Monessen Hearth HWB700HB manuale d’uso

HWB700/HWB700HB M ODELS I NST ALLA TION , O PERA TION AND M AINTENANCE M ANUAL F OR R ESIDENTIAL I NST ALLA TION 53D9036. Rev 1 03/03 T HIS FIREPLACE IS U.L. LISTED FOR USE WITH THE "L" S ERIES CHIMNEY SYSTEM COMPONENTS . ONL Y UNVENTED GAS LOG SETS WHICH HA VE BEEN FOUND TO COMPL Y WITH THE ST ANDARD FOR UNVENTED ROOM HEA TER, ANSI/IAS/A[...]

1 Y ou have chosen the finest wood burning fireplace available. Y our fireplace has been designed for years of heating and viewing enjoyment. Please take time to read this entire manual before installing or operating your fireplace. L ISTING AND C ODE A PPROV ALS The instructions contained in this manual provide the information necessary to install[...]

1. Read these instructions entirely before beginning any part of the installation. Save these instructions for any future repairs. 2. Use these instructions as a guide during the installation of the fireplace. 3. Be sure these instructions become the property of and are reviewed by all future users of this fireplace to encourage proper operation an[...]

5 3 O PERA TION G UIDELINES When a AK4 combustion air assembly and a combustion air duct are attached to the connecting point on the left of the fireplace, combustion air may enter the firebox through a dampered opening behind the left side panel. This feature is designed for your benefit to reduce the room air used for combustion and to prevent ex[...]

6 4 C LEARANCES RESIDENTIAL INSTALLATION 53 3/8" 53 3/8" MAINTAIN 2" MIN. AIR SPACE MAINTAIN 2" MIN. AIR SPACE BETWEEN CHIMNEY AND BETWEEN CHIMNEY AND COMBUSTIBLES COMBUSTIBLES L12 (1' PIPE) L12 (1' PIPE) L18 (11/2' PIPE) L18 (11/2' PIPE) L36 (3' PIPE) L36 (3' PIPE) L48[...]

C LEARANCES 5 NOTE: DIMENSIONS MAY VARY SLIGHTLY DUE TO MANUFACTURING TOLERENCES. NOTE: DIMENSIONS MAY VARY SLIGHTLY DUE TO MANUFACTURING TOLERENCES. 4 5/16 16 1/16 9 13/16 25 9/16 12 3/16 30 3/4 21 13/16 46 3/8 27 13/16 56 3/4 30 5/16 61 11/16 LE30 ELBOW L12 L 1 8 L18 L 3 6 L36 L 3 6 L36 L 3 6 L36 L48 L48 L 1 8 L18 L 3 6 L36 39 5/16 76 11/16 &q[...]

F IREPLACE L OCA TION CAUTION: Do not install fireplace over carpeting. This fireplace does not weigh more than large pieces of furniture and can normally be located near a load bearing wall without requiring additional foundations or supports. If however , the fireplace is to be trimmed with a heavy stone or brick facing and hearth extension, be s[...]

8' 0" LEVEL SOLID SURFACE FIRESTOP SPACER SEE NOTES  JOIST INSULATE SAME AS CEILING NOTES: 1. MODEL LF-FS-2 FIRESTOP  SPACER MUST BE USED. 2. LOCAL CODES MAY NOT REQUIRE FIRE STOPPING AT THE CEILING LEVEL FOR CHASE INSTALLATIONS, BUT IT IS RECOMMENDED FOR SAFETY AND  REDUCING HEAT LOSS. 3. DO NOT INSULA[...]

MULTIPLE STORY INSTALLATION ATTIC SPACE SINGLE STORY INSTALLATION WITH POOR  LOCATION PREFERRED  LOCATION 2" MIN. CLEARANCE  2" MIN. CLEARANCE  TO COMBUSTIBLES TO COMBUSTIBLES "L" SERIES CHIMNEY COMPONENTS "L" SERIES CHIMNEY COMPONENTS FIRESTOP SPACER FIRESTOP SPACER LF-FS-2 (2" AIR SPACE LF-F[...]

9 F LOOR P ROTECTION If this fireplace is installed on a combustible floor , the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 9, an H2068 hearth extens[...]

52 7/8" 52 7/8" 27" 27" 53 1/8" 53 1/8" 68" 68" 20" 20" FLOOR FLOOR COMBUSTIBLE COMBUSTIBLE 26 3/8" 26 3/8" WARNING: THE HEARTH EXTENSION AND THE  WARNING: THE HEARTH EXTENSION AND THE  METAL SAFETY STRIP SHOULD BE INSTALLED  METAL SAFETY STRIP SHOULD BE INSTALLED  ONLY IN A HO[...]

11 53D9036. Rev 1 03/03 F IREPLACE C OMPONENTS F IGURE 13[...]

F IREPLACE I NST ALLA TION L OCA TION S ELECTION Unpack and check the fireplace and chimney for damage. If any items have been damaged, report this to your dealer . Before beginning the installation, be sure you have the proper parts in sufficient quantity . Refer to Figure 28 for proper identification of parts. Do not substitute parts. Use only pa[...]

13 53D9036. Rev 1 03/03 C HIMNEY I NST ALLA TION 1. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will pass through. Unless the chimney is to be offset, the point where the center line of the chimney will pass through the ceiling and roof can be determined with a plumb line as shown by Figure 15. T[...]

IMAGINARY IMAGINARY CENTER POINT CENTER POINT ACTUAL ACTUAL CENTER POINT CENTER POINT CENTERLINE  CENTERLINE  OF CHIMNEY OF CHIMNEY PLUMB BOB PLUMB BOB PLUMB LINE PLUMB LINE TABLE 1 TABLE 1 MINIMUM REQUIRED ROOF OPENING MINIMUM REQUIRED ROOF OPENING MINIMUM FRAMED OPENING MINIMUM FRAMED OPENING "L" SERIES  "[...]

15 53D9036. Rev 1 03/03 C HIMNEY O FFSET I NST ALLA TION E LBOW I NST ALLA TION The following are important points that should be observed when installing elbows on the fireplace: 1. The support straps of all elbows not installed directly on top of the fireplace should be nailed securely to the surrounding structure. This allows the support strap t[...]

C HIMNEY O FFSET AND C AP I NST ALLA TION CHIMNEY HOUSING INSTALL ROUND CHIMNEY CAP OR CONTINUE CHIMNEY TO PROPER HEIGHT AND STORM CO L STORM COLLAR FLASH FLASHING ROOF FIRESTOP SPACER AS REQUIRED HEIGHT EXCEEDS 24FT. 2 IN. WHEN TOTAL INSTALLATION TWO ELBOWS MAY BE USED NOTE: FASTEN SUPPORT STRAPS SECURELY USE OF LF-FS-2 FI R USE OF LF-FS-2 FIRESTO[...]

17 53D9036. Rev 1 03/03 C HIMNEY C AP I NST ALLA TION M ODEL LC C HIMNEY C AP S PECIAL N OTE : The proper height as previously explained is important to assure proper draft and safety . The chimney cap extends the flue outlet four inches above the top of the last section of chimney . This should be kept in mind when determining the proper height fo[...]

C HIMNEY H EIGHT AND O FFSET C HARTS 17 17 26 1/2 26 1/2 31 3/4 31 3/4 36 36 41 1/4 41 1/4 47 1/4 47 1/4 50 3/4 50 3/4 57 3/4 57 3/4 62 62 67 3/4 67 3/4 72 1/2 72 1/2 77 1/2 77 1/2 82 82 88 88 92 1/4 92 1/4 98 1/2 98 1/2 102 3/4 102 3/4 107 3/4 [...]

19 53D9036. Rev 1 03/03 C HIMNEY C AP C HASE I NST ALLA TION The preinstalled chimney sections should be no more than 13 inches below the top of the chase. The installation should be planned so that either a two-foot or three-foot chimney section will be used for the top section. This is necessary to ensure complete engagement of the inlet air tele[...]

O UTSIDE C OMBUSTION A IR P RECAUTIONS & R ECOMMENDA TIONS CONCRETE SLAB INSTALLATION  (OPTIONAL OUTSIDE AIR RUNS) INLET GRILLE IN SOFFIT (OVERHANG) 8' MAX. FIRESTOP SPACER CAUTION: DO NOT TAKE  COMBUSTION AIR FROM ATTIC SPACE OR GARAGE. TERMINATION CAP INSTALLATION ABOVE BASEMENT INSTALLATION ABOVE BASEMENT OR CRAWL S[...]

21 53D9036. Rev 1 03/03 O UTSIDE C OMBUSTION A IR P RECAUTIONS & R ECOMMENDA TIONS O UTSIDE C OMBUSTION A IR R ECOMMENDA TIONS ( CONTINUED ) 1. Extremely long runs and numerous turns in the duct leading from the fireplace to the combustion air assembly should be avoided. These conditions will increase the resistance to the free flow of air thro[...]

C OMBUSTION A IR A SSEMBL Y M ODEL AK-4 C OMBUSTION A IR A SSEMBL Y 1. Remove the cover plate from the 4-inch outlet opening location on the left outside of the fireplace. DO NOT remove the cover if the outside air will not be connected. 2. Place the insulation ring between the AK-4 starting collar and fireplace wall and place the starting collar ([...]

23 53D9036. Rev 1 03/03 G AS A PPLIANCE I NST ALLA TION W ARNING : Improper installation or operation of a gas appliance in this fireplace can allow unburned gas to leak out which will cause a fire or explosion hazard, or the release of poisonous carbon monoxide into the dwelling which can cause serious injury or death to its inhabitants. T o reduc[...]

G AS A PPLIANCE I NST ALLA TION 7. Pack the insulation removed in step 4 around the pipe to prevent air flowing through the tube either into or out of the firebox. 8. Be sure the gas is turned off at the appliance, then turn the gas on at the cut of f valve and test the gas line connections for leaks with soapy water solution or a liquid leak detec[...]

25 53D9036. Rev 1 03/03 COMBUSTIBLE SURROUND PLACEMENT  COMBUSTIBLE SURROUND MATERIALS  COMBUSTIBLE SURROUND MATERIALS  MAY BE PLACED INSIDE THE SHADED  MAY BE PLACED INSIDE THE SHADED  AREAS. COMBUSTIBLES MAY NOT  AREAS. COMBUSTIBLES MAY NOT  OVERLAP EDGE OF BLACK PAINTED  OVERLAP EDGE OF BLACK PAINTED  FACE MOR[...]

F IREPLACE O PERA TION W ARNING : If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an open position. (See additional operation information in section titled “Operation Guidelines”.) A DV ANT AGES OF A W OOD B URNING F IREPLACE These are the practical, ecological advantages of wood as a fuel. Also to b[...]

27 53D9036. Rev 1 03/03 F IREPLACE O PERA TION A F EW W ORDS OF C AUTION Beware of burning certain material in your fireplace. Among these are plastics, poison ivy twigs and stems, and chemically treated woods such as discarded poles and railroad ties. These not only create air pollution, but can induce extreme irritation for some individuals. Use [...]

M AINTENANCE AND S AFETY F UEL S T ORAGE W ood can be dried suf ficiently for burning within a few weeks if protected form rain in a low humidity area. It is far better to cut wood and allow it to dry for a year . In all cases, the wood should be stacked so that both ends of the sticks are exposed to the air and protected from rain. The drier the w[...]

29 53D9036. Rev 1 03/03 F IREPLACE M AINTENANCE At the end of each heating season or when the fireplace will not be in use for an extended time, the ashes should be removed and the hearth area should be swept as clean as is practical. The slow absorption of moisture into the ashes over a long period of time could cause a condition which would be co[...]

18. Do store your fuel supply at a distance equal to or greater than the spacing recommended for combustible materials from the fireplace. 19. Do build fires of moderate intensity in the fireplace for the first three fires to allow materials to adjust and cure before being subjected to the intense heat of a large fire. DONT’S 1. Don’t allow oth[...]

31 53D9036. Rev 1 03/03 P ARTS D IAGRAM AND L IST F IGURE 26 All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number , and Quantity of parts needed. T echnical Service [...]

32 53D9036. Rev 1 03/03 P ARTS D IAGRAM AND L IST F IGURE 27 All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number , and Quantity of parts needed. T echnical Service [...]

33 53D9036. Rev 1 03/03 FACTORY-BUILT FIREPLACE AND COMPONENTS ( EXCEPT BLOWERS ) W HAT IS COVERED AND FOR HOW LONG •F IVE -Y EAR C OVERAGE - For five years from the date this fireplace and components are first purchased for use, Monessen Hearth Systems will, at its option, repair or replace any defective part of this fireplace or components, or [...]

34 53D9036. Rev 1 03/03 L IMITED W ARRANTY Y OUR D UTIES This fireplace must be installed by a qualified installer according to your local building codes and installation instructions and operated according to the owner’s instructions. You must keep an invoice, canceled check or payment record to verify the purchase date of the fireplace. I F Y O[...]

A TTENTION A PPLIANCE I NST ALLER P LEASE RETURN THESE O PERA TING AND I NST ALLA TION I NSTRUCTIONS TO THE A PPLIANCE FOR C ONSUMER U SE . 53D9036. R EV 1 03/03[...]