Lennox Hearth 1900HT-M manuale d’uso

INSTALLATION AND OPERATION MANUAL RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE EPA CERTIFIED WOOD BURNING STOVE THIS APPLIANCE MUST BE INSTALLE D BY A QUALIFIED INSTALLER. READ ENTIRE MANUAL THOROUGHLY BEFORE INSTALLATION. P/N 775002M , Rev. F 11/03 MODEL 1900HT-M[...]

IMPORTANT WARNINGS CAUTION: PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL AND USE YOUR NEW ROOM HEATER. FOR YOUR SAFETY, FOLLOW THE INST ALLATION, OPERATION AND MAINTENANCE INSTRUC- TIONS EXACTLY, WITHOUT DEVIATION. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY, OR EVEN DEATH. IF THIS APPLI ANCE IS NOT PROPER[...]

PAGE 3 TABLE OF CONTENTS Important Warn ings ................................................ 2 Testing/Listing, EPA, Using this Manual .................. 3 Planning Your Inst allation ..................................... 4-6 Manufactured (Mobile) Ho me Requirements ........... 7 Installati on ......................................................[...]

PLANNING YOUR INSTALLATION PAGE 4 QUESTIONS TO ASK LOCAL BUILDING OFFICIAL A correct installation is critical and imperative for reduc- ing fire hazards and perilous conditions that can arise when wood burning appliances are improperly installed. The installer must follow all of the manufacturers’ in- structions. The installation of a wood burnin[...]

PLANNING YOUR INSTALLATION PAGE 5 FLOOR PROTECTION This appliance requires non-combustible floor protector for embe r pro tectio n. If the floor protection is to be stone, tile, brick, etc., it must be mortared or grouted to form a continuous non-combustible surface. If a chimney connector extends horizontally over the floor, prot ection must cover[...]

PLANNING YOUR INSTALLATION PAGE 6 COMBUSTIBLE WALL CLEARANCE WARNING: IT IS VERY IMPORTANT THAT YOU OBSERVE THE MINIMUM CLEARANCES. There are listed clearances for your stove which were determined in a Laboratory test using various "classes" of stove pipe or chimney. Minimums are first estab- lished for the stove itself and increased base[...]

INSTALLATION PAGE 7 MANUFACTURED (MOBILE) HOME REQUIREMENTS Approved for USA only. This appliance is not approved for installation into a manufac tured home in Canada. This stove is certified as a Room Heater, Solid Fuel Type and may be used in Manufactured Housing providing the following requirements are followed: • WARNING: DO NOT INSTALL IN SL[...]

INSTALLATION PAGE 8 GROUNDING STOVE Manufactured (Mobile) Homes Only Regulations require that all stoves installed in Manufac- tured Homes must be grounded. To do this simply at- tach a piece of No. 8 copper wire, at least 18" in length from the stove to the c hassis of the Manufactured Home. INSTALLING MARBLE ACCENTS Marble is a natural produ[...]

INSTALLATION PAGE 9 ACCEPTABLE CONNECTOR PIPE FOR INSTALLA- TIONS For Standard Residential Clearances: Six (6) inch minimum, single wall, minimum MSG black or 25 MSG blued steel connector pipe with listed factory-built chim- ney suitable for use with solid fuels or masonry. Three (3) pre-drilled holes are provided in the flue collar for fastening t[...]

INSTALLATION PAGE 10 CHIMNEY HEIGHT REQUIREMENTS The chimney must extend 3 f eet above the level of roof penetration and a minimum of 2 feet higher than any roof surface within 10 feet (see below). Check with your local building officials for any additional requirements for your area. Due to prevailing winds, local terrain, adjacent tall trees, a h[...]

INSTALLATION PAGE 11 RESIDENTIAL STANDARD Using 6” Diameter Single Wall Connector Pip e Not A pproved For Manufa ctured (Mobile) Homes MANUFACTURED (MOBILE) HOME STAN- DARD - Using 6” Diameter Type L-Vent Connector Pipe MANUFACTURED (MOBILE) HOME STANDARD - Using 6” Diameter Type L-Vent Connector Pipe[...]

INSTALLATION Combustible Wall Chimney Connector Pass-Throughs Notes: 1. Connectors to a masonry chimney , excepting method B, sha ll extend in one continuous section through the wall pass-through sy stem and the chimney wall, to but not past the inner flue liner face. 2. A chimney connector shall not pass through an attic or roof space, closet or s[...]

PRODUCT FEATURES AND CONTROLS CARE AND OPERATION PAGE 13 ASH DRAWER The large ash drawer located on the left side of the ped- estal is designed to make cleaning easier by containing the ashes in a removable drawer. CAUTION: DO NOT OPERATE THE STOVE WITH THE ASH DRAWER OPEN OR AJAR, AS THIS WILL PRODUCE EXTREME TEMPERATURES WITHIN THE STOVE (OVERFIR[...]

CARE AND OPERATION PAGE 14 GLASS The Glass is a super heat resi stant ceramic that withstands continuous temperatures up to 1390° F. This temperature is well beyond the temperatures in which you operate your stove. This unit is designed to provide a flow of air over the inside of the glass, where along with high heat helps keep it clean. When oper[...]

CARE AND OPERATION PAGE 15 BREAK-IN PERIOD Your stove finish is a high te mperature paint that requires time and temperature to completely cure. We recom- mend that you ventilate the house during the initial burns. The paint emits non-toxic odors during this process. KEEP YOUR HOUSE WELL VENTILATED DURING THE CURING PROCESS TO PREVENT ACTIVATION OF[...]

CARE AND OPERATION FUEL PAGE 16 HOW TO START AND MAINTAIN A FIRE 1. Open the primary air control by pulling the handle out ward to the full open position. This allows the firebox and fresh fuel to quickly come up to ideal operating temperature. 2. Build your fire directly on the firebrick covering the bottom of the stove. a. Place five or six loose[...]

MAINTENANCE PAGE 17 SMALL AREA PAINT TOUCH-UP The stove body is painted with a quality high-temperature stove paint. Use only model TSPK-B Stove Paint, Cata- log # 70K99. Do not touch-up your stove with any other paint. Using one small piece of 320 grit sand paper and lightly sand the blemish so that the edges are “feathered” or smooth to the t[...]

MAINTENANCE PAGE 18 CREOSOTE FORMATION AND NEED FOR REMOVAL What is Creosote - When wood is burned slowly, it pro- duces tar and other organic vapors, which combine with expelled moisture to form creosote. The creosote vapors condense in the relatively cool chimney flue of a slow- burning fire. As a result, creosote residue accumulates on the flue [...]

TROUBLESHOOTING PAGE 19 SMOKES OUT FUEL DOOR WHEN OPEN (see  ) 1. The primary air control is closed. 2. The chimney is too cool. Set the primary air control on "HIGH" for a few minutes before opening the fuel door. 3. Excess creosote will not only re strict your draft but it will create a risk of a creosote fire. Strictly adhere to mai[...]

REPLACEMENT PARTS FOR MODEL: 1900HT-M For the location of the nearest Dealer for replacement parts, contact: Lennox Hearth Products 1110 West Taft Avenue Orange, CA 92865 PAGE 20 PART NO. DESCRIPTION CAT. NO. Door Parts G300 Door Assembly, Gold (Handle Included) 86-128 Gasket Kit, 3/4" Door Rope (Includes Adhesive) 27M81 Gasket, Glass Channel [...]

COMPONENT DIAGRAMS – Model 1900HT-M Firebrick (Note: All brick are 1 ¼” thick) Part/Catalog # Quantity Dimensions Part/Catalog # Quantity Dimensions FB-1 10 9 x 4 1/2” FB9 2 9 x 1” notched FB-2 2 9 x 4 1/2” w /notch FB11 2 4 1/2 x 4 1/2” FB-3 2 9 x 4 1/2” w /hole FB23 2 5 x 1” FB7 4 9 x 2 1/8” 37075 (grate) 2 4 1/2 x 4 3/8” PAG[...]

OPTIONAL ACCESSORIES- Model 1900HT-M Note: Install and use accessories per instructions provided with the accessory kit. PAGE 22 Catalog # Model Description 14M67 OAFD-S Outside Air Floor Duct 5 1/4" Square 14M68 BCP-19 Back Cover Plate 14M22 BK-100 Blower Kit Includes Dial-A-Temp for Variable Speed Control 14M21 SSK Stove Stat Kit Thermally C[...]

SPECIFICATIONS : Model 1900HT-M PAGE 23 Approximate heating capaci ty ............................. Up to ~2000 Sq. Ft. .................................................... Up to 508 Sq. M Manufactured (Mobile) Home Appr oved ............................. Yes , U.S.A. install- ations only. Outside air pr ovision..................... Yes Flue posit [...]

SAFETY/LISTING LABEL PAGE 24[...]

EPA LABEL PAGE 25[...]

Page 26 OWNERSHIP RECORDS Dealer’s Name: Dealer’s Address: City: State: Zip Code: Serial Number: Date of Purchase: Date Installed: Notes: SERVICE AND MAINTENANCE LOG Service Service Service Date Technician Description[...]

1110 West Taft Avenue Orange, CA 92865[...]