Lenovo 4222 manuale d’uso

Har dwar e Maint enance Manual Machine T yeps: 4215, 4219, 4220, 4221, and 4222.[...]

[...]

Har dwar e Maint enance Manual Machine T yeps: 4215, 4219, 4220, 4221, and 4222.[...]

Note Before using this information and the pr oduct it supports, be sur e to read and understand the Chapt er 2 “Safety information” on page 3 and Appendix A “Notices” on page 169. F ourth Edition (Octorber 2011) © Copyright Lenovo 2010, 2011. LENOVO pr oducts, data, computer softwar e, and services have been developed ex clusively at priv[...]

Contents Chapter 1. About this manual . . . . . . 1 Important Safety Information . . . . . . . . . . 1 Important information about r eplacing RoHS compliant FRUs . . . . . . . . . . . . . . . 1 Chapter 2. Safety information . . . . . . 3 General safety . . . . . . . . . . . . . . . . 3 Electrical safety . . . . . . . . . . . . . . . 3 V oltage-sele[...]

Replacing the front audio and USB assembly . . 100 Replacing the internal speaker . . . . . . . . 101 Completing the FRU replacement . . . . . . . 103 Chapter 10. FRU lists . . . . . . . . 105 Overall: MT 4215, 4219, 4220, 4221, and 4222 . . 105 Mechanical FRUs . . . . . . . . . . . . . 116 Keyboar d and Mouse . . . . . . . . . . . . 120 Adapters a[...]

Chapter 1. About this manual This manual contains service and r eference information for ThinkStation™ computers listed on the cover . It is intended only for tr ained servicers who are familiar with L enovo® comput er pr oducts. Before servicing a Lenovo pr oduct, be sur e to read the Safety Information in Chapter 2 “Safety information” on [...]

be noncompliant, but in all cases, if the parts are compliant, the replacement parts must also be compliant. Note: RoHS and non-RoHS FRU part numbers with the same t and function are identied with unique FRU part numbers. Lenovo plans to tr ansition t o RoHS compliance well before the implementation date and expects its suppliers to be r eady[...]

Chapter 2. Safety information This chapter contains the safety information that you need t o be familiar with before servicing a computer . General safety F ollow these rules to ensur e gener al safety: • Observe good housekeeping in the ar ea of the machines during and after maintenance. • When lifting any heavy object: 1. Ensure you can stand[...]

Important: Use only appr oved t ools and test equipment. Some hand t ools have handles covered with a soft material that does not insulate you when working with live electrical curr ents. Many customers have, near their equipment, rubber oor mats that contain small conductive bers to decr ease electrostatic dischar ges. Do not use this type o[...]

V oltage-selection switch Some comput ers are equipped with a voltage-selection switch located near the power -cord connection point on the computer . If your comput er has a voltage-selection switch, ensure that you set the switch to match the voltage available at your electrical outlet. Setting the voltage-selection switch incorrectly can cause p[...]

5. Check for any obvious alter ations. Use good judgment as to the safety of any alter ations. 6. Check inside the unit for any obvious unsafe conditions, such as metal lings, contamination, water or other liquids, or signs of r e or smok e damage. 7. Check for worn, fr ayed, or pinched cables. 8. Check that the power -supply cover fast eners[...]

• German • Hebr ew • Italian • K orean • Spanish DANGER Electrical curr ent fr om power , telephone and communication cables is hazardous. T o avoid a shock hazard: • Do not connect or disconnect any cables or perform installation, maintenance, or recongur ation of this product during an electrical storm. • Connect all power cords [...]

CA UTION: When laser products (such as CD-ROMs, DVD-ROM drives, ber optic devices, or transmitters) are installed, note the following: • Do not remove the covers. Removing the covers of the laser product could result in e xposure to hazardous laser r adiation. Ther e are no serviceable parts inside the device. • Use of contr ols or adjustmen[...]

Chapter 2 . Safety information 9[...]

≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) 1 2 PERIGO 10 Hardwar e Maintenance Manual[...]

A corrent e elétrica pr oveniente de cabos de alimentação, de telefone e de comunicações é perigosa. P ara evitar risco de choque elétrico: • Não conecte nem desconect e nenhum cabo ou e xecute instalação, manut enção ou r econguração deste pr oduto dur ante uma tempestade com raios. • Conect e t odos os cabos de alimentação [...]

• Não remova as tampas. A r emoção das tampas de um produt o a laser pode r esultar em e xposição prejudicial à r adiação de laser . Não e xistem peças que podem ser consertadas no int erior do dispositivo. • A utilização de controles ou ajustes ou a ex ecução de pr ocedimentos diferentes dos especicados aqui pode resultar em e[...]

Chapter 2 . Safety information 13[...]

1 2 14 Hardwar e Maintenance Manual[...]

Chapter 2 . Safety information 15[...]

1 2 DANGER Le cour ant électrique pr ovenant de l'alimentation, du téléphone et des câbles de transmission peut présenter un danger . P our éviter tout risque de choc électrique : • Ne manipulez aucun câble et n'effectue z aucune opér ation d'installation, d'entr etien ou de recongur ation de ce pr oduit au cours d[...]

Connexion Déconnexion 1. Mett ez les unit és HORS TENSION. 2. Commencez par brancher tous les cor dons sur les unités. 3. Br anchez les câbles d'interface sur des connecteurs. 4. Br anchez les cordons d'alimentation sur des prises. 5. Mett ez les unit és SOUS TENSION. 1. Mett ez les unit és HORS TENSION. 2. Débr anchez les cordons [...]

≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) A TTENTION: Soulevez la machine avec précaution. A TTENTION: L'interrupteur de contrôle d'alimentation de l'unité et l'interrupteur dubloc d'alimentation ne coupent pas le courant électrique alimentantl'unité. En outre, le système peut être équipé de p[...]

• Die V erbindung zu den angeschlossenen Netzkabeln, T elek ommunikationssystemen, Netzwerk en und Modems ist vor dem Öffnen des Gehäuses zu unterbrechen, sofern in den Installations- und Kongur ationsproz eduren k eine anders lautenden Anweisungen enthalten sind. • Z um Installieren, T ransportieren und Öffnen der Abdeckungen des Comput [...]

Laserstrahlung bei geöffneter V erkleidung. Nicht in den Strahl blicken. K eine Lupen oder Spiegel verwenden. Strahlungsbereich meiden. ≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ACHTUNG: Arbeitsschutzrichtlinien beim Anheben der Maschine beachten. ACHTUNG: Mit dem Netzschalt er an der Einheit und am Netzteil wird die Stromversorgu[...]

Chapter 2 . Safety information 21[...]

1 2 PERICOL O La corr ente elettrica pr oveniente dai cavi di alimentazione, del t elefono e di comunicazione può essere pericolosa. P er evitar e il rischio di scosse elettriche: • Non collegare o scollegar e qualsiasi cavo oppure effettuare l'installazione, la manutenzione o la ricongurazione del prodotto dur ante un temporale. • Col[...]

• Se possibile, utilizzare solo una mano per collegare o scollegare i cavi di segnale. • Non accendere assolutamente appar ecchiature in presenza di incendi, perdite d'acqua o danno strutturale. • Scollegar e i cavi di alimentazione, i sist emi di t elecomunicazione, le reti e il modem prima di aprire i coperchi del dispositivo, salvo is[...]

PERICOL O Alcune unità laser contengono un diodo laser di Classe 3A o Classe 3B. T ener presente quant o segue: Aprendo l'unità vengono emesse r adiazioni laser . Non ssare il fascio, non guar darlo direttamente con strumenti ottici ed evitare l'esposizione al fascio. ≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) A TTENZ[...]

Chapter 2 . Safety information 25[...]

1 2 PELIGRO La corrient e eléctrica pr ocedente de cables de alimentación, t eléfonos y cables de comunicación puede ser peligr osa. Par a evitar el riesgo de descarga eléctrica: • No conecte ni desconecte los cables ni realice ninguna tar ea de instalación, mantenimiento o reconguración de este producto durante una tormenta eléctrica.[...]

• Desconecte los cables de alimentación, los sistemas de telecomunicaciones, las redes y los módems conectados antes de abrir las cubiertas de los dispositivos, a menos que se indique lo contrario en los pr ocedimientos de instalación y congur ación. • Conecte y desconect e los cables, como se describe en la tabla siguiente, cuando insta[...]

Algunos product os láser tienen incorporado un diodo láser de clase 3A o clase 3B. T enga en cuenta lo siguiente: Cuando se abre, queda e xpuesto a radiación láser . No mire directamente al rayo láser , ni siquiera con instrumentos ópticos, y evite exponerse directamente al rayo láser . ≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 l[...]

Chapter 3. Gener al information This chapter pr ovides gener al information that applies to all machine types support ed by this publication. Online Books folder The Online Books folder pr einstalled on your comput er contains the ThinkStation User Guide , which provides information about your computer t o help you set up, use, and maintain your co[...]

• Downloads and drivers • Links t o other useful sour ces of information Specications This section lists the physical specications for your comput er . Dimensions Width: 174.8 mm (6.88 inches) Height: 425.2 mm (16.74 inches) (oor to top of handle) Depth: 430.8 mm (16.96 inches) Weight Maximum conguration: 11.2 kg (24.7 lbs) Environm[...]

Chapter 4. Gener al Checkout Attention The drives in the comput er you ar e servicing might have been r earranged or the drive startup sequence might have been changed. Be e xtremely careful during write operations such as copying, saving, or formatting. Data or progr ams can be overwritten if you select an incorr ect drive. General err or messages[...]

– Has this congur ation ever worked? – If it has been working, what changes wer e made prior to it failing? – Is this the original report ed failur e? • Diagnostics version – T ype and version level • Har dware conguration – P rint (print screen) conguration curr ently in use – BIOS level • Oper ating syst em softwar e ?[...]

Chapter 5. Diagnostics Diagnostic pr ograms are used t o test hardwar e components of your comput er . Diagnostic progr ams ar e also used to r eport oper ating-system-controlled settings that interfere with the correct operation of your computer . Ther e are two pr ograms preinstalled on your comput er to help you diagnose computer problems: • L[...]

PC-Doctor for Rescue and Recover y The PC-Doctor for Rescue and Recovery diagnostic progr am is part of the Rescue and Recovery workspace on each L enovo computer . Use the PC-Doctor for Rescue and Recovery diagnostic progr am if you are unable to start the Windows oper ating system. T o run the PC-Doct or for Rescue and Recovery diagnostic pr ogra[...]

Note: Y ou can insert the disc into the optical drive when you ar e setting the startup device sequence. However , if you insert the disc int o the optical drive when you have already ent ered the oper ating system, you need to restart the comput er to access the diagnostic progr am. 3. F ollow the instructions on the scr een t o select the diagnos[...]

• DeviceID: Contains the component's unit-ID that corresponds to a x ed disk drive, removable media drive, serial or parallel port, processor , specic RIMM, or a device on the PCI bus. • Date: Contains the date when the diagnostic test was run. The dat e is r etrieved fr om CMOS and displayed using the YYYYMMDD format. • ChkDigits:[...]

2. Pr ess F3 again to save the le t o diskette or pr ess F2 t o print the le. Chapter 5 . Diagnostics 37[...]

38 Hardwar e Maintenance Manual[...]

Chapter 6. Using the Setup Utility progr am The Setup Utility pr ogram is used to view and change the congur ation settings of your comput er , r egardless of which operating syst em you are using. However , the oper ating system settings might override any similar settings in the Setup Utility pr ogram. Starting the Setup Utility progr am T o s[...]

• Not be your name or your user name • Not be a common wor d or a common name • Be signicantly different fr om your pr evious passwords P ower-On P assword When a P ower -On P asswor d is set, you ar e pr ompted to type a valid password each time the computer is turned on. The computer cannot be used until the valid password is typed in. A[...]

1. Start the Setup Utility progr am. See “Starting the Setup Utility pr ogram” on page 39. 2. F rom the Setup Utility progr am main menu, select Devices . 3. Depending on the device you want to enable or disable, do one of the following: • Select USB Setup to enable or disable a USB device. • Select A T A Drives Setup t o enable or disable [...]

• If you want to save the new settings, pr ess F10 to save and exit the Setup Utility progr am. • If you do not want to save the settings, select Exit ® Discard Changes and Exit . • If you want t o r eturn to the default settings, press F9 to load the default settings. 42 Hardwar e Maintenance Manual[...]

Chapter 7. Conguring RAID This chapt er provides information about how t o congure Redundant Arr ay of Independent Disks (RAID) for your computer . Note: The information about conguring RAID in this chapter is applicable only for a Windows environment. F or information about conguring RAID in a Linux environment, contact your Linux soft[...]

7. Pr ess Ent er t o initiat e volume cr eation. 8. When pr ompted, press Y t o accept the warning message and create the volume. 9. Return to step 2 on page 43 to creat e additional RAID volumes, or select Exit and press Ent er . 10. Pr ess Y when prompted t o conrm the e xit. Deleting RAID volumes This section describes how to use the Int el M[...]

Chapter 8. Symptom-t o-FRU Index The Symptom-to-FRU inde x lists err or sympt oms and possible causes. The most likely cause is listed rst. Always begin with Chapter 4 “General Checkout” on page 31 . This inde x can also be used to help you decide which FRUs to have available when servicing a comput er . If you ar e unable to correct the pro[...]

Diagnostic err or codes Refer to the following diagnostic error codes when using the diagnostic tests. See “Running tests” on page 35 for the specic type for information about the diagnostic pr ograms. In the following inde x, X can repr esent any number . Diagnostic Error Code FRU/Action 000-000-XXX BIOS T est P assed No action 000-002-XXX [...]

Diagnostic Error Code FRU/Action 000-197-XXX BIOS test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility pr ogram” on page 39 . 2. Re-run test. 3. Replace the component that is called out in warning statement 4. Replace the component under test. 000-198-XXX BIOS test aborte[...]

Diagnostic Error Code FRU/Action 001-038-XXX System Extension failure 1. Adapt er car d 2. Syst em boar d 001-039-XXX Syst em DMI data structur e err or 1. Flash the syst em. See “Updating (ashing) the BIOS” on page 165. 2. Syst em boar d 001-040-XXX System IRQ failure 1. P ower -off/on system and re-t est. 2. Syst em boar d 001-041-XXX Syst[...]

Diagnostic Error Code FRU/Action 001-273-XXX Syst em IRQ6 (diskette drive) failure 1. Diskett e C able 2. Diskett e drive 3. Syst em boar d 001-274-XXX System IRQ7 failure 1. Device on IRQ7 2. Syst em boar d 001-275-XXX System IRQ8 failure 1. Device on IRQ8 2. Syst em boar d 001-276-XXX System IRQ9 failure 1. Device on IRQ9 2. Syst em boar d 001-27[...]

Diagnostic Error Code FRU/Action 005-016-XXX Video Simple P attern test failure 1. Video Ram 2. Video car d, if installed 3. Syst em boar d 005-024-XXX Video Addressing test failur e 1. Video card, if installed 2. Syst em boar d 005-025-XXX Video Checksum V alue error 1. Video car d, if installed 2. Syst em boar d 005-027-XXX Video Conguration/S[...]

Diagnostic Error Code FRU/Action 005-2XX-XXX 005-3XX-XXX Video subsystem err or 1. Video card, if installed 2. Syst em boar d 006-000-XXX Diskett e interface T est P assed No action 006-0XX-XXX Diskette interface err or 1. Diskette drive C able 2. Diskett e drive 3. Syst em boar d 006-195-XXX Diskette interface T est aborted by user Information onl[...]

Diagnostic Error Code FRU/Action 011-196-XXX Serial port test halt, error threshold e xceeded 1. Pr ess F3 to review the log le. 2. Restart the test to reset the log le. 011-197-XXX Serial port test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility pr ogram” on page 3[...]

Diagnostic Error Code FRU/Action 014-197-XXX P arallel port test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility pr ogram” on page 39 . 2. Re-run test. 3. Replace the component that is called out in warning statement. 4. Replace the component under test. 014-198-XXX P ara[...]

Diagnostic Error Code FRU/Action 015-196-XXX USB port test halt, error thr eshold e xceeded 1. P ress F3 to r eview the log le. 2. Restart the test to reset the log le. 015-197-XXX USB port t est warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility pr ogram” on page 39 .[...]

Diagnostic Error Code FRU/Action 018-250-XXX PCI C ard Services err or 1. PCI card 2. Riser car d, if installed. 3. Syst em boar d 020-000-XXX PCI Interface T est Passed No action 020-0XX-XXX PCI Interface error 1. PCI card 2. Riser car d, if installed. 3. Syst em boar d 020-195-XXX PCI T est aborted by user Information only Restart the test, if ne[...]

Diagnostic Error Code FRU/Action 025-02X-XXX 025-03X-XXX 025-04X-XXX IDE Interface failure 1. IDE signal cable 2. Check power supply . 3. Reseat IDE signal cable. 4. IDE device 5. Syst em boar d 025-195-XXX IDE interface T est aborted by user Information only Restart the t est, if necessary . 025-196-XXX IDE int erface test halt, err or threshold e[...]

Diagnostic Error Code FRU/Action 030-196-XXX SCSI interface test halt, err or thr eshold ex ceeded 1. P ress F3 to r eview the log le. 2. Restart the test to reset the log le. 030-197-XXX SCSI interface t est warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility pr ogram”[...]

Diagnostic Error Code FRU/Action 071-00X-XXX 071-01X-XXX 071-02X-XXX Audio port error 1. Run the Setup Utility pr ogram. 2. Flash the syst em. See “Updating (ashing) the BIOS” on page 165 . 3. Syst em boar d 071-03X-XXX Audio port failur e 1. Speakers 2. Micr ophone 3. Audio car d, if installed. 4. Syst em boar d 071-04X-XXX Audio port failu[...]

Diagnostic Error Code FRU/Action 080-197-XXX Game P ort int erface test warning 1. Make sur e the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility pr ogram” on page 39 . 2. Re-run test. 3. Replace the component that is called out in warning statement. 4. Replace the component under test. 080-198-X[...]

Diagnostic Error Code FRU/Action 086-199-XXX Mouse P ort interface test failed, cause unknown 1. See “Undetermined pr oblems” on page 67. 2. Flash the system and r e-test. See “Updating (ashing) the BIOS” on page 165 . 3. Replace component under function test. 089-000-XXX Micr oprocessor T est P assed No action 089-XXX-XXX Micr oprocesso[...]

Diagnostic Error Code FRU/Action 170-199-XXX V oltage Sensor(s) test failed, cause unknown 1. See “Undetermined problems” on page 67. 2. Flash the system and r e-test. See “Updating (ashing) the BIOS” on page 165 . 3. Replace component under function test. 170-250-XXX 170-251-XXX V oltage Sensor(s) V oltage limit err or 1. P ower supply [...]

Diagnostic Error Code FRU/Action 201-XXX-XXX System Memory error 1. Replace the memory module called out by the test. 2. Syst em boar d 202-000-XXX Syst em Cache T est P assed No action 202-XXX-XXX System Cache err or 1. C ache, if removable 2. Syst em boar d 3. Micr oprocessor 206-000-XXX Diskett e Drive T est Passed No action 206-XXX-XXX Diskette[...]

Diagnostic Error Code FRU/Action 305-000-XXX Monitor DDC T est P assed No action 305-250-XXX Monit or DDC self test failure 1. Run the Setup Utility pr ogram to enable DDC. 2. C able 3. Monit or 4. Video card 5. Syst em boar d 415-000-XXX Modem T est P assed No action 415-XXX-XXX Modem error Remove the Modem and r e-test the system. Beep symptoms B[...]

POS T error codes Each time you power -on the system, it performs a series of tests that check the oper ation of the system and some options. This series of t ests is called the Power -On Self- T est , or POS T . POS T does the following operations. • Checks some basic syst em-board oper ations • Checks the memory oper ation • Starts the vide[...]

POST Error Message Description/Action Pr ess T AB t o show POS T screen P ressing the T AB key permits the user to toggle between the default POS T display screen and a custom POST display scr een. Error: Non-System disk or disk error Replace and press any key when r eady The BIOS was unable to nd a suitable boot device. Make sure the boot drive[...]

Message/Symptom FRU/Action "Insert a Diskette" icon appears with a known-good diagnostics diskette in the rst 3.5-inch diskett e drive. 1. Syst em Boar d 2. Diskett e Drive C able 3. Network Adapter Intensity or color varies fr om left t o right of char acters and color bars 1. Display 2. Video adapt er (if pr esent) 3. Syst em Boar d [...]

Undetermined problems This section pr ovides instructions on how to nd out the failing devices or adapt ers. 1. P ower-off the computer . 2. Remove or disconnect the following components (if installed) one at a time. a. External devices (modem, printer , or mouse) b. Any adapters c. Memory modules d. Ext ended video memory e. External C ache f. [...]

68 Hardwar e Maintenance Manual[...]

Chapter 9. Replacing FRUs This chapt er provides step-by-st ep instructions for replacing major FRUs. Important Be sur e to r ead and understand the Chapter 2 “Safety information” on page 3 before replacing any FRU . These pr ecautions and guidelines will help you work safely . FRU r eplacements are to be done only by tr ained service technicia[...]

Figure 2. Rear connector locations 1 Power cor d connector 8 Micr ophone connector 2 Serial port 9 Audio line-out connect or 3 PS/2® keyboar d and mouse connect ors (optional) 10 Audio line-in connect or 4 VGA monitor connect or (not applicable on some models) 11 PCI Expr ess x16 gr aphics card slot 5 DisplayP ort connect or (not applicable on som[...]

Figure 3. Component locations 1 Heat sink 7 F r ont syst em fan 2 Micr oprocessor 8 Secondary har d disk drive (installed in some models) 3 Memory module 9 Primary har d disk drive 4 Optical drive 10 Syst em boar d 5 C ard r eader (installed in some models) 11 Rear fan assembly 6 F ront bez el assembly 12 P ower supply Locating parts on the system [...]

Figure 4. System board part locations 1 4-pin power connector 13 F ront panel connect or 2 Micr oprocessor 14 Clear CMOS (Complementary Metal Oxide Semiconductor) /Recovery jumper 3 Micr oprocessor fan connect or 15 F ront USB connect ors (2) 4 DIMM 2 16 F r ont audio connector 5 DIMM 1 17 Internal speak er connect or 6 DIMM 4 18 PCI card slots (2)[...]

Internal drives ar e installed in bays. In this manual, the bays ar e r eferred to as bay 1, bay 2, and so on. Figur e 5 “Drive bay locations” on page 73 shows the locations of the drive bays. Figure 5. Drive bay locations The following list describes the type and siz e of the drive that you can install in each bay: 1 Bay 1 - Maximum height: 43[...]

T o r emove the comput er cover , do the following: 1. Remove any media from the drives and turn off all attached devices and the computer . 2. Disconnect all power cords from electrical outlets. 3. Disconnect the power cords, Input/Output (I/O) cables, and any other cables that are connected t o the computer . See “L ocating connectors on the fr[...]

1. Remove all media fr om the drives and turn off all attached devices and the computer . Then, disconnect all power cords fr om electrical outlets and disconnect all cables that are connect ed t o the computer . 2. Remove the computer cover . See “Removing the computer cover” on page 73. 3. Remove the front bez el by releasing the three plasti[...]

Figure 8. Opening the PCI card latch 4. If you ar e installing a PCI car d, r emove the appr opriate metal slot cover . If you are replacing an old PCI card, gr asp the old car d that is currently installed and gently pull it out of the slot. 76 Hardwar e Maintenance Manual[...]

Figure 9. Removing a PCI card Note: The card ts tightly int o the car d slot. If necessary, alt ernate moving each side of the card a small amount until it is removed fr om the card slot. 5. Remove the new PCI card from its static-prot ective package. 6. Install the new PCI card int o the appr opriate slot on the system boar d. See “Locating p[...]

Figure 10. Installing a PCI card 8. T o complete the installation or r eplacement, go t o “Completing the FRU r eplacement” on page 103. Installing or replacing a memory module Attention Do not open your computer or att empt any repair befor e r eading and understanding the “Important safety information” in the ThinkStation Safety and Warra[...]

3. L ocate the memory slots. See “Locating parts on the system board” on page 71. 4. Remove any parts that might prevent your access to the memory slots. Depending on your comput er model, you might need to remove the PCI Express x16 gr aphics car d for easier access to the memory slots. See “Installing or r eplacing a PCI car d” on page 75[...]

Figure 13. Installing a memory module 7. Reinstall the PCI Express x16 gr aphics car d if you have r emoved it. 8. T o complete the installation or r eplacement, go t o “Completing the FRU r eplacement” on page 103. Installing or replacing the optical drive Attention Do not open your computer or att empt any repair befor e r eading and understa[...]

Figure 14. Removing the optical drive 5. Install the optical drive r etainer on the side of the new optical drive. Figure 15. Installing the optical drive retainer 6. Slide the new optical drive into the drive bay from the front of the computer until the optical drive snaps int o position. Chapter 9 . Replacing FRUs 81[...]

Figure 16. Installing the optical drive 7. Connect the signal cable and the power cable to the new optical drive. Figure 17. Connecting the optical drive 8. Reinstall the front bez el. See “Removing and r einstalling the front bez el” on page 74. 9. T o complete the installation or r eplacement, go t o “Completing the FRU r eplacement” on p[...]

T o r eplace the power supply assembly, do the following: 1. Remove all media fr om the drives and turn off all attached devices and the computer . Then, disconnect all power cords fr om electrical outlets and disconnect all cables that are connect ed t o the computer . 2. Remove the computer cover . See “Removing the computer cover” on page 73[...]

This section pr ovides instructions on how to replace the battery . Y our comput er has a special type of memory that maintains the date, time, and settings for built-in featur es, such as parallel-port assignments (congur ation). A battery k eeps this information active when you turn off the computer . The battery normally requir es no char gin[...]

10. Use the Setup Utility progr am to set the date, time, and any passwor ds. See Chapter 6 “Using the Setup Utility pr ogram” on page 39. Replacing the heat sink and fan assembly Attention Do not open your computer or att empt any repair befor e r eading and understanding the “Important safety information” in the ThinkStation Safety and Wa[...]

Figure 21. Removing the heat sink and fan assembly 7. Lift the failing heat sink and fan assembly off the syst em board. Notes: a. Y ou might have to gently twist the heat sink and fan assembly to free it fr om the micropr ocessor . b. Do not touch the thermal gr ease while handling the heat sink and fan assembly . 8. P osition the new heat sink an[...]

CA UTION: The heat sink and micr oprocessor might be very hot. T urn off the computer and wait three to ve minutes to let the computer cool before removing the computer cover . T o r eplace the micr oprocessor , do the following: 1. Remove all media fr om the drives and turn off all attached devices and the computer . Then, disconnect all power [...]

d. Do not drop anything onto the micr oprocessor socket while it is e xposed. The socket pins must be kept as clean as possible. Figure 22. Removing the microprocessor 7. Mak e sur e that the small handle is in the r aised position and the micropr ocessor retainer is fully open. 8. Hold the new micr oprocessor and align the notches on it with the a[...]

3. Lay the comput er on its side for easier access to the system board. 4. Remove all memory modules and PCI car ds that are currently installed. See “Installing or replacing a memory module” on page 78 and “Installing or r eplacing a PCI card” on page 75. 5. Remove the secondary har d disk drive. See “Replacing the secondary har d disk d[...]

The failing system board must be r eturned with a micr oprocessor socket cover to prot ect the pins during shipping and handling. T o install the micropr ocessor socket cover: 1. Remove the micr oprocessor fr om the micr oprocessor socket. See “Replacing the micropr ocessor ” on page 86 . 2. Align the notches 1 on the micr oprocessor socket cov[...]

Replacing the primary har d disk drive Attention Do not open your computer or att empt any repair befor e r eading and understanding the “Important safety information” in the ThinkStation Safety and Warranty Guide that came with your computer . T o obtain a copy of the ThinkStation Safety and W arranty Guide , go to: http://www.lenovo.com/suppo[...]

Note: If you ar e installing a 2.5-inch hard disk drive, install the hard disk drive int o a 2.5-inch to 3.5-inch hard disk drive tray rst and then install the tr ay int o the blue br acket. Figure 27. Installing the hard disk drive into the bracket 10. Slide the new har d disk drive int o the drive cage until it snaps int o position. 11. Align [...]

Figure 28. Installing the primary hard disk drive 14. T o complet e the r eplacement, go to “Completing the FRU r eplacement” on page 103. Replacing the secondary hard disk drive Attention Do not open your computer or att empt any repair befor e r eading and understanding the “Important safety information” in the ThinkStation Safety and War[...]

Figure 29. Removing the secondary har d disk drive 6. P ull on the blue handle t o release and remove the har d disk drive fr om the hard disk drive cage. 7. Fle x the sides of the blue br acket to r emove the hard disk drive fr om the br acket. 8. T o install a new hard disk drive into the blue br acket, e x the bracket and align pin 1 , pin 2 [...]

10. Slide the har d disk drive cage with the new hard disk drive int o the chassis until it is directly underneath the metal tab. Figure 31. Installing the secondary hard disk drive 11. P ress the har d disk drive cage downwar d until it snaps into position. 12. Connect the signal cable and the power cable to the new hard disk drive. 13. T o comple[...]

Note: If your computer has a secondary har d disk drive installed, remove the secondary hard disk drive to get easier access to the fr ont USB connector on the syst em boar d. 5. P ress the blue release button and slide the car d reader out of the fr ont of the computer . Figure 32. Removing the card reader 6. Install the car d reader retainer on t[...]

Note: Not all computers have the fr ont fan assembly . T o r eplace the front fan assembly, do the following: 1. Remove all media fr om the drives and turn off all attached devices and the computer . Then, disconnect all power cords fr om electrical outlets and disconnect all cables that are connect ed t o the computer . 2. Remove the computer cove[...]

Figure 35. Installing the front fan assembly 7. Connect the fr ont fan assembly cable t o the power fan connector on the syst em boar d. 8. Reinstall the secondary har d disk drive if removed. See “Replacing the secondary har d disk drive” on page 93. 9. T o complet e the r eplacement, go to “Completing the FRU r eplacement” on page 103. Re[...]

4. Disconnect the rear fan assembly cable fr om the system fan connector on the system boar d. See “Locating parts on the system boar d” on page 71. 5. The r ear fan assembly is attached to the chassis by four rubber mounts. Remove the rear fan assembly by cutting the rubber mounts and gently pulling the r ear fan assembly out of the chassis. F[...]

Figure 37. Installing the rear fan assembly 8. Connect the r ear fan assembly cable t o the syst em fan connector on the system board. 9. T o complet e the r eplacement, go to “Completing the FRU r eplacement” on page 103. Replacing the front audio and USB assembly Attention Do not open your computer or att empt any repair befor e r eading and [...]

5. Disconnect the front audio and USB assembly cables from the system board. See “L ocating parts on the syst em boar d” on page 71. Note: Make sure you not e the locations of the cables when you disconnect the cables fr om the syst em board. 6. Remove the screw that secures the front audio and USB assembly to the chassis. Figure 38. Removing t[...]

1. Remove all media fr om the drives and turn off all attached devices and the computer . Then, disconnect all power cords fr om electrical outlets and disconnect all cables that are connect ed t o the computer . 2. Remove the computer cover . See “Removing the computer cover” on page 73. 3. L ocate the internal speaker connector on the system [...]

Figure 40. Installing a new internal speaker 7. Connect the int ernal speaker cable to the system board. See “L ocating parts on the system board” on page 71. 8. T o complete the installation or r eplacement, go t o “Completing the FRU r eplacement” on page 103. Completing the FRU replacement This section provides instructions on how to com[...]

4. P osition the computer cover on the chassis so that the r ail guides on the bott om of the computer cover engage the r ails on the chassis. Then, push the cover to the front of the comput er until it snaps into position. Figure 41. Reinstalling the computer cover 5. If the comput er cover is secured with thumbscrews, install them. 6. If there is[...]

Chapter 10. FRU lists Attention: Read “Important information about r eplacing RoHS compliant FRUs” on page 1 befor e replacing any FRUs. Note: In the following tables, a CRU (Customer Replaceable Unit) is identied as "1", "2", or "N" in the CRU column. "N" means that the part is not a CRU, "1"[...]

Item # FRUs FRU # CRU • MT 4220: 22M 22J 24J 25J 18G 36U 36F 36S 41A 41Q 41T 41K 41R 42A 42Q 42T 42K 42R 59A C TO 69J 72J 73J 96A A1C A4U A4F B3B B3H • MT 4221: C TO • MT 4222: 41B 41H 41V 23M 24M 29J 32J 33J 44A 44Q 44T 44K 44R 43B 43H 43V 47C CT O 54G 58G 71J 73M 74M 86J 91C A8C 2 Micropr ocessor , Xeon - L ynneld X3440 / 2.53GHz • MT [...]

Item # FRUs FRU # CRU 2 Micropr ocessor , Clarkdale - Celeron P entuim G6950 / 2.80GHz • MT 4215: C TO • MT 4219: C TO • MT 4220: 49C C T O • MT 4221: 13C 13B 13H 13V CT O • MT 4222: C TO 71Y5303 N 2 Micropr ocessor , Cor e i3-530 ( 2.93GHz / 2C / 4T / 4M / 1333 / 73w / iG 733) • MT 4215: C TO • MT 4219: C TO • MT 4220: CT O 81J •[...]

Item # FRUs FRU # CRU 2 Micropr ocessor , Clarkdale - Core i5-670 / 3.46GHz • MT 4215: C TO • MT 4219: C TO • MT 4220: 58K 58R C TO 87U 87F 87S 87L 87D 87Y 87G 87M 87A 87Q 87T 87C 87B 87H 87V 87K 87R 87E 87J B1U B1F B1S B1P B1L B1D B1Y B1G B1M B1A B1Q B1T B1C B1B B1H B1V B1K B1R B1E B1J • MT 4221: C TO • MT 4222: 27M 46A 46Q 46K 46J C T O[...]

Item # FRUs FRU # CRU 3 Memory module, DDR3 ECC PC3-10600 2GB UDIMM (1333) • MT 4215: C TO • MT 4219: C TO • MT 4220: 22M 22J 24J 25J 26M 26J 31J 12G 13G 15G 16G 17G 18G 21G 35U 35F 35S 36U 36F 36S 37U 37F 37S 41A 41Q 41T 41K 41R 42A 42Q 42T 42K 42R 46B 47H 49C 52C 53A 53Q 53K 54A 54Q 54K 55A 56A 57A 58A 58Q 58K 58R 59A 61A 62A 63A CT O 64G 6[...]

Item # FRUs FRU # CRU 3 Memory module, DDR3 non-ECC PC3-10600 2GB UDIMM (1333) • MT 4215: C TO • MT 4219: C TO • MT 4220: 26M 26J 31J 32J 35U 35F 35S CT O B4B B4H • MT 4221: C TO • MT 4222: 23M 24M 25M 27M 34J 35U 35F 35S 36U 36F 36S 37U 37F 37S C TO 53G 54G 55G 72M 73M 74M 75M 76G 77G 81U 81F 93U 93F 94U 94F 95U 95F 96U 96F 97U 97F A4M A[...]

Item # FRUs FRU # CRU 4 Optical drive, Blu-Ray DVD Burner (SA T A) • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 71Y7266 1 5 Car d reader , 3.5" 25-in-1 USB media car d r eader (w/GPIO detect) • MT 4215: C TO • MT 4219: C TO • MT 4220: 49C 52C 53A 53Q 53K 54A 54Q 54K 55A 56A 57A 58A 58Q 58K 58R[...]

Item # FRUs FRU # CRU 8 Hard disk drive, 500GB SA T A - 7200 rpm, 3 Gb/s, 16MB cache, 3.5" • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 15G 16G 17G 18G 21G 34U 34F 34S 35U 35F 35S 36U 36F 36S 37U 37F 37S 44C 45H 46B 47H 49C 51C 52C 55A 56A 59A 62A 63A C T O 64G 82U 82F 82S 82L 82D 82Y 82G 82M 82A 82Q 82T 82C 82B 82H 82V 82K 82R 82E 82J[...]

Item # FRUs FRU # CRU • MT 4222: 21G 16G 36U 36F 36S 37U 37F 37S C TO 52G 53G 54G 55G 66U 66F 66S 67U 67F 67S 57G 58G 59G 61G 64J 67U 67F 68U 68F 69U 69F 72M 73M 74M 75M 76G 77G 89J 91C 92C A1J 93U 93F 95U 95F 96U 96F 97U 97F A2G A3G A4M A8C 8 Hard disk drive, 1TB SA T A - 7200 rpm, 3 Gb/s, 32MB cache, 3.5" • MT 4215: C TO • MT 4219: C T[...]

Item # FRUs FRU # CRU 8 Hard disk drive, 128GB solid state drive (SSD) - ML C HDD , 1.8" • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 45N8203 1 8 Hard disk drive, 80GB solid state drive (SSD) - ML C HDD , 2.5" • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: [...]

Item # FRUs FRU # CRU 49Q 49K 51A C T O 53G 54G 55G 65U 65F 65S 67U 67F 67S 57G 58G 59G 61G 66U 66F 67U 67F 68U 68F 69U 69F 71J 72M 73M 74M 75M 76G 77G 78G 81U 81F 82J 83J 84J 85J 86J 87J 89J 91C 92C 98J 99J A1J 93U 93F 94U 94F 95U 95F 96U 96F 97U 97F A2G A3G A4M A5M A6J A7J A8C 9 System board, Orkney system boar d (TPM disabled - Russia only) • [...]

Item # FRUs FRU # CRU 81F 82J 83J 84J 85J 86J 87J 89J 91C 92C 98J 99J A1J 93U 93F 94U 94F 95U 95F 96U 96F 97U 97F A2G A3G A4M A5M A6J A7J A8C Mechanical FRUs The FRUs list ed in the following tables ar e not illustr ated. FRUs FRU # CRU FRU, front and rear handle assembly, no handle cover • MT 4215: all models • MT 4219: all models • MT 4220:[...]

FRUs FRU # CRU FRU, speaker cable_R_9*5_400mm • MT 4215: all models • MT 4219: all models • MT 4220: all models • MT 4221: all models • MT 4222: all models 43N9091 2 FRU, EMC shield • MT 4215: all models • MT 4219: all models • MT 4220: all models • MT 4221: all models • MT 4222: all models 41N8080 2 FRU, cabel-SA T A 457mm (RoH[...]

FRUs FRU # CRU FRU, Intrusion switch assembly • MT 4215: all models • MT 4219: all models • MT 4220: all models • MT 4221: all models • MT 4222: all models 41R6116 2 FRU, cable-SA T A 250mm (RoHS) • MT 4215: all models • MT 4219: all models • MT 4220: all models • MT 4221: all models • MT 4222: all models 43N9012 2 FRU, HDD T r [...]

FRUs FRU # CRU FRU, PS2 cable_R_170mm_knock out (with screw) • MT 4215: all models • MT 4219: all models • MT 4220: all models • MT 4221: all models • MT 4222: all models 43N9149 2 FRU, eSA T A cable - FH • MT 4215: all models • MT 4219: all models • MT 4220: all models • MT 4221: all models • MT 4222: all models 41R3308 2 FRU, [...]

K eyboard and Mouse Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU US English • MT 4215: C TO • MT 4219: C TO • MT 4220: 22M 26M 33M 12G 13G 14G 15G 16G 17G 18G 21G 34U 35U 36U 37U 41A 41Q 41R 42A 42Q 42R 45H 47H 48H 53A 53Q 54A 54Q 55A 56A 57A 58A 58Q 58R 59A 61A 62A 63A CT O 64G 82U 82L 82G 82M 82A 82Q 82H 82R 82E 83U 83L 83[...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU Belgium English • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 76G 77G 78G A2G A3G 41A5293 1 Brazilian P ortuguese • [...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU Dutch • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 76G 77G 78G A2G A3G 41A5299 1 F rench • MT 4215: C TO • MT 421[...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU Greek/US • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 35F 37F CT O 67F 68F 69F 81F 41A5305 1 Hebrew • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 1[...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU Kor ean • MT 4215: C TO • MT 4219: C TO • MT 4220: 41K 42K 53K 54K 58K C TO 82K 83K 84K 85K 86K 87K 88K A5K A6K A7K A8K A9K B1K • MT 4221: C TO • MT 4222: 46K 49K C TO 41A5311 1 LA Spanish • MT 4215: C TO • MT 4219: C TO • MT 4220: 35S 36S 37S C T O 82S 82D 82Y 83S 83D 8[...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU Romanian • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 76G 77G 78G A2G A3G 41A5316 1 Russian/Cyrillic • MT 4215: C T[...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU SF/G • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 76G 77G 78G A2G A3G 41A5323 1 Thailand • MT 4215: C TO • MT 421[...]

Keyboard (L enovo P referred Pro USB -- without hub) FRU # CRU US Eur opean • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 76G 77G 78G A2G A3G 41A5328 1 Slovenian • MT 4215: C TO ?[...]

Keyboard (P referred Pro F ull Size PS/2) FRU # CRU PS/2--Belgium English • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5043 1 PS/2--Brazilian P ortuguese • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5044 1 PS/2--Bulgarian • MT 4215: C TO • MT 4219: C[...]

Keyboard (P referred Pro F ull Size PS/2) FRU # CRU PS/2--Dutch • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5049 1 PS/2--F rench • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5050 1 PS/2--F rench Canadian • MT 4215: C TO • MT 4219: C TO • MT 4220: [...]

Keyboard (P referred Pro F ull Size PS/2) FRU # CRU PS/2--Greek/US • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5080 1 PS/2--Hebrew • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5055 1 PS/2--Hungarian • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO [...]

Keyboard (P referred Pro F ull Size PS/2) FRU # CRU PS/2--Kor ean • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5060 1 PS/2--LA Spanish • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5061 1 PS/2--Norwegian • MT 4215: C TO • MT 4219: C TO • MT 4220: C [...]

Keyboard (P referred Pro F ull Size PS/2) FRU # CRU PS/2--Russian/Cyrillic • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5066 1 PS/2--Serbian/Cyrillic • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5067 1 PS/2--Slovak • MT 4215: C TO • MT 4219: C TO •[...]

Keyboard (P referred Pro F ull Size PS/2) FRU # CRU PS/2-- Thailand • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5072 1 PS/2-- T urkish • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A5073 1 PS/2-- T urkish • MT 4215: C TO • MT 4219: C TO • MT 4220: C[...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced--US English • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4961 1 Enhanced--Arabic • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4962 1 Enhanced--A/F • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO ?[...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced--Bulgarian • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4967 1 Enhanced--Chinese/US • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4968 1 Enhanced--Czech (ABB) • MT 4215: C TO • MT 4219: C TO • MT 4[...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced--F rench Canadian • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4973 1 Enhanced--F rench Canadian • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4974 1 Enhanced--German • MT 4215: C TO • MT 4219: C TO [...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced--Hungarian • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4978 1 Enhanced--Iceland • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4979 1 Enhanced--Italy • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO[...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced--Norwegian • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4984 1 Enhanced--P olish • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4985 1 Enhanced--P ortuguese • MT 4215: C TO • MT 4219: C TO • MT 4220[...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced--Slovak • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4990 1 Enhanced--Spanish • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4991 1 Enhanced--Swedish/Finnish • MT 4215: C TO • MT 4219: C TO • MT 422[...]

Keyboard (Enhanced P erformance) FRU # CRU Enhanced-- T urkish • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4996 1 Enhanced--UK English • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 41A4997 1 Enhanced--US European • MT 4215: C TO • MT 4219: C TO • MT 4[...]

Mice FRU # CRU B1S B1P B1L B1D B1Y B1G B1M B1A B1Q B1T B1C B1B B1H B1V B1K B1R B1E B1J B2G B3B B3H B4B B4H B5C B6J • MT 4221: 13C 14A 13B 13H 13V CT O • MT 4222: 41B 41H 41V 42B 42H 42V 43B 43H 43V 23M 24M 25M 27M 29J 32J 33J 34J 21G 16G 35U 35F 35S 37U 37F 37S 44A 44Q 44T 44K 44R 45A 45Q 45T 45K 45R 47C 46A 46Q 46K 46J 49A 49Q 49K 51A C TO 53G[...]

Adapters and miscellaneous FRUs FRU # CRU • MT 4219: C TO • MT 4220: 24J C T O 72J • MT 4221: C TO • MT 4222: 32J C TO 256MB NVIDIA FX380 (2xDVI) • MT 4215: C TO • MT 4219: C TO • MT 4220: 22M 22J 13G 35U 35F 35S 46B 49C 54A 54Q 54K 57A 58A 58Q 58K 58R 62A CT O 69J 97A A1C A2C A3U A3F • MT 4221: C TO • MT 4222: 23M 29J 13G 35U 35F[...]

Adapters and miscellaneous FRUs FRU # CRU DVI t o VGA Dongle • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 40Y7611 2 DP t o DVI dongle • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 43N9160 2 DP t o VGA dongle • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO[...]

P ower Cords P ower Cords --primary FRU # CRU Line Cor d - US • MT 4215: C TO • MT 4219: C TO • MT 4220: 35U 35F 35S 36U 36F 36S 37U 37F 37S 41A 42A 53A 54A 55A 56A 57A 58A 59A 61A 62A 63A C T O 82U 82F 82S 82L 82D 82A 82T 83U 83F 83S 83L 83D 83A 83T 84U 84F 84S 84L 84D 84A 84T 85U 85F 85S 85L 85D 85A 85T 86U 86F 86S 86L 86D 86A 86T 87U 87F 8[...]

P ower Cords --primary FRU # CRU Line Cord-Austr alia / New Z ealand • MT 4215: C TO • MT 4219: C TO • MT 4220: 22M 26M 33M C TO 82M 83M 84M 85M 86M 87M 88M A5M A6M A7M A8M A9M B1M • MT 4221: C TO • MT 4222: 23M 24M 25M 27M C T O 72M 73M 74M 75M A4M A5M 41R3196 1 Line Cor d - Kor ea • MT 4215: C TO • MT 4219: C TO • MT 4220: 41K 41R[...]

P ower Cords --primary FRU # CRU Line Cor d - A models • MT 4215: C TO • MT 4219: C TO • MT 4220: 53A 54A 55A 56A 57A 58A 59A 61A 62A 63A C T O 82A 83A 84A 85A 86A 87A 88A 95A 96A 97A 98A 99A A5A A6A A7A A8A A9A B1A • MT 4221: C TO • MT 4222: 46A 49A 51A C T O 41R3208 1 Line Cor d - Denmark • MT 4215: C TO • MT 4219: C TO • MT 4220:[...]

P ower Cords --primary FRU # CRU Line Cor d - India • MT 4215: C TO • MT 4219: C TO • MT 4220: 41Q 42Q 53Q 54Q C TO 82Q 83Q 84Q 85Q 86Q 87Q 88Q A5Q A6Q A7Q A8Q A9Q B1Q • MT 4221: C TO • MT 4222: 46Q C TO 41R3341 1 Line Cor d - Thailand • MT 4215: C TO • MT 4219: C TO • MT 4220: 41T 42T C TO 82T 83T 84T 85T 86T 87T 88T A5T A6T A7T A8[...]

P ower Cords --secondary FRU # CRU Line Cor d - Brazil • MT 4215: C TO • MT 4219: C TO • MT 4220: CT O A5P A6P A7P AP8 A9P B1P • MT 4221: C TO • MT 4222: C TO 41R3271 1 Line Cord - LA High V olt (APU) • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO 82Y 82L 83Y 83L 84Y 84L 85Y 85L 86Y 86L 87Y 87L 88L A5Y A5L A6Y A6L A7Y A7L A8Y A8L A[...]

P ower Cords --secondary FRU # CRU Line Cor d - Italy • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21G 35S 36S 37S C T O 64G 82G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G 35S 36S 37S C TO 53G 54G 55G 57G 58G 59G 61G 76G 77G 78G A2G A3G 41R3233 1 Line Cor d - A models • M[...]

P ower Cords --secondary FRU # CRU Line Cor d - South Africa • MT 4215: C TO • MT 4219: C TO • MT 4220: 22M 26M 33M 12G 13G 15G 16G 17G 18G 21G 53A 54A 55A 56A 57A 58A 59A 61A 62A 63A C TO 64G 82M 82G 83M 83G 84M 84G 85M 85G 86M 86G 87M 87G 88M 88G 95A 96A 97A 98A 99A A5M A5G A5A A6M A6G A6A A7M A7G A7A A8M A8G A8A A9M A9G A9A B1M B1G B1A B2G[...]

Windows 7 P rofessional 64 Recovery CD Windows 7 P rofessional 64 FRU # CRU US English • MT 4215: C TO • MT 4219: • MT 4220: 26M 12G 13G 15G 16G 17G 18G 21G 35U 36U 37U 41A 41T 41R 42A 42T 42R 45H 46B 47H 53A 54A 55A 56A 57A 58A 58R 61A 62A 63A C TO 64G 82U 82L 82G 82M 82A 82Q 82H 82R 82E 83U 83L 83G 83M 83A 83Q 83H 83R 83E 84U 84L 84G 84M 84[...]

Windows 7 P rofessional 64 FRU # CRU Czech • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC TO 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G 03W2716 1 P olish • MT 4215: C TO • MT 4219: C TO • MT 4220: [...]

Windows 7 P rofessional 64 FRU # CRU Greek • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC TO 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G 03W2719 1 Kor ean • MT 4215: C TO • MT 4219: C TO • MT 4220: [...]

Windows 7 P rofessional 64 FRU # CRU Sebian- Latin • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC TO 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G 03W2733 1 Slovakian • MT 4215: C TO • MT 4219: C TO • MT 4[...]

Windows 7 P rofessional 64 FRU # CRU T raditional Chinese • MT 4215: C TO • MT 4219: C TO • MT 4220: CT O 82V 83V 84V 85V 86V 87V 88V A5V A6V A7V A8V A9V B1V • MT 4221: C TO • MT 4222: C TO 03W2715 1 India English • MT 4215: C TO • MT 4219: C TO • MT 4220: 41Q 42Q 53Q 54Q 58Q C TO 82Q 83Q 84Q 85Q 86Q 87Q 88Q • MT 4221: C TO • MT[...]

Windows 7 Pr ofessional 64 Ofce 2010 S tarter Recover y CD Windows 7 Pr ofessional 64 Ofce 2010 Starter FRU # CRU US English • MT 4215: C TO • MT 4219: C TO • MT 4220: 26M 12G 13G 15G 16G 17G 18G 21G 35U 36U 37U 41A 41T 41R 42A 42T 42R 45H 46B 47H 53A 54A 55A 56A 57A 58A 58R 61A 62A 63A C TO 64G 82U 82L 82G 82M 82A 82Q 82H 82R 82E 83U 8[...]

Windows 7 Pr ofessional 64 Ofce 2010 Starter FRU # CRU Czech • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC T O 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G 03W2742 1 P olish • MT 4215: C TO • MT 42[...]

Windows 7 Pr ofessional 64 Ofce 2010 Starter FRU # CRU Hungarian • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC T O 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G 03W2748 1 Greek • MT 4215: C TO • MT [...]

Windows 7 Pr ofessional 64 Ofce 2010 Starter FRU # CRU Romanian • MT 4215: C TO • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC T O 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G 03W2754 1 Sebian- Latin • MT 4215: C TO [...]

Windows 7 Pr ofessional 64 Ofce 2010 Starter FRU # CRU Simplied Chinese • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO 82C 83C 84C 85C 86C 87C 88C A1C A2C A5C A6C A7C A8C A9C B1C B5C • MT 4221: C TO • MT 4222: CT O 91C 92C 03W2740 1 T raditional Chinese • MT 4215: C TO • MT 4219: C TO • MT 4220: CT O 82V 83V 84V 85V 86V 87V 8[...]

Windows 7 Pr ofessional 64 Ofce 2010 Starter FRU # CRU • MT 4219: C TO • MT 4220: 12G 13G 15G 16G 17G 18G 21GC T O 64G 83G 84G 85G 86G 87G 88G A5G A6G A7G A8G A9G B1G B2G • MT 4221: C TO • MT 4222: 21G 16G C TO 53G 54G 55G 57G 58G 59G 61G 62G67F 68F 76G 77G 78G A2G A3G Windows XP P rofessional 64 Recovery CD Windows XP P rofessional 64 F[...]

Windows XP P rofessional Recovery CD Windows XP Pr ofessional FRU # CRU Simplied Chinese • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 03W2705 1 F rench • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 03W2706 1 German • MT 4215: C TO • MT 4219: C TO • MT [...]

Windows XP Pr ofessional FRU # CRU Multilingual Nordics: DK/FI/SV/NO/EN • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 03W2711 1 Multilingual EMEA: NL/FR/GR/IT/EN • MT 4215: C TO • MT 4219: C TO • MT 4220: C TO • MT 4221: C TO • MT 4222: C TO 03W2712 1 Chapter 10 . FRU lists 163[...]

164 Hardwar e Maintenance Manual[...]

Chapter 11. Additional service information This chapter provides additional information that the service r epresentative might nd helpful. Security features Security features in this section include the following: • P asswords • Vital Pr oduct Data • Management Information F ormat (MIF) Hardware-contr olled passwor ds Hardwar e-controlled [...]

Updating (ashing) the BIOS from a disc System BIOS pr ogram updat es are available at: http://www.lenovo.com/support T o updat e (ash) the BIOS fr om a disc, do the following: 1. Mak e sur e the optical drive you want to use is set as the rst boot device in the startup device sequence. See “Selecting or changing the startup device sequen[...]

5. Y ou might need to remove the secondary har d disk drive to access the Clear CMOS /Recovery jumper . See “Replacing the secondary hard disk drive” on page 93. 6. Move the jumper fr om the standar d position (pin 1 and pin 2) t o the maintenance position (pin 2 and pin 3). 7. Reconnect any cables that wer e disconnect ed and reinstall the sec[...]

168 Hardwar e Maintenance Manual[...]

Appendix A. Notices Lenovo may not offer the products, services, or featur es discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo pr oduct, pr ogram, or service is not intended to stat e or imply that only th[...]

T elevision output notice The following notice applies to models that have the factory-installed television-output feature. This product incorporat es copyright pr otection technology that is pr otected by method claims of certain U .S. patents and other intellectual property rights owned by Macrovision Corpor ation and other rights owners. Use of [...]

[...]

Part Number: 71Y8031 Printed in USA (1P) P/N: 71Y8031 *71Y8031*[...]