by opening the lower louver panel on t[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 26 CLEANING AND MAINTENANCE Glass Door Pilot and Burners Logs Venting System PILOT AND BURNERS • Remove ember material before cleaning burners and replace when cleaning is complete. • Burner and controls should be cleaned with compressed air to [...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 27 27 TROUBLESHOOTING The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2 . Construction debris clogging the pilot and/or gas control valve filter OBSERVED PROBLEM Ignitor will not spark or pilot will not [...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 28 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neigh[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 29 29 (V)K42EN Series (V)K42EP Series Btu 28,000/40,000 Btu/hr 24,000/34,000 Btu/hr Gas Type Natural Propane/LP Ignition Electronic Electronic Manifold Pressure 3.5" w.c. 10.0" w.c. Minimum Inlet Supply Pressure 5.5" w.c. 11.0" w[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 30 ILLUSTRATED PARTS BREAKDOWN Models (V)K42EN, (V)K42ENH, (V)K42EP, (V)K42EPH ILLUSTRA TED P ARTS BREAKDOWN MODELS (V)K42EN, (V)K42ENH, (V)K42EP, (V)K42EPH 6 7 20 17 18 13 2 12 19 8 1 4 11 9 14 3 16 5 10-2 10-1 10-8 10-5 10-4 10-3 10-7 10-9 15 10-6[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 31 31 PARTS LIST Models (V)K42EN, (V)K42ENH, (V)K42EP, (V)K42EPH P AR TS LIST MODELS (V)K42N, (V)K42NH, (V)K42P, (V)K42PH This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacem[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 32 ILLUSTRATED PARTS BREAKDOWN Models (V)K42EN, (V)K42ENH, (V)K42EP, (V)K42EPH ILLUSTRA TED P ARTS BREAKDOWN BURNER ASSEMBLY FOR MODELS (V)K42EN, (V)K42ENH, (V)K42EP, (V)K42EPH 7 9 8 12 12 6 1 2 12 5 11 12 13 14 15 10 17 19 20 21 18 3 4 5 16 22 23 2[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 33 33 PARTS LIST Models (V)K42EN, (V)K42ENH, (V)K42EP, (V)K42EPH P AR TS LIST BURNER ASSEMBLY FOR MODELS (V)K42N, (V)K42NH, (V)K42P, (V)K42PH This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions l[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 34 ACCESSORIES Purchase these fireplace accessories from your local retailer. If they can not supply these accessories, call DESA’s Sales Department at 1-866-672-6040. for information. You can also write to the address listed on the back page of t[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 35 35 1. Where will the product be used? ❍ Living/F amily Room ❍ Office/Warehouse ❍ Utility Shed/Outbuilding ❍ Gar age ❍ Bedroom ❍ Bathroom ❍ Other 2. If you bought this product yourself , did you plan to purchase this type of product [...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 36 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 Postage Required T APE T APE[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 37 37 NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________________________[...]

111922-01A For more information, visit www.desatech.com For more information, visit www.desatech.com 38 LIMITED WARRANTY DIRECT-VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of first purchase, provided that the product has been properly installed, operated and maintaine[...]