HP (Hewlett-Packard) ZV6000 manuale d’uso

Main tenan ce and Ser vice Gu id e HP P a v ili o n z v6 000 Not ebook P C Co mpaq Pr esar io R4 000 Notebook P C Doc ument P art Number : 38 2 519-002 Jul y 2005 This guide is a troubleshooting reference used for maintaining and servicing the notebook. It provides comprehensi ve information on identifying notebook features, components, and spare p[...]

© Copyright 2005 He wlett-Packard De velopment Company , L.P . Microsoft and W indows are U.S. registered trademarks of Microsoft Corporation. AMD, Athlon, Sempron, and combinations thereof, are trademarks of Advanced Micro De vices, Inc. Bluetooth is a trademark owned b y its proprietor and used by Hewlett-P ackard Company under license. SD Logo [...]

Maintenance and Serv ice Guide iii Cont en ts 1 Product Description 1.1 Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1–1 1.2 Resetting the Notebook . . . . . . . . . . . . . . . . . . . . . . . 1–4 1.3 Power Management . . . . . . . . . . . . . . . . . . . . . . . . . . 1–5 1.4 External Components . . . . . .[...]

iv Maintenance and Servi c e Guide Cont ent s 5 Removal and Replacement Procedures 5.1 Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5–2 5.2 Disassembly Sequence Chart . . . . . . . . . . . . . . . . . . 5–3 5.3 Preparing the Notebook for Di sassembly . . . . . . . . . 5–5 5.4 Hard Drive . . . . . . . . . . . . . .[...]

Maintenance and Serv ice Guide 1–1 1 Product D esc ription The HP Pa vilion zv6000 Notebook PC 1 and Compaq Presario R4000 Notebook PC 2 offer adv anced modularity , AMD Mobile Athlon™ 64 and Mobile AMD Sempron™ processors, and extensi ve multimedia support. HP P av ilion zv6 000 Notebook P C and Compaq Pr esari o R4000 Notebook PC 1.1 F e a [...]

1–2 Maintenance and Service Guide Produc t Desc ripti on ■ 100-, 80-, 60-, or 40-GB high-capacity hard dri ve, v arying by notebook model ■ 256-MB DDR synchronous DRAM (SDRAM) at 333 MHz, expandable to 2.0 GB ■ Microsoft® W indows® XP Home Edition or W indows XP Professional, v arying by notebook model ■ Full-size W indows ke yboard wit[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–3 ❏ Consumer infrared (full-featured HP Pa vilion zv6000 models only) ❏ Digital Media Slot (full-featured HP Pa vilion zv6000 models only) ❏ Expansion port 2 ❏ ExpressCard slot (full-featured models only) ❏ External monitor ❏ IEEE 1394 (full-featured models only) ❏ Memory Reade[...]

1–4 Maintenance and Service Guide Produc t Desc ripti on 1 .2 Reset tin g t he Notebook If the notebook you are servicing has an unkno wn password, follo w these steps to clear the password. These steps also clear CMOS: 1. Prepare the notebook for disassembly (refer to Section 5.3, “Preparing the Notebook for Disassembly , ” for more informat[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–5 1. 3 P o w e r M a n a g e m e n t The notebook comes with po wer management features that extend battery operating time and conserv e po wer . The notebook supports the follo wing po wer management features: ■ Standby ■ Hibernation ■ Setting customization by the user ■ Hotke ys fo[...]

1–6 Maintenance and Service Guide Produc t Desc ripti on 1 .4 External C ompon ents The external components on the front of the HP P a vilion zv6000 are sho wn belo w and described in T able 1-1. Depending on your notebook model, component locations may v ary . F r ont Components, HP P av ilion zv6000 Ta b l e 1 - 1 Front Components, HP P avilion[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–7 3 Displa y release latch Opens the notebook. 4 Batter y light* ■ On: The batter y pack is charging. ■ Blinking: The battery pack has reached a low-battery condition. ■ Off: The batter y pack is fully charged or not inser ted. 5 Stereo speakers (2) Produce stereo sound. 6 V olume do w[...]

1–8 Maintenance and Service Guide Produc t Desc ripti on The external components on the front of the Compaq Presario R4000 are sho wn belo w and described in T able 1-2. Depending on your notebook model, component locations may v ary . F r ont Components, Com paq Pre sar io R4000 Ta b l e 1 - 2 Front Components, Compaq Presario R4000 Item Compone[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–9 The external components on the rear panel of the notebook are sho wn belo w and described in T able 1-3. Depending on your notebook model, component locations may v ary . Rea r P an e l Co mp o n en t s Ta b l e 1 - 3 Rear P anel Components Item Component Function 1 P ower connector Connec[...]

1–10 Maintenance and Serv ice Guide Produc t Desc ripti on The external components on the right side of the notebook are sho wn belo w and described in T able 1-4. Depending on your notebook model, component locations may v ary . R igh t-Side C ompone nts Ta b l e 1 - 4 Right-Side Components Item Component Function 1 A udio-out (headphone) jack C[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–11 4 USB por t Connects optional USB de vices. 5 Exhaust ve nt Provides airflo w to cool internal components. ✎ To prevent overheating, do not obstruct vents. Do not allow a hard surface, such as a printer, or a soft surface, such as pi llows or thick rugs or clothing, to block airflow. 6 [...]

1–12 Maintenance and Serv ice Guide Produc t Desc ripti on The external components on the left side of the notebook are sho wn belo w and described in T able 1-5. Depending on your notebook model, component locations may v ary . Lef t -Sid e Comp on en ts Ta b l e 1 - 5 Left-Side Components Item Component Function 1 ExpressCard slot (select model[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–13 3 Digital Media Slot (select HP P avilion zv6000 models only) Memory Reader (select Compaq Presario R4000 models only) Suppor ts most digi tal memor y cards, including Secure Digital (SD) Memor y Card, Memor y Stick, Memory Stick Pro , xD-Picture Card, MultiMediaCard, or Smar tMedia (SM) [...]

1–14 Maintenance and Serv ice Guide Produc t Desc ripti on The standard ke yboard components on the notebook are sho wn belo w and described in T able 1-6. Standar d K e y board C omponents[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–15 T able 1-6 Standard K eyboard Components Item Component Function 1 Function ke ys (12) P erform system and application tasks. When combined with the fn ke y , the function ke ys perform additional tasks as hotke ys. 2 caps lock key Enables caps loc k and turns on the caps lock light. 3 fn[...]

1–16 Maintenance and Serv ice Guide Produc t Desc ripti on The top components on the HP Pa vilion zv6000 are shown belo w and described in T able 1-7. T op Components , HP P av ilion zv6 000 Models T able 1-7 T op Components, HP Pa vilion zv6000 Item Component Function 1 Digital Media Slot light (select models only) On: An optional digital memor [...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–17 4 P ower/standby b utton When the notebook is ■ Off , press to turn on the notebook. ■ On, briefly press to initiate hiber nation. ■ In standby , briefly press to resume from standby . ■ In hibernation, br iefly press to restore from hibernation. ✎ If the system has stopped resp[...]

1–18 Maintenance and Serv ice Guide Produc t Desc ripti on The top components on Compaq Presario R4000 models are sho wn belo w and described in T able 1-8. T op Components , Compaq Pr esari o R4000 Models T able 1-8 T op Components, Compaq Presario R4000 Item Component Function 1 Memor y Reader light (select models only) On: A digital memor y ca[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–19 3 Wireless button (select models only) T urns the wireless functionality on or off, but does not create a wireless connection. ✎ To establish a wireless connection, a wireless network must already be set up. 4 P ower/standby b utton When the notebook is ■ Off , press to turn on the no[...]

1–20 Maintenance and Serv ice Guide Produc t Desc ripti on The HP Pa vilion zv6000 notebook T ouchPad components are sho wn belo w and described in T able 1-9. T ouchP ad C omponents, HP P avili on zv6 000 T able 1-9 T ouchP ad Components, HP P a vilion zv6000 Item Component Function 1 T ouchP ad on/off button Enables/disab l es the T ouchP ad. 2[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–21 The Compaq Presario R4000 notebook T ouchPad components are sho wn belo w and described in T able 1-10. T ouchP ad C omponents, C ompaq Pr esario R4 000 T able 1-10 T ouchP ad Components, Compaq Presario R4000 Item Component Function 1 T ouchP ad light On: T ouchP ad is enabled. 2 T ouchP[...]

1–2 2 Maintenance and Servi c e Guide Produc t Desc ripti on The external components on the bottom of the notebook are sho wn belo w and described in T able 1-11. Bottom Components T able 1-11 Bottom Components Item Component Function 1 V ents (4) Provide airflow to cool internal components. ✎ To prevent overheating, do not obstruct vents. Do n[...]

Pr oduct Des cr iption Maintenance and Serv ice Guide 1–2 3 3 Batter y pack release latch Releases a battery pack from the battery bay . 4 Labels area Contains the serial number and other inf ormation labels. 5 Optical drive Suppor ts an optical disc, such as a CD or D VD . 6 Memor y module compar tment cov er Contains a memor y module slot that [...]

1–2 4 Maintenance and Servi c e Guide Produc t Desc ripti on 1. 5 D e s i g n O v e r v i e w This section presents a design ov ervie w of ke y parts and features of the notebook. Refer to Chapter 3, “Illustrated Parts Catalog, ” to identify replacement parts, and Chapter 5, “Remov al and Replacement Procedures, ” for disassembly steps. T[...]

Maintenance and Serv ice Guide 2–1 2 T r oub leshooting Å W ARN ING: Only author i z ed technic ians trained b y HP should repair this equipment . All trou bleshooting and r epair procedur es ar e detailed to allo w only su bass embly-/module-lev el r epair . Becau se of the comple x ity of the indiv idual boards and su basse mblies , do not at [...]

2–2 Maintenance and Service Guide T roubleshooting Acce ssing Co mputer Setup The information and settings in Computer Setup are accessed from the Main , Security , Advanced , T ools , and Exit menus. 1. Open Computer Setup by turning on or restarting the notebook. Press f10 while the “Press <F10> to enter Setup” message is displayed in[...]

T roubleshooting Maintenance and Serv ice Guide 2–3 Comp uter Setu p Defaults T o return all settings in Computer Setup to the values that were set at the factory: 1. Open Computer Setup by turning on or restarting the notebook. Press f10 while the “Press <F10> to enter Setup” message is displayed in the lo wer -left corner of the scree[...]

2–4 Maintenance and Service Guide T roubleshooting Selec ting from th e Main Men u Selectin g from the Securit y Menu Ta b l e 2 - 1 Main Menu Select T o Do This System Inf ormation ■ View identification inf or mation about the notebook. ■ View specification inf or mation about the processor , memor y and cache size, k e yboard controller ver[...]

T roubleshooting Maintenance and Serv ice Guide 2–5 Selec ting from the Adv an ced Menu Selectin g from the T ools Menu Ta b l e 2 - 3 Adv anced Menu Select T o Do This Video Graphic Mode Select UMA, SideP or t, or UMA+SideP or t video memory modes. Dedicated Video Memor y View the siz e of the on-board video memory . T otal Video Memor y View th[...]

2–6 Maintenance and Service Guide T roubleshooting Ta b l e 2 - 5 Exit Menu Select T o Do This Exit Saving Changes Sav e changes entered during the current session. Then e xit and restar t the notebook. The changes you sa v e are in eff ect when the notebook restar ts. Exit Discarding Changes Cancel changes enter ed during the current session. Th[...]

T roubleshooting Maintenance and Serv ice Guide 2–7 2.2 T r oubl eshooting Flo wc h arts Ta b l e 2 - 6 T roubleshooting Flo wcharts Overview Flowchart Description 2.1 “Flowchart 2.1—Initial T roubleshooting” 2.2 “Flowchart 2.2—No Po wer , P ar t 1” 2.3 “Flowchart 2.3—No Po wer , P ar t 2” 2.4 “Flowchart 2.4—No Po wer , P ar[...]

2–8 Maintenance and Service Guide T roubleshooting Flowchart Description 2.14 “Flowchart 2.14—No OS Loading, Optical Dr ive” 2.15 “Flowchart 2.15—No Audio , Part 1” 2.16 “Flowchart 2.16—No Audio , Part 2” 2.17 “Flowchart 2.17—Nonfunctioning Device” 2.18 “Flowchart 2.18—Nonfunctioning Ke yboard” 2.19 “Flowchart 2.19[...]

T roubleshooting Maintenance and Serv ice Guide 2–9 Flo wc h art 2. 1—Initial T roubleshootin g Connecting to network or modem? Begin troubleshooting. Is there power? Is the OS loading? Is there video? (no boot) Is there sound? Beeps, LEDs, or error messages? Keyboard/ pointing device working? Go to “Flowchart 2.17—Nonfunc- tioning Device .[...]

2–10 Maintenance and Serv ice Guide T roubleshooting Flo wc h art 2.2—N o P o w er , P ar t 1 1. Reseat the power cables in the docking device and at the AC outlet. 2. Ensure the AC power source is active. 3. Ensure that the power strip is working. Done Remove from docking device (if applicable). Pow e r u p on batter y power? Po we r u p on AC[...]

T roubleshooting Maintenance and Serv ice Guide 2–11 Flo wc h art 2.3—No P o w er , P ar t 2 Continued from “Flowchart 2.2—No P ower , Pa r t 1 . ” Visually check for debris in batter y socket and clean if necessary . Done N Y Po we r o n? Check battery by recharging it, moving it to another notebook, or replacing it. Pow e r o n? Done Y [...]

2–12 Maintenance and Serv ice Guide T roubleshooting Flo wc h art 2.4—N o P o w er , P ar t 3 Continued from “Flowchart 2.3—No P ower , Pa r t 2 . ” Reseat AC adapter in notebook and at pow er sou rce . Internal or external AC adapter? Done Done Done Done Po we r o n? Pow e r o n? Po we r o n? Plug directly into AC outlet. Po we r L ED on[...]

T roubleshooting Maintenance and Serv ice Guide 2–13 Flowc ha r t 2.5— No P ow e r , P art 4 Y N Continued from “Flowchart 2.4—No P ower , Pa r t 3 . ” Reseat loose components and boards and replace damaged items. Open notebook. Loose or damaged parts? Y Close notebook and retest. Pow er on ? Done N Replace the following items (if applica[...]

2–14 Maintenance and Serv ice Guide T roubleshooting Flo wc h art 2.6—N o Video, P ar t 1 A N Stand-alone or docking device? No video. Replace the following one at a time . T est after each replacement. 1. Cable between notebook and not ebook display (if applicable) 2. Display 3. System board Internal or external display*? Adjust brightness. Vi[...]

T roubleshooting Maintenance and Serv ice Guide 2–15 Flo wc h art 2.7—N o Video, P ar t 2 Y N Continued from “Flowchart 2.6—No Video , Pa r t 1 . ” Done Adjust external monitor display . Video OK? Adjust display brightness. Video OK? Video OK? Done Done Check that notebook is properly seated in docking device, for bent pins on cable, and [...]

2–16 Maintenance and Serv ice Guide T roubleshooting F l o w cha rt 2 .8 — No nf un cti o n in g D ock in g De vi c e (if applic able) Y N Reseat power cord in docking device and power outlet. N Check voltage setting on docking device. Reset monitor cable connector at docking device. Reinstall notebook into docking device. Docking device operat[...]

T roubleshooting Maintenance and Serv ice Guide 2–17 Flo wc h art 2.9—N o Opera ting Sy stem (OS) Loading No OS loading from hard drive, go to “Flowchart 2.10—No OS Loading, Hard Drive, P ar t 1. ” Reseat power cord in docking device and power outlet. No OS loading.* *NOTE: Before beginning troubleshooting, always check cable connections,[...]

2–18 Maintenance and Serv ice Guide T roubleshooting Flowch ar t 2. 1 0— No OS Lo ad in g , H ard Drive, Pa r t 1 Go to “Flowchart 2.17—Nonfunctioning Device . ” Y Done N OS not loading from hard drive. Nonsystem disk message? Go to “Flowchart 2.11—No OS Loading, Hard Drive, P ar t 2. ” Reseat external hard drive. OS loading? Done B[...]

T roubleshooting Maintenance and Serv ice Guide 2–19 Flowc ha r t 2. 1 1—No OS Lo a din g , H a rd Driv e, Pa r t 2 Load OS using Operating System disc (if applicable). Continued from “Flowchart 2.10—No OS Loading, Hard Drive, P ar t 1. ” Reseat hard drive. Done Disc or diskette in drive? 1. Replace hard drive. 2. Replace system board. Go[...]

2–20 Maintenance and Serv ice Guide T roubleshooting Flowc ha r t 2. 1 2—N o O S Loa d in g , H ard Driv e, Pa r t 3 Y System files on hard drive? Continued from “Flowchart 2.11—No OS Loading, Hard Drive, P ar t 2. ” Clean virus. Done N Install OS and reboot. Virus on hard drive? OS loading from hard drive? Y N Y N Y N Diagnostics on disc[...]

T roubleshooting Maintenance and Serv ice Guide 2–21 Flo wc h art 2. 1 3—No OS Load ing , Disk et te Driv e Replace the following components individually , retesting after each replacement: ■ Diskette drive ■ System board Done Y N Reseat diskette drive. OS not loading from diskette drive. Done Y Y Y Y Y Y Y N N N N N N N OS loading? Nonsyst[...]

2–2 2 Maintenance and Servi c e Guide T roubleshooting Flo wc h art 2. 1 4—No OS Loa ding , O ptical Driv e Y Done N Bootable disc in drive? Disc in drive? No OS loading from CD-ROM or DVD-ROM drive. Install bootable disc and reboot notebook. Go to “Flowchart 2.17—Nonfunctioning Device . ” Go to “Flowchart 2.17—Nonfunctioning Device .[...]

T roubleshooting Maintenance and Serv ice Guide 2–2 3 Flo wc h ar t 2. 1 5—N o Audio, Part 1 No audio. N Notebook in docking device (if applicable)? Internal audio? Audio? Done Undock Audio? Done T urn up audio internally or externally . Go to “Flowchart 2.16—No Audio , Pa r t 2 . ” Go to “Flowchar t 2.17—Nonfunctioning De vice. ” Y[...]

2–2 4 Maintenance and Servi c e Guide T roubleshooting Flo wc h art 2. 1 6—No Audio, P art 2 YN Continued from “Flowchart 2.15—No Audio , Pa r t 1 . ” Reload audio drivers. Audio driver in OS configured? Audio? Y Y Y N N N Correct drivers for application? Connect to external speaker . Load drivers and set configuration in OS. Audio? Done [...]

T roubleshooting Maintenance and Serv ice Guide 2–25 Flo wc h art 2. 1 7—N onfunc tioning Dev ice Done Any physical device detected? Y N Unplug the nonfunctioning device from the notebook and inspect cables and plugs for bent or broken pins or other damage. Reseat device. Clear CMOS. Done Fix o r replace broken item. Nonfunctioning device. Reat[...]

2–2 6 Maintenance and Servi c e Guide T roubleshooting Flo wc h art 2. 1 8—Nonfunc tionin g K e yboar d Y N Keyboard operating properly? Keyboard not operating properly . External device works? Replace system board. Replace system board. Connect notebook to good external keyboard. Reseat internal keyboard connector (if applicable). Replace inte[...]

T roubleshooting Maintenance and Serv ice Guide 2–2 7 Flo wc h art 2. 1 9—Nonfunc tioning P oin ting De vice Y N Pointing device not operating properly . External device works? Replace system board. Replace system board. Connect notebook to good external pointing device. Reseat internal pointing device connector (if applicable). Replace interna[...]

2–2 8 Maintenance and Servi c e Guide T roubleshooting Flo wc har t 2.20—No N et w ork/Modem Conne ction Y Disconnect all power from the notebook and open. No network or modem connection. N Done Digital line? Network or modem jack active? Replace jack or have jack activated. Connect to nondigital line. NIC/modem configured in OS? Reload drivers[...]

Maintenance and Serv ice Guide 3–1 3 I llustra ted P arts C a talog This chapter provides an illustrated parts breakdo wn and a reference for spare part numbers. 3. 1 S erial N umber Location When ordering parts or requesting information, provide the notebook serial number and model number located on the bottom of the notebook. Seri al Number Loc[...]

3–2 Maintenance and Service Guide Illustrated P ar ts Catalog 3.2 Notebook Major C ompon ents Notebook Major C omponents , HP P a v ilion z v6 000[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–3 Ta b l e 3 - 1 Spare P arts: Notebook Major Components Item Description Spare P art Number 1 Display assemb lies (include displa y cable , wireless antenna boards, and antenna cables) F or use with HP P avilion zv6000 models with wireless capability 15.4-inch, WXGA, TFT with BrightVi[...]

3–4 Maintenance and Service Guide Illustrated P ar ts Catalog Notebook Major C omponents, C ompaq Pr esario R4 000[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–5 Ta b l e 3 - 1 Spare P arts: Notebook Major Components (Continued) Item Description Spare P art Number 2 Ke yboard co vers F or use with HP P avilion zv6000 models with wireless capability F or use with HP P avilion zv6000 models without wireless capability 383915-001 383916-001 F or[...]

3–6 Maintenance and Service Guide Illustrated P ar ts Catalog Notebook Major C omponents , HP P a v ilion z v6 000[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–7 Ta b l e 3 - 1 Spare P arts: Notebook Major Components (Continued) Item Description Spare P art Number 5 Bluetooth® wireless board (includes Bluetooth board cable) 394733-001 Miscellaneous Plastics Kit 383670-001 6a 6b 6c 6d 6e 6f Includes: T op cov er rear bezel (for use with HP P [...]

3–8 Maintenance and Service Guide Illustrated P ar ts Catalog Notebook Major C omponents, C ompaq Pr esario R4 000[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–9 Ta b l e 3 - 1 Spare P arts: Notebook Major Components (Continued) Item Description Spare P art Number 9 Thermal frames (include f an and thermal paste) F or use with HP P avilion zv6000 models F or use with Compaq Presario R4000 models 383880-001 383881-001 10 Thermal modules F or u[...]

3–10 Maintenance and Serv ice Guide Illustrated P ar ts Catalog Notebook Major C omponents , HP P a v ilion z v6 000[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–11 Ta b l e 3 - 1 Spare P arts: Notebook Major Components (Continued) Item Description Spare P art Number 13 Memory modules 1024 MB 512 MB 256 MB 383950-001 383949-001 383948-001 14 Speakers F or use with HP P avilion zv6000 models F or use with Compaq Presario R4000 models 383919-001 [...]

3–12 Maintenance and Serv ice Guide Illustrated P ar ts Catalog Notebook Major C omponents, C ompaq Pr esario R4 000[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–13 Ta b l e 3 - 1 Spare P arts: Notebook Major Components (Continued) Item Description Spare P art Number 18 Base enclosures F or use with full-f eatured HP P avilion zv6000 models F or use with def eatured HP P avilion zv6000 models 383921-001 383922-001 F or use with Compaq Presario [...]

3–14 Maintenance and Serv ice Guide Illustrated P ar ts Catalog 3.3 M a s s S to ra g e D e vic es[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–15 Ta b l e 3 - 2 Mass Storage Devices Spare P art Number Information Item Description Spare P art Number 1 Hard drives (include frame and connector) 5400 r pm 80-GB 60-GB 383954-001 392575-001 4200-r pm 100-GB 80-GB 60-GB 40-GB 392576-001 383953-001 383952-001 383951-001 2 Optical dri[...]

3–16 Maintenance and Serv ice Guide Illustrated P ar ts Catalog 3.4 Miscell aneous Plas tic s Kit T able 3-3 Miscellaneous Plastics Kit Spare P art Number 383670-001 Item Description 1 T op cov er rear bezel 2 PC Card slot space sav er 3 ExpressCard slot space sav er 4 R TC battery 5 Memor y module compar tment cov e r (includes 1 captiv e screw [...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–17 3.5 Miscell aneous (N ot I llustrated) Ta b l e 3 - 4 Miscellaneous (Not Illustrated) Spare P art Number Information Description Spare P art Number All-in-one media cable 375759-001 A udio Y-cable 379452-001 Cable Kit 383671-001 HP remote control (f or use with HP P avilion zv6000 m[...]

3–18 Maintenance and Serv ice Guide Illustrated P ar ts Catalog Screw Kit (include the f ollowing screws; ref er to Appendix C , “Screw Listing, ” f or more inf ormation on specifications and usage) 383673-001 ■ Phillips PM2.5×8.0 screw ■ Phillips PM2.5×7.0 screw ■ Phillips PM2.5×4.0 screw ■ Phillips PM2.0×16.0 screw ■ Phillips [...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–19 3.6 Sequen tial P ar t N umber Listin g Ta b l e 3 - 5 Sequential P art Number Listing Spare P art Number Description 309674-001 USB tra vel mouse 350188-001 P ower cord f o r use in Canada, F rench Canada, Latin Amer ica, T aiwan, Thailand, and the United States 350188-021 P ower c[...]

3–20 Maintenance and Serv ice Guide Illustrated P ar ts Catalog 383664-051 K eyboard for use with HP P avi lion zv6000 models in F rance 383664-061 K eyboard for use with HP P avi lion zv6000 models in Italy 383664-071 K eyboard for use with HP P avi lion zv6000 models in Spain 383664-081 K eyboard for use with HP P avi lion zv6000 models in Denm[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–21 383665-091 K eyboard for use with Compaq Presario R4000 models in Norwa y 383665-121 K eyboard for use with Compaq Presario R4000 models in F rench Canada 383665-331 K eyboard for use with Compaq Presario R4000 models in the Netherlands 383665-B71 K eyboard for use with Compaq Presa[...]

3–2 2 Maintenance and Servi c e Guide Illustrated P ar ts Catalog 383912-001 V olume board (includes v olume board cable; f or use only on Compaq Presario R4000 models) 383913-001 T ouchP ad suppor t brac k et (f or use with Compaq Presario R4000 models) 383914-001 Displa y latch kit 383915-001 K eyboard cov er f or use with HP P avilion zv6000 m[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–2 3 383936-001 Displa y assembly , 15.4-inch, WXGA, TFT , f or use with HP P avilion zv6000 models with out wireless capability (includes displa y cable) 383937-001 Displa y assembly , 15.4-inch, WXGA, TFT , f or use with Compaq Presario R4000 models with wireless capability (includes [...]

3–2 4 Maintenance and Servi c e Guide Illustrated P ar ts Catalog 383951-001 4200-rpm 40-GB hard dr ive (includes frame and connector) 383952-001 4200-rpm, 60-GB hard dr ive (includes frame and connector) 383953-001 4200-rpm, 80-GB hard dr ive (includes frame and connector) 383954-001 5400-rpm, 80-GB hard dr ive (includes frame and connector) 383[...]

Illustr a ted P arts Catalog Maintenance and Serv ice Guide 3–25 394208-001 120-watt, PFC po wer supply 394209-001 120-watt, non-PFC po wer supply 394210-001 90-watt, PFC po wer supply 394211-001 90-watt, non-PFC po wer supply 394733-001 Bluetooth wireless board (i ncludes Bluetooth board cable) 396869-001 System board f or use with def eatured m[...]

3–2 6 Maintenance and Servi c e Guide Illustrated P ar ts Catalog 398032-001 D VD±R W and CD-R W Dual Layer Combo Driv e f or use with HP P avilion zv6000 models 398033-001 T op cov er for use with def eatured HP Pa vilion zv6000 models 398034-001 T op cov er for use with full-f ea tured HP Pa vili on zv6000 models 398035-001 T op cov er for use[...]

Maintenance and Serv ice Guide 4–1 4 Remo v al an d Repla cemen t Preliminaries This chapter provides essential information for proper and safe remov al and replacement service. 4. 1 T ools Required Y ou will need the following tools to complete the remov al and replacement procedures: ■ Magnetic scre wdri ver ■ Phillips P0 scre wdri ver ■ [...]

4–2 Maintenance and Service Guide Remo val and Replaceme nt Pr eliminar ies 4.2 Ser vice Consi dera tions The follo wing sections include some of the considerations that you should keep in mind during disassembly and assembly procedures. ✎ As you remov e each subassembly from the notebook, place the subassembly (and all accompanying scre ws) aw[...]

Remo val and Replacemen t Preliminar ies Maintenance and Serv ice Guide 4–3 4. 3 P r e v ent ing Da mage to Re mo v able Driv es Remov able driv es are fragile components that must be handled with care. T o prev ent damage to the notebook, damage to a remov able driv e, or loss of information, observe the follo wing precautions: ■ Before removi[...]

4–4 Maintenance and Service Guide Remo val and Replaceme nt Pr eliminar ies 4.4 Pre v enting El ec trostatic D ama ge Many electronic components are sensiti ve to electrostatic discharge (ESD). Circuitry design and structure determine the degree of sensiti vity . Networks b uilt into man y integrated circuits provide some protection, b ut in many[...]

Remo val and Replacemen t Preliminar ies Maintenance and Serv ice Guide 4–5 4.5 P ac k a ging an d T ranspor ting Precautions Use the follo wing grounding precautions when packaging and transporting equipment: ■ T o av oid hand contact, transport products in static-safe containers, such as tubes, bags, or boxes. ■ Protect all electrostatic-se[...]

4–6 Maintenance and Service Guide Remo val and Replaceme nt Pr eliminar ies 4.6 W orks tation Precau tions Use the follo wing grounding precautions at workstations: ■ Cov er the workstation with appro ved static-shielding material (refer to T able 4-2, “Static-Shielding Materials” ). ■ Use a wrist strap connected to a properly grounded wo[...]

Remo val and Replacemen t Preliminar ies Maintenance and Serv ice Guide 4–7 4.7 Groundin g Eq uipm ent and Methods Grounding equipment must include either a wrist strap or a foot strap at a grounded workstation. ■ When seated, wear a wrist strap connected to a grounded system. Wrist straps are flexible straps with a minimum of one megohm ±10% [...]

4–8 Maintenance and Service Guide Remo val and Replaceme nt Pr eliminar ies T able 4-1 shows ho w humidity af fects the electrostatic voltage le vels generated b y different acti vities. T able 4-2 lists the shielding protection provided by antistatic bags and floor mats. Ta b l e 4 - 1 T ypical Electr ostatic V oltage Levels Relative Humidity Ev[...]

Maintenance and Serv ice Guide 5–1 5 Remo v al an d Repla cemen t Procedur es This chapter provides remo v a l and replacement procedures. There are as many as 75 scre ws, in 9 different sizes, that may hav e to be removed, replaced, or loosened when servicing the notebook. Make special note of each scre w and screw lock size and location during [...]

5–2 Maintenance and Service Guide Remo val and Replaceme nt Pr ocedur es 5 . 1 Serial N umber Report the notebook serial number to HP when requesting information or ordering spare parts. The serial number is located on the bottom of the notebook. Seri al Number Location[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–3 5 .2 Disassembl y Sequence Chart Use the chart belo w to determine the section number to be referenced when removing notebook components. Disassembl y Sequence Chart Section Description # of Screws Remo ved 5.3 Preparing the Notebook for Disassembly Batter y pack 0 5.4 Hard D[...]

5–4 Maintenance and Service Guide Remo val and Replaceme nt Pr ocedur es Section Description # of Screws Remo ved 5.13 Internal Memor y Module 0 5.14 Displa y Assembly 8 on HP P avilion zv6000 models 6 on Compaq Presario R4000 models 5.15 Base Enclosure 17 on HP Pa vilion zv6000 models 15 on Compaq Presario R4000 models 5.16 F an Assembly 3 5.17 [...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–5 5 .3 Preparing t he N otebook for Disasse mbl y Before you begin an y remov al or installation procedures: 1. Shut do wn the notebook. If you are unsure whether the notebook is of f or in hibernation, turn the notebook on, and then shut it do wn through the operating system. [...]

5–6 Maintenance and Service Guide Remo val and Replaceme nt Pr ocedur es 4. Remov e the battery pack b y follo wing these steps: a. T urn the notebook upside down with the front to ward you. b . Slide the battery release latch 1 to ward the notebook rear panel. (The right edge of the battery pack disengages from the notebook.) c. Lift the right e[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–7 5 .4 H ard Driv e 1. Prepare the notebook for disassembly ( Section 5.3 ). Hard Drive Spare P ar t Number Information 5400-rpm 80-GB 383954-001 5400-rpm 60-GB 392575-001 4200-r pm 100-GB 392576-001 4200-rpm 80-GB 383953-001 4200-rpm 60-GB 383952-001 4200-rpm 40-GB 383951-001[...]

5–8 Maintenance and Service Guide Remo val and Replaceme nt Pr ocedur es 2. Loosen the two PM2.0×7.0 scre ws 1 that secure the hard dri ve co v er to the notebook. 3. Lift the left side of the cov er 2 up and swing it to the right. 4. Remov e the hard dri ve cov er . ✎ The hard dri ve co ver is included in the Miscellaneous Plastics Kit, spare[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–9 5. Remov e the two PM2.0×7.0 hard dri ve retention scre ws 1 that secure the hard dri ve to the notebook. 6. Slide the hard dri ve 2 to the right to disconnect it from the system board. 7. Lift the hard dri ve 3 straight up and remo ve it from the hard dri ve bay . Re mo v i[...]

5–10 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 8. Remov e the four PM3.0×4.5 scre ws 1 that secure the hard dri ve frame to the hard dri ve. 9. Lift the frame 2 to remov e if from the hard dri ve. Re mo v ing the Hard Dr iv e F rame Re verse the abo v e procedure to reassemble and install the hard dri ve.[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–11 5 .5 Notebook Feet The notebook feet are adhesi ve-back ed rubber pads. The feet are included in the Miscellaneous Plastics Kit, spare part number 383670-001. Replac ing the Notebook F eet 5 .6 External Memor y Modul e 1. Prepare the notebook for disassembly (refer to Sectio[...]

5–12 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 2. Loosen the PM2.0×7.0 scre w 1 that secures the memory module compartment cov er to the notebook. 3. Lift the rear edge of the cov er 2 up and swing it to ward you. 4. Remov e the memory module compartment cov er . ✎ The memory module compartment cov er is included in[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–13 5. Spread the retaining tabs 1 on each side of the memory module socket to release the memory module. (The side of the module opposite the socket rises aw ay from the notebook.) 6. Slide the module 2 away from the sock et at an angle. 7. Remov e the memory module. ✎ Memory[...]

5–14 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 5 .7 O ptical Driv e 1. Prepare the notebook for disassembly ( Section 5.3 ). Optical Drive Spare P art Number Information F or use with HP P avilion zv6000 models D VD±R W and CD-R W Double La yer Combo Drive with LightScribe 396871-001 D VD±R W and CD-R W Double La yer[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–15 2. Remov e the PM2.0×7.0 scre w 1 that secures the optical dri ve to the notebook. 3. Insert a thin tool, such as a paper clip, into the media tray release hole 2 . The optical dri ve media tray releases from the optical dri ve. 4. Use the media tray frame to slide the opti[...]

5–16 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 5 .8 K e yboard Co v er 1. Prepare the notebook for disassembly ( Section 5.3 ). 2. T urn the notebook upside down with the rear panel to ward you. Ke yboar d Co ver Spare P ar t Number Information F or use with HP P avilion zv6000 models with wireless capability 383915-00[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–17 3. Remov e the four PM2.0×15.0 scre ws that secure the ke yboard cov er to the notebook. Re mo v ing the K ey board Co ver Sc re w s[...]

5–18 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 4. T urn the notebook right-side up with the front tow ard you. 5. Open the notebook as far as possible. ✎ Steps 6 through 10 apply to HP Pa vilion zv6000 models. See steps 11 through 15 in this section to remov e the ke yboard cov er on Compaq Presario R4000 models. 6. [...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–19 7. Press do wn on the label area of the ke yboard cov e r 1 to release the ke yboard cov er hook from the notebook. 8. Lift the right side of the ke yboard cov er 2 and slide the right side of the cov er to ward the notebook rear panel. Re leasing the K ey board Co ver , HP [...]

5–20 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 9. Continue pressing do wn on the pressure points on the ke yboard cov er (locations indicated by 1 , 2 , 3 ) to release the ke yboard cov er hooks from the notebook. As you do so, continue lifting the right side of the ke yboard cov er and sliding the cov er 4 to ward the[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–21 ✎ Steps 11 through 15 apply to Compaq Presario R4000 models. 11. Insert a flat blade scre wdri ver into the notch 1 behind the insert ke y and lift up the right side of the ke yboard cov er 2 . 12. Lift up on the middle 3 of the ke yboard cov er until it disengages from th[...]

5–2 2 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 13. Lift the rear edge of the ke yboard cov er 1 and swing it forward until it rests on the ke yboard. 14. Release the zero insertion force (ZIF) connector to which the volume board cable is attached and disconnect the v olume board cable 2 from the system board. 15. Rem[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–2 3 5. 9 V o l u m e B o a rd ✎ The volume board remo val procedures in this section apply to Compaq Presario R4000 models. 1. Prepare the notebook for disassembly ( Section 5.3 ). 2. Remov e the ke yboard cov er ( Section 5.8 ). 3. Remov e the two PM2.0×4.0 scre ws 1 that s[...]

5–2 4 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 5 . 1 0 Bluetooth B oard 1. Prepare the notebook for disassembly ( Section 5.3 ). 2. Remov e the ke yboard cov er ( Section 5.8 ). 3. Disconnect the Bluetooth board cable 1 from the system board. 4. Remov e the two PM1.5×3.0 scre ws 2 that secure the Bluetooth board to [...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–25 5. 1 1 Ke y b o a r d 1. Prepare the notebook for disassembly ( Section 5.3 ). 2. Remov e the ke yboard cov er ( Section 5.8 ). Ke yboar d Spare P ar t Number Information F or use with HP P avilion zv6000 models: Belgium Denmark F rance F rench Canada Germany Italy The Nethe[...]

5–2 6 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 3. Remov e the four PM2.0×4.0 scre ws that secure the keyboard to the notebook. Re mo v ing the K ey boar d Scr e w s[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–2 7 4. Lift the rear edge of the ke yboard and swing it forward until it rests on the palm rest. Rel e a si n g t h e Ke ybo a rd[...]

5–2 8 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 5. Release the ZIF connector 1 to which the ke yboard cable is connected and disconnect the ke yboard cable 2 from the system board. 6. Remov e the ke yboard. Disconnecting the K e y boar d Cable Re verse the abo v e procedure to install the ke yboard.[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–29 5. 1 2 M i n i PC I C o m m u n i c a t i o n s C a r d 1. Prepare the notebook for disassembly ( Section 5.3 ). 2. Remov e the ke yboard cov er ( Section 5.8 ). 3. Remov e the ke yboard ( Section 5.11 ). Mini PCI Communications Car d Spare P art Number Information 802.11b/g[...]

5–30 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es ✎ Make note of which antenna cable is attached to which antenna clip on the Mini PCI communications card before disconnecting the cables. 4. Disconnect the auxiliary and main antenna cables 1 from the Mini PCI communications card. 5. Spread the retaining tabs 2 on each s[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–31 Re verse the abo v e procedure to install a Mini PCI communications card. 5 . 1 3 Internal Mem or y Module 1. Prepare the notebook for disassembly (refer to Section 5.3 ). 2. Remov e the ke yboard cov er ( Section 5.8 ). 3. Remov e the ke yboard ( Section 5.11 ). Memory Modu[...]

5–3 2 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 4. Spread the retaining tabs 1 on each side of the memory module socket to release the memory module. (The side of the module opposite the socket rises aw ay from the notebook.) 5. Slide the module aw ay from the socket at an angle 2 . 6. Remov e the memory module. ✎ M[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–33 5 . 1 4 Displa y Assembl y 1. Prepare the notebook for disassembly ( Section 5.3 ). 2. Remov e the ke yboard cov er ( Section 5.8 ). 3. Remov e the ke yboard ( Section 5.11 ). Display Assemb ly Spare P art Number Information Displa y assemblies include displa y ca ble and (f[...]

5–34 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 4. T urn the notebook upside down with the rear panel to ward you. ✎ Steps 5 through 13 apply to HP Pa vilion zv6000 models. See steps 14 through 21 in this section to remov e the ke yboard cov er on Compaq Presario R4000 models. 5. Remov e the two Mylar scre w covers 1 [...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–35 7. T urn the notebook right-side up with the front tow ard you. 8. Open the notebook as far as possible. 9. Disconnect the wireless antenna cables1 1 from the Mini PCI communications card. 10. Remov e the wireless antenna cables from the clips 2 in the top cov er . 11. Disco[...]

5–3 6 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es Ä CAUT ION: Su pport the display as sembl y whe n re mo v ing the follo wing scr ew s. F ailure t o support the display as sembl y can r esult in damage to the display a ssembl y and other notebook components. 12. Remov e the four PM2.0×7.0 scre ws 1 that secure the dis[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–3 7 ✎ Steps 14 through 21 apply to Compaq Presario R4000 models. 14. Remov e the two PM2.0×7.0 scre ws that secure the display assembly to the notebook. Remo ving the Displa y Sc r ews , Co mpaq Pr esar io R4000 Models[...]

5–38 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 15. T urn the notebook right-side up with the front tow ard you. 16. Open the notebook. 17. Disconnect the wireless antenna cables 1 from the Mini PCI communications card. 18. Remov e the wireless antenna cables from the clips 2 in the top cov er . 19. Disconnect the displ[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–39 Ä CAUT ION: Su pport the display as sembl y whe n re mo v ing the follo wing scr ew s. F ailure t o support the display as sembl y can r esult in damage to the display a ssembl y and other notebook components. 20. Remov e the four PM2.0×7.0 scre ws 1 that secure the displa[...]

5–40 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 5. 1 5 B a s e E n c l o s u r e 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.7 ) c. K eyboard co ve r ( Section 5.8 ) d. K eyboard ( Section 5.11 ) e. Display as[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–41 ✎ Steps 3 through 7 apply to HP Pa vilion zv6000 models. See steps 8 through 12 in this section to remov e the base enclosure on Compaq Presario R4000 models. 3. Remov e the thirteen PM2.0×15.0 scre ws that secure the base enclosure to the notebook. Remo ving the Base Enc[...]

5–4 2 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 4. Remov e the four PM2.0×7.0 scre ws that secure the base enclosure to the notebook. Remo ving the Base Enc losure Sc re w s, P a rt 2 , HP P av ilion z v 6000 Models[...]

Remo val and Replacement Pr ocedures Maintenance and Servi ce Guide 5–43 5. Access the fan cable through the memory module e xpansion compartment and disconnect the fan cable from the system board. Disconnecting the F an Cable , HP P av ilion z v6000 Models[...]

5–44 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 6. Swing the rear edge of the base enclosure 1 up and forward until it rests at an angle. 7. Lift the base enclosure 2 up and remov e it. Remo ving the Base Enc losure , HP P av ilion z v6000 Models[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–45 ✎ Steps 8 through 12 apply to Co mpaq Presario R4000 models. 8. Remov e the ten PM2.0×15.0 scre ws that secure the base enclosure to the notebook. Remo ving the Base Enc losur e Scr e w s, P art 1, Compaq Pr esario R4000 Models[...]

5–46 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 9. Remov e the f i ve PM2.0×7.0 scre ws that secure the base enclosure to the notebook. Remo ving the Base Enc losur e Scr e w s, P art 2 , Compaq Pr esario R4000 Models[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–4 7 10. Access the fan cable through the memory module e xpansion compartment and disconnect the fan cable from the system board. Disconnecting the F an Cable , Compaq Pr esario R4 000 Models[...]

5–48 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 11. Swing the rear edge of the base enclosure 1 up and forward until it rests at an angle. 12. Lift the base enclosure up 2 and remov e it. Re mo v ing the Base Enc losur e, C ompaq Pr esari o R4000 Models Re verse the abo v e procedure to install the base enclosure.[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–49 5. 1 6 Fa n A s s e m b l y 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.7 ) c. K eyboard co ve r ( Section 5.8 ) d. K eyboard ( Section 5.11 ) e. Display assembly [...]

5–50 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 3. Remov e the three PM2.0×4.0 coarse scre ws 1 that secure the fan to the base enclosure. ✎ The scre ws remov ed in Step 3 have a coarser thread than other PM2.0×4.0 scre ws used in the notebook. 4. Remov e the fan assembly 2 . Re mo v ing the F an Assembly Re verse t[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–51 5. 1 7 S p e a ke r 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.7 ) c. K eyboard co ve r ( Section 5.8 ) d. K eyboard ( Section 5.11 ) e. Display assembly ( Sectio[...]

5–5 2 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 3. Disconnect the speaker cable 1 from the system board. 4. Lift the rear edge of the speaker 2 up and swing it forward. 5. Remov e the speaker 3 . Re mo v ing the Speak er Re verse the abo v e procedure to install the speaker .[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–53 5. 1 8 Fr o n t B o a r d ✎ The front board remov al procedures in this section apply to HP Pa vilion zv6000 models. 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.[...]

5–54 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 3. Release the ZIF connector 1 to which the front board cable is attached and disconnect the cable 2 . Disconnecting the F ront Boar d Cable[...]

Remo val and Replacement Pr ocedures Maintenance and Servi ce Guide 5–5 5 4. Remov e the two PM2.0×4.0 scre ws 1 that secure the front board to the top cov er . 5. Remov e the front board 2 . Remo ving the F ront Boar d Re verse the abo v e procedure to install the front board.[...]

5–5 6 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 5 . 1 9 Thermal Module 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.7 ) c. K eyboard co ve r ( Section 5.8 ) d. K eyboard ( Section 5.11 ) e. Display assembly ( [...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–5 7 2. Position the top cov er with the rear panel to ward you. 3. Remov e the four PM2.0×11.0 spring-loaded shoulder scre ws 1 that secure the thermal module to the notebook. 4. Remov e the thermal module 2 . Remo ving the T hermal Module[...]

5–5 8 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es ✎ The thermal paste should be thoroughly cleaned from the surfaces of the thermal module 1 and processor 2 each time the thermal module is remov ed. Thermal paste is included with all thermal module and processor spare part kits. Ther mal P ast e Locati ons Re verse the[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–5 9 5. 2 0 P ro c e s s o r 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.7 ) c. K eyboard co ve r ( Section 5.8 ) d. K eyboard ( Section 5.11 ) e. Display assembly ( S[...]

5–60 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 2. Slide the tip of the processor release arm 1 to the right until it clears the tab 2 on the processor socket. 3. Swing the arm 3 up and back as far as possible. 4. Remov e the processor 4 . ✎ The gold triangle 5 on the processor should be aligned in the front left corn[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–61 5. 2 1 T h e r m a l Fr a m e 1. Prepare the notebook for disassembly ( Section 5.3 ) and remov e the following components: a. Hard dri ve ( Section 5.4 ) b . Optical dri ve ( Section 5.7 ) c. K eyboard co ve r ( Section 5.8 ) d. K eyboard ( Section 5.11 ) e. Display assembl[...]

5–6 2 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 3. Remov e the PM2.0×7.0 scre w that secures the thermal frame to the top cov er . Remo ving the T hermal F rame Sc re w[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–63 4. T urn the notebook upside down with the rear panel to ward you. ✎ Steps 5 and 6 apply to HP Pa vilion zv6000 models. 5. Remov e the two PM2.0×3.0 scre ws 1 that secure the top cov er rear bezel to the top co ver . 6. Remov e the top cov er rear bezel 2 . ✎ The top co[...]

5–64 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 7. Disconnect the fan cable 1 from the system board. 8. Remov e the six PM2.0×7.0 scre ws 2 that secure the thermal frame to the top cov er . 9. Remov e the thermal frame 3 . Remo ving the T hermal F rame[...]

Remo val and Replacement Pr ocedures Maintenance and Servi ce Guide 5–65 10. Remov e the PM1.5×3.0 scre w 1 that secures the fan shield to the thermal frame. 11. Remov e the fan shield 2 . Re mo v ing the F an Shield[...]

5–66 Maintenance and Servi ce Guide Remo val and Replaceme nt Pr ocedur es 12. Remov e the three PM1.5×3.0 scre ws 1 that secure the fan to the thermal frame. 13. Remov e the fan 2 . Re mo v ing the F an Re verse the abo v e procedure to install the thermal frame.[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–6 7 5. 22 Sys t e m B o a r d ✎ When replacing the system board, ensure that the follo wing components are remov ed from the defecti ve system board and installed on the replacement system board: ■ Memory modules ( Section 5.6 and Section 5.13 ) ■ Mini PCI communications [...]

5–6 8 Maintenance and Serv ice Guide Remo val and Replaceme nt Pr ocedur es 2. Release the system board ZIF connector to which the T ouchPad cable is connected and disconnect the T ouchPad cable from the system board.[...]

Remo val and Replacement Pr ocedures Maintenance and Servi ce Guide 5–6 9 3. T urn the notebook upside down with the front to ward you. 4. Position the top cov er with the front to ward you. 5. Remov e the four PM2.0×7.0 scre ws 1 that secure the system board to the top cov er . 6. Remov e the two SM1.5×8.0 shoulder scre ws 2 on each side of th[...]

5–7 0 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 8. Lift the left side of the system board 1 until it rests at an angle. 9. Slide the system board 2 to the left and remov e it. Re mo v ing the S ystem Boar d[...]

Remo val and Replacement Pr ocedures Maintenance and Serv ice Guide 5–71 10. If necessary , disconnect both ends of the RJ-11 modem cable 1 from the system board and remov e the cable 2 . ✎ The RJ-11 modem cable is included in the Miscellaneous Cable Kit, spare part number 383671-001. Re mo v ing the RJ-11 Modem Cable[...]

5–7 2 Maintenance and Servi c e Guide Remo val and Replaceme nt Pr ocedur es 11. T urn the system board upside down with the rear panel to ward you. 12. Insert a flat blade tool into the notch on the R TC battery socket 1 and remo ve the R TC battery 2 . ✎ The R TC battery is included in the Miscellaneous Plastics Kit, spare part number 383670-[...]

Maintenance and Serv ice Guide 6–1 6 Spec ifica tions This chapter provides physical and performance specif ications. Ta b l e 6 - 1 Notebook Dimensions Metric U.S . HP P avilion zv6000 Height Width Depth Compaq Presario R4000 Height Width Depth 5.26 cm 36.20 cm 29.45 cm 5.26 cm 36.20 cm 28.40 cm 2.07 in 14.25 in 11.60 in 2.07 in 14.25 in 11.18 i[...]

6–2 Maintenance and Service Guide Spe cificat ions Input P ower Operating v oltage Operating current 18.5 V dc 4.9 A or 6.5 A T emperature Operating Nonoperating 10°C to 35°C -20°C to 60°C 50°F to 95°F -4°F to 140°F Relative humidity (noncondensing) Operating Nonoperating 10% to 90% 5% to 95% 10% to 90% 5% to 95% Maximum altitude (unpress[...]

Specific atio ns Maintenance and Serv ice Guide 6–3 Ta b l e 6 - 2 15.4-inch, WXGA, TFT Displa y Dimensions Height Width Diagonal 20.7 cm 33.1 cm 39.1 cm 8.1 in 13.0 in 15.4 in Number of colors Up to 16.8 million Contrast ratio 200:1 Brightness 180 nits typical Pixel resolution Pitch Fo r m at Configuration 0.259 × 0.259 mm 1280 × 800 RGB verti[...]

6–4 Maintenance and Service Guide Spe cificat ions Ta b l e 6 - 3 15.0-inch, XGA, TFT Displa y Dimensions Height Width Diagonal 22.9 cm 30.0 cm 38.1 cm 9.0 in 11.8 in 15.0 in Number of colors Up to 16.8 million Contrast ratio 250:1 Brightness 150 nits typical Pixel resolution Pitch Fo r m at Configuration 0.264 × 0.264 mm 1024 × 768 RGB vertica[...]

Specific atio ns Maintenance and Serv ice Guide 6–5 Ta b l e 6 - 4 Hard Drives 100-GB* 80-GB* 60-GB* 40-GB* Dimensions Height Width We i g h t 9.5 mm 70 mm 99 g 9.5 mm 70 mm 99 g 9.5 mm 70 mm 102 g 9.5 mm 70 mm 99 g Interface type ATA - 5 ATA - 5 ATA - 5 ATA - 5 T ransfer rate Synchronous (maximum) Security 100 MB/sec A T A security 100 MB/sec A [...]

6–6 Maintenance and Service Guide Spe cificat ions Ta b l e 6 - 5 D VD/CD-R W Combo Drive Applicable disc Read: D VD-R, D VD-R W , D VD-ROM (D VD-5, D VD-9, D VD-10, D VD-18), CD-ROM (Mode 1 and 2) CD Digital A udio , CD-XA ready (Mode 2, F orm 1 and 2), CD-I ready (Mode 2, F orm 1 and 2), CD-R, CD-R W , Photo CD (single and multisession), and CD[...]

Specific atio ns Maintenance and Serv ice Guide 6–7 Access time CD media DV D m e d i a Random Full stroke < 110 ms < 210 ms < 130 ms < 225 ms A udio output level Line-out, 0.7 V rms Cache b uffer 2 MB Data transfer rate CD-R (24X) CD-R W (10X) CD-ROM (24X) DV D ( 8 X ) Multiword DMA mode 2 3600 KB/s (150 KB/s at 1X CD rate) 1500 KB/s[...]

6–8 Maintenance and Service Guide Spe cificat ions Ta b l e 6 - 6 D VD±R W and CD-R W Combo Drive Applicable disc Read: DV D - R , DV D - R W, DV D - R O M ( DV D - 5 , D VD-9, D VD-10, D VD-18) CD-ROM (Mode 1 and 2) CD Digital A udio CD-XA ready (Mode 2, F orm 1 and 2) CD-I ready (Mode 2, F orm 1 and 2) CD-R CD-R W Photo CD (single and multises[...]

Specific atio ns Maintenance and Serv ice Guide 6–9 Access time CD DV D Random Full stroke < 175 ms < 285 ms < 230 ms < 335 ms A udio output level A udio-out, 0.7 Vr ms Cache b uffer 2 MB Data transfer rate CD-R (16X) CD-R W (8X) CD-ROM (24X) DV D ( 8 X ) D VD-R (4X) DV D - R W ( 2 X ) Multiword DMA mode 2 2,400 KB/s (150 KB/s at 1X C[...]

6–10 Maintenance and Serv ice Guide Spe cificat ions Ta b l e 6 - 7 System DMA Hard ware DMA System Function DMA0 Not applicable DMA1 Not applicable DMA2 Not applicable DMA3 Not applicable DMA4 Direct memor y access controller DMA5 A vailable f or PC Card DMA6 Not assigned DMA7 Not assigned[...]

Specific atio ns Maintenance and Serv ice Guide 6–11 Ta b l e 6 - 8 System Interrupts Hard ware IRQ System Function IRQ0 System timer IRQ1 Quick Launch b uttons IRQ2 Cascaded IRQ3 USB2 Enhanced Host Controller—24CD IRQ4 COM1 IRQ5* Cone xant A C—Link A udio SMBus Controller—24C3 Data F ax Modem with Smar tCP IRQ6 Diskette drive IRQ7* Pa r a [...]

6–12 Maintenance and Serv ice Guide Spe cificat ions Hard ware IRQ System Function IRQ12 Synaptics PS/2 por t pointing device IRQ13 Numeric data processor IRQ14 Primar y IDE channel IRQ15 Secondar y IDE channel IRQ17 Cone xant A C -Link A udio IRQ17 Soft V90 Data F ax Modem with Smar tCP IRQ17 A Ti Mobility Radeon Xpress 200 Series IRQ19 Standard[...]

Specific atio ns Maintenance and Serv ice Guide 6–13 Ta b l e 6 - 9 System I/O Addresses I/O Address (he x) System Function (shipping configuration) 0x00000000-0x00000CF7 PCI bus 0x00000000-0x00000CF7 Direct memor y access controller 0x00000020-0x00000021 Programmab le interrupt controller 0x0000002E-0x0000002F System board resources 0x00000040-0[...]

6–14 Maintenance and Serv ice Guide Spe cificat ions I/O Address (he x) System Function (shipping configuration) 0x000001F0-0x000001F7 Primar y IDE Channel 0x00000220-0x0000022F System board resources 0x00000274-0x00000277 ISAPNP Read Data P or t 0x00000279-0x00000279 ISAPNP Read Data P or t 0x00000280-0x00000293 System board resources 0x00000376[...]

Specific atio ns Maintenance and Serv ice Guide 6–15 I/O Address (he x) System Function (shipping configuration) 0x00000C6F-0x00000C6F System board resources 0x00000CD4-0x00000CD5 System board resources 0x00000CD6-0x00000CD7 System board resources 0x00000CD8-0x00000CDF System board resources 0x00000D00-0x0000FFFF PCI bus 0x00000F40-0x00000F47 Sys[...]

6–16 Maintenance and Serv ice Guide Spe cificat ions T able 6-10 System Memory Map Memory Map Address (he x) System Function (shipping configuration) 0xD4100000-0xD41FFFFF PCI standard PCI-to-PCI bridge 0xD4100000-0xD41FFFFF A TI MOBILITY RADEON Xpress 200 Series 0xD8000000-0xDBFFFFFF PCI standard PCI-to-PCI bridge 0xD8000000-0xDBFFFFFF A TI MOBI[...]

Specific atio ns Maintenance and Serv ice Guide 6–17 Memory Map Address (he x) System Function (shipping configuration) 0xD4208000-0xD42087FF T e xas Instruments OHCI Compliant IEEE 1394 Host Controller 0xD4200000-0xD4203FFF T e xas Instruments OHCI Compliant IEEE 1394 Host Controller 0xD4204000-0xD4205FFF Broadcom 802.11b/g WLAN 0xFFEFF000-0xFFE[...]

6–18 Maintenance and Serv ice Guide Spe cificat ions Memory Map Address (he x) System Function (shipping configuration) 0xD4209400-0xD42094FF Realtek R TL8139/810x F a mily F ast Ethernet NIC 0xD4003400-0xD40034FF Cone xant A C-Link A udio 0xD4003800-0xD40038FF SoftV90 Data F ax Modem with Smar tCP 0xFEC00000-0xFEC00FFF System board resources 0xF[...]

Maintenance and Serv ice Guide A–1 A Con necto r P in Ass i gn ment s Ta b l e A - 1 A udio-Out (Headphone) Pin Signal Pin Signal 1 A udio out, left channel 3 Ground 2 A udio out, right channel[...]

A–2 Maintenance and Service Guide Connec tor P in Assignments Ta b l e A - 2 A udio-In (Micr ophone) Pin Signal Pin Signal 1 A udio in, left channel 3 Ground 2 A udio in, right channel Ta b l e A - 3 Universal Serial Bus Pin Signal Pin Signal 1 +5 VDC 3 Data + 2 Data – 4 Ground[...]

Connect or P in Assi gnments Maintenance and Serv ice Guide A–3 Ta b l e A - 4 External Monitor Pin Signal Pin Signal 1 Red analog 9 +5 VDC 2 Green analog 10 Ground 3 Blue analog 11 Monitor detect 4 Not connected 12 DDC 2B data 5 Ground 13 Horizontal sync 6 Ground 14 V ertical sync 7 Ground 15 DDC 2B clock 8 Ground[...]

A–4 Maintenance and Service Guide Connec tor P in Assignments Ta b l e A - 5 RJ-45 (Network) Pin Signal Pin Signal 1 T ransmit + 5 Unused 2 T ransmit – 6 Receive – 3 Receive + 7 Unused 4 Unused 8 Unused[...]

Connect or P in Assi gnments Maintenance and Serv ice Guide A–5 Ta b l e A - 6 RJ-11 (Modem) Pin Signal Pin Signal 1 Unused 4 Unused 2 Tip 5 Unused 3 Ring 6 Unused[...]

A–6 Maintenance and Service Guide Connec tor P in Assignments Ta b l e A - 7 S-Video-Out Pin Signal Pin Signal 1 C (chrominance) 5 Composite video 2 Ground 6 Not connected 3 Y (luminance) 7 Ground 4 Ground[...]

Maintenance and Serv ice Guide B–1 B P o w er Co rd Set Requiremen ts 3-Con duc tor P o w er Cord Set The wide range input feature of the notebook permits it to operate from any line v oltage from 100 to 120 or 220 to 240 volts A C. The po wer cord set included with the notebook meets the requirements for use in the country where the equipment is[...]

B–2 Maintenance and Service Guide P ow er Cord Set Requir ements Gen eral Requirements The requirements listed belo w are applicable to all countries. ■ The length of the po wer cord set must be at least 1.5 m (5.0 ft) and a maximum of 2.0 m (6.5 ft). ■ All po wer cord sets must be approv ed by an acceptable accredited agency responsible for [...]

P o wer C or d Set Requir ements Maintenance and Serv ice Guide B–3 Countr y- Spec ifi c Requirements 3-Conductor P ower Cord Set Requirements Country/Region Accredited Agency Applicable Note Number Au s t ra l i a EANSW 1 Au s t r i a OV E 1 Belgium CEBC 1 Canada CSA 2 Denmark DEMK O 1 Finland FIMK O 1 F rance UTE 1 Germany VDE 1 Italy IMQ 1 Jap[...]

B–4 Maintenance and Service Guide P ow er Cord Set Requir ements Ko r e a EK 4 The Netherlands KE A 1 Norwa y NEMK O 1 P eople’ s Republic of China CCC 5 Sweden SEMK O 1 Switzerland SEV 1 Ta i w a n BSMI 4 United Kingdom BSI 1 United States UL 2 ✎ NOTES: 1. The fle xible cord m ust be <HAR> T ype HO5VV -F , 3-conductor , 1.0 mm² conduc[...]

Maintenance and Serv ice Guide C–1 C Scre w List ing This appendix provides specif ication and reference information for the scre ws and scre w locks used in the notebook. All scre ws listed in this appendix are av ailable in the Screw Kit, spare part number 383673-001.[...]

C–2 Maintenance and Servi ce Guide Scr ew L isting Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 1 T wo scre ws that secure the hard driv e co v er to the notebook (screws are captured on the cov er by C clips; documented in Sectio[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–3 Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 1 T wo scre ws that secure the hard driv e to the notebook (documented in Section 5.4 ) 2 One screw that secures the o[...]

C–4 Maintenance and Servi ce Guide Scr ew L isting Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the displa y assemb ly to the notebook on HP P avilion zv6000 models (documented in Section 5.14 ) mm[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–5 Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the displa y assemb ly to the notebook on HP P avilion zv6000 models (documented in Section 5.14 [...]

C–6 Maintenance and Servi ce Guide Scr ew L isting Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the displa y as sembly to the notebook on Compaq Presario R4000 models (documented in Section 5.14 ) [...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–7 Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 1 T wo scre ws that secure the disp la y assembly to the notebook on Compaq Presario R4000 models (documented in Secti[...]

C–8 Maintenance and Servi ce Guide Scr ew L isting Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the base enclosure to the notebook on HP P avilion zv6000 models (documented in Section 5.15 ) mm[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–9 Phillips P M2 .0×7 . 0 Scr e w L ocation Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: One screw that secures the thermal frame to the top cov er (documented in Section 5.21 ) mm[...]

C–10 Maintenance and Serv ice Guide Scr ew L isting Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 6 screws that secure the thermal fr ame to the top cov er (documented in Section 5.21 ) mm[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–11 Phillips P M2 .0×7 . 0 Scr e w L ocations Ta b l e C - 1 Phillips PM2.0×7.0 Screw (Continued) Color Qty . Length Thread Head Width Black 40 7.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the system boar d to the top co v er (documented in Section 5.22 ) mm[...]

C–12 Maintenance and Serv ice Guide Scr ew L isting Phillips P M3 . 0×4. 5 Sc r e w L ocations Ta b l e C - 2 Phillips PM3.0×4.5 Screw Color Qty . Length Thread Head Width Black 4 4.5 mm 3.0 mm 4.0 mm Where used: 4 screws that secure the hard driv e fram e to the hard drive (documented in Section 5.4 ) mm[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–13 Phillips P M2 .0×15 . 0 Sc r e w L ocations Ta b l e C - 3 Phillips PM2.0×15.0 Screw Color Qty . Length Thread Head Width Black 27 15.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the k e yboard co v er to the notebook (documented in Section 5.8 ) mm[...]

C–14 Maintenance and Serv ice Guide Scr ew L isting Phillips P M2 .0×15 . 0 Sc r e w L ocations Ta b l e C - 3 Phillips PM2.0×15.0 Screw (Continued) Color Qty . Length Thread Head Width Black 27 15.0 mm 2.0 mm 4.5 mm Where used: 13 screws that secure the base enclos ure to the top co v er on HP P avilion zv6000 models (documented in Section 5.1[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–15 Phillips P M2 .0×15 . 0 Sc r e w L ocations Ta b l e C - 3 Phillips PM2.0×15.0 Screw (Continued) Color Qty . Length Thread Head Width Black 27 15.0 mm 2.0 mm 4.5 mm Where used: 10 screws that secure the base en closure to the to p cov er on Compaq Presar io R4000 models (documented in Sect[...]

C–16 Maintenance and Serv ice Guide Scr ew L isting Phillips P M2 .0×4. 0 Scr ew L ocations Ta b l e C - 4 Phillips PM2.0×4.0 Screw Color Qty . Length Thread Head Width Black 8 4.0 mm 2.0 mm 4.5 mm Where used: 2 screws that secure the v olume board to the keyboard co v er on Compaq Presario R4000 models (documented in Section 5.9 ) mm[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–17 Phillips P M2 .0×4. 0 Scr ew L ocations Ta b l e C - 4 Phillips PM2.0×4.0 Screw (Continued) Color Qty . Length Thread Head Width Black 8 4.0 mm 2.0 mm 4.5 mm Where used: 4 screws that secure the k e yboard to the notebook (documented in Section 5.11 ) mm[...]

C–18 Maintenance and Serv ice Guide Scr ew L isting Phillips P M2 .0×4. 0 Scr ew L ocations Ta b l e C - 4 Phillips PM2.0×4.0 Screw (Continued) Color Qty . Length Thread Head Width Black 8 4.0 mm 2.0 mm 4.5 mm Where used: 2 screws that secure the front board to the top co v er on HP P avilion zv6000 models (documented in Section 5.18 ) mm[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–19 Phillips P M1.5×3 .0 Sc re w Locati ons Ta b l e C - 5 Phillips PM1.5×3.0 Screw Color Qty . Length Thread Head Width Silver 6 3.0 mm 1.5 mm 4.0 mm Where used: 2 screws that secure the Bluetooth boa rd to the notebook (documented in Section 5.10 ) mm[...]

C–20 Maintenance and Serv ice Guide Scr ew L isting Phillips P M1.5×3 .0 Sc re w Locati ons Ta b l e C - 5 Phillips PM1.5×3.0 Screw (Continued) Color Qty . Length Thread Head Width Silver 6 3.0 mm 1.5 mm 4.0 mm Where used: 1 One screw that secures the f an cover to the thermal frame (documented in Section 5.16 ) 2 Three screws that secure the f[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–21 Phillips P M2 .0×4. 0 Coarse T hr ead Sc r e w L ocations Ta b l e C - 6 Phillips PM2.0×4.0 Coarse Thread Scre w Color Qty . Length Thread Head Width Black 3 4.0 mm 2.0 mm 4.0 mm Where used: 3 screws that secure the f an assembly to the base enclosure (documented in Section 5.16 ) mm[...]

C–2 2 Maintenance and Servi c e Guide Scr ew L isting Phillips P M2 .0×11. 0 Spring-L oaded Shoulder Scr ew Locati ons Ta b l e C - 7 Phillips PM2.0×11.0 Spring-Loaded Shoulder Screw Color Qty . Length Thread Head Width Silver 4 11.0 mm 2.0 mm 8.0 mm Where used: 4 screws that secure the thermal module to the no tebook (documented in Section 5.2[...]

Sc rew Li s t i n g Maintenance and Serv ice Guide C–2 3 Phillips P M2 .0×3 .0 S cr ew L ocations Ta b l e C - 8 Phillips PM2.0×3.0 Screw Color Qty . Length Thread Head Width Silver 2 3.0 mm 2.0 mm 5.0 mm 2 screws that secure the top co v er rear bezel to the top co v er (documented in Section 5.21 ) mm[...]

C–2 4 Maintenance and Servi c e Guide Scr ew L isting Phillips P M1.5×8. 0 Scr ew L ocations Ta b l e C - 9 Phillips PM1.5×8.0 Screw Color Qty . Length Thread Head Width Silver 2 8.0 mm 1.5 mm 2.0 mm 2 screws that secure the system boar d to the top co v er (documented in Section 5.22 ) mm[...]

Maintenance and Serv ice Guide Index–1 Ind e x 1394 port 1–10 A all-in-one media cable, spare part number 3–17 , 3–19 arrow keys 1–15 audio troubleshooting 2–23 audio Y-cable, spare part number 3–17 audio-in jack location 1–10 pin assignments A–2 audio-out jack location 1–10 pin assignments A–1 B base enclosure removal 5–40 [...]

Index–2 Maintenance and Servi ce Guide Index Computer Setup defaults 2–3 connector pin assignments audio-in A–2 audio-out A–1 external monitor A–3 headphone jack A–1 microphone jack A–2 RJ-11 A–5 RJ-45 A–4 S-Video-out A–6 Universal Serial Bus (USB) A–2 connectors, service considerations 4–2 D design overview 1–24 Digital M[...]

Index Maintenance and Serv ice Guide Index–3 features 1–1 feet illustrated 3–16 locations 5–11 flowcharts, troubleshooting no audio 2–23 , 2–24 no network/modem connection 2–28 no OS loading 2–17 no OS loading from diskette drive 2–21 no OS loading from hard drive 2–18 , 2–19 , 2–20 no OS loading from optical drive 2–22 no[...]

Index–4 Maintenance and Servi ce Guide Index L Label Kit, spare part number 3–17 , 3–21 left-side components 1–12 M mass storage devices, spare part numbers 3–14 memory module removal 5–11 , 5–31 spare part numbers 3–11 , 3–23 , 5–11 , 5–31 memory module compartment cover illustrated 3–16 location 1–23 removal 5–12 Memor[...]

Index Maintenance and Serv ice Guide Index–5 power cord set requirements B–2 spare part numbers 3–17 , 3–19 power management features 1–5 power supply, spare part numbers 3–17 , 3–25 power, troubleshooting 2–10 power/standby button 1–17 , 1–19 power/standby light 1–6 , 1–8 precautions DVD/CD-RW Combo Drive 4–3 DVD±RW and [...]

Index–6 Maintenance and Servi ce Guide Index notebook 6–1 optical drive 6–6 system DMA 6–10 static shielding materials 4–8 S-Video-out jack location 1–11 pin assignments A–6 system board removal 5–67 spare part numbers 3–9 , 3–25 , 5–67 system DMA 6–10 T thermal frame removal 5–61 spare part numbers 3–9 , 3–21 , 5–61[...]

Index Maintenance and Serv ice Guide Index–7 USB digital drive, spare part number 3–18 USB travel mouse, spare part number 3–18 , 3–19 V vent, locations 1–9 , 1–11 , 1–16 , 1–22 video troubleshooting 2–14 volume board removal 5–23 spare part number 3–5 , 3–22 , 5–23 volume buttons 1–7 , 1–19 W Windows applications key [...]