Graco 3A0595D manuale d’uso

      3A0595D EN -For Compressed Air Deliver y- -For outdoor use only-   Read all warnings and instructions in this manual[...]

2       [...]

 3 The following warnings are for the setup, use, maintenance, and repair of this equipment. The exclama- tion point symbol alerts you to a general warning and the hazard symbols refer to pr ocedure-specic risks. When these symbols appear in the body of this manual, refer back to these W ar nings. Product-specic hazard symbols and warnings[...]

4  before r efueling. • Do not refuel indoors or in a poorly ventilated ar ea. • Always refuel slowly to avoid the possibility of spilled fuel which may cause a risk of r e. • Do not operate the unit if gasoline is spilled. Wipe unit clean and move the unit away from the spill. Avoid cr eating any ignition until the gasoline has evap[...]

 5    Risk of bodily injury from moving parts. • Before performing maintenance always turn off air compr essor . Bleed pressur e from the air hose and disconnect spark plug wire to pr event engine from starting unexpectedly . All repairs to the air compr es- sor should be made by an Auth[...]

6    Item Description 1  Beltguard 2  AirFilter 3  OilFillPort 4  AirCompressorPump 5  PumpOilDrain 6  OilSightGlass 7  PilotV alve[...]

 7   Item Description 1  Engine 2  EngineSwitch 3  Engine AirThrottleControl 4  PilotV alve 5  OilSightGlass 6  PumpOilDrain 7  PressureR[...]

8   SAFETY RELIEF V AL VE: This valve is designed to pr e- vent system failures by r elieving pressur e from the sys- tem when the compressed air r eaches a predetermined level. The valve is preset by the manufactur er and must not be modied in any way . T o verify the[...]

 9         Read safety warnings before setting-up air compres- sor . The following information contains operating and maintenance instructions. Ensure the oil level in the air compr essor [...]

10         Review “Fire & Explosion Pr ecautions” pg. 3, before fueling. Locate the Safety Decals on your unit and heed their warnings. Read the engine manual accompanying th[...]

 1 1     Read all safety warnings before performing operation. Do not attempt to operate this air compressor until you have read and understood all safety pr ecautions and instructions listed in this manual. 1. Flip the toggle on top of the pilot valve t[...]

12    Read the instruction manual before performing main- tenance. The following procedur es must be performed when stopping the air compressor for maintenance or service. 1. T urn off air compr essor . 2. Disconnect spark plug wire fr om engine. 3. Open all drains. 4.[...]

  Engine will not start. V arious engine problems. Refer to the engine manual accom- panying your unit. Low engine oil level. Engine is equipped with an Oil Alert System which will not allow the engine to start if oil level is low . Add oil, if needed. Noisy operation. Loose engine pulley or pump y- w[...]

  Excessive oil consumption or oil in hose. Restricted Air Intake Filter . Clean or replace. Air compressor on unlevel surface. Do not incline the air compressor more than 10° in any dir ection while running. Crankcase overlled with oil. Drain oil. Rell to proper level with SAE-30W non deter gent [...]

 15 [...]

16    [...]

 17         1 Handle Grip 16E762 2 2 Petcock 16E719 2 3 Decal - T ank Drain 2 4 Isolator 16E686 4 5 Bolt 100022 8 6 W asher 110755 8 7 Locknut - 1/4-20 102[...]

18   [...]

 19        Kit, Repair , V alve Plate Assy 24E998 1 Includes 2-8 (1) Kit, Repair , Piston Seals 24E999 2 Includes 15[...]

20    [...]

 21         1 Wheel 16E476 2 2 Collar 16E750 2 3 p Decal - Maintenance Instructions (E) 1 4 p Decal - Maintenance Instructions (S/F) 1 5 Decal - Graco Airm[...]

22   [...]

 23        KIT , REP AIR, V AL VE PLA TE ASSY 24F003 1 INCLUDE 2-9 (1) KIT , REP AIR, PISTON SEALS 24F004 1 INCLUDES[...]

24  [...]

 25   MODEL NUMBER 262360 262361 Engine: Honda Size 200cc 270cc Engine T ype 4 Stroke, Overhead V alve, Single Cylinder Oil T ype SAE 10W 30 Oil Capacity (oz./liters) 20 oz./591 ml 37 oz. /1094 ml Fuel T ype Unleaded Gasoline 86 Octane Minimum Fuel Capacity (gallon/liters) .95/3.6 1.6/6.05 Engine RPM 330[...]

26     Graco warrants all equipment refer enced in this document which is manufactured by Graco and bearing its name to be free fr om defects in material and workmanship on the date of sale to the original purchaser for use. With the exception of any special, extended, or li[...]