Heat & Glo LifeStyle CF750ENH manuale d’uso

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 1 Owner ’ s Manual Installation and Operation Models: CF550E CF550ENH CF550EV CF750E CF750ENH CF750EV Electric Fireplace DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible [...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 2 Read this manual before installing or operating this heater . Please retain this owner ’ s manual for future reference. Congratulations on selecting a Heat & Glo electric fi replace. The insert you have selected is designed to provide the utmost in safety ,[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 3 Note: An arrow (  ) found in the te x t signifi es change in content. T able of Contents 1 Listing and Code Approvals 4 A. Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started 5 A. Important Instructions . . . .[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 4 A. Certifi cation This heater has been tested in accordance with the UL2021 Standards for fi xed and location-dedicated electric room heaters in the United States, the current CSA C22.2 No. 46 in Canada and has been listed by Underwriters Laboratories Inc. for i[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 5 Not inte nded f or use a s a prim ar y he at source . This heater is tested and appro ved as a decorative heater . It should not be factored as a primar y heat sourc e in resident ial heating c alculati ons. Improper installation, adjustment, alteration, service o[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 6 B. Design and Installation Considerations Check building codes prior to installation. • Installation MUST comply with local, regional, state and national codes and regulations. • Consult insurance carrier , local building inspector , fi re offi cials or auth[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 7 3 F raming and Clearances A. Selecting Heater Location Several options are available to you when choosing a loca- tion for your heater . This heater may be used as a room divider , installed along a wall, across a corner or used in an exterior chase. See Figure 3.[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 8 C. Framing Figure 3.2 shows a typical framing (using 2 x 4 lumber) of the heater , assuming combustible materials are used. All re- quired clearances to combustibles around the heater must be adhered to. A* B* (header height) 14 in. (356 mm) *If using the PBT or B[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 9 Note: This heater must be elect rically w ired and grounded in acc ordance with loc al codes or , in the absence of loc al codes, with National Electric Code ANSI/ NFP A 70- latest edition or the Canad ian Ele ctr ic Code, C SA C2. 1 as appropriate. All wiring mus[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 10 + - A A B B FLAME MOTOR THERMOST A T RELA Y HEA T SWITCH OPTIONAL BLOWER BLOWER HEATER1 HEATER2 240V AC BLACK RED HIGH LIMIT POWER NEUTRAL MUST NOT CONNECT TO VIR TUAL NEUTRAL OF HEA TERS OR BLOWER IN 240V AC VERSION 120V AC - 240V AC 60HZ SPLIT -PHASE 3 PIN WIRI[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 11 5 H eater P reparation A. Secure and Level the Heater Shock Risk Improperly grounded outlets could cause electrical shock. • Always use properly grounded, fused and polarized outlets. • Always use ground fault protection where required by electrical code. W A[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 12 6 Finishing A. Finishing Material • Combustible Material Material which is made of or surfaced with wood, compressed paper , plant fi bers, plastics, or any material capable of igniting and burning, whether fl ame proofed or not, plastered or not plastered. ?[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 13 C. Mantel Mantel height listed is measured from the BASE of the heater . 3/4 in. - 12 in. (19 mm - 305 mm) A (CEILING) 30 in. min. (762 mm) Figure 6.4 Mantel Specifi cations Fire Risk Do NOT obstruct air inlet or outlet grilles. Do NOT modify grilles. • Modify[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 14 A. Remove Shipping Materials Cut and discard ties securing the logs to the grate and bun- dling the fi rescreen. Remove screws holding ember bed shipping tabs in place (located in front of ember bed), re- move tabs and discard. Replace screws. B. Clean Heater Th[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 15 Fire Risk • Do not operate heater before reading and understanding operating instructions. Failure to operate heater properly may cause fi re. W ARNING A. Manual Controls Access Controls • Controls are located behind the lower grille panel. T o access the co[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 16 B. Hand Held Remote Control T ransmitter RCE-HNG-B (Optional) • The RCE-HNG-B is an optional accessory listed with the Crestfi re Series heaters. • The transmitter is a radio frequency remote control. The frequency can be found on the back side of the transm[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 17 • Remote T ransmitter Function - The hand held remote transmitter is only an ON/OFF control. When the transmitter is active, the remote LED light will be RED. Upon initial use, there may be a delay of three seconds before the remote receiver will respond to the[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 18 9 Tr o u b l e s h o o t i n g A. T roubleshooting Guide Is sues Possible Causes Solutions Heater doesn’t turn on with the main switch or remote transmitter . 1. Power switch is off. 1. T urn the power switch to the “ON” position. 2. Circuit breaker is trip[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 19 1 0 10 Maintenance and Ser vice Shock Risk Burn Risk Cleaning, performing maintenance or moving this electric heater without disconnecting power and allowing the heater to cool could create a shock or burn hazard. • T urn controls to “OFF”. • Remove plug [...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 20 E. Maintenance T ask List Inspect Maintenance T asks Glass Doors 1. Inspect glass panels for cracks. Replace if this condition is present. 2. Confi rm there is no damage to glass or glass frame. Replace as necessary . 3. Clean glass using a non-abrasive cleaner [...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 21 1 1 11 Reference Materials A. Heater Dimensions 16-7/8 in. (429 mm) 36 in. (914 mm) 14 in. (356 mm) 31 in. (787 mm) 30 in. (762 mm) 17-1/4 in. (438 mm) 31-1/8 in. (791 mm) 3-1/8 in. (79 mm) 6-1/2 in. (165 mm) CF550E/CF550EV/CF550ENH 22 in. (559 mm) 41 in. (1041 m[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 22 B. Optional Components ON OFF 12V BATTERY COMPARTMENT FRONT BACK SIGNAL LIGHT ON/OFF BUTTONS RCE-HNG-B Remote Control DM1031 DM1036 DM1031B DM1036B DM1031S DM1036S Bi-fold Glass Doors WSK-21 WSK-21-W W all Switch Kit (left) (right) RF550E (CF550E Series) RF750E ([...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 23 Fronts T rim Kits PBT = Polished Brass Finish BKT = Black Finish PBT -550 (CF550E Series) BKT -550 (CF750E Series) PBT -6 (CF750E Series) BKT -6 (CF750E Series) Cabinet T rim RP31E (CF550E Series) RP36E (CF750E Series) CF550E/CF550EV/CF550ENH Item Description DF-[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 24 Marble Lux VTS-550 (CF550E Series) VTS-550-BK (CF550E Series) VTS-36 (CF750E Series) VTS-36-BK (CF750E Series) Quick Tile Black and Brass Surrounds Surrounds no suffi x = Polished Brass Finish BK = Black Finish Flush Surrounds (chase installations only) CF550E S[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 25  C. Service Parts Exploded Parts Diagram CF550E Series & CF750E Series Service Parts CRESTFIRE Beginning Manufacturing Date: 3/24/03 Ending Manufacturing Date: Active 3 9 8 10 5 7 1 11 6 4 2 16 15 1 1 - Light T ray Assembly 14 13 12[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 26 Service Parts List CF550E Series & CF750E Series Service Parts CRESTFIRE Beginning Manufacturing Date: 3/24/03 Ending Manufacturing Date: Active # Description of Part CF550E Series CF750E Series Qty . 5 Door T rack 4030-321 15425 1 10 Door Pivot Clip 31527 31[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 27 D. Limited W arranty Hearth & Home T echnologies Inc. 800 W . Jefferson Lake City , MN 55041 W ARRANTY Hearth & Home T echnologies Inc. (HHT) Electric Fireplaces are tested and inspected prior to shipment and are guaranteed from defect to the purchaser of[...]

Heat & Glo • CRESTFIRE Series Electric Fireplace • 4030-239 Rev J • 04/05 28 Hearth & Home T echnologies Inc. 800 W . Jefferson Lake City , MN 55041 Please contact your Heat & Glo dealer with any questions or concerns. For the number of your nearest Heat & Glo dealer , please call 1-888-427-3973. – NOTES – E. Contact Infor[...]