Intel Full-size CPU Card manuale d’uso

Full - size CPU Card FSB - 865G FSB - 865G Intel ® Pentium ® 4 & Celeron ® Processors Full - size CPU Card With DDR, Ethernet, CompactFlash ™ & Mini PCI FSB - 865G Rev. A Manual 2nd Ed. Dec . 2004[...]

Full - size CPU Card FSB - 865G i Copyright Notice This document is copyrighted, 200 4 . All rights are reserved. The original manufacturer reserves the right to make improvements to the products described in this manual at any time without notice. No part of this man ual may be reproduced, copied, translat ed, or transmitted in any form or by any [...]

Full - size CPU Card FSB - 865G ii Acknowledg ments All other product s ’ name or trademarks are properties of their respective owners. l Award is a trademark of Award Software International, Inc. l CompactFlash ™ is a trademark of the Compact Flash Association . l Intel ® , Pentium ® M, and Celeron ® M are trademarks of Intel ® Corporation[...]

Full - size CPU Card FSB - 865G iii Packing List Before you begin installing your card, please make sure that the following materials have been shipped: • 1 FSB - 865G CPU Card • 1 Floppy Cable • 1 ATA - 100 Cable • 1 USB Cable • 1 KB Cable • 1 Ser ial + Parallel Cable • 1 Serial Cable • 1 ATX Cable • 1 Quick Installation Guide ?[...]

Full - size CPU Card FSB - 865G iv Conte nts Chapter 1 General Information 1. 1 Introduction .................................................................................. 1 - 2 1. 2 Feature ........................................................................................... 1 - 4 1. 3 Specification ......................................[...]

Full - size CPU Card FSB - 865G v 2.18 ATX Power Control Connector (CN2) ................................... 2 - 15 2. 19 Audio Connector (CN 3) ............................................................ 2 - 15 2.20 PS/2 keyboard & Mouse Connector (CN4) ........................... 2 - 16 2.21 Internal Keyboard Connector (CN5) ................[...]

Full - size CPU Card FSB - 865G vi Appendix A I/O Informa tion A .1 I/O Address Map ................................................................... A - 2 A.2 1 st MB Memory Address Map ............................................... A - 3 A.3 IRQ Mapping Chart ............................................................... A - 4 A.4 DMA Channel[...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 1 General Information Chapter 1[...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 2 1.1 Introduction Introducing AAEON’s new FSB - 865G, powered by Intel ® Pentium ® 4/Prescott processor, full size form factor single board computer (SBC) with an onboard VGA, 10/100/1000Mb LAN optional and seven USB 2.0 ports. FSB - 865G successfully deployed Intel ® most adva[...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 3 In dustrial applications will benefit from the seven USB 2.0 by three pin - headers and one Type A connector onboard, offering 480Mbps high - speed efficiency and value without compromising performance. Moreover, FSB - 865G is also equipped with Dual Intel ® Ethern et controllers.[...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 4 1. 2 Feature • Support Intel ® Pentium ® 4 CPU up to 3.2GHz (Prescott CPU) • Integrated AC - 97 Codec Audio (Daughter Board optional) • Support Ultra ATA100 & SATA & CompactFlash ™ Type II Storage • Support 7 USB 2.0 Port • Support RS - 232 x 1, RS - 232/422/4[...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 5 1.3 Specification System l CPU: Support Intel R Pentium ® 4 and Celeron R Processors up to 3.2 GHz (400/533/800MHz FSB) l Chipset: Intel ® 865GV + Intel ® 82801EB/ER (ICH5/ICH5R) l I/O Chipset : Winbond W83627HF l Ethernet : 10/100Mb or 10/100/1000Mb LAN opt ional, RJ - 45 x 2 I[...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 6 l Battery : Lithium battery l Power Supply Voltage : +12V ATX, other supply from Backplane l VGA Controller: Integrat ed on Intel ® 865GV, AGP, Core frequency up to 266MH z l LCD Controller: Chrontel CH7017A support TV - Out and LVDS output l Audio Daughter board : Realtek ALC655 [...]

Full - size CPU Card FSB - 865G Chapter 1 General Information 1 - 7 l Memory size: Shared memory up to 6 4 MB l Resolution s : Up to 2048 X 1536 @ 75MHz for CRT I/O l Enhanced IDE Interface ATA - 100 x 2 channel (support 4 ATAPI devices) l FDD Interface: Standard FDD port x 1 (support up to 2 floppy devices) l Serial Ports: COM 1: RS - 232 COM 2: R[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 1 Quick Installation Guide Chapter 2 Part No. 2007 8650 10 Printed in Taiwan Nov. 2004 Notice: The Quick Installation Guide is derived from Chapter 2 of user manual. For other chapters and further installation instruction s , please refer to the user manual CD - ROM that c a me [...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 2 2.1 Safety Precaution Always completely disconnect the power cord from your board whenever you are working on it. Do not make connections while the power is on, because a sudden rush of power can damage sen sitive electronic components . Always ground yourself to remove any st[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 3 2. 2 Location of Connectors and Jumpers Component Side CN3 SATA2 SATA1 JP2 CN6 TV1 IR1 CN8 CN7 CN5 MPCI1 FAN ATX2 ATX1 CN2 DIM1 DIM2 DIM3 DIM4 FP2 FP1 LPT1 COM1 COM2 IDE1 IDE2 FDD1 USB4 LAN1 VGA1 LAN2 CN4 JP1 USB3 USB2 USB1 inbond W83627HF-AW W[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 4 Solder Side CFD1[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 5 2. 3 Mechanical Dra wing Component Side 92.08 78.64 53.43 27.71 9.37 14.10 12.55 6.28 1.60 13.40 14.50 6.50 100.51 102.49 98.50 92.25 82.73 72.57 53.42 38.25 2.49 8.84 15.70 W83627HF-AW W inbond 3.02 19.51 98.60 94.56 94.56 98.60 10.36 28.78 76.40 90.37 100.38 197.82 208.48 10[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 6 Solder Side 335.48 19.51 102.49 3.02 331.50 98.50 256.75 56.43 89.61 30.18 74.47 1.73 98.50 0.00 0.00 CFD1[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 7 2. 4 List of Jumper s The board has a number of jumpers that allow you to configure your system to suit your application. The table below shows the function of each of the board's jumpers : Jumpers Label Function JP1 Clear CMOS JP2 LCD Voltage Selection[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 8 2. 5 List of Connectors The board has a number of connectors that allow you to configure your system to suit your application. The table below shows t he function of each board's connectors: Connectors Label Function FAN Fan Connector CN2 ATX Power Control Connector CN3 A[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 9 CFD1 CompactFlash Slot COM1 RS - 232 Serial Port Connector COM2 RS - 232/422/485 Serial Port Connector IR1 IrDA Connector LPT1 LPT Port Connector USB1~3 USB Connector USB4 USB Connector LAN1 10/100 or 100/1000Base - Tx Ethernet Connector LAN2 10/100 or 100/1000Base - Tx Ethern[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 10 2. 6 Setting Jumpers You configure your card to match the needs of your application by setting jumpers. A jumper is the simplest ki nd of electric switch. It consists of two metal pins and a small metal clip (often protected by a plastic cover) that slides over the pins to co[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 11 2. 7 Clear CMOS ( JP1 ) JP1 Function Close Cl ear Open Protected (Default) 2. 8 LCD Voltage Select ion ( J P 2 ) JP 2 Function 1 - 2 +5V 2 - 3 +3.3 V (Default) 2. 9 Front Panel Connector (F P 1) Pin Signal Pin Signal 1 Power On Button (+) 2 Reset Switch (+) 3 Power On Button [...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 12 2. 10 Front Panel Connector (FP2) Close Pin 5 - 7: Internal Buzzer Enable Close Pin 1 - 7: External Speaker Enable Pin Signal Pin Signal 1 External Speaker (+) 2 Keyboard Lock (+) 3 N.C. 4 GND 5 Inte rnal Buzzer ( -) 6 I2C Bus SMB Clock 7 External Speaker ( -) 8 I2C Bus SMB D[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 13 2. 13 RS - 232/422/485 Serial Port Connector (COM2) Pin Signal Pin Signal 1 DCD (422TXD - /485DATA -) 2 RXD (422RXD+) 3 TXD (422TXD+/485DATA+) 4 DTR (422RXD -) 5 GND 6 DSR 7 RTS 8 CTS 9 RI 10 N.C. 2. 14 IrDA Connector (IR1) Pin Signal 1 +5V 2 N.C. 3 IRRX 4 GND 5 IRTX 6 N.C. 2[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 14 7 DATA2 8 #SLIN 9 DA TA3 10 GND 11 DATA4 12 GND 13 DATA5 14 GND 15 DATA6 16 GND 17 DATA7 18 GND 19 #ACK 20 GND 21 BUSY 22 GND 23 PE 24 GND 25 SELECT 26 N.C. 2. 16 USB Connector (USB1~3) Pin Signal Pin Signal 1 +5V 2 GND 3 USBD1 - 4 GND 5 USBD1+ 6 USBD2+ 7 GND 8 US BD2 - 9 GND[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 15 2. 17 Fan Connector (CN1 ) Pin Signal 1 GND 2 +12V 3 Speed Sense 2. 18 ATX Power Control Con nector (CN2 ) AT Power Use: Close Pin 2, 3 Pin Signal 1 PS - ON 2 +5V 3 5VSB 2. 19 A udio Connector (CN3 ) Pin Signal Pin Signal 1 AC_RST - 2 AC_SYNC 3 AC_DAIN2 4 AC_DAOUT 5 GND 6 AC_[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 16 2. 20 PS/2 keyboard & Mouse Con nector (CN4 ) Pin Signal 1 KB_DATA 2 MS_DATA 3 GND 4 +5V 5 KB_CLK 6 MS_CLK 2. 21 Internal keyboard Con nector (CN5 ) Pin Signal 1 KB_CLK 2 KB_DATA 3 N.C. 4 GND 5 +5V[...]

Full - size CPU Card FSB - 865G Chapter 2 Quick Installation Guide 2 - 17 2. 22 LVDS Channel Con nector (CN6 ) Pin Signal Pin Signal 1 BKLEN 2 BKLCTL 3 PPVCC 4 GND 5 CH1_CLK# 6 CH1_CLK 7 PPVCC 8 GND 9 CH1_TX0# 10 CH1_TX0 11 CH1_TX1# 12 CH1_TX1 13 CH1_TX2# 14 CH1_TX2 15 CH1_TX3# 16 CH1_TX3 17 I2C_DATA 18 I2C_CLK 19 CH2_TX0# 20 CH2_ TX0 21 CH2_TX1# 2[...]

Full - size CPU Card FSB - 865G Chapter 3 Award BIOS Setup 3 - 1 Award BIOS Setup Chapter 3[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 2 3.1 System Test and Initialization These routines test and initialize board hardware. If the routines encounter an error during the tests, you will either hear a few short beeps or see an error message on the screen. There are two kinds of errors: fatal and non - fatal. The system can[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 3 3.2 Award BIOS Setup Awards BIOS ROM has a built - in Setup program that allows users to modify the basic system configuration. This type of information is stored in battery - backed CMOS RAM so that it retains the Setup information when the power is turned off. Entering setup Power o[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 4 Integrated Peripherals Use this menu to specify your settings for integrated peripherals. (Primary slave, secondary slave, keyboard, mouse etc.) Power Management Setup Use this menu to s pecify your settings for power management. (HDD power down, power on by ring etc.) PnP/PCI Configu[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 5 Exit Without Saving Abandon all CMOS value changes and exit setup.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 6 3.3 Standard CMOS Features When you choose the S tandard CMOS Features option from the INITIAL SETUP SCREEN menu , the screen shown below is displayed. This standard Setup Menu allows users to configure system components such as date, time, hard disk drive, floppy drive and display. O[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 7 3.4 Advanced BIOS F eatures B y choosing the Advanced BIOS Features option from the INITIAL SETUP SCREEN menu, the screen below is displayed. This sample screen contains the manufacturer’s default values for the FSB - 865G[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 8 l CPU Feature l Hard Disk Boot Priority[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 9 3.5 Advanced Chipset Features B y choosing the Advanced Chipset Features option from the INITIAL SETUP SCREEN menu, the screen below is displayed. This sample screen contains the manufacturer’s default values for the FSB - 8 65G.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 10 3.6 Integrated Peripherals By choosing the I ntegrated P eripherals from the INITIAL SETUP SCREEN menu, the screen below is displayed. This sample screen contains the manufacturer’s default values for the FSB - 865G.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 11 3.7 Power management Set up By choosing the P ower Management Setup from the INITIAL SETUP SCREEN menu, the screen below is displayed. This sample screen contains the manufacturer’s default values for the FSB - 865G.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 12 3.8 PnP / PCI configuration By choosing the PnP/PCI configurat ions from the Initial Setup Screen menu, the screen below is displayed. This sample screen contains the manufacturer’s default values for the FSB - 865G.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 13 3.9 PC Health Status By choosing the P C Health Status from the Initial Setup Screen menu, the screen below is displayed. This sample screen contains the manufacturer’s default values for the FSB - 865G.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 14 3.10 Frequency / Voltage control By choosing the Frequency/Voltage Control from the Initial Setup Screen menu, the screen below is displayed. This sampl e screen contains the manufacturer’s default values for the FSB - 865G .[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 15 3.11 Load Fail - Safe Defaults When you press <Enter> on this item you get a confirmation dialog box with a message similar to: Load Fail - Safe Default (Y/N)? Pressing "Y" loads the BIOS default values for the most stable, minimal performance system operations.[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 16 3.1 2 Load Optimized Defaults When you press <Enter> on this item you get a confirmation dialog box with a message similar to: Load Optimized Defaults (Y/N)? Pressing "Y" loads the default values that are manufacturer ’ s settings for optimal performance system oper[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 17 3.13 Set Supervisor / User Password You can set either SUPERVISOR or USER PASSWORD, or both of them. The difference between the two is that the supervisor pa ssword allows unrestricted access to enter and change the options of the setup menus, while the user password only allows entr[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 18 3.14 Save & E xit Setup If you select this option and press <Enter>, the values entered in the setup utilities will be recorded in the chipset’s CMOS memory. The microprocessor will check this every time you turn on your system and compare this to what it finds as it chec[...]

Full - size CPU Card FSB - 865G C hapter3 Award BIOS Setup 3 - 19 3.15 Exit without saving Selecting this option and pressing <Enter> allows you to exit the Setup program without recording any new value or changing old one.[...]

Full - size CPU Card FSB - 865G Chapter 4 Driver Installation 4 - 1 Driver Installation Chapter 4[...]

Full - size CPU Card FSB - 865G Chapter4 Drivers Installation 4 - 2 The FSB - 865G come s with a CD - ROM that contains all drive r s and utilities that meet your needs. F ollow the sequence below to install the drivers: Step 1 – Install Intel ® INF Update Step 2 – Install Graphic Driver Step 3 – Install Ethernet Driver Step 4 – Install A [...]

Full - size CPU Card FSB - 865G Chapter4 Drivers Installation 4 - 3 4.1 Installation: Insert the FSB - 865G CD - ROM into the CD - ROM Drive. And install the drivers from Step 1 to Step 6 in order. Step 1 – Install Intel ® INF Update 1. Click on the Intel ® INF Update folder and then double click on t he setup .exe. 2. Follow the instructions t[...]

Full - size CPU Card FSB - 865G Chapter4 Drivers Installation 4 - 4 Step 4 – Install A C97 Audi o Driver 1. Click on the AC97 Audio Driver folder and then enter ALC655 folder. 2. Choose the OS folder that meet s your system and execute on the setup. exe. 3. Follow the instructions that the window will show you. 4. The system will help you install[...]

Full - size CPU Card FSB - 865G Appendix A I/O Information A - 1 I/O Information Appendix A[...]

Full - size CPU Card FSB - 865G Appendix A I/O Informaion A - 2 A.1 I / O Address Map[...]

Full - size CPU Card FSB - 865G Appendix A I/O Informaion A - 3 A.2 1 st MB Memory Address Map[...]

Full - size CPU Card FSB - 865G Appendix A I/O Informaion A - 4 A.3 IRQ Mapping Chart[...]

Full - size CPU Card FSB - 865G Appendix A I/O Informaion A - 5 A.4 DMA Channel Assignments[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Watchdog Timer B - 1 Programming the Watchdog Timer Appendix B[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Wa tchdog Timer B - 2 B.1 Programming FSB - 865G utilizes W83627H F chipset as its watchdog timer controller. Below are the procedures to complete its configuration and the AAEON intial watchdog timer program is also attached base d on which you can develop customized program to fit your ap[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Wa tchdog Timer B - 3 There are three steps to complete the configuration setup: (1) Enter the W83627HF config Mode (2) Modify the data of configuration r egisters (3) Exit the W83627HF config Mode. Undesired result may occur if the config Mode is not exited normally. (1) Enter the W83627HF[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Wa tchdog Timer B - 4 WatchDog Timer Register I (Index= F5 h, Defa ult=00h) CRF5 (PLED mode register. Default 0 x 00) Bit 7 - 6 : select PLED mode = 00 Power LED pin is tri - stated. = 01 Power LED pin is drived low. = 10 Power LED pin is a 1Hz toggle pulse with 50 duty cycle. = 11 Power LE[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Wa tchdog Timer B - 5 second/minutes ……………………………… .. = 0 x FF Time - o ut occurs after 255 second/minutes WatchDog Timer Register III (Index= F7 h, Default=00h) Bit 7 : Mouse interrupt reset Enable or Disable = 1 Watchdog Timer is reset upon a Mouse interrupt = 0 Wat[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Wa tchdog Timer B - 6 B.2 W83627HF Watchdog Timer Initia l Program Example: Setting 10 sec. as Watchdog timeout interval ;/////////////////////////////////////////////////////////////////////////////////////////////// M ov dx,2eh ;Enter W83627HF config mode M ov al,87h (out 87h to 2eh twice[...]

Full - size CPU Card FSB - 865G Appendix B Programming the Wa tchdog Timer B - 7 Dec dx Mov al,0f5h ;CRF5 (PLED mo de register) Out dx,al Inc dx In al,dx And al,not 08h ;Set second as counting unit Out dx,al ;/////////////////////////////////////////////////////////////////////////////////////////////// Dec dx Mov al,0f6h ; CRF6 Out dx,al Inc dx Mo[...]