Husqvarna HUV 4213-GXP manuale d’uso

Owner’s Ma nual 2007 4213 Utilit y Vehicle Gasoline HUV 4213-G HUV 4213-GXP[...]

[...]

Husqvarna Forest an d Garden 7349 S t atesvil le Rd. Charlotte , NC 2826 9 USA www .usa.hu sqvarna.c om/huv 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 1 NOTICE The Hus qvarna® L imited T wo Y ear Warranty for 2007 Transportation and Utili ty V ehicle s and California Emi s- sion Co ntrol Warranty St atemen t appe ar on the la st page[...]

Page 2 200 7 HUV4213 G asolin e Vehic le Owner ’s Manua l FOREWORD Thank y ou for cho osing Husqv arna, a world lea der in outdoor products. Y ou hav e chosen the finest u tility vehicl e on the mark et. Plea se protec t your investme nt and ens ure that yo ur Husq varn a vehicl e provid es yea rs of reliab le, supe rior per formance by read ing [...]

2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 3 TABLE OF CONTENTS Vehicl e Feature Identi ficatio n ............... ............. ............. ............. ............. ................... .......... .......... .......... 4 Safety De tails ............. ............. ............. ............. ............. ................... ......[...]

Vehicl e Fea ture Ident ifica tion Page 4 200 7 HUV4213 G asolin e Vehic le Owner ’s Manua l HUV4213-G VEHICLE LO ADING DECAL OPERA TING INSTRUCTIONS DECAL DIFFERENTIAL LOCK CONTROL DECAL BED LO AD W ARNING DECAL DRIVER/P ASSENGER W ARNING DECAL UNDERA GE W ARNING DECAL (UNDER SEA T SUPPORT) (ON T OP OF FUEL T ANK) KEY SWITCH FUEL SHUT -OFF VA LV[...]

Vehicl e Fea ture Ident ifica tion 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 5 HUV4213-G P ARK BRAKE RECEIVER HITCH (SHO WN WITH OPTIONAL TUBE BUMPER) WINCH CABLE W ARNING DECAL FOR W ARD/REVERSE HANDLE CHOKE BED LA TCH W ARNING DECAL DIODE WIRING DECAL (ON FRONT AND REAR RECEIVER HITCHES) FRAME GROUND AND GO VERNOR W ARNING DECAL (O[...]

Page 6 200 7 HUV4213 G asolin e Vehic le Owner ’s Manua l HUV4213-GXP VEHICLE LO ADING DECAL OPERA TING INSTRUCTIONS DECAL DIFFERENTIAL LOCK CONTROL DECAL BED LO AD W ARNING DECAL DRIVER/P ASSENGER W ARNING DECAL UNDERA GE W ARNING DECAL (UNDER SEA T SUPPORT) (ON T OP OF FUEL T ANK) KEY SWITCH FUEL SHUT -OFF VA LV E (T OP OF P ASSENGER SIDE FENDE[...]

2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 7 HUV4213-GXP P ARK BRAKE RECEIVER HITCH WINCH CABLE W ARNING DECAL FOR W ARD/REVERSE HANDLE CHOKE BED LA TCH W ARNING DECAL DIODE WIRING DECAL (ON FRONT AND REAR RECEIVER HITCHES) FRAME GROUND AND GO VERNOR W ARNING DECAL (ON FRAME) RO T A TING P ARTS AND HO T MANIFOLD DECAL (ON ST ARTER/GEN[...]

Page 8 200 7 HUV4213 G asolin e Vehic le Owner ’s Manua l PR OPOSITION 65 - ST A TE OF CALIFORNIA This product contains or emits c hemicals or substances that have been determined by the state of Calif ornia to cause cancer and birth defects or other repr oductive harm. ! W ARNING Rotating P a r t s Practice Saf ety Safety signs like y ou see abo[...]

Safety D etails 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 9 SAFETY DET AILS ý W ARNING • This owner’s ma nual should be r ead completely befor e attempting to drive or service the vehicle. Failure to follow the in structions in this manual could result in property damage, severe personal injury , or death. It is important to not[...]

General W arnings Page 10 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual GENERAL W ARNINGS The foll owing safet y statements must b e heeded wheneve r the vehi cle is be ing oper ated, repair ed, or ser - viced. V ehicle feature iden tific ation inform atio n is also i ncluded be ginni ng on page 4. Othe r specific safety statements ap pear th[...]

Mode l Ident ificatio n 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 11 ý W ARNING • Frame ground – Do not allow tools or other met al object s to cont act frame when disconnecting batt ery cables or other electric al wiring. Do not allow a positive wire to touch the vehicle frame , engine, or any other met al component. • Wear s[...]

Controls and Indicato rs Page 12 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual CONTROLS AND INDICATORS See General W arnings on p age 10. ý W ARNING • Be fore allowi ng an yone to dr ive t he ve hic le, ma ke su re th e driv er i s fam ilia r with all contro ls and operating pr ocedures. • Do not t amper with th e governor . Doing so wil[...]

Controls and Indicato rs 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 13 CA UT ION • Do not “rev” the engine for long periods of time while the Forward/Reverse handle is in the NEUTRAL position. Failure to heed this caution could result in damage to t he unitized transaxle . • Do not shift the Fo rward/R everse h andle w hile t [...]

Controls and Indicato rs Page 14 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual BRAKE PEDAL The brake pe dal is th e large pedal on the l eft with the word S TOP molde d into it (Figure 5) . T o slow or stop the ve hicle, p ress the brake p edal (Figure 6) . PARK BRAKE The park brake han dle is located bet ween the dr iver an d passenger seats[...]

Controls and Indicato rs 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 15 DIFFERENTIAL LOCK ý W ARNING • With the differential lock engaged, vehicle turning functions are greatly reduced. T o prevent loss of vehic le contro l when differ ential loc k is engage d, do not op erate vehi cle at spee ds greater than half throttle and use c[...]

Seat Latc h and A djustmen t Page 16 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual HEADLAMP CONTROL The headl amp contr ol is lo cated o n the inst rument panel between the fuel gaug e/hour meter and steering col- umn. Pu ll the head lamp c ontro l knob out to turn the head lamps on and p ush the knob i n to tur n the hea dlamps off. NOTE: Us[...]

Perfor mance In spec tion 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 17 • Fuel: Check fuel l evel. See Fueling Instructions on pa ge 33. Check fuel tank, lines , fuel cap, p ump, fuel filte rs, and carb uretor fo r fuel leak age on a daily basis . • Exhaust system: Chec k for le aks. • Hydrau lic brake s: Check fl uid leve l. Se[...]

Drivin g Instruc tions Page 18 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual DRIVING INSTRUCTIONS ý W ARNING • Only lic ensed drivers sh ould be al lowe d to drive this ve hicle. • Be fore allowi ng an yone to dr ive t he ve hic le, ma ke su re th e driv er i s fam ilia r with all contro ls and operating pr ocedures. • No one under the[...]

Drivin g Instruc tions 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 19 ST ARTING THE V EHICLE 1. Read safet y warnin gs on dash and v ehicle loading i nformati on loc ated abov e pedal s. 2. Be su re lo ad, if a ny , is secu re. 3. S tudy and un derstand co ntrols. 4. Be su re all passeng ers a re seated and hol ding on to hand h olds. [...]

Bed Latc h and P rop Rod Page 20 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual PARKING AND LEAVING THE V EHICLE 1. After stoppi ng the v ehicle , set ha nd br ake un til it loc ks. Make sur e it is f ully engaged . This w ill pre vent the ve hicle fr om roll ing. 2. T urn the k ey switc h to th e OFF po sitio n and pla ce the Forward/Re verse[...]

Front Shock A bsor bers 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 21 FRONT SHOCK ABSORBERS The veh icle arriv es from th e facto ry with th e front co il-ove r shock s pre-adj usted for optim um vehic le perfor- mance. We do not reco mmend adj usting the s hock abso rbers unl ess the vehicle will be equipped with a cab enclosu r e. I[...]

Towing with the Ve hicle Page 22 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual T OWING WITH T HE V EHICLE ý W ARNING • Do not tow a vehicle or trailer on public street s or highways. • Normal vehicle operating speed should be reduced when towing. • Extreme caution should be used when towing. • Do not allow riders in the vehicle or tr[...]

Storag e 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 23 ST ORAGE See General W arnings on p age 10. ý DA N G E R • Do not attempt to drain gasoline when the engine is hot or while it is running. • Be sure t o clean up an y spilled gasolin e before opera ting the v ehicle. • Store gasoli ne in an approv ed gasoline co ntainer onl[...]

Storag e Page 24 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual 7. Disconn ect the batter y cables, nega tive (–) cab le first. See W ARNIN G “T o avoid unintentionally start- ing...” on p age 10. 8. Batterie s shou ld be c lea n and free of co rrosi on. Wash tops and terminal s of batt er ies with a solutio n of baking soda a nd water ([...]

Maintena nce 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 25 6. Connect batte ry cabl es, posi tive (+) ca ble firs t, and tighten ter minals to 12 ft-lb (16 N·m). Coat terminals with Batte ry T ermi nal Prot ector Spray (P/N 603 00 0 0-03). 7. Comple tely open the fuel s hut-o ff valve (Figure 13) . Ma ke sure t he valve is fully open[...]

Period ic Se rvice Schedul e Page 26 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual ý W ARNING • Only trained te chnicians should service or r epa ir the vehicle. Anyone doing even simple rep airs or service should have knowledge and experience in electrica l and mechanical rep air . The appropriat e instructions must be used w hen performi[...]

Period ic Se rvice Schedul e 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 27 ý W ARNING • If any problems are found during scheduled inspection or service, do not operate vehicle until repairs are made. Failure t o make ne cessar y repairs could r esult in fire, pro perty dama ge, severe personal injury , or death. PERIODI C SERVI CE[...]

Perio dic Lubr ication Sched ule Page 28 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual PERIODIC LUBRICATION SCHEDULE PERIODIC LUBRICATION SCHEDULE REGULAR INTERVAL SERVICE LUBRICATION POINTS RECOMMENDED LUBRICANT Semian nually b y owner or traine d t echnicia n (o r every 50 hou rs of operation, w hichever comes first) Brake pedal shaft beari[...]

Mast er Cy linde r 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 29 MASTER CYLINDER The mas ter cyl inder is lo cated u nder th e passenger bucket s eat toward t he cent er of the ve hicl e (Figure 16) . Raise or r emove the se at to c heck the brake fl uid leve l. When che cking th e bra ke fluid, also ins pect the follow ing: • The p[...]

Engin e Oil Page 30 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual ENGINE OIL AND FILTER CHA NGE Engine oil and oil fil ter shoul d be changed after the fir st 100 hour s of operatio n. After that, they should be changed e very 2 00 hour s of oper ation or annua lly , wh ichever come s first. 1. T urn the key switch to the O FF positi on then [...]

Engin e Oil 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 31 9. Place a floo r jack unde r the rear receiv er hitch where the hi tch and bod y frame are fasten ed. Lift the vehi- cle bod y sl ightly , allowi ng the fr ont o f the e ngine to tilt s lightly downw ard. This will allo w the oi l filt er mor e cleara nce under the elec trical[...]

Engin e Oil Page 32 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual NOTE: An oil drip guard can be used to prev ent exces s oil from d rippi ng int o the engi ne base pl ate. Us e an empt y quart (1 liter ) containe r and cu t the bo ttom off at an a ngle, then slid e the op en area o f the container up and under the oil filter prior to rem ova[...]

Fuelin g Instruc tions 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 33 OIL V ISCOSITY Choose the visco sity ac cording to the t emper ature as shown in the oil visco sity ch art (Figure 23) . NOTE: Us ing multi -grade o ils (5W-20, 10 W-30, and 1 0W-40) will in crea se oil c onsumptio n. Chec k oil lev el more frequ ently when usin g th[...]

Battery Page 34 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual NOTE: Wh eneve r possib le, avo id using oxyg enated fuels and fuels tha t are b lended wit h alc ohol. Vehicles to be stored for ex tended pe riods shoul d be prepared for storage as ins tructed. See Pr eparin g the V ehicle for Extended S torage on page 23. 3. Replace f uel cap o[...]

Battery 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 35 ý W ARNING • Do not jump-st art a dead batt ery using another battery and jumper cables. The battery in a Husqvarna v ehicle is a 12-volt, low-maint enance battery that requir es inf requent ch ecks (Figure 25) . Electrolyte le vel s hould be che cked s emiann ually . 1. T urn t[...]

Cleaning the Ve hicle Page 36 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual Be sur e battery hold -down cl amp is properl y tighten ed. Tighten to 12 ft -lb (16 N·m ). A loose c lamp may allo w the batt ery to be come damaged fr om vibr ation or jarri ng. If battery app ears weak, hav e it charged by a trained tec hnicia n. The battery s hou[...]

Subse quent Ow ner Regi stratio n 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 37 ELECTR IC WINCH ACCES SORY If your veh icle is equipped with an e lectri c winch, rea d and fo llow all man ufacture r safety warnings and instruc tions i n the win ch op erator manual, a s well a s the fol lowin g WA RNING and CAUTION sta tements. Make su[...]

Vehicl e Specif icati ons Page 38 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual V EHICLE SPE CIFICATIONS SPECIFICATIO NS HUV4213-GXP H UV4213-G POWER SOURCE Engi ne: 4-cycle OHV , 40 0 cc, 13.0 max imum HP @3600 rpm (per SAE J 1 940/1349), single- cylinde r , air-co oled, wi th pressu re lubr icatio n system • Fuel sy stem : Side- draft car[...]

Vehicl e Specif icati ons 2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 39 DIMENSIONS/WEIGHT , Con tinued Seat hei ght 35 in. (89 cm) Load bed heigh t 31.1 in. (79 cm ) Load bed size (box b ed insi de dim ensions) 48.0 x 49.8 x 10.9 in. (121.4 x 1 26.4 x 27.6 cm) (15.3 cu bic feet) Load bed size (fla t bed di mension s) 46.9 x 48 .3 in. [...]

Page 40 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual HUSQVARNA ® LIMITED T WO Y EAR W ARRANTY FOR 2007 T RANSPORTATION AND UTILITY V EHICLES 1. W ARRANTY : HUSQV ARNA, INC., ("HUSQV ARNA") hereby warrants to the Original Reta il Purchaser that its new 2007 Model T ransportatio n and Utility V ehicles purchased from HUSQV ARN A or [...]

2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 41 6. DISCLAIMER: THIS LIMITED WARRANTY IS EXCLUSIVE. HUS QV ARNA MAKES NO OTHER WARRANTY OF A NY KIND, EXPRESSED OR IMPLIED. ANY IMPL IED W ARRANTIES OF ME RCHANT ABILITY O R FITNESS FOR A P AR TICULAR PURPOSE WHI CH EXCE ED THE OBLIGA TIO NS OR TIME LIMITS ST A TED IN THIS WARRANTY ARE HERE[...]

Page 42 2007 HUV42 13 Ga soline V ehicle Own er’s Ma nual CALIFORNIA EMISSION CONTROL W ARRANTY ST ATEMENT Y ou r new Husqvarn a, Inc . ("HUS QV ARNA") v ehicle e ngine co mplie s with both the U.S. E P A and State of Cal ifornia emissio n regulat i ons. YOUR W ARRANTY RIGHTS AND OBLIGA T IONS: The Cali fornia A ir Reso urces B oard (&q[...]

2007 HUV421 3 Gasol ine Vehi cle Owne r’s Man ual Page 43 FUEL AND OIL RECOMMENDATIONS Fuel Use only clean, fresh, unleaded regular grade gasoline. Octane Rating The octane rating of a gasoline is a measure of its resistance to “knocking”.Use of a mini- mum of 87 octane of the anti-knock index is recommended.The anti-knock index is posted on [...]

[...]

[...]

Publication Part Number 5 31 30 81-87 Edition Code 0706A 00000 CCI P/N 103218318[...]